Citation: MA Ya-ya, MA Feng-yun, MO Wen-long, FAN Xing. Influence of acid treatment on the structure and extraction performance of Xinjiang Hefeng low-rank coal[J]. Journal of Fuel Chemistry and Technology, ;2019, 47(6): 649-660. shu

Influence of acid treatment on the structure and extraction performance of Xinjiang Hefeng low-rank coal

Key Laboratory of Coal Clean Conversion & Chemical Engineering Process(Xinjiang Uyghur Autonomous Region), College of Chemistry and Chemical Engineering, Xinjiang University, Urumqi 830046, China

Corresponding author: MA Feng-yun, ma_fy@126.com MO Wen-long, mowenlong@xju.edu.cn
Received Date: 28 December 2018
Revised Date: 24 March 2019

Fund Project: The project was supported by the National Natural Science Foundation of China-Key Project of Xinjiang Joint Fundation (U1503293) and the National Natural Science Foundation of China (21276219)the National Natural Science Foundation of China-Key Project of Xinjiang Joint Fundation U1503293the National Natural Science Foundation of China 21276219

Figures(14)

The acid treatment experiment to remove the inorganic minerals in Xinjiang Hefeng low-rank coal was conducted, and the effects of deashing treatment on the main structure of coal sample and its extraction performance by petroleum ether and CS₂ were analyzed by instrumental characterizations. The FT-IR results show that the main structure of the treated coal changes slightly compared with the untreated one. And the acid-washed coal sample (AC) presents a very weak absorption peak at 1712 cm^-1 attributed to carboxylic acid (C=O), which could not be observed in the raw coal sample (RC). It can also be seen from TG-DTG characterization that the process of acid treatment results in a cleavage of small molecular bonds in the coal without destroying the macromolecular network structure. The performance of two-stage ultrasonic extraction of RC and AC samples with petroleum ether (PE) and CS₂ as solvents proposes that the extraction proportions of PE and CS₂ of AC sample are higher than that of RC sample, from 0.16% and 0.53% (RC) to 0.17% and 0.64%, respectively, and the extraction rate of AC sample is larger than that of RC sample, reducing the number of solvent extraction operation significantly.FT-IR and GC-MS analysis of the extracts shows that the acid treatment not only effectively removes the heteroatoms in the coal sample, but also increases the type of CS₂ extracts. In addition, from the results of TG-DTG for the residues, it can be noted that the ultrasonic extraction is a physical swelling process, and does not destroy the macromolecular structure of the coal sample.
- Hefeng coal,
- acid treatment,
- coal structure,
- extraction performance
1. [1]
  MARZEC A. Towards an understanding of the coal structure:A review[J]. Fuel Process Technol, 2002,77:25-32.
2. [2]
  ASHIDA R, MORIMOTO M, MAKINO Y, UMEMOTO S, NAKAGAWA H, MIURA K. Fractionation of brown coal by sequential high temperature solvent extraction[J]. Fuel, 2009,88(8):1485-1490. doi: 10.1016/j.fuel.2008.12.003
3. [3]
  TAHMASEBI A, YU J, HAN Y, YIN F, BHATTACHARYA S, STOKIE D. Study of chemical structure changes of Chinese lignite upon drying in superheated steam, microwave, and hot air[J]. Energy Fuels, 2012,26(6):3651-3660. doi: 10.1021/ef300559b
4. [4]
  ZHENG A L, FAN X, WANG S Z, LIU F J, WEI X Y, ZHAO Y P. Analysis of the products from the oxidation of Geting bituminous coal by atmospheric pressure photoionization-mass spectrometry[J]. Anal Lett, 2014,47(6):958-969. doi: 10.1080/00032719.2013.860541
