Citation: LI Zeng-jie, HUANG Yu-hui, ZHU Ming, CHEN Xiao-rong, MEI Hua. Catalytic performance of Ni/Al₂O₃ catalyst for hydrogenation of 2-methylfuran to 2-methyltetrahydrofuran[J]. Journal of Fuel Chemistry and Technology, ;2018, 46(1): 54-58. shu

Catalytic performance of Ni/Al₂O₃ catalyst for hydrogenation of 2-methylfuran to 2-methyltetrahydrofuran

LI Zeng-jie ¹ ,
HUANG Yu-hui ¹ ,
ZHU Ming ^1,2,, ,
CHEN Xiao-rong ^1,2 ,
MEI Hua ^1,2

1.
College of Chemistry and Chemical Engineering, Nanjing University of Technology, Nanjing 210009, China
2.
Catalytic Hydrogenation Engineering Technology Research Center, Nuomeng Chem, Nanjing 210009, China

Corresponding author: ZHU Ming, mingzhu84@njtech.edu.cn
Received Date: 27 September 2017
Revised Date: 27 November 2017

Figures(4)

Ni/Al₂O₃ catalyst with various NiO loading was prepared with impregnation method. The catalytic performance for hydrogenation of 2-methylfuran to 2-methyltetrahydrofuran was investigated in this work. The results indicated that with an increase of NiO contents (10%, 20%, 25%, 30% and 40%), 2-methylfuran conversion rate first increased and then droped to a low level. The selectivity of this hydrogenation reaction showed the same trend. It was mainly because that NiO can produce more active center on catalyst surface, which was good for hydrogenation reaction. However, overloading of NiO blocked the mesopores of supportive Al₂O₃, and thus reduce the reaction selectivity and conversion rate. In batch reactor, after optimization the hydrogenation selectivity rate can be improved under hydrogen partial pressure of 3 MPa, reaction temperature of 150℃ and stirring speed of 1000 r/min. As a result, 2-methyltetrahydrofuran selectivity of 97.1% and 2-methylfuran conversion rate of 99.4% can be achieved with 25% NiO loading.
- impregnation method,
- 2-methylfuran,
- 2-methyltetrahydrofuran,
- hydrogenation,
- Ni/Al₂O₃ catalyst
1. [1]
  XIU S, SHAHBAZI A. Bio-oil production and upgrading research:A review[J]. Renewable Sustainable Energy Rev, 2012,16(7):4406-4414. doi: 10.1016/j.rser.2012.04.028
2. [2]
  ZHENG H, ZHU Y, TENG B, BA Z, ZHANG C, XIANG H, LI Y. Towards understanding the reaction pathway in vapour phase hydrogenation of furfural to 2-methylfuran[J]. J Mol Catal A:Chem, 2006,246(1):18-23.
3. [3]
  RAGAN J A, ENDE D J, BRENEK S J, EISENBEIS S A, SINGER R A, TICKNER D L, TEIXEIRA J J, VANDERPLAS B C, WESTONET N. Safe execution of a large-scale ozonolysis:Preparation of the bisulfite adduct of 2-hydroxyindan-2-carboxaldehyde and its utility in a reductive amination[J]. Org Process Res Dev, 2003,7(2):155-160. doi: 10.1021/op0202235
4. [4]
  YANG J, ZHENG H, ZHU Y, ZHAO G, ZHANG C, TENG B, XIANG H, LI Y. Effects of calcination temperature on performance of Cu-Zn-Al catalyst for synthesizing c-butyrolactone and 2-methylfuran through the coupling of dehydrogenation and hydrogenation[J]. Catal Commun, 2004,5(9):505-510. doi: 10.1016/j.catcom.2004.06.005
5. [5]
