Citation: LIU Shao-lin, KONG Jiao, SHEN Yan-feng, LI Ting, YANG Nuan-nuan, WANG Mei-jun, CHANG Li-pin. Sulfur occurrence and transformation during pyrolysis of the flotation fraction from coking coals with high organic sulfur[J]. Journal of Fuel Chemistry and Technology, ;2019, 47(8): 915-924. shu

Sulfur occurrence and transformation during pyrolysis of the flotation fraction from coking coals with high organic sulfur

Key Laboratory of Coal Science and Technology, Ministry of Education and Shanxi Province, Taiyuan University of Technology, Taiyuan 030024, China

Corresponding author: WANG Mei-jun, wangmeijun@tyut.edu.cn
Received Date: 20 March 2019
Revised Date: 27 May 2019

Fund Project: the Youth Fund of Taiyuan University of Technology 2017QN60National Nature Science Foundation of China 21878208The project was supported by National Nature Science Foundation of China (21878208, 21808152), the Shanxi Province Science Foundation for Youth (201801D221361) and the Youth Fund of Taiyuan University of Technology (2017QN60)National Nature Science Foundation of China 21808152the Shanxi Province Science Foundation for Youth 201801D221361

Figures(8)

Two coking coals with high organic sulfur were separated into five fractions with different density ranges by heavy medium separation. The occurrences and transformation of sulfur during pyrolysis of different fractions were investigated by X-ray photoelectron spectroscopy (XPS), solid state ¹³C nuclear magnetic resonance (¹³C NMR) and pyrolysis mass spectrometry (Py-MS). The results show that different fractions have significant differences in distribution, occurrence, and chemical environment of sulfur. Organic sulfur is mainly distributed in the low density fraction (D1) and exists in the form of thiophene. Inorganic sulfur such as mineral component is mainly distributed in the high density fraction (D5). As the increase of density of coal fraction, the proportion of aliphatic carbon decreases, and aromatic carbon increases, as well as content of mercaptan and thioether in D1 increases greatly. The volatiles are greatly released since decomposition of aliphatic carbon structure during pyrolysis, which promotes the release of sulfur containing gases, and then improves desulfurization efficiency of D1. However, transformation of sulfur is mainly affected by minerals during D5 pyrolysis.
- heavy medium separation,
- high sulfur coal,
- occurrence,
- pyrolysis,
- sulfur transformation
1. [1]
  WU Chen-xiao. Preparation of blended raw high-sulphur coal in Dongpang coal mine[J]. Clean Coal Technol, 2013,19(1):61-64.
2. [2]
  WANG Jian, YU Cheng-heng, JI Wu-pin. Preparation of blending coking high sulfur coal[J]. Fuel Chem Process, 2011,42(5):26-27. doi: 10.3969/j.issn.1001-3709.2011.05.010
3. [3]
  IBARRA J V, PALACIOS J M, MOLINER R, BONET A J. Evidence of reciprocal organic matter-pyrite interactions affecting sulfur removal during coal pyrolysis[J]. Fuel, 1994,73(7):1046-1050. doi: 10.1016/0016-2361(94)90235-6
4. [4]
  CALKINS W H. The chemical forms of sulfur in coal:A review[J]. Fuel, 1994,73(4):475-484. doi: 10.1016/0016-2361(94)90028-0
5. [5]
  GRYGLEWICA G, WILK P, YPERMAN J, FRANCO D V, MAES I I, MUILENS J, POUCKE L C V. Interaction of the organic matrix with pyrite during pyrolysis of a high-sulfur bituminous coal[J]. Fuel, 1996,75(13):1499-1504. doi: 10.1016/0016-2361(96)00141-X
6. [6]
