Citation: Zhenzhen Wang, Yichao Cai, Youxuan Ni, Yong Lu, Liu Lin, Haoxiang Sun, Haixia Li, Zhenhua Yan, Qing Zhao, Jun Chen. Ultrafine RuO₂ nanoparticles/MWCNTs cathodes for rechargeable Na-CO₂ batteries with accelerated kinetics of Na₂CO₃ decomposition[J]. Chinese Chemical Letters, ;2023, 34(3): 107405. doi: 10.1016/j.cclet.2022.04.003 shu

Ultrafine RuO₂ nanoparticles/MWCNTs cathodes for rechargeable Na-CO₂ batteries with accelerated kinetics of Na₂CO₃ decomposition

Haihe Laboratory of Sustainable Chemical Transformations, Key Laboratory of Advanced Energy Materials Chemistry (Ministry of Education), Renewable Energy Conversion and Storage Center (RECAST), College of Chemistry, Nankai University, Tianjin 300071, China

zhaoq@nankai.edu.cn

Received Date: 5 March 2022
Revised Date: 26 March 2022
Accepted Date: 2 April 2022
Available Online: 5 April 2022

Figures(5)

Na-CO₂ batteries have attracted extensive attention due to their high theoretical energy density (1125 Wh/kg), efficient utilization of CO₂, and abundant sodium resources. However, they are trapped by the sluggish decomposition kinetic of discharge products (mainly Na₂CO₃) on cathode side during the charging process. Here we prepared a series of nano-composites composed of RuO₂ nanoparticles in situ loaded on activated multi-walled carbon nanotubes (RuO₂@a-MWCNTs) through hydrolyzing reaction followed by calcination method and used them as cathode catalysts to accelerate the decomposition of Na₂CO₃. Among all catalysts, the RuO₂@a-MWCNTs with appropriate ratio of RuO₂ (49.7 wt%) demonstrated best stability and rate performance in Na-CO₂ batteries, benefiting from both high specific surface area (160.3 m²/g) and highly dispersed RuO₂ with ultrafine nanostructures (~2 nm). At a limited capacity of 500 mAh/g, Na-CO₂ batteries could afford the operation of over 120 cycles at 100 mA/g, and even at the current density to 500 mA/g, the charge voltage was still lower than 4.0 V after 40 cycles. Further theoretical calculations proved that RuO₂ was the catalytically active center and contributed to the decomposition of Na₂CO₃ by weakening the C=O bond. The synergetic functions of high specific surface (CNTs) and high catalytic activity (RuO₂) will inspire more progress on metal-CO₂ batteries.
- Na-CO₂ batteries,
- Cathode catalyst,
- RuO₂@a-MWCNTs,
- High rate performance,
- Low charge overpotential
1. [1]
  J. Sun, Y. Lu, H. Yang, et al., Research 2018 (2018) 6914626.
2. [2]
  X. Mu, H. Pan, P. He, et al., Adv Mater. 32 (2019) e1903790.
3. [3]
  Y. Hou, J. Wang, L. Liu, et al., Adv. Funct. Mater. 27 (2017) 1700564. doi: 10.1002/adfm.201700564
4. [4]
  S. Shen, C. Han, B. Wang, et al., Chin. Chem. Lett. 33 (2022) 3721–3725. doi: 10.1016/j.cclet.2021.10.063
5. [5]
  X. Hu, J. Sun, Z. Li, et al., Angew. Chem. Int. Ed. 55 (2016) 6482–6486. doi: 10.1002/anie.201602504
6. [6]
  Y. Lu, Y. Cai, Q. Zhang, et al., Chem. Sci. 10 (2019) 4306–4312. doi: 10.1039/C8SC05178J
7. [7]
  S. Thoka, C.M. Tsai, Z. Tong, et al., ACS Appl. Mater. Interfaces 13 (2021) 480–490. doi: 10.1021/acsami.0c17373
8. [8]
  S. Yang, Y. Qiao, P. He, et al., Energy Environ. Sci. 10 (2017) 972–978. doi: 10.1039/C6EE03770D
9. [9]
