Citation: YANG Shu-qian, ZHANG Na, HE Jian-ping, ZHANG Lei, WANG Hong-hao, BAI Jin, ZHANG Jian, LIU Dao-sheng, YANG Zhan-xu. Effect of impregnation sequence of Ce on the performance of Cu/Zn-Al catalysts derived from hydrotalcite precursor in methanol steam reforming[J]. Journal of Fuel Chemistry and Technology, ;2018, 46(4): 479-488. shu

Effect of impregnation sequence of Ce on the performance of Cu/Zn-Al catalysts derived from hydrotalcite precursor in methanol steam reforming

1.
College of Chemistry, Chemical Engineering, and Environmental Engineering, Liaoning Shihua University, Fushun 113001, China
2.
Department of Chemical Engineering, Fushun Vocational Technology Institute, Fushun 113122, China

Corresponding author: ZHANG Lei, lnpuzhanglei@163.com BAI Jin, baijin_fy@163.com
Received Date: 30 October 2017
Revised Date: 13 December 2017

Fund Project: the Science Research General Foundation of Liaoning Education Department L2015296the Doctoral Scientific Research Foundation of Liaoning Provinve 201601322The project was supported by the National Natural Science Foundation of China (21376237), the Doctoral Scientific Research Foundation of Liaoning Provinve (201601322), the Science Research General Foundation of Liaoning Education Department(L2015296) and Research Fund Project for the Construction of Instrument and Equipment Sharing Service Platform of Liaoningthe National Natural Science Foundation of China 21376237

Figures(11)

ZnAl-LDHs was prepared by in-situ synthesis method on γ-Al₂O₃ and the Cu/Zn-Al, Ce/Cu/Zn-Al, Cu/Ce/Zn-Al and Cu-Ce/Zn-Al catalysts were then obtained by wet impregnation method for methanol steam reforming. The catalysts were characterized by XRD, XRF, SEM, N₂ sorption, XPS, H₂-TPR and N₂O titration; the effect of impregnation sequence of Ce on the performance of the Cu/Zn-Al catalysts in methanol steam reforming to produce hydrogen was investigated. The results showed that the impregnation sequence of Ce has a significant influence on the reducibility of resultant catalyst, which subsequently affects the catalytic performance. The Ce/Cu/Zn-Al catalyst exhibits the highest activity; over it, the methanol conversion reaches 100% under 250℃ and with a water/methanol molar ratio of 1.2 and gas hourly space velocity of 800 h^-1, which is almost 40% higher than that achieved on the Cu/Zn-Al catalyst.
- impregnation sequence,
- hydrotalcite,
- ceria,
- methanol steam reforming,
- hydrogen
1. [1]
  SA S, SILVA H, BRANDAO L, SOUSA J M, MENDES A. Catalysts for methanol steam reforming-A review[J]. Appl Catal B:Environ, 2010,99(1/2):43-57.
2. [2]
  LYTKINA A A, ZHILYAEVA N A, ERMILOVA M M, OREKHOVA N V, YAROSLAVTSEV A B. Influence of the support structure and composition of Ni-Cu-based catalysts on hydrogen production by methanol steam reforming[J]. Int J Hydrogen Energy, 2015,40(31):9677-9684. doi: 10.1016/j.ijhydene.2015.05.094
3. [3]
  ZHANG Lei, LEI Jun-teng, TIAN Yuan, HU Xin, BAI Jin, LIU Dan, YANG Yi, PAN Li-wei. Effect of precursor and precipitant concentration on the performance of CuO/ZnO/CeO₂-ZrO₂ catalyst for methanol steam reforming[J]. J Fuel Chem Technol, 2015,43(11):1366-1374. doi: 10.3969/j.issn.0253-2409.2015.11.012
4. [4]
  BASILE A, PARMALIANA A, TOSTI S, LULIANELLI A, GALLUCCI F, ESPRO C, SPOOREN J. Hydrogen production by methanol steam reforming carried out in membrane reactor on Cu/Zn/Mg-based catalyst[J]. Catal Today, 2008,137(1):17-22. doi: 10.1016/j.cattod.2008.03.015
5. [5]
  MA Y F, GUAN G Q, PHANTHONG P, LI X M, CAO J, HAO X G, WANG Z D, ABUDULA A. Steam reforming of methanol for hydrogen production over nanostructured wire-like molybdenum carbide catalyst[J]. Int J Hydrogen Energy, 2014,39(33):18803-18811. doi: 10.1016/j.ijhydene.2014.09.062
6. [6]
