Citation: Longxing Hu, Fan Yang, Lianpei Zou, Hang Yuan, Xing Hu. CoFe/SBA-15 catalyst coupled with peroxymonosulfate for heterogeneous catalytic degradation of rhodamine B in water[J]. Chinese Journal of Catalysis, ;2015, 36(10): 1785-1797. doi: 10.1016/S1872-2067(15)60939-1 shu

CoFe/SBA-15 catalyst coupled with peroxymonosulfate for heterogeneous catalytic degradation of rhodamine B in water

1.
School of Environmental and Chemical Engineering, Shanghai University, Shanghai 2000444, China

Corresponding author: Longxing Hu,
Received Date: 18 May 2015
Available Online: 17 June 2015
Fund Project: 大学创新研究团队项目(IRT 13078). (IRT 13078)

CoFe/SBA-15 catalysts were prepared by simultaneous incipient wetness impregnation using Co(NO₃)₂·6H₂O and Fe(NO₃)₃·9H₂O as the precursors and SBA-15 as the support. The catalysts were used to activate generation of sulfate radicals from peroxymonosulfate (PMS) for rhodamine B (RhB) dye degradation in aqueous solutions. The catalyst was characterized using X-ray diffraction, N₂ adsorption-desorption, scanning electron microscopy and energy-dispersive X-ray spectroscopy, transmission electron microscopy, and vibrating sample magnetometry. The effects of the Co and Fe loadings and calcination temperature on the catalytic performance, catalyst reusability, and kinetics and mechanism of catalytic oxidative degradation of RhB in the presence of CoFe/SBA-15 and PMS were investigated. The results show that the predominant Co-Fe oxide loaded on the support was the composite CoFe₂O₄, which provided the active catalytic sites, and was present in the SBA-15 matrix. The surface area, pore volume, and mean pore diameter of 10Co9.5Fe/SBA-15-700 were 506.1 m²/g, 0.669 cm³/g, and 7.4 nm, respectively, lower than those of SBA-15. 10Co9.5Fe/SBA-15-700 consisted of rod-like aggregates with diameters greater than 0.25 μm. It had a magnetic intensity of 8.3 emu/g; therefore, magnetic separation was feasible. 10Co9.5Fe/SBA-15-700 showed good catalytic activity and stability, with a RhB degradation rate higher than 96% and Co leaching lower than 32.4 μg/L. The catalytic oxidative degradation of RhB in the presence of FeCo/SBA-15 and PMS obeyed first-order kinetics, and the degradation rate increased with increasing CoFe/SBA-15 and PMS dosages and with decreasing initial reactant concentrations. Quenching tests showed that sulfate radicals played a dominant role in RhB catalysis. CoFe/SBA-15 maintained high catalytic activity and good stability during 10 recycling runs, with a RhB degradation rate greater than 84%, Co and Fe leaching for each run lower than 72.1 and 35 μg/L, respectively. CoFe/SBA-15 is an efficient catalyst for PMS oxidation, and has potential applications in the removal of refractory organics such as RhB in water.
