Citation: Hongmei Ai, Hongyuan Yang, Qing Liu, Guoming Zhao, Jing Yang, Fangna Gu. ZrO₂-modified Ni/LaAl₁₁O₁₈ catalyst for CO methanation:Effects of catalyst structure on catalytic performance[J]. Chinese Journal of Catalysis, ;2018, 39(2): 297-308. doi: 10.1016/S1872-2067(17)62995-4 shu

ZrO₂-modified Ni/LaAl₁₁O₁₈ catalyst for CO methanation:Effects of catalyst structure on catalytic performance

Hongmei Ai ^a,b, ,
Hongyuan Yang ^a ,
Qing Liu ^a ,
Guoming Zhao ^a ,
Jing Yang ^a ,
Fangna Gu ^c

a Key Laboratory of Low Carbon Energy and Chemical Engineering, College of Chemical and Environmental Engineering, Shandong University of Science and Technology, Qingdao 266590, Shandong, China;
b Assets Management Division, Shandong University of Science and Technology, Qingdao 266590, Shandong, China;
c State Key Laboratory of Multiphase Complex Systems, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, China

Received Date: 26 September 2017
Revised Date: 11 December 2017

Fund Project: This work was supported by the National Natural Science Foundation of China (21606146), Natural Science Foundation of Shandong Province (ZR2016BB17, 2016ZRB01037), Scientific Research Foundation of Shandong University of Science and Technology for Recruited Talents (2016RCJJ005, 2016RCJJ006), Government Sponsored Visiting Scholar Foundation of Shandong University of Science and Technology (2016), Qingdao Postdoctoral Applied Research Project (2015202), and China National Coal Association Science and Technology Research Program (MTKJ2016-266).

