Citation: ZHANG E-song, YU Jie, WANG Le-le, WANG Ben, SUN Lu-shi. Deactivation and regeneration of commercial SCR catalysts used in coal fired power plant[J]. Journal of Fuel Chemistry and Technology, ;2018, 46(10): 1249-1256. shu

Deactivation and regeneration of commercial SCR catalysts used in coal fired power plant

ZHANG E-song ¹ ,
YU Jie ^1,, ,
WANG Le-le ^1,2 ,
WANG Ben ¹ ,
SUN Lu-shi ¹

1.
State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology, Wuhan 430074, China
2.
Xi'an Thermal Power Research Institute Co. Ltd., Suzhou branch, Suzhou 215153, China

Corresponding author: YU Jie, yujie@hust.edu.cn
Received Date: 12 June 2018
Revised Date: 23 July 2018

Figures(11)

The activity of SCR catalyst used in a coal-fired power plant for 24000 h was tested. With the help of XRD, BET, XRF, FT-IR and XPS, it is found that the catalyst has some problems such as micropore and mesopore plugging and the oxidation of active substances, which leads to the deactivation of the catalyst. Water washing and H₂SO₄ washing were used to remove plugs in the pores of the catalyst. The result shows that water washing can resume part of vanadium species and H₂SO₄ washing can renew the active sites on the surface of catalyst and uniformly load the sulfur species which can increase the acidity of active site. The SO₂ sulphation treatment was performed on the catalyst after water washing. It is indicated that the Brønsted acid and the Lewis acid sites have higher strength and the Lewis acid has higher density than that by H₂SO₄ washing. After the regeneration treatment, H₂SO₄ washed catalyst activity is restored to the level of fresh catalyst above 250 ℃. And the activity of SO₂ sulphation catalyst at 450 ℃ reaches 104.6% of the fresh catalyst activity at 380 ℃.
- SCR catalysts,
- denitrification,
- deactivation,
- regeneration,
- sulphation
1. [1]
  Ministry of environmental protection of People's Republic of China. China Environmental Statistics Annual Report. 2015[M]. China Environmental Press, 2016.
2. [2]
  XIE X, LU J, HUMS E, HUANG Q, LU Z. Study on the deactivation of V₂O₅-WO₃/TiO₂ selective catalytic reduction catalysts through transient kinetics[J]. Energy Fuels, 2015,29(6):3890-3896. doi: 10.1021/acs.energyfuels.5b01034
3. [3]
  TANG Hao, LU Qiang, YANG Jiang-yi, LI Hui, LI Wen-yan, YANG Yong-ping. Research on recycling and characterization analysis of the waste SCR catalyst[J]. J Fuel Chem Technol, 2018,46(2):233-242. doi: 10.3969/j.issn.0253-2409.2018.02.014
4. [4]
  WU Wei-hong, WU Hua, LUO Jia, JIANG Xiao. Research progress on the regeneration of SCR catalysts for flue gas denitrification[J]. Appl Chem Ind, 2013,42(7):1304-1307.
5. [5]
  YU Yan-ke, HE Chi, CHEN Jin-sheng, MENG Xiao-ran. Deactivation mechanism of de NO_x catalyst (V₂O₅-WO₃/TiO₂) used in coal fired power plant[J]. J Fuel Chem Technol, 2012,40(11):1359-1365. doi: 10.3969/j.issn.0253-2409.2012.11.013
6. [6]
  LEE J B, KIM S K, DONG W K, KIM K H, CHUN S N, HUR K B, SANG M J. Effect of H₂SO₄ concentration in washing solution on regeneration of commercial selective catalytic reduction catalyst[J]. Korean J Chem Eng, 2012,29(2):270-276. doi: 10.1007/s11814-011-0156-8
7. [7]
  LI Ru-bing, WU Yu-feng, ZHANG Qi-jun, CHEN Xi, LIU Bin. A comprehensive review of the regeneration and recovery of commercial SCR catalyst (V₂O₅-WO₃/TiO₂)[J]. Mod Chem Ind, 2017(3):29-33.
8. [8]