5. [5]
  IINO M. Network structure of coals and association behavior of coal-derived materials[J]. Fuel Process Technol, 2000,62(2):89-101.
6. [6]
  WANG J, TAKARADA T. Characterization of high-temperature coal tar and supercritical-water extracts of coal by laser desorption ionization-mass spectrometry[J]. Fuel Process Technol, 2003,81(3):247-258. doi: 10.1016/S0378-3820(03)00025-0
7. [7]
  WANG S Q, TANG Y G, SCHOBERT H H, GUO Y N, GAO W C, LU X K. FTIR and simultaneous TG/MS/FTIR study of Late Permian coals from Southern China[J]. J Anal Appl Pyrolysis, 2013,100:75-80. doi: 10.1016/j.jaap.2012.11.021
8. [8]
  MAO J D, SCHIMMELMANN A, MASTALERZ M, HATCHER P, LI Y. Structural features of a bituminous coal and their changes during low-temperature oxidation and loss of volatiles investigated by advanced solid-state NMR spectroscopy[J]. Energy Fuels, 2010,24(4):2536-2544. doi: 10.1021/ef9015069
9. [9]
  FAN X, JIANG J, CHEN L, ZHOU C C, ZHU J L, ZHU T G, WEI X Y. Identification of organic fluorides and distribution of organic species in an anthracite with high content of fluorine[J]. Fuel Process Technol, 2016,142:54-58. doi: 10.1016/j.fuproc.2015.09.024
10. [10]
  GRYGLEWICZ G, RUTKOWSKI P, YPERMAN J. Characterization of sulfur compounds in supercritical coal extracts by gas chromatography-mass spectrometry[J]. Fuel Process Technol, 2002,77:167-172.
11. [11]
  YU X Y, WEI X Y, LI Z K, CHEN Y, ZONG Z M, MA F Y. Comparison of three methods for extracting Liuhuanggou bituminous coal[J]. Fuel, 2017,210:290-297. doi: 10.1016/j.fuel.2017.08.071
12. [12]
  IINO M, TAKANOHASHI T, OHSUGA H, TODA K. Extraction of coals with CS₂-N-methyl-2-pyrrolidinone mixed solvent at room temperature[J]. Fuel, 1988,67(12):1639-1647. doi: 10.1016/0016-2361(88)90208-6
13. [13]
  WEI X Y, SHEN J L, TAKANOHASHI T, IINO M. Effect of extractable substances on coal dissolution. Use of CS₂-N-methyl-2-pyrrolidinone mixed solvent for dissolution re-action products[J]. Energy Fuels, 1989,3(5):575-579. doi: 10.1021/ef00017a008
14. [14]
  TAKANOHASHI T, XIAO F, TAKAHIRO YOSHIDA A, SAITO I. Difference in extraction yields between CS₂/NMP and NMP for upper freeport coal[J]. Energy Fuels, 2003,17(1):255-256. doi: 10.1021/ef020141h
15. [15]
  TAKANOHASHI T, TAKAYUKI YANAGIDA A, IINO M, MAINWARING D E. Extraction and swelling of low-rank coals with various solvents at room temperature[J]. Energy Fuels, 1996,10(5):1128-1132. doi: 10.1021/ef960033t
16. [16]
  LU H Y, WEI X Y, YU R, PENG Y L, QI X Z, QIE L M. Sequential thermal dissolution of Huolinguole lignite in methanol and in ethanol[J]. Energy Fuels, 2011,25(6):2741-2745. doi: 10.1021/ef101734f
17. [17]
  ISHIZUKA T, TAKANOHASHI T, ITO O, LINO M. Effects of additives and oxygen on ex-traction yield with CS₂-NMP mixed solvent for argonne premium coal samples[J]. Fuel, 1993,72(4):579-580. doi: 10.1016/0016-2361(93)90120-Q
18. [18]
  NISHIOKA M. Multistep extraction of coal[J]. Fuel, 1991,70(12):1413-1419. doi: 10.1016/0016-2361(91)90007-W
19. [19]
  LI Q C, TAKANOHASHI T, YOSHIDA T, SAITO I, AOKI H, MASHIMO K. Effect of acid treatment on thermal extraction yield in ashless coal production[J]. Fuel, 2004,83(6):727-732. doi: 10.1016/j.fuel.2003.06.002
20. [20]