  YAN K, WU G, LAFLEUR T, JARVIS C. Production, properties and catalytic hydrogenation of furfural to fuel additives and value-added chemicals[J]. Renewable Sustainable Energy Rev, 2014,38(5):663-676.
6. [6]
  NAKAGAWA Y, TAMURA M, TOMISHIGE K. Catalytic reduction of biomass-derived furanic compounds with hydrogen[J]. Acs Catal, 2013,3(12):2655-2668. doi: 10.1021/cs400616p
7. [7]
  GUO Qing-quan, CHEN Huan-qin. Development on prepartion of levulinic acid and its derivatives[J]. Spec Petrochem, 2003,20(3):45-48.
8. [8]
  DENNEY D B, DENNEY D Z, GIGANTINO J J. Cyclodehydration of 1, 4-butanediols by pentaethoxyphosphorane[J]. J Org Chem, 1984,49(15):2831-2832. doi: 10.1021/jo00189a044
9. [9]
  BISWAS P, LIN J H, KANG J, GULIANTS V V. Vapor phase hydrogenation of 2-methylfuran over noble and base metal catalysts[J]. Appl Catal A:Gen, 2014,475(5):379-385.
10. [10]
  SITTHISA S, SOOKNOI T, MA Y, BALBUENA P B, RESASCO D E. Kinetics and mechanism of hydrogenation of furfural on Cu/SiO₂ catalysts[J]. J Catal, 2011,277(1):1-13. doi: 10.1016/j.jcat.2010.10.005
11. [11]
  DONG F, ZHU Y, DING G, CUI J, LI X, LI Y. One-step conversion of furfural into 2-methyltetrahydrofuran under mild conditions[J]. ChemSusChem, 2015,8(9):1534-1537. doi: 10.1002/cssc.201500178
12. [12]
  WANG Bao-wei, SHANG Yu-guang, DING Guo-zhong, WANG Hai-yang, WANG Er-dong, LI Zhen-hua, MA Xin-bin, QIN Shao-dong, SUN Qi. Ceria-alumina composite support on the sulfur-resistant methanation activity of Mo-based catalyst[J]. J Fuel Chem Technol, 2012,40(11):1390-1396. doi: 10.3969/j.issn.0253-2409.2012.11.018
13. [13]
  SUN Jiao, REN Guo-qing, HUANG Yu-hui, CHEN Xiao-rong, MEI Hua. Effect of calcination temperature on the catalytic performance of CuMgAl catalysts for furfural gas phese selective hydrogenation to furfuryl alcohol[J]. J Fuel Chem Technol, 2017,45(1):43-47.
14. [14]
  SEPEHRI S, REZAEI M. Preparation of highly active nickel catalysts supported on mesoporous nanocrystallineγ-Al₂O₃ for methane autothermal reforming[J]. Chem Eng Technol, 2015,38(9):1637-1645. doi: 10.1002/ceat.201400566
15. [15]
  BSHISH A, YAAKOB Z, EBSHISH A, ALHASAN F H. Hydrogen production via ethanol steam reforming over Ni/Al₂O₃ catalysts:Effect of Ni loading[J]. J Energy Resour Technol, 2014,136(1):1-13.
16. [16]
  ZHAO A, YING W, ZHANG H, MA H, FANG D. Ni-Al₂O₃ catalysts prepared by solution combustion method for syngas methanation[J]. Catal Commun, 2012,17(5):34-38.
17. [17]
  BASF European Company. One step preparation of 2-mthyltetrahydrofuran from furfural in structured-bed with two catalysts:CN, 101558052A[P]. 2009-11-25.
18. [18]
  MO Yong, WANG Gui-wu, CHEN Xi-wen. Liquid phase furfural hydrogenation to synthesize 2-methyltetrahydrofuran over Cu/Ni ultrafne mixed catalyst[J]. Fine Chem, 2013,30(7):821-824.
1. [1]
  Hailian Tang , Siyuan Chen , Qiaoyun Liu , Guoyi Bai , Botao Qiao , Liu Fei . Stabilized Rh/hydroxyapatite Catalyst for Furfuryl Alcohol Hydrogenation: Application of Oxidative Strong Metal-Support Interactions in Reducing Conditions. Acta Physico-Chimica Sinica, 2025, 41(4): 2408004-0. doi: 10.3866/PKU.WHXB202408004