  LI J, TANG X, GAO F, YI H, ZHAO S. Studies on the calcium poisoning and regeneration of commercial De-NO_x SCR catalyst[J]. Chem Pap, 2017,71(10):1921-1928. doi: 10.1007/s11696-017-0186-8
9. [9]
  YU Xiao-wei, ZHOU Yu, LIU Shuai, SONG Chao. Reason analysis for deactivation of commercial SCR de-NO_x catalyst and its regeneration[J]. Therm Power Gener, 2014,43(2):109-113. doi: 10.3969/j.issn.1002-3364.2014.02.109
10. [10]
  GAO F, TANG X, YI H, ZHAO S, ZHANG T, LI D, MA D. The poisoning and regeneration effect of alkali metals deposed over commercial V₂O₅-WO₃/TiO₂ catalysts on SCR of NO by NH₃[J]. Sci Bull, 2014,59(31)3966. doi: 10.1007/s11434-014-0496-y
11. [11]
  GAO Feng-yu, TANG Xiao-long, YI Hong-hong, ZHAO Shun-zheng, LI Dong, MA Ding, ZHANG Tong-tong. Sodium poisoning mechanism and regeneration of commercial De-NO_x SCR catalysts[J]. J Cent South Univ Technol, 2015,46(6):2382-2390.
12. [12]
  TANABE K, MISONO M, ONO Y, HATTORI H. New solid acids and bases:Their catalytic properties[J]. Stud Surf Sci Catal, 1989,51:1-365. doi: 10.1016/S0167-2991(08)61044-7
13. [13]
  LIETTI L, RAMIS G, BERTI F, TOLEDO G, ROBBA D, BUSCA G, FORZATTI P. Chemical, structural and mechanistic aspects on NO_x SCR over commercial and model oxide catalysts[J]. Catal Today, 1998,42(1/2):101-116.
14. [14]
  KHODAYARI R, ODENBRAND C U I. Regeneration of commercial TiO₂-V₂O₅-WO₃ SCR catalysts used in bio fuel plants[J]. Appl Catal B:Environ, 2001,30(1/2):87-99.
15. [15]
  SHEN Jia-quan, ZHANG Jian-hua, ZOU Yi-jin, YU Yan-ke, CHEN Jin-sheng, WANG Jin-xiu, JIANG Chang-shui. Mechanism of deactivation and regeneration for corrugated type SCR catalysts[J]. Electron Power Environ Protect, 2016(3):8-11. doi: 10.3969/j.issn.1674-8069.2016.03.003
16. [16]
  ZHANG Pei, WU Si-ming, FANG Tuo-tuo, CHEN Yan-ping, SHI Yao, HE Yi. Deactivation and regeneration of commercial SCR catalysts used in a 660 MW coal-fired power plant[J]. J Chem Eng Chin Univ, 2017,31(5):1186-1192. doi: 10.3969/j.issn.1003-9015.2017.05.023
17. [17]
  NICOSIA D, CZEKAJ I, KRÖCHER O. Chemical deactivation of V₂O₅/WO₃-TiO₂ SCR catalysts by additives and impurities from fuels, lubrication oils and urea solution:Part Ⅱ. Characterization study of the effect of alkali and alkaline earth metals[J]. Appl Catal B:Environ, 2008,77(3/4):228-236.
18. [18]
  ZHANG Dao-jun, MA Zi-ran, SUN Qi, XU Wen-qiang, LI Yong-long, WANG Bao-dong, ZHU Tao, LIN De-hai, JI Guang-hui, MA Jing. Formation mechanism, effects and prevention of NH₄HSO₄ formed on the surface of V₂O₅ based catalysts[J]. Chem Ind Eng Prog, 2018(7):2635-2643.
19. [19]
  KLING Å, ANDERSSON C, MYRINGER Å, ESKILSSON D, JÄRÅS S G. Alkali deactivation of high-dust SCR catalysts used for NO_x reduction exposed to flue gas from 100 MW-scale biofuel and peat fired boilers:Influence of flue gas composition[J]. Appl Catal B:Environ, 2007,69(3/4):240-251.
20. [20]
  LIU F, ASAKURA K, HE H, SHAN W, SHI X, ZHANG C. Influence of sulfation on iron titanate catalyst for the selective catalytic reduction of NO_x with NH₃[J]. Appl Catal B:Environ, 2011,103(3):369-377.
21. [21]
  SHANG X, HU G, CHI H, ZHAO J, ZHANG F, XU Y, ZHANG Y, LI J, CHEN J. Regeneration of full-scale commercial honeycomb monolith catalyst (V₂O₅-WO₃/TiO₂) used in coal-fired power plant[J]. J Ind Eng Chem, 2012,18(1):513-519. doi: 10.1016/j.jiec.2011.11.070
22. [22]