  LIU L L, YUAN Y, KUMAR S, WANG Z H, HE Y, LV Y, LIU J Z, GUL-E-RANA J, CEN K F. Catalytic effect of metal chlorides on coal pyrolysis and gasification part Ⅱ. Effects of acid washing on coal characteristics[J]. Thermochim Acta, 2018,666:41-50. doi: 10.1016/j.tca.2018.06.001
21. [21]
  GENG W, NAKAJIMA T, TAKANASHI H, OHKI A. Analysis of carboxyl group in coal and coal aromaticity by Fourier transform infrared (FT-IR) spectrometry[J]. Fuel, 2009,88(1):139-144. doi: 10.1016/j.fuel.2008.07.027
22. [22]
  WIJAYA N, ZHANG L. A critical review of coal demineralization and its implication on understanding the speciation of organically bound metals and submicrometer mineral grains in coal[J]. Energy Fuels, 2011,25(1):1-16.
23. [23]
  LIU X P, WU X T, WANG J. Substantial upgrading of a high-ash lignite by hydrothermal treatment followed by Ca(OH)₂ digestion/acid leaching[J]. Fuel, 2018,222:269-277. doi: 10.1016/j.fuel.2018.02.034
24. [24]
  TANG L F, CHEN S J, WANG S W, TAO X X, HE H, FENG L, ZHENG L, MA C Y, ZHAO Y D. Exploration on the action mechanism of microwave with peroxyacetic acid in the process of coal desulfurization[J]. Fuel, 2018,214:554-560. doi: 10.1016/j.fuel.2017.10.087
1. [1]
  Pei Li , Yuenan Zheng , Zhankai Liu , An-Hui Lu . Boron-Containing MFI Zeolite: Microstructure Control and Its Performance of Propane Oxidative Dehydrogenation. Acta Physico-Chimica Sinica, 2025, 41(4): 100034-. doi: 10.3866/PKU.WHXB202406012
2. [2]
  Yongwei ZHANG , Chuang ZHU , Wenbin WU , Yongyong MA , Heng YANG . Efficient hydrogen evolution reaction activity induced by ZnSe@nitrogen doped porous carbon heterojunction. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 650-660. doi: 10.11862/CJIC.20240386
3. [3]
  Qiaowen CHANG , Ke ZHANG , Guangying HUANG , Nuonan LI , Weiping LIU , Fuquan BAI , Caixian YAN , Yangyang FENG , Chuan ZUO . Syntheses, structures, and photo-physical properties of iridium phosphorescent complexes with phenylpyridine derivatives bearing different substituting groups. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 235-244. doi: 10.11862/CJIC.20240311
4. [4]
  Lihui Jiang , Wanrong Dong , Hua Yang , Yongqing Xia , Hongjian Peng , Jun Yuan , Xiaoqian Hu , Zihan Zeng , Yingping Zou , Yiming Luo . Study on Extraction of p-Hydroxyacetophenone. University Chemistry, 2024, 39(11): 259-268. doi: 10.12461/PKU.DXHX202402056
5. [5]
  Yingchun ZHANG , Yiwei SHI , Ruijie YANG , Xin WANG , Zhiguo SONG , Min WANG . Dual ligands manganese complexes based on benzene sulfonic acid and 2, 2′-bipyridine: Structure and catalytic properties and mechanism in Mannich reaction. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1501-1510. doi: 10.11862/CJIC.20240078
6. [6]
  Zhanxiang Liu , Chengshan Yuan , Jie Han , Shuanglian Cai , Qihan Zhang , Lin Wu , Yuan Zheng , Xingwen Sun , Qingwen Liu , Ying Xiong , Guangao Yu , Xin Du , Houjin Li , Jianrong Zhang , Shuyong Zhang . Recommendations for Basic Operations and Standards for Organic Chemical Extraction and Washing Experiments. University Chemistry, 2025, 40(5): 55-65. doi: 10.12461/PKU.DXHX202410039
7. [7]
  Yonghui ZHOU , Rujun HUANG , Dongchao YAO , Aiwei ZHANG , Yuhang SUN , Zhujun CHEN , Baisong ZHU , Youxuan ZHENG . Synthesis and photoelectric properties of fluorescence materials with electron donor-acceptor structures based on quinoxaline and pyridinopyrazine, carbazole, and diphenylamine derivatives. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 701-712. doi: 10.11862/CJIC.20230373
8. [8]