2. [2]
  Liuyun Chen , Wenju Wang , Tairong Lu , Xuan Luo , Xinling Xie , Kelin Huang , Shanli Qin , Tongming Su , Zuzeng Qin , Hongbing Ji . Soft template-induced deep pore structure of Cu/Al₂O₃ for promoting plasma-catalyzed CO₂ hydrogenation to DME. Acta Physico-Chimica Sinica, 2025, 41(6): 100054-0. doi: 10.1016/j.actphy.2025.100054
3. [3]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
4. [4]
  Lina Guo , Ruizhe Li , Chuang Sun , Xiaoli Luo , Yiqiu Shi , Hong Yuan , Shuxin Ouyang , Tierui Zhang . Effect of Interlayer Anions in Layered Double Hydroxides on the Photothermocatalytic CO₂ Methanation of Derived Ni-Al₂O₃ Catalysts. Acta Physico-Chimica Sinica, 2025, 41(1): 100002-0. doi: 10.3866/PKU.WHXB202309002
5. [5]
  Feifei Yang , Wei Zhou , Chaoran Yang , Tianyu Zhang , Yanqiang Huang . Enhanced Methanol Selectivity in CO₂ Hydrogenation by Decoration of K on MoS₂ Catalyst. Acta Physico-Chimica Sinica, 2024, 40(7): 2308017-0. doi: 10.3866/PKU.WHXB202308017
6. [6]
  Aiyi Xin , Jiawei Li , Xinyang Ran , Chuanjiang Fu , Zhiguo Wang . Collaborative Science and Education Based Experimental Design in Organic Chemistry: A Case Study of the Nucleophilic Substitution Reaction of 2-Hydroxymethyl-4,6-Di-Tert-Butylphenol. University Chemistry, 2025, 40(5): 366-375. doi: 10.12461/PKU.DXHX202407031
7. [7]
  Yongqing Xu , Yuyao Yang , Mengna Wu , Xiaoxiao Yang , Xuan Bie , Shiyu Zhang , Qinghai Li , Yanguo Zhang , Chenwei Zhang , Robert E. Przekop , Bogna Sztorch , Dariusz Brzakalski , Hui Zhou . Review on Using Molybdenum Carbides for the Thermal Catalysis of CO₂ Hydrogenation to Produce High-Value-Added Chemicals and Fuels. Acta Physico-Chimica Sinica, 2024, 40(4): 2304003-0. doi: 10.3866/PKU.WHXB202304003
8. [8]
  Wei Zhong , Dan Zheng , Yuanxin Ou , Aiyun Meng , Yaorong Su . Simultaneously Improving Inter-Plane Crystallization and Incorporating K Atoms in g-C₃N₄ Photocatalyst for Highly-Efficient H₂O₂ Photosynthesis. Acta Physico-Chimica Sinica, 2024, 40(11): 2406005-0. doi: 10.3866/PKU.WHXB202406005
9. [9]
  Anqiu LIU , Long LIN , Dezhi ZHANG , Junyu LEI , Kefeng WANG , Wei ZHANG , Junpeng ZHUANG , Haijun HAO . Synthesis, structures, and catalytic activity of aluminum and zinc complexes chelated by 2-((2,6-dimethylphenyl)amino)ethanolate. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 791-798. doi: 10.11862/CJIC.20230424
10. [10]
  Kangmin Wang , Liqiu Wan , Jingyu Wang , Chunlin Zhou , Ke Yang , Liang Zhou , Bijin Li . Multifunctional 2-(2′-hydroxyphenyl)benzoxazoles: Ready synthesis, mechanochromism, fluorescence imaging, and OLEDs. Chinese Chemical Letters, 2024, 35(10): 109554-. doi: 10.1016/j.cclet.2024.109554
11. [11]
  Xi YANG , Chunxiang CHANG , Yingpeng XIE , Yang LI , Yuhui CHEN , Borao WANG , Ludong YI , Zhonghao HAN . Co-catalyst Ni₃N supported Al-doped SrTiO₃: Synthesis and application to hydrogen evolution from photocatalytic water splitting. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 440-452. doi: 10.11862/CJIC.20240371