  CHEN L, LI J, GE M. Promotional effect of Ce-doped V₂O₅-WO₃/TiO₂ with low vanadium loadings for selective catalytic reduction of NOx by NH₃[J]. J Phys Chem C, 2009,113(50):21177-21184. doi: 10.1021/jp907109e
23. [23]
  DUAN Rui-rui. Influence on modulation of the V4+/5+ ratio and rate of V4+ and V5+ redox and SCR DeNO_x activity[D]. Harbin: Engineering University, 2014.
24. [24]
  CHENG Hua. Study of the deactivation causes and the regeneration methods for commercial V₂O₅-WO₃/TiO₂ SCR catalyst[D]. Guangzhou: South China University of Technology, 2013.
25. [25]
  MA Jian-rong, HUANG Zhang-gen, LIU Zhen-yu, GUO Shi-jie. Effect of regeneration method on activity for simultaneous removal of SO₂ and nO over V₂O₅/AC catalyst-sorbent[J]. Chin J Catal, 2005,26(6):463-469. doi: 10.3321/j.issn:0253-9837.2005.06.009
26. [26]
  JIANG Ye, GAO Xiang, WU Wei-hong, ZHANG Yong-xin. Review of the deactivation of selective catalytic reduction DeNO_x catalysts[J]. Proc CSEE, 2013,33(14):18-31.
27. [27]
  PENG Y, LI J, SHI W, XU J, HAO J. Design strategies for development of SCR catalyst:Improvement of alkali poisoning resistance and novel regeneration method[J]. Environ Sci Technol, 2012,46(22)12623. doi: 10.1021/es302857a
28. [28]
  BUSCA G, LIETTI L, RAMIS G, BERTI F. Chemical and mechanistic aspects of the selective catalytic reduction of NO_x by ammonia over oxide catalysts:A review[J]. Appl Catal B:Environ, 1998,18(1/2):1-36.
29. [29]
  KHODAYARI R, ODENBRAND C U I. Regeneration of commercial SCR catalysts by washing and sulphation:Effect of sulphate groups on the activity[J]. Appl Catal B:Environ, 2001,33(4):277-291. doi: 10.1016/S0926-3373(01)00193-X
1. [1]
  Qiangqiang SUN , Pengcheng ZHAO , Ruoyu WU , Baoyue CAO . Multistage microporous bifunctional catalyst constructed by P-doped nickel-based sulfide ultra-thin nanosheets for energy-efficient hydrogen production from water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1151-1161. doi: 10.11862/CJIC.20230454
2. [2]
  Hengyi ZHU , Liyun JU , Haoyue ZHANG , Jiaxin DU , Yutong XIE , Li SONG , Yachao JIN , Mingdao ZHANG . Efficient regeneration of waste LiNi_0.5Co_0.2Mn_0.3O₂ cathode toward high-performance Li-ion battery. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 625-638. doi: 10.11862/CJIC.20240358
3. [3]
  Fangxuan Liu , Ziyan Liu , Guowei Zhou , Tingting Gao , Wenyu Liu , Bin Sun . Hollow structured photocatalysts. Acta Physico-Chimica Sinica, 2025, 41(7): 100071-. doi: 10.1016/j.actphy.2025.100071
4. [4]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
5. [5]
  Kun WANG , Wenrui LIU , Peng JIANG , Yuhang SONG , Lihua CHEN , Zhao DENG . Hierarchical hollow structured BiOBr-Pt catalysts for photocatalytic CO₂ reduction. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1270-1278. doi: 10.11862/CJIC.20240037
6. [6]
  Xuejie Wang , Guoqing Cui , Congkai Wang , Yang Yang , Guiyuan Jiang , Chunming Xu . 碳基催化剂催化有机液体氢载体脱氢研究进展. Acta Physico-Chimica Sinica, 2025, 41(5): 100044-. doi: 10.1016/j.actphy.2024.100044
7. [7]
  Peng GENG , Guangcan XIANG , Wen ZHANG , Haichuang LAN , Shuzhang XIAO . Hollow copper sulfide loaded protoporphyrin for photothermal-sonodynamic therapy of cancer cells. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1903-1910. doi: 10.11862/CJIC.20240155
8. [8]
  Yongjian Zhang , Fangling Gao , Hong Yan , Keyin Ye . Electrochemical Transformation of Organosulfur Compounds. University Chemistry, 2025, 40(5): 311-317. doi: 10.12461/PKU.DXHX202407035
