Citation: HUANG Chun-jie, CHEN Shao-yun, FEI Xiao-yao, LIU Dai, CHEN Jian, ZHANG Yong-chun. Preparation of nanometer CuO-ZnO-ZrO₂ catalysts through citrate-gel process and their catalytic properties for methanol synthesis from CO₂[J]. Journal of Fuel Chemistry and Technology, ;2016, 44(3): 375-384. shu

Preparation of nanometer CuO-ZnO-ZrO₂ catalysts through citrate-gel process and their catalytic properties for methanol synthesis from CO₂

State Key Laboratory of Fine Chemistry, Dalian University of Technology, Dalian 116023, China

Corresponding author: ZHANG Yong-chun, zalidy5518@vip.sina.com
Received Date: 20 October 2015
Revised Date: 30 December 2015

Figures(8)

CuO-ZnO-ZrO₂(CZZ) nanocatalysts were successfully prepared by citrate-gel method. The catalysts and their precursors were characterized by X-ray photoelectron spectroscopy (XPS), N₂ adsorption specific surface area measurement (BET), X-ray diffraction (XRD), H₂-temperature-programmed reduction (H₂-TPR), H₂ and CO₂-temperature-programmed desorption (H₂ and CO₂-TPD) and thermogravimetric analysis (TG-DTA). Drying time of the wet gel and the dosage of citric acid were systematicly studied, while combustion method was also conducted with the comparison of those obtained catalysts. Results show that, prolonged drying process can effectively prevent particle spattering during calcination, benefit the dispersion of different components in the catalyst, and improve the adsorption ability of catalyst for H₂ and CO₂. Sample CZZ-48h, which was dried at 112℃, 48h, maintained a much higher BET specific surface area than that prepared by combustion method. The CuO-ZnO-ZrO₂ catalyst, in which 100% of stoichiometric amount of citric acid was added, exhibited an optimum catalytic behavior with a space-time-yield of methanol 109.4g·h^-1·kg^-1 under the condition of 240℃, 2.6 MPa, 3600h^-1, H₂/CO₂=3. The detriment of the catalytic performance excessive amounts of citric acid is ascribed to decline dispersion of the catalyst component, and decomposition residual covering on the surface active species of the catalyst.
- citrate-gel process,
- CuO-ZnO-ZrO₂,
- CO₂ catalytic hydrogenation,
- methanol
1. [1]
  OLAH G A, PRAKASH G K S, GOEPPERT A. Anthropogenic chemical carbon cycle for a sustainable future[J]. J Am Chem Soc, 2011,133(33):12881-12898. doi: 10.1021/ja202642y
2. [2]
  OLAH G A. Towards oil independence through renewable methanol chemistry[J]. AngewChemInt Ed, 2013,52(1):104-107.
3. [3]
  MEITZNER G, IGLESIA E. New insights into methanol synthesis catalysts from X-ray absorption spectroscopy[J]. Catal Today, 1999,53(3):433-441. doi: 10.1016/S0920-5861(99)00135-2
4. [4]
  CONG Yu, BAO Xin-he, ZHANG Tao, SUN Xiao-ying, LIANG Dong-bai, TIAN Jin-zhong, HUANG Ning-biao. TPSR and TPD studies of ultrafine Cu-ZnO-ZrO₂ catalysts for methanol synthesis[J]. J Fuel Chem Technol, 2000,28(3):238-243.
5. [5]
  SUN Q, LIU C W, PAN W, ZHU Q M, DENG J F. In situ IR studies on the mechanism of methanol synthesis over an ultrafine Cu/ZnO/Al₂O₃ catalyst[J]. ApplCatal A: Gen, 1998,171:301-308.
6. [6]
  CONG Yu, TIAN Jin-zhong, HUANG Ning-biao, XU Zhang-hai, ZHANG Tao, SUN Xiao-ying, GUAN Wen, LIANG Dong-bai. Preparation of ultrafine Cu-ZnO-ZrO₂catalysts and CO₂ hydrogenation performance[J]. Chin J Catal, 2000,21(3):247-250.
7. [7]
  ARENA F, BARBERA K, ITALIANO G, BONURAG , SPADARO L, FRUSTERI F. Synthesis, characterization and activity pattern of Cu-ZnO/ZrO₂ catalystsin the hydrogenation of carbon dioxide to methanol[J]. J Catal, 2007,249(2):185-194. doi: 10.1016/j.jcat.2007.04.003