  ZHANG D K, YANI S. Sulphur transformation during pyrolysis of an Australian lignite[J]. Proc Combust Inst, 2011,33(2):1747-1753. doi: 10.1016/j.proci.2010.07.074
7. [7]
  CHEN H K, LI B Q, YANG J L, ZHANG B J. Transformation of sulfur during pyrolysis and hydroprolysis of coal[J]. Fuel, 1998,77:487-493. doi: 10.1016/S0016-2361(97)00275-5
8. [8]
  WANG M J, LIU L J, WANG J C, CHANG L P, WANG H, HU Y F. Sulfur K-edge XANES study of sulfur transformation during pyrolysis of four coals with different ranks[J]. Fuel Process Technol, 2015,131:262-269. doi: 10.1016/j.fuproc.2014.10.038
9. [9]
  WANG M J, JIA T H, WANG J C, HU Y F, LIU F R, WANG H, CHANG L P. Changes of sulfur forms in coal after tetrachloroethylene extraction and theirs transformations during pyrolysis[J]. Fuel, 2016,186:726-733. doi: 10.1016/j.fuel.2016.09.007
10. [10]
  CHEN Hao-kan, LI Bao-qing, ZHANG Bi-jiang. effects of mineral matter on evolution of sulfur - containing gases in pyrolysis and hydropyrolysis[J]. J Fuel Chem Technol, 1999,27(S1):5-10.
11. [11]
  ZHOU Shi-xue, NIE Xi-wen, WANG Ron-chun, LIU Ze-chang. Study on co-pyrolysis of high sulfur and strongly caking coal with biomass[J]. J Fuel Chem Technol, 2000,28(4):294-297. doi: 10.3969/j.issn.0253-2409.2000.04.002
12. [12]
  KANG Xi-dong, HU Shan-ting, PANG Zhi-gui, PAN Yin-miao, WANG Ling-zhi. Study on relationship between microscopic coal petrology and coke intensity[J]. Geosci, 1997,11(2):164-169.
13. [13]
  ZHOU Shi-yon, ZHAO Jun-guo. Properties of Coking Coal and Quality of Coke for the Blast Furnace[M]. Beijing:Metallurgical Industry Press, 2005.
14. [14]
  ZHANG L, LIU W L, MEN D P. Preparation and coking properties of coal maceral concentrates[J]. Int J Min Sci Technol, 2014,24(1):93-98. doi: 10.1016/j.ijmst.2013.12.016
15. [15]
  TSENG B H, BUCKENTIN M, HSIEH K C. Organic sulphur in coal macerals[J]. Fuel, 1986,5(3):385-389.
16. [16]
  DEMIR I, HARVEY R D. Variation of organic sulfur in macerals of selected Illinois Basin coals[J]. Org Geochem, 1991,7(4):525-533.
17. [17]
  LEI Jia-jin, REN De-yi, HAN De-xin, TANG Xiu-yi. The distribution of organic sulfur in macerals of coals accumulated in different environments[J]. Coal Geol Explor, 1995,3(5):14-18.
18. [18]
  SUN Qing-lei, LI Wen, CHEN Hao-kan, LI Bao-qing. Characteristic of sulfur-containing gases released from the pyrolysis of coal macerals[J]. J China Univ Min Technol, 2005,4(4):518-522. doi: 10.3321/j.issn:1000-1964.2005.04.024
19. [19]
  CHEN Peng. Application of XPS in study forms of organic sulfur in macerals of Yanzhou coal[J]. J Fuel Chem Technol, 1997,5(3):238-241.
20. [20]
  LI C L, YANG S S, CHEN X J, LIN X C, WANG Y G. The characteristic of Shengli brown coal fractions from heavy medium separation and its influence on CO₂ gasification[J]. Fuel Process Technol, 2017,155:232-237. doi: 10.1016/j.fuproc.2016.06.041
21. [21]
  LIN X C, LUO M, LI S Y, YANG Y P, CHEN X J, B , WANG Y G. The evolutionary route of coal matrix during integrated cascade pyrolysis of a typical low-rank coal[J]. Appl Energy, 2017,199:335-346. doi: 10.1016/j.apenergy.2017.05.040
22. [22]
  QUEROL X, CABRERA L, PICKEL W, LÓPEZ-SOLER A, HAGEMANN H W, FERNÁNDEZ-TURIEL J L. Geological controls on the coal quality of the Mequinenza subbituminous coal deposit, northeast Spain[J]. Int J Coal Geol, 1996,29(1):67-91.
23. [23]
  GE Tao, CAI Chuan-chuan. The XPS analysis of different density level organic sulfur in coking coal[J]. J Anhui Univ Sci Technol, 2015,35(3):14-16. doi: 10.3969/j.issn.1672-1098.2015.03.005