12. [12]
  Yajin Li , Huimin Liu , Lan Ma , Jiaxiong Liu , Dehua He . Photothermal Synthesis of Glycerol Carbonate via Glycerol Carbonylation with CO₂ over Au/Co₃O₄-ZnO Catalyst. Acta Physico-Chimica Sinica, 2024, 40(9): 2308005-0. doi: 10.3866/PKU.WHXB202308005
13. [13]
  Qing Li , Guangxun Zhang , Yuxia Xu , Yangyang Sun , Huan Pang . P-Regulated Hierarchical Structure Ni₂P Assemblies toward Efficient Electrochemical Urea Oxidation. Acta Physico-Chimica Sinica, 2024, 40(9): 2308045-0. doi: 10.3866/PKU.WHXB202308045
14. [14]
  Yuexiang Liu , Xiangqiao Yang , Tong Lin , Guantian Yang , Xiaoyong Xu , Bubing Zeng , Zhong Li , Weiping Zhu , Xuhong Qian . Efficient continuous synthesis of 2-[3-(trifluoromethyl)phenyl]malonic acid, a key intermediate of Triflumezopyrim, coupling with esterification-condensation-hydrolysis. Chinese Chemical Letters, 2025, 36(1): 109747-. doi: 10.1016/j.cclet.2024.109747
15. [15]
  Xiaofang Li , Zhigang Wang . 调节金助催化剂的d_z²占据轨道增强光催化合成H₂O₂. Acta Physico-Chimica Sinica, 2025, 41(7): 100080-0. doi: 10.1016/j.actphy.2025.100080
16. [16]
  Junjie TANG , Yunting ZHANG , Zhengjiang LIU , Jiani WU . Preparation of CeO₂ by starch template method for photo-Fenton degradation of methyl orange. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1617-1631. doi: 10.11862/CJIC.20240420
17. [17]
  Rui HUANG , Shengjie LIU , Qingyuan WU , Nanfeng ZHENG . Enhanced selectivity of catalytic hydrogenation of halogenated nitroaromatics by interfacial effects. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 201-212. doi: 10.11862/CJIC.20240356
18. [18]
  Wei Sun , Yongjing Wang , Kun Xiang , Saishuai Bai , Haitao Wang , Jing Zou , Arramel , Jizhou Jiang . CoP Decorated on Ti₃C₂T_x MXene Nanocomposites as Robust Electrocatalyst for Hydrogen Evolution Reaction. Acta Physico-Chimica Sinica, 2024, 40(8): 2308015-0. doi: 10.3866/PKU.WHXB202308015
19. [19]
  Hongyi LI , Aimin WU , Liuyang ZHAO , Xinpeng LIU , Fengqin CHEN , Aikui LI , Hao HUANG . Effect of Y(PO₃)₃ double-coating modification on the electrochemical properties of Li[Ni_0.8Co_0.15Al_0.05]O₂. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1320-1328. doi: 10.11862/CJIC.20230480
20. [20]
  Ruolin CHENG , Haoran WANG , Jing REN , Yingying MA , Huagen LIANG . Efficient photocatalytic CO₂ cycloaddition over W₁₈O₄₉/NH₂-UiO-66 composite catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 523-532. doi: 10.11862/CJIC.20230349

Get Citation

PDF

XML

Metrics

PDF Downloads(7)
Abstract views(1931)
HTML views(263)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Catalytic performance of Ni/Al2O3 catalyst for hydrogenation of 2-methylfuran to 2-methyltetrahydrofuran

Metrics

通讯作者: 陈斌, bchen63@163.com

Catalytic performance of Ni/Al₂O₃ catalyst for hydrogenation of 2-methylfuran to 2-methyltetrahydrofuran