8. [8]
  LI C M, YUAN X D, FUJIMOTO K. Development of highly stable catalyst for methanol synthesis from carbon dioxide[J]. Appl Catal A: Gen, 2014,469:306-311. doi: 10.1016/j.apcata.2013.10.010
9. [9]
  GAO P, LI F, XIAO F K, ZHAO N, WEI W, ZHONG L S, SUN Y H. Effect of hydrotalcite-containing precursors on the performance of Cu/Zn/Al/Zr catalysts for CO₂ hydrogenation: Introduction of Cu²⁺ at different formation stages of precursors[J]. Catal Today, 2012,194(1):9-15. doi: 10.1016/j.cattod.2012.06.012
10. [10]
  YANG R Q, YU X C, ZHANG Y, LI W Z, TSUBAKI N. A new method of low-temperature methanol synthesis on Cu/ZnO/Al₂O₃ catalysts from CO/CO₂/H₂[J]. Fuel, 2008,87(4/5):443-450.
11. [11]
  GUO X M, MAO D S, WANG S, WU G S, LU G Z. Combustion synthesis of CuO-ZnO-ZrO₂ catalysts for the hydrogenation of carbon dioxide to methanol[J]. Catal Commun, 2009,10(13):1661-1664. doi: 10.1016/j.catcom.2009.05.004
12. [12]
  GUO Xiao-ming, MAO Dong-sen, LU Guan-zhong, WANG Song. Preparation of CuO-ZnO-ZrO₂ by citric acid combustion method and its catalytic property for methanol synthesis from CO₂ hydrogenation[J]. Acta Phys-Chem Sin, 2012,28(1):170-176.
13. [13]
  SHI L, YANG R Q, TAO K, YONEYAMA Y, TAN Y S, TSUBAKI N. Surface impregnation combustion method to prepare nanostructured metallic catalysts without further reduction: As-burnt Cu-ZnO/SiO₂ catalyst for low-temperature methanol synthesis[J]. Catal Today, 2012,185(1):54-60. doi: 10.1016/j.cattod.2011.10.015
14. [14]
  ZHU Yi-qing, WEN Yi, LAI Li-fang, ZONG Feng-qi, WANG Jian. Characterization and catalytic activity evaluation of ultrafine CuO/ZnO/TiO₂-SiO₂ catalysts for CO₂ hydrogenation to methanol[J]. J Fuel Chem Technol, 2004,32(4):486-491.
15. [15]
  JUN K W, SHEN W J, RAO KS R, LEE K W. Residual sodium effect on the catalytic activity of Cu/ZnO/Al₂O₃ in methanol synthesis from CO₂ hydrogenation[J]. Appl Catal A: Gen, 1998,174:231-238. doi: 10.1016/S0926-860X(98)00195-1
16. [16]
  KONG Xiu-qin, TANG Xing-jiang, XU Shan, WANG Xiao-lai. Preparation of CuO-ZnO/Al₂O₃ by sol-gel auto-combustion method and its catalytic property for methanol synthesis from CO₂ hydrogenation[J]. J Mol Catal, 2013,27(2):159-165.
17. [17]
  LIN Jian-xin, WANG Zi-qing, ZHANG Liu-ming, NI Jun, WANG Rong, WEI Ke-mei. Ammonia synthesis over ruthenium catalysts using barium-doped zirconia as supports prepared by citric acid method[J]. Chin J Catal, 2012,33(7):1075-1079.
18. [18]
  JING Mao-xiang, SHEN Xiang-qian, SHEN Yu-jun. Preparation of nanometer nickel oxide by the citrate-gel process[J]. J Inorg Mater, 2004,19(2):289-294.
19. [19]
  BONURA G, CORDARO M, CANNILLA C, ARENA F, FRUSTERI F. The changing nature of the active site of Cu-Zn-Zr catalysts for the CO₂ hydrogenation reaction to methanol[J]. Appl Catal B: Environ, 2014,52-153:152-161.
20. [20]
  KARELOVIC A, BARGIBANT A, FERNÁNDEZ C, RUIZ P. Effect of the structural and morphological properties of Cu/ZnO catalysts prepared by citrate method on their activity toward methanol synthesis from CO₂ and H₂ under mild reaction conditions[J]. Catal Today, 2012,197(1):109-118. doi: 10.1016/j.cattod.2012.07.029
21. [21]
  ZHANG Lu-xiang, ZHANG Yong-chun, CHEN Shao-yun. Effect of promoter TiO₂ on the performance of CuO-ZnO-Al₂O₃ catalyst for CO₂ catalytic hydrogenation to methanol[J]. J Fuel Chem Technol, 2011,39(12):912-917. doi: 10.1016/S1872-5813(12)60002-4
22. [22]
  ZHANG Y P, FEI J H, YU Y M, ZHENG X M. Methanol synthesis from CO₂ hydrogenation over Cu based catalyst supported on zirconia modified Al₂O₃[J]. Energy Convers Manage, 2006,47(18/19):3360-3367.
