Citation: XU Bin, GAO Rui, DAI Zheng-hua, LIU Hai-feng, WANG Fu-chen. Study on gas and solid phase products of rapid pyrolysis process of oil slurry at high temperature[J]. Journal of Fuel Chemistry and Technology, ;2019, 47(10): 1181-1186. shu

Study on gas and solid phase products of rapid pyrolysis process of oil slurry at high temperature

XU Bin ^1,2 ,
GAO Rui ^1,2 ,
DAI Zheng-hua ^1,2,, ,
LIU Hai-feng ^1,2 ,
WANG Fu-chen ^1,2

1.
School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China
2.
Shanghai Engineering Research Center of Coal Gasification, East China University of Science and Technology, Shanghai 200237, China

Corresponding author: DAI Zheng-hua, chinadai@ecust.edu.cn
Received Date: 10 June 2019
Revised Date: 31 July 2019

Fund Project: National Natural Science Foundation of China 21776087National Key R & D Program of China 2018YFB0605000Program of Shanghai Technology Research Leader 19XD1434800The project was supported by National Key R & D Program of China (2018YFB0605000), National Natural Science Foundation of China (21776087) and Program of Shanghai Technology Research Leader (19XD1434800)

Figures(4)

The characteristics of high temperature rapid pyrolysis of oil slurry were studied by using a rapid pyrolysis device of high-frequency furnace. The effects of pyrolysis temperature and nitrogen flow rate on the compositions and yields of gas and solid phase products were investigated. The results show that the temperature is the key factor to affect the yields of gas phase products. The gas phase products are mainly methane, hydrogen and ethylene. Higher temperature can increase the yields of hydrogen and methane, while the yield of ethylene is affected by the secondary reaction at high temperature and decreased gradually after reaching the maximum at 800℃. The yields of ethane and propylene are lower, and gradually decrease after reaching the maximum at 700℃ due to the secondary reaction. A small amount of acetylene is formed when the temperature is higher than 800℃ and the yield of acetylene will be increased by increasing the temperature. Meanwhile, increasing the nitrogen flow rate can reduce the partial pressure of methane and hydrogen and shorten the residence time of ethylene and propylene in the high temperature area, leading to an increase in the yield of gas phase products. The yield of carbon deposition increases rapidly with the increase of temperature, while the increase of nitrogen flow rate could weaken the secondary reaction and reduce the yield of carbon deposition.
- oil slurry,
- rapid pyrolysis,
- ethylene,
- pyrolysis temperature,
- nitrogen flow rate
1. [1]
  ZHONG Li-ke, SUN Zhi-qian, REN Xiang-jun, XU Shan-shan, CHEN A-qiang, WANG Zhen-bo. Research progress of catalytic cracking slurry dehardening method[J]. Petrochem Technol, 2017,46(9):1209-1213. doi: 10.3969/j.issn.1000-8144.2017.09.019
2. [2]
  XUE Y, GE Z, LI F, SU S, LI B. Modified asphalt properties by blending petroleum asphalt and coal tar pitch[J]. Fuel, 2017,207:64-70. doi: 10.1016/j.fuel.2017.06.064
3. [3]
  LI Yao-wei. Optimization of catalytic cracking slurry to improve asphalt quality[D]. Shandong: Shandong University of Science and Technology, 2006.
4. [4]