24. [24]
  YAO Qiu-xiang, DU Mei-li, WANG Shui-li, LIU Jing, YANG Jian-li. Modes of occurrence and washability evaluation of sulfur in high sulfur coal[J]. Coal Convers, 2013,36(1):24-27. doi: 10.3969/j.issn.1004-4248.2013.01.006
25. [25]
  LIU F R, LI W, CHEN H K, LI B Q. Uneven distribution of sulfurs and their transformation during coal pyrolysis[J]. Fuel, 2007,86(3):360-366. doi: 10.1016/j.fuel.2006.07.021
26. [26]
  KOZLOWSKI M. XPS Study of reductively and non-reductively modified coals[J]. Fuel, 2004,83(3):259-265. doi: 10.1016/j.fuel.2003.08.004
27. [27]
  MA Ling-ling, QIN Zhi-hong, ZHANG Lu, LIU Xu, CHEN Hang. Peak fitting methods and parameter settings in XPS analysis for organic sulfur in coal[J]. J Fuel Chem Technol, 2014,42(3):277-283.
28. [28]
  HOU J L, MA Y, LI S Y, SHI J, HE L, LI J. Transformation of sulfur and nitrogen during Shenmu coal pyrolysis[J]. Fuel, 2018,231:134-144. doi: 10.1016/j.fuel.2018.05.046
29. [29]
  LIU P, LE J W, WANG L L, PAN T Y, LU X L, ZHANG D X. Relevance of carbon structure to formation of tar and liquid alkane during coal pyrolysis[J]. Appl Energy, 2016,183:470-477. doi: 10.1016/j.apenergy.2016.08.166
30. [30]
  WANG M J, HU Y F, WANG J C, CHANG L P, WANG H. Transformation of sulfur during pyrolysis of inertinite-rich coals and correlation with their characteristics[J]. J Anal Appl Pyrolysis, 2013,104:585-592. doi: 10.1016/j.jaap.2013.05.010
1. [1]
  Yingtong Shi , Guotong Xu , Guizeng Liang , Di Lan , Siyuan Zhang , Yanru Wang , Daohao Li , Guanglei Wu . PEG-VN改性PP隔膜用于高稳定性高效率锂硫电池. Acta Physico-Chimica Sinica, 2025, 41(7): 100082-0. doi: 10.1016/j.actphy.2025.100082
2. [2]
  Tao Wang , Qin Dong , Cunpu Li , Zidong Wei . Sulfur Cathode Electrocatalysis in Lithium-Sulfur Batteries: A Comprehensive Understanding. Acta Physico-Chimica Sinica, 2024, 40(2): 2303061-0. doi: 10.3866/PKU.WHXB202303061
3. [3]
  Weihan Zhang , Menglu Wang , Ankang Jia , Wei Deng , Shuxing Bai . Surface Sulfur Species Influence Hydrogenation Performance of Palladium-Sulfur Nanosheets. Acta Physico-Chimica Sinica, 2024, 40(11): 2309043-0. doi: 10.3866/PKU.WHXB202309043
4. [4]
  Hongyao Li , Youyan Liu , Luwei Dai , Min Yang , Qihui Wang . The Blessing of Indium Sulfide：Confronting the Narrow Path with Uric Acid. University Chemistry, 2024, 39(5): 325-335. doi: 10.3866/PKU.DXHX202311104
5. [5]
  Ruiqing LIU , Wenxiu LIU , Kun XIE , Yiran LIU , Hui CHENG , Xiaoyu WANG , Chenxu TIAN , Xiujing LIN , Xiaomiao FENG . Three-dimensional porous titanium nitride as a highly efficient sulfur host. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 867-876. doi: 10.11862/CJIC.20230441
6. [6]
  Jinyao Du , Xingchao Zang , Ningning Xu , Yongjun Liu , Weisi Guo . Electrochemical Thiocyanation of 4-Bromoethylbenzene. University Chemistry, 2024, 39(6): 312-317. doi: 10.3866/PKU.DXHX202310039
7. [7]
  Nan Xiao , Fang Sun . 二芳基硫醚化合物的构建及应用. University Chemistry, 2025, 40(6): 360-363. doi: 10.12461/PKU.DXHX202407099
8. [8]
  Haitao Wang , Lianglang Yu , Jizhou Jiang , Arramel , Jing Zou . S-Doping of the N-Sites of g-C₃N₄ to Enhance Photocatalytic H₂ Evolution Activity. Acta Physico-Chimica Sinica, 2024, 40(5): 2305047-0. doi: 10.3866/PKU.WHXB202305047
9. [9]