  S. Ma, Y. Lu, H. Yao, et al., Chin. Chem. Lett. 33 (2022) 2933–2936. doi: 10.1016/j.cclet.2021.10.089
10. [10]
  Y. Dong, S. Li, S. Hong, L. Wang, B. Wang, Chin. Chem. Lett. 31 (2020) 635–642. doi: 10.1016/j.cclet.2019.08.021
11. [11]
  X. Zhang, C. Wang, H. Li, et al., J. Mater. Chem. A 6 (2018) 2792–2796. doi: 10.1039/C7TA11015D
12. [12]
  Y. Xing, Y. Yang, D. Li, et al., Adv. Mater. 30 (2018) e1803124. doi: 10.1002/adma.201803124
13. [13]
  C. Yang, K. Guo, D. Yuan, et al., J. Am. Chem. Soc. 142 (2020) 6983–6990. doi: 10.1021/jacs.9b12868
14. [14]
  Z. Zhang, Q. Zhang, Y. Chen, et al., Angew. Chem. Int. Ed. 54 (2015) 6550–6553. doi: 10.1002/anie.201501214
15. [15]
  K. Chen, G. Huang, J.L. Ma, et al., Angew. Chem. Int. Ed. 59 (2020) 16661–16667. doi: 10.1002/anie.202006303
16. [16]
  R. Pipes, A. Bhargav, A. Manthiram, Adv. Energy Mater. 9 (2019) 1900453. doi: 10.1002/aenm.201900453
17. [17]
  Z. Zheng, C. Wu, Q. Gu, et al., J. Energy Environ. Mater. 4 (2021) 158–177. doi: 10.1002/eem2.12139
18. [18]
  S. Thoka, Z. Tong, A. Jena, et al., J. Mater. Chem. A 8 (2020) 23974. doi: 10.1039/D0TA09235E
19. [19]
  Z. Zhang, X.G. Wang, X. Zhang, et al., Adv. Sci. 5 (2018) 1700567. doi: 10.1002/advs.201700567
20. [20]
  L. Qie, Y. Lin, J.W. Connell, et al., Angew. Chem. Int. Ed. 56 (2017) 6970–6974. doi: 10.1002/anie.201701826
21. [21]
  L. Guo, B. Li, V. Thirumal, et al., Chem. Commun. 55 (2019) 7946–7949. doi: 10.1039/C9CC02737H
22. [22]
  C. Fang, J. Luo, C. Jin, et al., ACS Appl. Mater. Interfaces 10 (2018) 17240–17248. doi: 10.1021/acsami.8b04034
23. [23]
  X. Xing, I. Kimihiko, K. Yoshimi, Electrochim. Acta 261 (2018) 323e329.
24. [24]
  S. Ma, Y. Wu, J. Wang, et al., Nano Lett. 15 (2015) 8084–8090. doi: 10.1021/acs.nanolett.5b03510
25. [25]
  Z. Xie, X. Zhang, Z. Zhang, et al., Adv. Mater. 29 (2017) 1605891. doi: 10.1002/adma.201605891
26. [26]
  S. Bie, M. Du, W. He, et al., ACS Appl. Mater. Interfaces 11 (2019) 5146–5151. doi: 10.1021/acsami.8b20573
27. [27]
  Y. Eda, Y. Chihiro, Y. Keisuke, et al., Nano Lett. 13 (2013) 4679–4684. doi: 10.1021/nl4020952
28. [28]
  P. Xua, C. Chen, J. Zhu, et al., J. Electroanal. Chem. 842 (2019) 98–106. doi: 10.1016/j.jelechem.2019.04.055
29. [29]
  Z. Jian, P. Liu, F. Li, et al., Angew. Chem. Int. Ed. 53 (2014) 442–446. doi: 10.1002/anie.201307976
30. [30]
  R. Wang, X. Zhang, Y. Cai, et al., Nano Res. 12 (2019) 2543–2548. doi: 10.1007/s12274-019-2482-9
31. [31]
  S. -. M. Xu, Z. -. C. Ren, X. Liu, et al., Energy Storage Mater. 15 (2018) 291–298. doi: 10.1016/j.ensm.2018.05.015
32. [32]
  M. Chuai, J. Yang, M. Wang, et al., eScience 1 (2021) 178–185. doi: 10.1016/j.esci.2021.11.002
33. [33]
  S. Kundu, Y. Wang, W. Xia, et al., J. Phys. Chem. C 112 (2008) 16869–16878. doi: 10.1021/jp804413a
34. [34]
  X. Gao, J. Chen, X. Sun, et al., ACS Appl. Nano Mater. 3 (2020) 12269–12277. doi: 10.1021/acsanm.0c02739
35. [35]
  A. Huang, Y. Ma, J. Peng, et al., eScience 1 (2021) 141–162. doi: 10.1016/j.esci.2021.11.006
36. [36]
  J.G. Zhou, H.T. Fang, Y.F. Hu, et al., J. Phys. Chem. C 113 (2009) 10747–10750. doi: 10.1021/jp902871b
1. [1]