  SYROEZHKO A M, PROSKURYAKOV V A, BEGAK O Y, FEDOROV V V, KORCHEMKIN S N, SOKOLOVA Y V, KUZNETSOVA O Y. Softeners for rubber and corrosion-resistant coatings based on shale and petroleum raw materials[J]. Russ J Appl Chem, 2001,74(7):1235-1239. doi: 10.1023/A:1013008126894
5. [5]
  LI P, XIONG J, GE M, SUN J, ZHANG W, SONG Y. Preparation of pitch-based general purpose carbon fibers from catalytic slurry oil[J]. Fuel Process Technol, 2015,140:231-235. doi: 10.1016/j.fuproc.2015.09.011
6. [6]
  GUNNING , HARRY E. Atomic and free radical reactions[J]. J Am Chem Soc, 1955,77(8):2347-2348.
7. [7]
  RANZI E, DENTE M, GOLDANIGA A, BOZZANO G, FARAVELLI T. Lumping procedures in detailed kinetic modeling of gasification, pyrolysis, partial oxidation and combustion of hydrocarbon mixtures[J]. Prog Energy Combust Sci, 2001,27(1):99-139. doi: 10.1016/S0360-1285(00)00013-7
8. [8]
  GHASSABZADEH H, DARIAN J T, ZAHERI R. Experimental study and kinetic modeling of kerosene thermal cracking[J]. J Anal Appl Pyrolysis, 2009,86(1):221-232. doi: 10.1016/j.jaap.2009.06.006
9. [9]
  ZHOU Zhi. Study on influencing factors of naphtha to produce low carbon olefin[J]. Petrochem Technol, 2018,47(4):338-343. doi: 10.3969/j.issn.1000-8144.2018.04.006
10. [10]
  CORMA A, ORCHILLES A V. Current views on the mechanism of catalytic cracking[J]. Microporous Mesoporous Mater, 2000,35:21-30.
11. [11]
  CHEN Jun-wu. Catalytic Cracking Process and Engineering[M]. 2nd ed, Beijing:China Petrochemical Press, 2005.
12. [12]
  AFSHAREBRAHIMI A, TARIGHI S. The influence of temperature and catalyst additives on catalytic cracking of a heavy fuel oil[J]. Petrol Sci Technol, 2015,33(4):415-421. doi: 10.1080/10916466.2014.987298
13. [13]
  KHATTAF A, FAHAD S S, A LI, AHMED S. Catalytic cracking of arab super light crude oil to light olefins:An experimental and kinetic study[J]. Energy Fuels, 2018,32(2):2234-2244. doi: 10.1021/acs.energyfuels.7b04045
14. [14]
  HAGHIGHI S S, RAHIMPOUR M R, RAEISSI S, DEHGHANI O. Investigation of ethylene production in naphtha thermal cracking plant in presence of steam and carbon dioxide[J]. Chem Eng J, 2013,228:1158-1167. doi: 10.1016/j.cej.2013.05.048
15. [15]
  LIAO Shi-jian, ZHANG Ji-ren. Theoretical discussion on the product composition of acetylene produced by partial combustion of methane[J]. J Fuel Chem Technol, 1966,7(1):1-7.
16. [16]
  TIAN Li-da. Analysis on the polymerization mechanism of advanced alkyne in natural gas acetylene process[J]. Nat Gas Chem Ind, 2014,39(3):16-20. doi: 10.3969/j.issn.1001-9219.2014.03.004
17. [17]
  HONG Y. Advances in technology for preparation of acetylene via partial oxidation of natural gas[J]. China Pet Process Pet Technol, 2010,12(2):8-12.
18. [18]
  ZHANG Hao, ZHU Feng-sen, LI Xiao-dong, WU Ang-jian, BO Zheng, CEN Ke-fa. Rotating sliding-arc argon plasma cracking methane to produce hydrogen[J]. J Fuel Chem Technol, 2016,44(2):192-200. doi: 10.3969/j.issn.0253-2409.2016.02.009
19. [19]
  YAN B, CHENG Y, LI T, CHENG Y. Detailed kinetic modeling of acetylene decomposition/soot formation during quenching of coal pyrolysis in thermal plasma[J]. Energy, 2017,121:10-20. doi: 10.1016/j.energy.2016.12.130
20. [20]
  LAHAYE J, BADIE P, DUCRET J. Mechanism of carbon formation during steamcracking of hydrocarbons[J]. Carbon, 1977,15(2):87-93. doi: 10.1016/0008-6223(77)90022-7
21. [21]