- Cobalt,
- Iron,
- SBA-15,
- Peroxymonosulphate,
- Rhodamine B degradation,
- Advanced oxidation technologies,
- Sulfate radical
1. [1]
  [1] Malato S, Blanco J, Richter C, Braun B, Maldonado M I. Appl Catal B, 1998, 17: 347
2. [2]
  [2] Chamarro E, Marco A, Esplugas S. Water Res, 2001, 35: 1047
3. [3]
  [3] Anipsitakis G P, Dionysiou D D. Environ Sci Technol, 2003, 37: 4790
4. [4]
  [4] Cheng M M, Ma W H, Li J, Huang Y P, Zhao J C, Wen Y X, Xu Y M. Environ Sci Technol, 2004, 38: 1569
5. [5]
  [5] Chen X Y, Chen J W, Qiao X L, Wang D G, Cai X Y. Appl Catal B, 2008, 80: 116
6. [6]
  [6] Neta P, Huie R E, Ross A B. J Phys Chem Ref Data, 1988, 17: 1027
7. [7]
  [7] Anipsitakis G P, Dionysiou D D. Environ Sci Techol, 2004, 38: 3705
8. [8]
  [8] Anipsitakis G P, Stathatos E, Dionysiou D D. J Phys Chem B, 2005, 109: 13052
9. [9]
  [9] Chan K H, Chu W. Water Res, 2009, 43: 2513
10. [10]
  [10] Yang Q J, Choi H, Al-Abed S R, Dionysiou D D. Appl Catal B, 2009, 88: 462
11. [11]
  [11] Ding Y B, Zhu L H, Huang A Z, Zhao X R, Zhang X Y, Tang H Q. Catal Sci Technol, 2012, 2: 1977
12. [12]
  [12] Su S N, Guo W L, Leng Y Q, Yi C L, Ma Z N. J Hazard Mater, 2013, 244-245: 736
13. [13]
  [13] Yang Q J, Choi H, Dionysiou D D. Appl Catal B, 2007, 74: 170
14. [14]
  [14] Yang Q J, Choi H, Chen Y J, Dionysiou D D. Appl Catal B, 2008, 77: 300
15. [15]
  [15] Zhang W, Tay H L, Lim S S, Wang Y S, Zhong Z Y, Xu R. Appl Catal B, 2010, 95: 93
16. [16]
  [16] Shukla P, Sun H Q, Wang S B, Ang H M, Tadé M O. Sep Purif Technol, 2011, 77: 230
17. [17]
  [17] Liang H W, Ting Y Y, Sun H Q, Ang H M, Tadé M O. J Colloid Interf Sci, 2012, 372: 58
18. [18]
  [18] Zhu Y Q, Chen S, Quan X, Zhang Y B. RSC Adv, 2013, 3: 520
19. [19]
  [19] Shukla P R, Wang S B, Sun H Q, Ang H M, Tadé M. Appl Catal B, 2010, 100: 529
20. [20]
  [20] Hardjono Y, Sun H Q, Tian H Y, Buckley C E, Wang S B. Chem Eng J, 2011, 174: 376
21. [21]
  [21] Sun H Q, Tian H Y, Hardjono Y, Buckley C E, Wang S B. Catal Toady, 2012, 186: 63
22. [22]
  [22] Yao Y J, Yang Z H, Zhang D W, Peng W C, Sun H Q, Wang S B. Ind Eng Chem Res, 2012, 51: 6044
23. [23]
  [23] Shi P H, Su R J, Wan F Z, Zhu M C, Li D X, Xu S H. Appl Catal B, 2012, 123-124: 265
24. [24]
  [24] Shi P H, Su R J, Zhu S B, Zhu M C, Li D X, Xu S H. J Hazard Mater, 2012, 229-230: 331
25. [25]
  [25] Shukla P, Wang S B, Singh K, Ang H M, Tadé M O. Appl Catal B, 2010, 99: 163
26. [26]
  [26] Chu W, Choy W K, Kwan C Y. J Agr Food Chem, 2007, 55: 5708
27. [27]
  [27] Saputra E, Muhammad S, Sun H Q, Ang H M, Tadé M O, Wang S B. Catal Toady, 2012, 190: 68
28. [28]
  [28] Hu L X, Yang X P, Dang S T. Appl Catal B, 2011, 102: 19
29. [29]
  [29] Shukla P, Sun H Q, Wang S B, Ang H M, Tadé M O. Catal Toady, 2011, 175: 380
30. [30]
  [30] Hu L X, Yang F, Lu W C, Hao Y, Yuan H. Appl Catal B, 2013, 134-135: 7
31. [31]
  [31] Liang H W, Sun H Q, Patel A, Shukla P, Zhu Z H, Wang S B. Appl Catal B, 2012, 127: 330
32. [32]
  [32] Qi F, Chu W, Xu B B. Appl Catal B, 2013, 134-135: 324
33. [33]
  [33] Zhao D Y, Huo Q S, Feng J L, Chmelka B F, Stucky G D. J Am Chem Soc, 1998, 120: 6024
34. [34]
  [34] Jun S, Joo S H, Ryoo R, Kruk M, Jaroniec M, Liu Z, Ohsuna T, Terasaki O. J Am Chem Soc, 2000, 122: 10712
35. [35]
  [35] Wang Y R, Chu W. Ind Eng Chem Res, 2011, 50: 8734
36. [36]
  [36] Martí nez-de la Cruz A, García Pé rez U M. Mater Res Bull, 2010, 45: 135