  Miaomiao Li , Mengwei Yuan , Xingzi Zheng , Kunyu Han , Genban Sun , Fujun Li , Huifeng Li . Highly polar CoP/Co₂P heterojunction composite as efficient cathode electrocatalyst for Li-air battery. Chinese Chemical Letters, 2024, 35(9): 109265-. doi: 10.1016/j.cclet.2023.109265
2. [2]
  Huyi Yu , Renshu Huang , Qian Liu , Xingfa Chen , Tianqi Yu , Haiquan Wang , Xincheng Liang , Shibin Yin . Te-doped Fe3O4 flower enabling low overpotential cycling of Li-CO2 batteries at high current density. Chinese Journal of Structural Chemistry, 2024, 43(3): 100253-100253. doi: 10.1016/j.cjsc.2024.100253
3. [3]
  Ruofan Yin , Zhaoxin Guo , Rui Liu , Xian-Sen Tao . Ultrafast synthesis of Na₃V₂(PO₄)₃ cathode for high performance sodium-ion batteries. Chinese Chemical Letters, 2025, 36(2): 109643-. doi: 10.1016/j.cclet.2024.109643
4. [4]
  Ruonan Yang , Jiajia Li , Dongmei Zhang , Xiuqi Zhang , Xia Li , Han Yu , Zhanhu Guo , Chuanxin Hou , Gang Lian , Feng Dang . Grain-refining Co_0.85Se@CNT cathode catalyst with promoted Li₂O₂ growth kinetics for lithium-oxygen batteries. Chinese Chemical Letters, 2024, 35(12): 109595-. doi: 10.1016/j.cclet.2024.109595
5. [5]
  Guangchang Yang , Shenglong Yang , Jinlian Yu , Yishun Xie , Chunlei Tan , Feiyan Lai , Qianqian Jin , Hongqiang Wang , Xiaohui Zhang . Regulating local chemical environment in O3-type layered sodium oxides by dual-site Mg²⁺/B³⁺ substitution achieves durable and high-rate cathode. Chinese Chemical Letters, 2024, 35(9): 109722-. doi: 10.1016/j.cclet.2024.109722
6. [6]
  Hengyi ZHU , Liyun JU , Haoyue ZHANG , Jiaxin DU , Yutong XIE , Li SONG , Yachao JIN , Mingdao ZHANG . Efficient regeneration of waste LiNi_0.5Co_0.2Mn_0.3O₂ cathode toward high-performance Li-ion battery. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 625-638. doi: 10.11862/CJIC.20240358
7. [7]
  Jiayu Bai , Songjie Hu , Lirong Feng , Xinhui Jin , Dong Wang , Kai Zhang , Xiaohui Guo . Manganese vanadium oxide composite as a cathode for high-performance aqueous zinc-ion batteries. Chinese Chemical Letters, 2024, 35(9): 109326-. doi: 10.1016/j.cclet.2023.109326
8. [8]
  Tao Long , Peng Chen , Bin Feng , Caili Yang , Kairong Wang , Yulei Wang , Can Chen , Yaping Wang , Ruotong Li , Meng Wu , Minhuan Lan , Wei Kong Pang , Jian-Fang Wu , Yuan-Li Ding . Reinforced concrete-like Na_3.5V_1.5Mn_0.5(PO₄)₃@graphene hybrids with hierarchical porosity as durable and high-rate sodium-ion battery cathode. Chinese Chemical Letters, 2024, 35(4): 109267-. doi: 10.1016/j.cclet.2023.109267
9. [9]
  Bin Feng , Tao Long , Ruotong Li , Yuan-Li Ding . Rationally constructing metallic Sn-ZnO heterostructure via in-situ Mn doping for high-rate Na-ion batteries. Chinese Chemical Letters, 2025, 36(2): 110273-. doi: 10.1016/j.cclet.2024.110273
10. [10]
  Pingping HAO , Fangfang LI , Yawen WANG , Houfen LI , Xiao ZHANG , Rui LI , Lei WANG , Jianxin LIU . Hydrogen production performance of the non-platinum-based MoS₂/CuS cathode in microbial electrolytic cells. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1811-1824. doi: 10.11862/CJIC.20240054
11. [11]
  Tsegaye Tadesse Tsega , Jiantao Zai , Chin Wei Lai , Xin-Hao Li , Xuefeng Qian . Earth-abundant CuFeS2 nanocrystals@graphite felt electrode for high performance aqueous polysulfide/iodide redox flow batteries. Chinese Journal of Structural Chemistry, 2024, 43(1): 100192-100192. doi: 10.1016/j.cjsc.2023.100192