  KUC J, NEUMANN M, ARMBRUSTER M, YOON S, ZHANG Y C, ERNI R, WEIDENKAFF A, MATAM S K. Methanol steam reforming catalysts derived by reduction of perovskite-type oxides LaCo_1-x-yPd_xZn_yO_3±δ[J]. Catal Sci Technol, 2016,6(5):1455-1468. doi: 10.1039/C5CY01410G
7. [7]
  AGRELL J, GERMANI G, JARAS S G, BOUTONNET M. Production of hydrogen by partial oxidation of methanol over ZnO-supported palladium catalysts prepared by microemulsion technique[J]. Appl Catal A:Gen, 2003,242(2):233-245. doi: 10.1016/S0926-860X(02)00517-3
8. [8]
  LIU N, YUAN Z S, WANG C W, WANG S D, ZHANG C X, WANG S J. The role of CeO₂-ZrO₂ as support in the ZnO-ZnCr₂O₄ catalysts for autothermal reforming of methanol[J]. Fuel Process Technol, 2008,89(6):574-581. doi: 10.1016/j.fuproc.2007.11.029
9. [9]
  HUANG G, LIAW B J, JHANG C J, CHEN Y Z. Steam reforming of methanol over CuO/ZnO/CeO₂/ZrO₂/Al₂O₃ catalysts[J]. Appl Catal A:Gen, 2009,358(1):7-12. doi: 10.1016/j.apcata.2009.01.031
10. [10]
  LI Y F, DONG X F, LIN W M. Effects of ZrO₂-promoter on catalytic performance of CuZnAlO catalysts for production of hydrogen by steam reforming of methanol[J]. Int J Hydrogen Energy, 2004,29(15):1617-1621. doi: 10.1016/j.ijhydene.2004.03.001
11. [11]
  JIANG Yuan-li, HUANG Qiang, WANG Fu-an, HYUN K D, SOOK L M. Kinetic study of methanol steam reforming over Cu/ZnO/Al₂O₃ catalysts[J]. J Fuel Chem Technol, 2001,29(4):347-350.
12. [12]
  FIERRO G, JACONO M L, INVERSI M, PORTA P, CIOCI F, LAVECCHIA R. Study of the reducibility of copper in CuO/ZnO catalysts by temperature-programmed reduction[J]. Appl Catal A:Gen, 1996,137(2):327-348. doi: 10.1016/0926-860X(95)00311-8
13. [13]
  CHOI Y, FUTAGAMI K, FUTAGAMI K, FUJITANI T, NAKAMURA J. The role of ZnO in Cu/ZnO methanol synthesis catalysts-morphology effect or active site model[J]. Appl Catal A:Gen, 2001,208(1/2):163-167.
14. [14]
  KIM W, MOHAIDEEN K K, SEO D J, YOON W L. Methanol-steam reforming reaction over Cu-Al-based catalysts derived from layered double hydroxides[J]. Int J Hydrogen Energy, 2017,42(4):2081-2087. doi: 10.1016/j.ijhydene.2016.11.014
15. [15]
  CHAO Lei, WU Dan-dan, LI Gong. Study on catalytic properties of Cu-Fe-MgO/AlPO₄-5 for hydrogen production from steam reforming of methanol[J]. J Fuel Chem Technol, 2017,45(9):1105-1113.
16. [16]
  DAS D, LLORCA J, DOMINGUEZ M, COLUSSI S, TROVARELLI A, GAYEN A. Methanol steam reforming behavior of copper impregnated over CeO₂-ZrO₂ derived from a surfactant assisted coprecipitation route[J]. Int J Hydrogen Energy, 2015,40(33):10463-10479. doi: 10.1016/j.ijhydene.2015.06.130
17. [17]
  HAMMOUD D, GENNEQUIN C, ABOUKAIS A, AAD E A. Steam reforming of methanol over x% Cu/Zn-Al 400500 based catalysts for production of hydrogen:Preparation by adopting memory effect of hydrotalcite and behavior evaluation[J]. Int J Hydrogen Energy, 2015,40(2):1283-1297. doi: 10.1016/j.ijhydene.2014.09.080
18. [18]
  LIN K S, CHOWDHURY S, YEH H P, HONG W T, YEH C T. Preparation and characterization of CuO/ZnO-Al₂O₃ catalyst washcoats with CeO₂ sols for autothermal reforming of methanol in a microreactor[J]. Catal Today, 2011,164(1):251-256. doi: 10.1016/j.cattod.2010.11.038
19. [19]
  UDANI P P C, GUNAWARDANA P V D S, LEE H C, KIM D H. Steam reforming and oxidative steam reforming of methanol over CuO-CeO₂ catalysts[J]. Int J Hydrogen Energy, 2009,34(18):7648-7655. doi: 10.1016/j.ijhydene.2009.07.035
20. [20]
  PATEL S, PANT K K. Hydrogen production by oxidative steam reforming of methanol using ceria promoted copper-alumina catalysts[J]. Fuel Process Technol, 2007,88(8):825-832. doi: 10.1016/j.fuproc.2007.04.004
21. [21]
  ZHANG Xin-rong, SHI Peng-fei. Catalytic production of hydrogen form steam reforming of methanol on CeO₂ promoted Cu/Al₂O₃ catalysts[J]. Acta Phys-Chim Sin, 2003,19(1):85-89.