We report Ni/LaHA@ZrO₂ catalysts prepared by a facile modified successive adsorption and reaction method for CO methanation. N₂ adsorption, X-ray diffraction, transmission electron microscopy, scanning electron microscopy, thermogravimetric analysis, H₂ temperature-programmed reduction, H₂ temperature-programmed desorption, X-ray photoelectron spectroscopy, thermogravimetric analysis, and inductively coupled plasma atomic emission spectrometry were used to characterize the samples. The results indicated that the ZrO₂ nanoparticles were distributed over the surface of the Ni/LaHA@ZrO₂ catalyst and even partially covered some Ni particles, resulting in the coating exerting a confinement effect. The excess ZrO₂ had an adverse effect on the enhancement of CO conversion because of the coverage of the surface Ni particles; however, the Ni/LaHA@ZrO₂ catalyst displayed much higher CH₄ selectivity than Ni/LaHA because of the activation of the byproduct CO₂ molecules by ZrO₂ species. Therefore, even though 20Ni/LaHA@ZrO₂-5 exhibited similar CO conversion as 20Ni/LaHA, the use of the former resulted in a higher CH₄ yield than the use of the latter. A 107-h-lifetime test revealed that the Ni/LaHA@ZrO₂ catalyst was highly stable with superior anti-sintering and anti-coking properties because of its coating structure and the promoter effect of ZrO₂.
- Lanthanum hexaaluminate,
- ZrO₂,
- Nickel catalyst,
- Coating structure,
- CO methanation
1. [1]
2. [2]
3. [3]
4. [4]
5. [5]
6. [6]
7. [7]
8. [8]
9. [9]
10. [10]
11. [11]
12. [12]
13. [13]
14. [14]
15. [15]
16. [16]
17. [17]
18. [18]
19. [19]
20. [20]
21. [21]
22. [22]
23. [23]
24. [24]
25. [25]
26. [26]
27. [27]
28. [28]
29. [29]
30. [30]
31. [31]
32. [32]
33. [33]
34. [34]
35. [35]
36. [36]
37. [37]
38. [38]
39. [39]
40. [40]
41. [41]
42. [42]
43. [43]
44. [44]
45. [45]
46. [46]
47. [47]
48. [48]
49. [49]
50. [50]
51. [51]
52. [52]
53. [53]
54. [54]
55. [55]
1. [1]
  Wen YANG , Didi WANG , Ziyi HUANG , Yaping ZHOU , Yanyan FENG . La promoted hydrotalcite derived Ni-based catalysts: In situ preparation and CO₂ methanation performance. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 561-570. doi: 10.11862/CJIC.20230276
2. [2]
  Lina Guo , Ruizhe Li , Chuang Sun , Xiaoli Luo , Yiqiu Shi , Hong Yuan , Shuxin Ouyang , Tierui Zhang . Effect of Interlayer Anions in Layered Double Hydroxides on the Photothermocatalytic CO₂ Methanation of Derived Ni-Al₂O₃ Catalysts. Acta Physico-Chimica Sinica, 2025, 41(1): 100002-0. doi: 10.3866/PKU.WHXB202309002
3. [3]
  Junke LIU , Kungui ZHENG , Wenjing SUN , Gaoyang BAI , Guodong BAI , Zuwei YIN , Yao ZHOU , Juntao LI . Preparation of modified high-nickel layered cathode with LiAlO₂/cyclopolyacrylonitrile dual-functional coating. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1461-1473. doi: 10.11862/CJIC.20240189
4. [4]
  Kun WANG , Wenrui LIU , Peng JIANG , Yuhang SONG , Lihua CHEN , Zhao DENG . Hierarchical hollow structured BiOBr-Pt catalysts for photocatalytic CO₂ reduction. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1270-1278. doi: 10.11862/CJIC.20240037
5. [5]
  Yixuan Wang , Canhui Zhang , Xingkun Wang , Jiarui Duan , Kecheng Tong , Shuixing Dai , Lei Chu , Minghua Huang . Engineering Carbon-Chainmail-Shell Coated Co₉Se₈ Nanoparticles as Efficient and Durable Catalysts in Seawater-Based Zn-Air Batteries. Acta Physico-Chimica Sinica, 2024, 40(6): 2305004-0. doi: 10.3866/PKU.WHXB202305004
6. [6]
  Wenlong Wang , Wentao Hao , Lang He , Jia Qiao , Ning Li , Chaoqiu Chen , Yong Qin . Bandgap and adsorption engineering of carbon dots/TiO₂ S-scheme heterojunctions for enhanced photocatalytic CO₂ methanation. Acta Physico-Chimica Sinica, 2025, 41(9): 100116-0. doi: 10.1016/j.actphy.2025.100116
7. [7]
  Bo YANG , Gongxuan LÜ , Jiantai MA . Corrosion inhibition of nickel-cobalt-phosphide in water by coating TiO₂ layer. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 365-384. doi: 10.11862/CJIC.20240063
8. [8]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
9. [9]
  Xueting Feng , Ziang Shang , Rong Qin , Yunhu Han . Advances in Single-Atom Catalysts for Electrocatalytic CO₂ Reduction. Acta Physico-Chimica Sinica, 2024, 40(4): 2305005-0. doi: 10.3866/PKU.WHXB202305005
10. [10]
  Xinpeng LIU , Liuyang ZHAO , Hongyi LI , Yatu CHEN , Aimin WU , Aikui LI , Hao HUANG . Ga₂O₃ coated modification and electrochemical performance of Li_1.2Mn_0.54Ni_0.13Co_0.13O₂ cathode material. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1105-1113. doi: 10.11862/CJIC.20230488
11. [11]
  Shiqi Peng , Yongfang Rao , Tan Li , Yufei Zhang , Jun-ji Cao , Shuncheng Lee , Yu Huang . Regulating the electronic structure of Ir single atoms by ZrO₂ nanoparticles for enhanced catalytic oxidation of formaldehyde at room temperature. Chinese Chemical Letters, 2024, 35(7): 109219-. doi: 10.1016/j.cclet.2023.109219
12. [12]
  Fangxuan Liu , Ziyan Liu , Guowei Zhou , Tingting Gao , Wenyu Liu , Bin Sun . 中空结构光催化剂. Acta Physico-Chimica Sinica, 2025, 41(7): 100071-0. doi: 10.1016/j.actphy.2025.100071
13. [13]
  Dong Xiang , Kunzhen Li , Kanghua Miao , Ran Long , Yujie Xiong , Xiongwu Kang . Amine-Functionalized Copper Catalysts: Hydrogen Bonding Mediated Electrochemical CO₂ Reduction to C₂ Products and Superior Rechargeable Zn-CO₂ Battery Performance. Acta Physico-Chimica Sinica, 2024, 40(8): 2308027-0. doi: 10.3866/PKU.WHXB202308027
14. [14]
  Qing Li , Guangxun Zhang , Yuxia Xu , Yangyang Sun , Huan Pang . P-Regulated Hierarchical Structure Ni₂P Assemblies toward Efficient Electrochemical Urea Oxidation. Acta Physico-Chimica Sinica, 2024, 40(9): 2308045-0. doi: 10.3866/PKU.WHXB202308045
15. [15]
  Feifei Yang , Wei Zhou , Chaoran Yang , Tianyu Zhang , Yanqiang Huang . Enhanced Methanol Selectivity in CO₂ Hydrogenation by Decoration of K on MoS₂ Catalyst. Acta Physico-Chimica Sinica, 2024, 40(7): 2308017-0. doi: 10.3866/PKU.WHXB202308017
16. [16]
  Yulian Hu , Xin Zhou , Xiaojun Han . A Virtual Simulation Experiment on the Design and Property Analysis of CO₂ Reduction Photocatalyst. University Chemistry, 2025, 40(3): 30-35. doi: 10.12461/PKU.DXHX202403088
17. [17]
  Hongyi LI , Aimin WU , Liuyang ZHAO , Xinpeng LIU , Fengqin CHEN , Aikui LI , Hao HUANG . Effect of Y(PO₃)₃ double-coating modification on the electrochemical properties of Li[Ni_0.8Co_0.15Al_0.05]O₂. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1320-1328. doi: 10.11862/CJIC.20230480
18. [18]
  Ruolin CHENG , Haoran WANG , Jing REN , Yingying MA , Huagen LIANG . Efficient photocatalytic CO₂ cycloaddition over W₁₈O₄₉/NH₂-UiO-66 composite catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 523-532. doi: 10.11862/CJIC.20230349
19. [19]
  Yi YANG , Shuang WANG , Wendan WANG , Limiao CHEN . Photocatalytic CO₂ reduction performance of Z-scheme Ag-Cu₂O/BiVO₄ photocatalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 895-906. doi: 10.11862/CJIC.20230434
20. [20]
  Haoyu Sun , Dun Li , Yuanyuan Min , Yingying Wang , Yanyun Ma , Yiqun Zheng , Hongwen Huang . Hierarchical Palladium-Copper-Silver Porous Nanoflowers as Efficient Electrocatalysts for CO₂ Reduction to C₂₊ Products. Acta Physico-Chimica Sinica, 2024, 40(6): 2307007-0. doi: 10.3866/PKU.WHXB202307007

Get Citation

PDF

XML

Metrics

PDF Downloads(1)
Abstract views(683)
HTML views(44)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

ZrO2-modified Ni/LaAl11O18 catalyst for CO methanation:Effects of catalyst structure on catalytic performance

Metrics

通讯作者: 陈斌, bchen63@163.com

ZrO₂-modified Ni/LaAl₁₁O₁₈ catalyst for CO methanation:Effects of catalyst structure on catalytic performance