37. [37]
  [37] Hou M F, Liao L, Zhang W D, Tang X Y, Wan H F, Yin G C. Chemosphere, 2011, 83: 1279
38. [38]
  [38] Merouani S, Hamdaoui O, Saoudi F, Chiha M. Chem Eng J, 2010, 158: 550
39. [39]
  [39] Bai C P, Xiong X F, Gong W Q, Feng D X, Xian M, Ge Z X, Xu N. Desalination, 2011, 278: 84
40. [40]
  [40] Du L, Wu J, Hu C W, Electrochim Acta, 2012, 68: 69
41. [41]
  [41] Marler B, Oberhagemann U, Vortmann S, Gies H. Microporous Mater, 1996, 6: 375
42. [42]
  [42] Kim S J, Lee S W, An S Y, Kim C S. J Magn Magn Mater, 2000, 215-216: 210
43. [43]
  [43] Melero J A, Calleja G, Martínez F, Molina R, Pariente M I. Chem Eng J, 2007, 131: 245
44. [44]
  [44] Liang H W, Sun H Q, Patel A, Shukla P, Zhu Z H, Wang S B. Appl Catal B, 2012, 127: 330
45. [45]
  [45] Ramirez J H, Maldonado-Hódar F J, Pérez-Cadenas A F, Moreno-Castilla C, Costa C A, Madeira L M. Appl Catal B, 2007, 75: 312
46. [46]
  [46] Anipsitakis G P, Dionysiou D D, Gonzalez M A. Environ Sci Technol, 2006, 40: 1000
47. [47]
  [47] Wu T X, Liu G M, Zhao J C, Hidaka H, Serpone N. J Phys Chem B, 1998, 102: 5845
48. [48]
  [48] He Z, Yang S G, Ju Y M, Sun C. J Environ Sci, 2009, 21: 268
1. [1]
  Xinxin YU , Yongxing LIU , Xiaohong YI , Miao CHANG , Fei WANG , Peng WANG , Chongchen WANG . Photocatalytic peroxydisulfate activation for degrading organic pollutants over the zero-valent iron recovered from subway tunnels. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 864-876. doi: 10.11862/CJIC.20240438
2. [2]
  Xia ZHANG , Yushi BAI , Xi CHANG , Han ZHANG , Haoyu ZHANG , Liman PENG , Shushu HUANG . Preparation and photocatalytic degradation performance of rhodamine B of BiOCl/polyaniline. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 913-922. doi: 10.11862/CJIC.20240255
3. [3]
  Jianjun LI , Mingjie REN , Lili ZHANG , Lingling ZENG , Huiling WANG , Xiangwu MENG . UV-assisted degradation of tetracycline hydrochloride by MnFe₂O₄@activated carbon activated persulfate. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1869-1880. doi: 10.11862/CJIC.20240187
4. [4]
  Xinhao Yan , Guoliang Hu , Ruixi Chen , Hongyu Liu , Qizhi Yao , Jiao Li , Lingling Li . Polyethylene Glycol-Ammonium Sulfate-Nitroso R Salt System for the Separation of Cobalt (II). University Chemistry, 2024, 39(6): 287-294. doi: 10.3866/PKU.DXHX202310073
5. [5]
  Yuan GAO , Yiming LIU , Chunhui WANG , Zhe HAN , Chaoyue FAN , Jie QIU . A hexanuclear cerium oxo cluster stabilized by furoate: Synthesis, structure, and remarkable ability to scavenge hydroxyl radicals. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 491-498. doi: 10.11862/CJIC.20240271
6. [6]
  Yan LIU , Jiaxin GUO , Song YANG , Shixian XU , Yanyan YANG , Zhongliang YU , Xiaogang HAO . Exclusionary recovery of phosphate anions with low concentration from wastewater using a CoNi-layered double hydroxide/graphene electronically controlled separation film. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1775-1783. doi: 10.11862/CJIC.20240043
7. [7]
  Guang Huang , Lei Li , Dingyi Zhang , Xingze Wang , Yugai Huang , Wenhui Liang , Zhifen Guo , Wenmei Jiao . Cobalt’s Valor, Nickel’s Foe: A Comprehensive Chemical Experiment Utilizing a Cobalt-based Imidazolate Framework for Nickel Ion Removal. University Chemistry, 2024, 39(8): 174-183. doi: 10.3866/PKU.DXHX202311051
8. [8]
  .