12. [12]
  Xingxing Jiang , Yuxin Zhao , Yan Kong , Jianju Sun , Shangzhao Feng , Xin Lu , Qi Hu , Hengpan Yang , Chuanxin He . Support effect and confinement effect of porous carbon loaded tin dioxide nanoparticles in high-performance CO₂ electroreduction towards formate. Chinese Chemical Letters, 2025, 36(1): 109555-. doi: 10.1016/j.cclet.2024.109555
13. [13]
  Long Li , Kang Yang , Chenpeng Xi , Mengchao Li , Borong Li , Gui Xu , Yuanbin Xiao , Xiancai Cui , Zhiliang Liu , Lingyun Li , Yan Yu , Chengkai Yang . Highly-chlorinated inert and robust interphase without mineralization of oxide enhancing high-rate Li metal batteries. Chinese Chemical Letters, 2024, 35(6): 108814-. doi: 10.1016/j.cclet.2023.108814
14. [14]
  Xinpin Pan , Yongjian Cui , Zhe Wang , Bowen Li , Hailong Wang , Jian Hao , Feng Li , Jing Li . Robust chemo-mechanical stability of additives-free SiO₂ anode realized by honeycomb nanolattice for high performance Li-ion batteries. Chinese Chemical Letters, 2024, 35(10): 109567-. doi: 10.1016/j.cclet.2024.109567
15. [15]
  Jie Zhou , Chuanxiang Zhang , Changchun Hu , Shuo Li , Yuan Liu , Zhu Chen , Song Li , Hui Chen , Rokayya Sami , Yan Deng . Electrochemical aptasensor based on black phosphorus-porous graphene nanocomposites for high-performance detection of Hg²⁺. Chinese Chemical Letters, 2024, 35(11): 109561-. doi: 10.1016/j.cclet.2024.109561
16. [16]
  Min LUO , Xiaonan WANG , Yaqin ZHANG , Tian PANG , Fuzhi LI , Pu SHI . Porous spherical MnCo₂S₄ as high-performance electrode material for hybrid supercapacitors. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 413-424. doi: 10.11862/CJIC.20240205
17. [17]
  Yaoyin Lou , Xiaoyang Jerry Huang , Kuang-Min Zhao , Mark J. Douthwaite , Tingting Fan , Fa Lu , Ouardia Akdim , Na Tian , Shigang Sun , Graham J. Hutchings . Stable core-shell Janus BiAg bimetallic catalyst for CO₂ electrolysis into formate. Chinese Chemical Letters, 2025, 36(3): 110300-. doi: 10.1016/j.cclet.2024.110300
18. [18]
  Xiaoxing Ji , Xiaojuan Li , Chenggang Wang , Gang Zhao , Hongxia Bu , Xijin Xu . Ni_xB/rGO as the cathode for high-performance aqueous alkaline zinc-based battery. Chinese Chemical Letters, 2024, 35(10): 109388-. doi: 10.1016/j.cclet.2023.109388
19. [19]
  Yue Wang , Caixia Xu , Xingtao Tian , Siyu Wang , Yan Zhao . Challenges and Modification Strategies of High-Voltage Cathode Materials for Li-ion Batteries. Chinese Journal of Structural Chemistry, 2023, 42(10): 100167-100167. doi: 10.1016/j.cjsc.2023.100167
20. [20]
  Shengyu Zhao , Xuan Yu , Yufeng Zhao . A water-stable high-voltage P3-type cathode for sodium-ion batteries. Chinese Chemical Letters, 2024, 35(9): 109933-. doi: 10.1016/j.cclet.2024.109933

Get Citation

PDF

XML

Metrics

PDF Downloads(9)
Abstract views(878)
HTML views(120)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Ultrafine RuO2 nanoparticles/MWCNTs cathodes for rechargeable Na-CO2 batteries with accelerated kinetics of Na2CO3 decomposition

Metrics

通讯作者: 陈斌, bchen63@163.com

Ultrafine RuO₂ nanoparticles/MWCNTs cathodes for rechargeable Na-CO₂ batteries with accelerated kinetics of Na₂CO₃ decomposition