23. [23]
  DONG X, ZHANG H B, LIN G D, YUAN Y Z, TSAI K R. Highly active CNT-promoted Cu-ZnO-Al₂O₃ catalyst for methanol synthesis from H₂/CO/CO₂[J]. Catal Lett, 2003,85(3):237-246.
24. [24]
  LI Ji-tao, ZHANG Wei-de, CHEN Ming-dan, QU Ze-tang. TPD and TPSR study of CO₂ adsorption on Cu-based catalysts[J]. J Nat Gas Chem, 1998,23(5):14-17.
25. [25]
  ARENA F, ITALIANO G, BARBERA K, BORDIGA S, BONURA G, SPADARO L, FRUSTERI F. Solid-state interactions, adsorption sites and functionality of Cu-ZnO/ZrO₂ catalysts in the CO₂ hydrogenation to CH₃OH[J]. Appl Catal A: Gen, 2008,350:16-23. doi: 10.1016/j.apcata.2008.07.028
26. [26]
  ZHUANG Hao-ren, LI Cheng-en, YIN Zhi-wen. Pyrolysis of PLZT citrate precursor[J]. J Inorg Mater, 1988,3(1):27-31.
27. [27]
  SHI L, ZENG C Y, JIN Y Z, WANG T J, TSUBAKI N. A sol-gel auto-combustion method to prepare Cu/ZnO catalysts for low-temperature methanol synthesis[J]. Catal Sci Technol, 2012,2:2569-2577. doi: 10.1039/c2cy20423a
28. [28]
  XU Zheng, MAO Li-qun, QIAN Zai-hu, SHENG Shi-shan, XIONG Guo-xing. Photoelectron spectroscopic study of CuO/ZnO/ZrO₂ catalyst in low pressure methanol synthesis from CO₂ and H₂[J]. J Fuel Chem Technol, 1992,20(3):272-277.
29. [29]
  BIESINGER M C, LAU L W M, GERSON A R, SMART R S C. Resolving surface chemical states in XPS analysis of first row transition metals, oxides and hydroxides: Sc, Ti, V, Cu and Zn[J]. Appl Surf Sci, 2010,257(3):887-898. doi: 10.1016/j.apsusc.2010.07.086
1. [1]
  Liuyun Chen , Wenju Wang , Tairong Lu , Xuan Luo , Xinling Xie , Kelin Huang , Shanli Qin , Tongming Su , Zuzeng Qin , Hongbing Ji . Soft template-induced deep pore structure of Cu/Al₂O₃ for promoting plasma-catalyzed CO₂ hydrogenation to DME. Acta Physico-Chimica Sinica, 2025, 41(6): 100054-. doi: 10.1016/j.actphy.2025.100054
2. [2]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
3. [3]
  Kun WANG , Wenrui LIU , Peng JIANG , Yuhang SONG , Lihua CHEN , Zhao DENG . Hierarchical hollow structured BiOBr-Pt catalysts for photocatalytic CO₂ reduction. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1270-1278. doi: 10.11862/CJIC.20240037
4. [4]
  Xuejiao Wang , Suiying Dong , Kezhen Qi , Vadim Popkov , Xianglin Xiang . Photocatalytic CO₂ Reduction by Modified g-C₃N₄. Acta Physico-Chimica Sinica, 2024, 40(12): 2408005-. doi: 10.3866/PKU.WHXB202408005
5. [5]
  Xianghai Song , Xiaoying Liu , Zhixiang Ren , Xiang Liu , Mei Wang , Yuanfeng Wu , Weiqiang Zhou , Zhi Zhu , Pengwei Huo . Insights into the greatly improved catalytic performance of N-doped BiOBr for CO₂ photoreduction. Acta Physico-Chimica Sinica, 2025, 41(6): 100055-. doi: 10.1016/j.actphy.2025.100055
6. [6]
  Honghong Zhang , Zhen Wei , Derek Hao , Lin Jing , Yuxi Liu , Hongxing Dai , Weiqin Wei , Jiguang Deng . Recent advances in synergistic catalytic valorization of CO₂ and hydrocarbons by heterogeneous catalysis. Acta Physico-Chimica Sinica, 2025, 41(7): 100073-. doi: 10.1016/j.actphy.2025.100073
7. [7]
  Kai CHEN , Fengshun WU , Shun XIAO , Jinbao ZHANG , Lihua ZHU . PtRu/nitrogen-doped carbon for electrocatalytic methanol oxidation and hydrogen evolution by water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1357-1367. doi: 10.11862/CJIC.20230350
8. [8]
  Yongmei Liu , Lisen Sun , Zhen Huang , Tao Tu . Curriculum-Based Ideological and Political Design for the Experiment of Methanol Oxidation to Formaldehyde Catalyzed by Electrolytic Silver. University Chemistry, 2024, 39(2): 67-71. doi: 10.3866/PKU.DXHX202308020
9. [9]