  HARRIS S J, WEINER A M. Soot particle growth in premixed toluene/ethylene flames[J]. Combust Sci Technol, 1984,38(1/2):75-87.
22. [22]
  QU Guo-hua. Delayed Coking Process and Engineering[M]. Beijing:China Petrochemical Press, 2008.
23. [23]
  WANG Gang, WU Yong-tao, XU Chun-ming, LIU Wei-kang, GAO Jin-sen. Study on catalytic pyrolysis of FCC gasoline to produce low carbon alkenes[J]. J Fuel Chem Technol, 2009,37(5):552-559. doi: 10.3969/j.issn.0253-2409.2009.05.007
24. [24]
  CHEN Bin. Ethylene Engineering[M]. Beijing:Chemical Industry Press, 1997.
1. [1]
  Yucai Zhang , Jun Jiang . Electrochemical Carbon Dioxide Reduction to Ethylene. University Chemistry, 2026, 41(2): 190-196. doi: 10.12461/PKU.DXHX202503006
2. [2]
  Rohit Kumar , Anita Sudhaik , Aftab Asalam Pawaz Khan , Van Huy Neguyen , Archana Singh , Pardeep Singh , Sourbh Thakur , Pankaj Raizada . Designing tandem S-scheme photo-catalytic systems: Mechanistic insights, characterization techniques, and applications. Acta Physico-Chimica Sinica, 2025, 41(11): 100150-0. doi: 10.1016/j.actphy.2025.100150
3. [3]
  Min Hu , Yinghuan Li , Yanhong Bai , Yanping Ren , Juanjuan Song , Yongxian Fan , Dongcheng Liu , Xiuqiong Zeng , Faqiong Zhao , Wenwei Zhang , Mei Shi , Wan Li , Xiuyun Wang , Weihong Li , Xiaohang Qiu , Yong Fan , Jianrong Zhang , Shuyong Zhang . Suggestions on the Method of Hydrothermal-Solventthermal Synthesis and Their Operation Standards. University Chemistry, 2026, 41(3): 208-215. doi: 10.12461/PKU.DXHX202507034
4. [4]
  Kexin Yan , Zhaoqi Ye , Lingtao Kong , He Li , Xue Yang , Yahong Zhang , Hongbin Zhang , Yi Tang . Seed-Induced Synthesis of Disc-Cluster Zeolite L Mesocrystals with Ultrashort c-Axis: Morphology Control, Decoupled Mechanism, and Enhanced Adsorption. Acta Physico-Chimica Sinica, 2024, 40(9): 2308019-0. doi: 10.3866/PKU.WHXB202308019
5. [5]
  Zhuo WANG , Junshan ZHANG , Shaoyan YANG , Lingyan ZHOU , Yedi LI , Yuanpei LAN . Preparation and photocatalytic performance of CeO₂-reduced graphene oxide by thermal decomposition. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1708-1718. doi: 10.11862/CJIC.20240067
6. [6]
  Yang Lv , Yingping Jia , Yanhua Li , Hexiang Zhong , Xinping Wang . Integrating the Ideological Elements with the “Chemical Reaction Heat” Teaching. University Chemistry, 2024, 39(11): 44-51. doi: 10.12461/PKU.DXHX202402059
7. [7]
  Yang ZHOU , Lili YAN , Wenjuan ZHANG , Pinhua RAO . Thermal regeneration of biogas residue biochar and the ammonia nitrogen adsorption properties. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1574-1588. doi: 10.11862/CJIC.20250032
8. [8]
  Zehua Zhao , Xiaoyan An , Jinrong Xu , Ling Yang , Hao Zhao , Zhongyun Wu . Independent Development and Application of Calorimetric Experiment Data Acquisition and Processing Software. University Chemistry, 2025, 40(11): 402-408. doi: 10.12461/PKU.DXHX202505045
9. [9]
  Bolin Sun , Jie Chen , Ling Zhou . 乙烯型卤代烃的亲核取代反应. University Chemistry, 2025, 40(8): 152-157. doi: 10.12461/PKU.DXHX202410032
10. [10]
  Limei CHEN , Mengfei ZHAO , Lin CHEN , Ding LI , Wei LI , Weiye HAN , Hongbin WANG . Preparation and performance of paraffin/alkali modified diatomite/expanded graphite composite phase change thermal storage material. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 533-543. doi: 10.11862/CJIC.20230312
11. [11]