  Dongdong Yao , JunweiGu , Yi Yan , Junliang Zhang , Yaping Zheng . Teaching Phase Separation Mechanism in Polymer Blends Using Process Representation Teaching Method: A Teaching Design for Challenging Theoretical Concepts in “Polymer Structure and Properties” Course. University Chemistry, 2025, 40(4): 131-137. doi: 10.12461/PKU.DXHX202408125
9. [9]
  Yahui HAN , Jinjin ZHAO , Ning REN , Jianjun ZHANG . Synthesis, crystal structure, thermal decomposition mechanism, and fluorescence properties of benzoic acid and 4-hydroxy-2, 2′: 6′, 2″-terpyridine lanthanide complexes. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 969-982. doi: 10.11862/CJIC.20240395
10. [10]
  Zunxiang Zeng , Yuling Hu , Yufei Hu , Hua Xiao . Analysis of Plant Essential Oils by Supercritical CO₂Extraction with Gas Chromatography-Mass Spectrometry: An Instrumental Analysis Comprehensive Experiment Teaching Reform. University Chemistry, 2024, 39(3): 274-282. doi: 10.3866/PKU.DXHX202309069
11. [11]
  Yanhui Zhong , Ran Wang , Zian Lin . Analysis of Halogenated Quinone Compounds in Environmental Water by Dispersive Solid-Phase Extraction with Liquid Chromatography-Triple Quadrupole Mass Spectrometry. University Chemistry, 2024, 39(11): 296-303. doi: 10.12461/PKU.DXHX202402017
12. [12]
  Fangxuan Liu , Ziyan Liu , Guowei Zhou , Tingting Gao , Wenyu Liu , Bin Sun . Hollow structured photocatalysts. Acta Physico-Chimica Sinica, 2025, 41(7): 100071-. doi: 10.1016/j.actphy.2025.100071
13. [13]
  Yan Liu , Yuexiang Zhu , Luhua Lai . Introduction to Blended and Small-Class Teaching in Structural Chemistry: Exploring the Structure and Properties of Crystals. University Chemistry, 2024, 39(3): 1-4. doi: 10.3866/PKU.DXHX202306084
14. [14]
  Zitong Chen , Zipei Su , Jiangfeng Qian . Aromatic Alkali Metal Reagents: Structures, Properties and Applications. University Chemistry, 2024, 39(8): 149-162. doi: 10.3866/PKU.DXHX202311054
15. [15]
  Wen-Bing Hu . Systematic Introduction of Polymer Chain Structures. University Chemistry, 2025, 40(4): 15-19. doi: 10.3866/PKU.DXHX202401014
16. [16]
  Kun WANG , Wenrui LIU , Peng JIANG , Yuhang SONG , Lihua CHEN , Zhao DENG . Hierarchical hollow structured BiOBr-Pt catalysts for photocatalytic CO₂ reduction. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1270-1278. doi: 10.11862/CJIC.20240037
17. [17]
  Haitang WANG , Yanni LING , Xiaqing MA , Yuxin CHEN , Rui ZHANG , Keyi WANG , Ying ZHANG , Wenmin WANG . Construction, crystal structures, and biological activities of two Ln^Ⅲ₃ complexes. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1474-1482. doi: 10.11862/CJIC.20240188
18. [18]
  Dongju Zhang . Exploring the Descriptions and Connotations of Basic Concepts of Teaching Crystal Structures. University Chemistry, 2024, 39(3): 18-22. doi: 10.3866/PKU.DXHX202304003
19. [19]
  Weina Wang , Fengyi Liu , Wenliang Wang . “Extracting Commonality, Delving into Typicals, Deriving Individuality”: Constructing a Knowledge Graph of Crystal Structures. University Chemistry, 2024, 39(3): 36-42. doi: 10.3866/PKU.DXHX202308029
20. [20]
  Ji Qi , Jianan Zhu , Yanxu Zhang , Jiahao Yang , Chunting Zhang . Visible Color Change of Copper (II) Complexes in Reversible SCSC Transformation: The Effect of Structure on Color. University Chemistry, 2024, 39(3): 43-57. doi: 10.3866/PKU.DXHX202307050

Get Citation

PDF

XML

Metrics

PDF Downloads(4)
Abstract views(1559)
HTML views(163)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142