  Weikang Wang , Yadong Wu , Jianjun Zhang , Kai Meng , Jinhe Li , Lele Wang , Qinqin Liu . Green H₂O₂ synthesis via melamine-foam supported S-scheme Cd_0.5Zn_0.5In₂S₄/S-doped carbon nitride heterojunction: synergistic interfacial charge transfer and local photothermal effect. Acta Physico-Chimica Sinica, 2025, 41(8): 100093-0. doi: 10.1016/j.actphy.2025.100093
10. [10]
  Yiming Liang , Ziyan Pan , Kin Shing Chan . One Drink, Two Tears in the Central Nervous System: The Perils of Disulfiram-Like Reactions. University Chemistry, 2025, 40(4): 322-325. doi: 10.12461/PKU.DXHX202406016
11. [11]
  Xue Xiao , Jiachun Li , Xiangtong Meng , Jieshan Qiu . Sulfur-Doped Carbon-Coated Fe_0.95S_1.05 Nanospheres as Anodes for High-Performance Sodium Storage. Acta Physico-Chimica Sinica, 2024, 40(6): 2307006-0. doi: 10.3866/PKU.WHXB202307006
12. [12]
  Yan'e LIU , Shengli JIA , Yifan JIANG , Qinghua ZHAO , Yi LI , Xinshu CHANG . MoO₃/cellulose derived carbon aerogel: Fabrication and performance as cathode for lithium-sulfur battery. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1565-1573. doi: 10.11862/CJIC.20250054
13. [13]
  Hong CAI , Jiewen WU , Jingyun LI , Lixian CHEN , Siqi XIAO , Dan LI . Synthesis of a zinc-cobalt bimetallic adenine metal-organic framework for the recognition of sulfur-containing amino acids. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 114-122. doi: 10.11862/CJIC.20240382
14. [14]
  Qianli Ma , Tianbing Song , Tianle He , Xirong Zhang , Huanming Xiong . Sulfur-doped carbon dots: a novel bifunctional electrolyte additive for high-performance aqueous zinc-ion batteries. Acta Physico-Chimica Sinica, 2025, 41(9): 100106-0. doi: 10.1016/j.actphy.2025.100106
15. [15]
  Xiaofeng Zhu , Bingbing Xiao , Jiaxin Su , Shuai Wang , Qingran Zhang , Jun Wang . Transition Metal Oxides/Chalcogenides for Electrochemical Oxygen Reduction into Hydrogen Peroxides. Acta Physico-Chimica Sinica, 2024, 40(12): 2407005-0. doi: 10.3866/PKU.WHXB202407005
16. [16]
  Kexin Yan , Zhaoqi Ye , Lingtao Kong , He Li , Xue Yang , Yahong Zhang , Hongbin Zhang , Yi Tang . Seed-Induced Synthesis of Disc-Cluster Zeolite L Mesocrystals with Ultrashort c-Axis: Morphology Control, Decoupled Mechanism, and Enhanced Adsorption. Acta Physico-Chimica Sinica, 2024, 40(9): 2308019-0. doi: 10.3866/PKU.WHXB202308019
17. [17]
  Zhuo WANG , Junshan ZHANG , Shaoyan YANG , Lingyan ZHOU , Yedi LI , Yuanpei LAN . Preparation and photocatalytic performance of CeO₂-reduced graphene oxide by thermal decomposition. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1708-1718. doi: 10.11862/CJIC.20240067
18. [18]
  Yang Lv , Yingping Jia , Yanhua Li , Hexiang Zhong , Xinping Wang . Integrating the Ideological Elements with the “Chemical Reaction Heat” Teaching. University Chemistry, 2024, 39(11): 44-51. doi: 10.12461/PKU.DXHX202402059
19. [19]
  Yang ZHOU , Lili YAN , Wenjuan ZHANG , Pinhua RAO . Thermal regeneration of biogas residue biochar and the ammonia nitrogen adsorption properties. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1574-1588. doi: 10.11862/CJIC.20250032
20. [20]
  Yongming Zhu , Huili Hu , Yuanchun Yu , Xudong Li , Peng Gao . Construction and Practice on New Form Stereoscopic Textbook of Electrochemistry for Energy Storage Science and Engineering: Taking Basic Course of Electrochemistry as an Example. University Chemistry, 2024, 39(8): 44-47. doi: 10.3866/PKU.DXHX202312086

Get Citation

PDF

XML

Metrics

PDF Downloads(11)
Abstract views(516)
HTML views(57)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142