  CCS Chemistry | 超分子活化底物为自由基促进高效选择性光催化氧化
  . CCS Chemistry, 2025, 7(10.31635/ccschem.025.202405229): -.
9. [9]
  Mi Wen , Baoshuo Jia , Yongqi Chai , Tong Wang , Jianbo Liu , Hailong Wu . Improvement of Fluorescence Quantitative Analysis Experiment: Simultaneous Determination of Rhodamine 6G and Rhodamine 123 in Food Using Chemometrics-Assisted Three-Dimensional Fluorescence Method. University Chemistry, 2025, 40(4): 390-398. doi: 10.12461/PKU.DXHX202405147
10. [10]
  Yuyao Wang , Zhitao Cao , Zeyu Du , Xinxin Cao , Shuquan Liang . Research Progress of Iron-based Polyanionic Cathode Materials for Sodium-Ion Batteries. Acta Physico-Chimica Sinica, 2025, 41(4): 100035-. doi: 10.3866/PKU.WHXB202406014
11. [11]
  Zhicheng JU , Wenxuan FU , Baoyan WANG , Ao LUO , Jiangmin JIANG , Yueli SHI , Yongli CUI . MOF-derived nickel-cobalt bimetallic sulfide microspheres coated by carbon: Preparation and long cycling performance for sodium storage. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 661-674. doi: 10.11862/CJIC.20240363
12. [12]
  Lei Shi . Nucleophilicity and Electrophilicity of Radicals. University Chemistry, 2024, 39(11): 131-135. doi: 10.3866/PKU.DXHX202402018
13. [13]
  Min LIU , Huapeng RUAN , Zhongtao FENG , Xue DONG , Haiyan CUI , Xinping WANG . Neutral boron-containing radical dimers. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 123-130. doi: 10.11862/CJIC.20240362
14. [14]
  Xin Zhou , Zhi Zhang , Yun Yang , Shuijin Yang . A Study on the Enhancement of Photocatalytic Performance in C/Bi/Bi₂MoO₆ Composites by Ferroelectric Polarization: A Recommended Comprehensive Chemical Experiment. University Chemistry, 2024, 39(4): 296-304. doi: 10.3866/PKU.DXHX202310008
15. [15]
  Pingping LU , Shuguang ZHANG , Peipei ZHANG , Aiyun NI . Preparation of zinc sulfate open frameworks based probe materials and detection of Pb²⁺ and Fe³⁺ ions. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 959-968. doi: 10.11862/CJIC.20240411
16. [16]
  Jiajia Li , Xiangyu Zhang , Zhihan Yuan , Zhengyang Qian , Jian Zhu . 3D Printing Based on Photo-Induced Reversible Addition-Fragmentation Chain Transfer Polymerization. University Chemistry, 2024, 39(5): 11-19. doi: 10.3866/PKU.DXHX202309073
17. [17]
  Zijian Zhao , Yanxin Shi , Shicheng Li , Wenhong Ruan , Fang Zhu , Jijun Jiang . A New Exploration of the Preparation of Polyacrylic Acid by Free Radical Polymerization Based on the Concept of Green Chemistry. University Chemistry, 2024, 39(5): 315-324. doi: 10.3866/PKU.DXHX202311094
18. [18]
  Jingke LIU , Jia CHEN , Yingchao HAN . Nano hydroxyapatite stable suspension system: Preparation and cobalt adsorption performance. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1763-1774. doi: 10.11862/CJIC.20240060
19. [19]
  Bo YANG , Gongxuan LÜ , Jiantai MA . Corrosion inhibition of nickel-cobalt-phosphide in water by coating TiO₂ layer. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 365-384. doi: 10.11862/CJIC.20240063
20. [20]
  Zhongyan Cao , Shengnan Jin , Yuxia Wang , Yiyi Chen , Xianqiang Kong , Yuanqing Xu . Advances in Highly Selective Reactions Involving Phenol Derivatives as Aryl Radical Precursors. University Chemistry, 2025, 40(4): 245-252. doi: 10.12461/PKU.DXHX202405186

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(659)
HTML views(98)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142