22. [22]
  SHIM J O, NA H S, JHA A, JANG W J, JEONG D W, NAH I W, JEON B H, ROH H S. Effect of preparation method on the oxygen vacancy concentration of CeO₂-promoted Cu/γ-Al₂O₃ catalysts for HTS reactions[J]. Chem Eng J, 2016,306:908-915. doi: 10.1016/j.cej.2016.08.030
23. [23]
  HE J P, YANG Z X, ZHANG L, LI Y, PAN L W. Cu supported on ZnAl-LDHs precursor prepared by in-situ synthesis method on γ-Al₂O₃ as catalytic material with high catalytic activity for methanol steam reforming[J]. Int J Hydrogen Energy, 2017,42(15):9930-9937. doi: 10.1016/j.ijhydene.2017.01.229
24. [24]
  XIE R F, FAN G L, YANG L, LI F. Solvent-free oxidation of ethylbenzene over hierarchical flower-like core-shell structured Co-based mixed metal oxides with significantly enhanced catalytic performance[J]. Catal Sci Technol, 2015,5(1):540-548. doi: 10.1039/C4CY00744A
25. [25]
  AGARWAL V, PATEL S, PANT K K. H₂ production by steam reforming of methanol over Cu/ZnO/Al₂O₃ catalysts:Transient deactivation kinetics modeling[J]. Appl Catal A:Gen, 2005,279(1/2):155-164.
26. [26]
  ZHANG L, PAN L W, NI C J, SUN T J, ZHAO S S, WANG S D, WANG A J, HU Y K. CeO₂-ZrO₂-promoted CuO/ZnO catalyst for methanol steam reforming[J]. Int J Hydrogen Energy, 2013,38(11):4397-4406. doi: 10.1016/j.ijhydene.2013.01.053
27. [27]
  ZHANG L PAN L W, SUN T J, WANG S D, HU Y K, WANG A J, ZHAO S S. Effects of precipitation aging time on the performance of CuO/ZnO/CeO₂-ZrO₂ for methanol steam reforming[J]. J Fuel Chem Technol, 2013,41(7):883-888. doi: 10.1016/S1872-5813(13)60038-9
28. [28]
  HURST N W, GENTRY S J, JONES A, MCNICOL B D. Temperature programmed reduction[J]. Catal Rev Sci Eng, 1982,24(2):233-309. doi: 10.1080/03602458208079654
29. [29]
  WANG C, CHENG Q P, WANG X L, MA K, BAI X Q, TAN S R, TIAN Y, TONG D, ZHENG L R, ZHANG J, LI X G. Enhanced catalytic performance for CO preferential oxidation over CuO catalysts supported on highly defective CeO₂ nanocrystals[J]. Appl Surf Sci, 2017,422:932-943. doi: 10.1016/j.apsusc.2017.06.017
30. [30]
  JONES S D, NEAL L M, HAGELIN WEAVER H E. Steam reforming of methanol using Cu-ZnO catalysts supported on nanoparticle alumina[J]. Appl Catal B:Environ, 2008,84(3/4):631-642.
31. [31]
  ZHANG Guo-qiang, GUO Tian-yu, ZHNEG Hua-yan, LI Zhong. Effect of calcination temperature on catalytic performance of CuCe/Ac catalysts for oxidative carbonylation of methanol[J]. J Fuel Chem Technol, 2016,44(6):674-679.