9. [9]
  Lisha LEI , Wei YONG , Yiting CHENG , Yibo WANG , Wenchao HUANG , Junhuan ZHAO , Zhongjie ZHAI , Yangbin DING . Application of regenerated cellulose and reduced graphene oxide film in synergistic power generation from moisture electricity generation and Mg-air batteries. Chinese Journal of Inorganic Chemistry, 2025, 41(6): 1151-1161. doi: 10.11862/CJIC.20240202
10. [10]
  Juntao Yan , Liang Wei . 2D S-Scheme Heterojunction Photocatalyst. Acta Physico-Chimica Sinica, 2024, 40(10): 2312024-. doi: 10.3866/PKU.WHXB202312024
11. [11]
  Yuanyin Cui , Jinfeng Zhang , Hailiang Chu , Lixian Sun , Kai Dai . Rational Design of Bismuth Based Photocatalysts for Solar Energy Conversion. Acta Physico-Chimica Sinica, 2024, 40(12): 2405016-. doi: 10.3866/PKU.WHXB202405016
12. [12]
  Dan Li , Hui Xin , Xiaofeng Yi . Comprehensive Experimental Design on Ni-based Catalyst for Biofuel Production. University Chemistry, 2024, 39(8): 204-211. doi: 10.3866/PKU.DXHX202312046
13. [13]
  Haodong JIN , Qingqing LIU , Chaoyang SHI , Danyang WEI , Jie YU , Xuhui XU , Mingli XU . NiCu/ZnO heterostructure photothermal electrocatalyst for efficient hydrogen evolution reaction. Chinese Journal of Inorganic Chemistry, 2025, 41(6): 1068-1082. doi: 10.11862/CJIC.20250048
14. [14]
  Zhanggui DUAN , Yi PEI , Shanshan ZHENG , Zhaoyang WANG , Yongguang WANG , Junjie WANG , Yang HU , Chunxin LÜ , Wei ZHONG . Preparation of UiO-66-NH₂ supported copper catalyst and its catalytic activity on alcohol oxidation. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 496-506. doi: 10.11862/CJIC.20230317
15. [15]
  Juan WANG , Zhongqiu WANG , Qin SHANG , Guohong WANG , Jinmao LI . NiS and Pt as dual co-catalysts for the enhanced photocatalytic H₂ production activity of BaTiO₃ nanofibers. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1719-1730. doi: 10.11862/CJIC.20240102
16. [16]
  Yang WANG , Xiaoqin ZHENG , Yang LIU , Kai ZHANG , Jiahui KOU , Linbing SUN . Mn single-atom catalysts based on confined space: Fabrication and the electrocatalytic oxygen evolution reaction performance. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2175-2185. doi: 10.11862/CJIC.20240165
17. [17]
  Wen YANG , Didi WANG , Ziyi HUANG , Yaping ZHOU , Yanyan FENG . La promoted hydrotalcite derived Ni-based catalysts: In situ preparation and CO₂ methanation performance. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 561-570. doi: 10.11862/CJIC.20230276
18. [18]
  Asif Hassan Raza , Shumail Farhan , Zhixian Yu , Yan Wu . 用于高效制氢的双S型ZnS/ZnO/CdS异质结构光催化剂. Acta Physico-Chimica Sinica, 2024, 40(11): 2406020-. doi: 10.3866/PKU.WHXB202406020
19. [19]
  Qingqing SHEN , Xiangbowen DU , Kaicheng QIAN , Zhikang JIN , Zheng FANG , Tong WEI , Renhong LI . Self-supporting Cu/α-FeOOH/foam nickel composite catalyst for efficient hydrogen production by coupling methanol oxidation and water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1953-1964. doi: 10.11862/CJIC.20240028
20. [20]
  Zhiquan Zhang , Baker Rhimi , Zheyang Liu , Min Zhou , Guowei Deng , Wei Wei , Liang Mao , Huaming Li , Zhifeng Jiang . Insights into the Development of Copper-based Photocatalysts for CO₂ Conversion. Acta Physico-Chimica Sinica, 2024, 40(12): 2406029-. doi: 10.3866/PKU.WHXB202406029

Get Citation

PDF

XML

Metrics

PDF Downloads(8)
Abstract views(854)
HTML views(64)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142