  Yuting Bai , Cenqi Yan , Zhen Li , Jiaqiang Qin , Pei Cheng . Preparation of High-Strength Polyimide Porous Films with Thermally Closed Pore Property by In Situ Pore Formation Method. Acta Physico-Chimica Sinica, 2024, 40(9): 2306010-0. doi: 10.3866/PKU.WHXB202306010
12. [12]
  Mengxiu Li , Jiahui Mao , Jiangfeng Ni , Liang Li . Three birds with one stone: modification of Li₅FeO₄ with thermal induction of Lewis acid. Acta Physico-Chimica Sinica, 2026, 42(4): 100189-0. doi: 10.1016/j.actphy.2025.100189
13. [13]
  Yongqing Xu , Yuyao Yang , Mengna Wu , Xiaoxiao Yang , Xuan Bie , Shiyu Zhang , Qinghai Li , Yanguo Zhang , Chenwei Zhang , Robert E. Przekop , Bogna Sztorch , Dariusz Brzakalski , Hui Zhou . Review on Using Molybdenum Carbides for the Thermal Catalysis of CO₂ Hydrogenation to Produce High-Value-Added Chemicals and Fuels. Acta Physico-Chimica Sinica, 2024, 40(4): 2304003-0. doi: 10.3866/PKU.WHXB202304003
14. [14]
  Zihan Cheng , Kai Jiang , Jun Jiang , Henggang Wang , Hengwei Lin . Achieving thermal-stimulus-responsive dynamic afterglow from carbon dots by singlet-triplet energy gap engineering through covalent fixation. Acta Physico-Chimica Sinica, 2026, 42(2): 100169-0. doi: 10.1016/j.actphy.2025.100169
15. [15]
  Jiaqi Chen , Liang Chen , Xiaocui Wei , Yankai Wang , Yahui Chang , Xinghao Ji , Haoyu Yang , Yue Sun , Yawen Wang , Xiufeng Shi , Xu Wu . Digital Empowerment for Foundational Excellence: A Digitally Enhanced Coordination Titration Experiment of Heating Pack Component Analysis. University Chemistry, 2026, 41(1): 382-393. doi: 10.12461/PKU.DXHX202506008
16. [16]
  Huiying ZHANG , Ping LI , Weixia DONG , Zhiwen HU , Qifu BAO , Qizheng DONG , Mingmin BAI , Wenqi LI . Photocatalytic performance of spheroidal nano Bi₄Ti₃O₁₂ prepared by surfactant-assisted hydrothermal reaction. Chinese Journal of Inorganic Chemistry, 2026, 42(3): 551-561. doi: 10.11862/CJIC.20250269
17. [17]
  Xiaopei HE , Jing HAN , Zhong YU , Na YE , Yi WAN . Preparation and antimicrobial properties of polyvinyl alcohol composite film based on Ag(Ⅰ) complex. Chinese Journal of Inorganic Chemistry, 2026, 42(3): 531-542. doi: 10.11862/CJIC.20250271
18. [18]
  Wenwei Zhang , Yiru Wang , Chanzi Ruan , Juanjuan Song , Yongxian Fan , Houjin Li , Dongcheng Liu , Yanping Ren , Xiuqiong Zeng , Faqiong Zhao , Mei Shi , Min Hu , Wan Li , Xiuyun Wang , Weihong Li , Xiaohang Qiu , Yong Fan , Jianrong Zhang , Shuyong Zhang . Suggestions on Heating and Heating Instruments (Part III): Indirect Heating and the Use of Thermal Baths (Water Bath, Oil Bath, Metal Bath and Sand Bath). University Chemistry, 2026, 41(3): 163-171. doi: 10.12461/PKU.DXHX202507039
19. [19]
  Chengqian Mao , Yanghan Chen , Haotong Bai , Junru Huang , Junpeng Zhuang . Photodimerization of Styrylpyridinium Salt and Its Application in Silk Screen Printing. University Chemistry, 2024, 39(5): 354-362. doi: 10.3866/PKU.DXHX202312014
20. [20]
  Zhaoxuan ZHU , Lixin WANG , Xiaoning TANG , Long LI , Yan SHI , Jiaojing SHAO . Application of poly(vinyl alcohol) conductive hydrogel electrolytes in zinc ion batteries. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 893-902. doi: 10.11862/CJIC.20240368

Get Citation

PDF

XML

Metrics

PDF Downloads(6)
Abstract views(1669)
HTML views(102)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142