  Yuejiao An , Wenxuan Liu , Yanfeng Zhang , Jianjun Zhang , Zhansheng Lu . Revealing Photoinduced Charge Transfer Mechanism of SnO₂/BiOBr S-Scheme Heterostructure for CO₂ Photoreduction. Acta Physico-Chimica Sinica, 2024, 40(12): 2407021-. doi: 10.3866/PKU.WHXB202407021
10. [10]
  Zhijie Zhang , Xun Li , Huiling Tang , Junhao Wu , Chunxia Yao , Kui Li . Cs₂CuBr₄ perovskite quantum dots confined in mesoporous CuO framework as a p-n type S-scheme heterojunction for efficient CO₂ photoconversion. Chinese Chemical Letters, 2024, 35(11): 109700-. doi: 10.1016/j.cclet.2024.109700
11. [11]
  Ruolin CHENG , Haoran WANG , Jing REN , Yingying MA , Huagen LIANG . Efficient photocatalytic CO₂ cycloaddition over W₁₈O₄₉/NH₂-UiO-66 composite catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 523-532. doi: 10.11862/CJIC.20230349
12. [12]
  Yi YANG , Shuang WANG , Wendan WANG , Limiao CHEN . Photocatalytic CO₂ reduction performance of Z-scheme Ag-Cu₂O/BiVO₄ photocatalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 895-906. doi: 10.11862/CJIC.20230434
13. [13]
  Wen YANG , Didi WANG , Ziyi HUANG , Yaping ZHOU , Yanyan FENG . La promoted hydrotalcite derived Ni-based catalysts: In situ preparation and CO₂ methanation performance. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 561-570. doi: 10.11862/CJIC.20230276
14. [14]
  Runhua Chen , Qiong Wu , Jingchen Luo , Xiaolong Zu , Shan Zhu , Yongfu Sun . 缺陷态二维超薄材料用于光/电催化CO₂还原的基础与展望. Acta Physico-Chimica Sinica, 2025, 41(3): 2308052-. doi: 10.3866/PKU.WHXB202308052
15. [15]
  Fangfang WANG , Jiaqi CHEN , Weiyin SUN . CuBi@Cu-MOF composite catalysts for electrocatalytic CO₂ reduction to HCOOH. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 97-104. doi: 10.11862/CJIC.20240350
16. [16]
  Yulian Hu , Xin Zhou , Xiaojun Han . A Virtual Simulation Experiment on the Design and Property Analysis of CO₂ Reduction Photocatalyst. University Chemistry, 2025, 40(3): 30-35. doi: 10.12461/PKU.DXHX202403088
17. [17]
  Xueqi Yang , Juntao Zhao , Jiawei Ye , Desen Zhou , Tingmin Di , Jun Zhang . 调节NNU-55(Fe)的d带中心以增强CO₂吸附和光催化活性. Acta Physico-Chimica Sinica, 2025, 41(7): 100074-. doi: 10.1016/j.actphy.2025.100074
18. [18]
  Xiutao Xu , Chunfeng Shao , Jinfeng Zhang , Zhongliao Wang , Kai Dai . Rational Design of S-Scheme CeO₂/Bi₂MoO₆ Microsphere Heterojunction for Efficient Photocatalytic CO₂ Reduction. Acta Physico-Chimica Sinica, 2024, 40(10): 2309031-. doi: 10.3866/PKU.WHXB202309031
19. [19]
  Xingyang LI , Tianju LIU , Yang GAO , Dandan ZHANG , Yong ZHOU , Meng PAN . A superior methanol-to-propylene catalyst: Construction via synergistic regulation of pore structure and acidic property of high-silica ZSM-5 zeolite. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1279-1289. doi: 10.11862/CJIC.20240026
20. [20]
  Qingqing SHEN , Xiangbowen DU , Kaicheng QIAN , Zhikang JIN , Zheng FANG , Tong WEI , Renhong LI . Self-supporting Cu/α-FeOOH/foam nickel composite catalyst for efficient hydrogen production by coupling methanol oxidation and water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1953-1964. doi: 10.11862/CJIC.20240028

Get Citation

PDF

XML

Metrics

PDF Downloads(10)
Abstract views(2003)
HTML views(218)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Preparation of nanometer CuO-ZnO-ZrO2 catalysts through citrate-gel process and their catalytic properties for methanol synthesis from CO2

Metrics

通讯作者: 陈斌, bchen63@163.com

Preparation of nanometer CuO-ZnO-ZrO₂ catalysts through citrate-gel process and their catalytic properties for methanol synthesis from CO₂