32. [32]
  YAO X J, GAO F, YU Q, QI L, TANG C J, DONG L, CHEN Y. NO reduction by CO over CuO-CeO₂ catalysts:Effect of preparation methods[J]. Catal Sci Technol, 2013,3(5):1355-1366. doi: 10.1039/c3cy20805b
33. [33]
  XIAO S, ZHANG Y F, GAO P, ZHONG L S, LI X P, ZHANG Z Z, WANG H, WEI W, SUN Y H. Highly efficient cu-based catalysts via hydrotalcite-like precursors for CO₂ hydrogenation to methanol[J]. Catal Today, 2017,281:327-336. doi: 10.1016/j.cattod.2016.02.004
34. [34]
  LIU L J, YAO Z J, DENG Y, GAO F, LIU B, DONG L. Morphology and crystal plane effects of nanoscale ceria on the activity of CuO/CeO₂ for NO reduction by CO[J]. ChemCatChem, 2011,3(6):978-989. doi: 10.1002/cctc.v3.6
35. [35]
  LIANG F L, YU Y, ZHOU W, XU X Y, ZHU Z H. Highly defective CeO₂ as a promoter for efficient and stable water oxidation[J]. J Mater Chem A, 2015,3(2):634-640. doi: 10.1039/C4TA05770H
36. [36]
  SU Shi-long, ZHANG Lei, ZHANG Yan, LEI Jun-teng, GUI Jian-zhou, LIU Dan, LIU Dao-sheng, PAN Li-wei. Thermodynamic simulation for hydrogen production in the methanol steam reforming system of kilowatt PEMFC[J]. Journal of Petrochemical Universities, 2015,28(2):19-25.
1. [1]
  Tongtong Zhao , Yan Wang , Shiyue Qin , Liang Xu , Zhenhua Li . New Experiment Development: Upgrading and Regeneration of Discarded PET Plastic through Electrocatalysis. University Chemistry, 2024, 39(3): 308-315. doi: 10.3866/PKU.DXHX202309003
2. [2]
  Yuchen Zhou , Huanmin Liu , Hongxing Li , Xinyu Song , Yonghua Tang , Peng Zhou . Designing thermodynamically stable noble metal single-atom photocatalysts for highly efficient non-oxidative conversion of ethanol into high-purity hydrogen and value-added acetaldehyde. Acta Physico-Chimica Sinica, 2025, 41(6): 100067-0. doi: 10.1016/j.actphy.2025.100067
3. [3]
  Junjie TANG , Yunting ZHANG , Zhengjiang LIU , Jiani WU . Preparation of CeO₂ by starch template method for photo-Fenton degradation of methyl orange. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1617-1631. doi: 10.11862/CJIC.20240420
4. [4]
  Qin Hu , Liuyun Chen , Xinling Xie , Zuzeng Qin , Hongbing Ji , Tongming Su . Construction of Electron Bridge and Activation of MoS₂ Inert Basal Planes by Ni Doping for Enhancing Photocatalytic Hydrogen Evolution. Acta Physico-Chimica Sinica, 2024, 40(11): 2406024-0. doi: 10.3866/PKU.WHXB202406024
5. [5]
  Xue Liu , Lipeng Wang , Luling Li , Kai Wang , Wenju Liu , Biao Hu , Daofan Cao , Fenghao Jiang , Junguo Li , Ke Liu . Research on Cu-Based and Pt-Based Catalysts for Hydrogen Production through Methanol Steam Reforming. Acta Physico-Chimica Sinica, 2025, 41(5): 100049-0. doi: 10.1016/j.actphy.2025.100049
6. [6]
  Meiran Li , Yingjie Song , Xin Wan , Yang Li , Yiqi Luo , Yeheng He , Bowen Xia , Hua Zhou , Mingfei Shao . Nickel-Vanadium Layered Double Hydroxides for Efficient and Scalable Electrooxidation of 5-Hydroxymethylfurfural Coupled with Hydrogen Generation. Acta Physico-Chimica Sinica, 2024, 40(9): 2306007-0. doi: 10.3866/PKU.WHXB202306007
7. [7]
  Kai CHEN , Fengshun WU , Shun XIAO , Jinbao ZHANG , Lihua ZHU . PtRu/nitrogen-doped carbon for electrocatalytic methanol oxidation and hydrogen evolution by water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1357-1367. doi: 10.11862/CJIC.20230350
8. [8]
  Qingqing SHEN , Xiangbowen DU , Kaicheng QIAN , Zhikang JIN , Zheng FANG , Tong WEI , Renhong LI . Self-supporting Cu/α-FeOOH/foam nickel composite catalyst for efficient hydrogen production by coupling methanol oxidation and water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1953-1964. doi: 10.11862/CJIC.20240028
9. [9]
  Yaping Li , Sai An , Aiqing Cao , Shilong Li , Ming Lei . The Application of Molecular Simulation Software in Structural Chemistry Education: First-Principles Calculation of NiFe Layered Double Hydroxide. University Chemistry, 2025, 40(3): 160-170. doi: 10.12461/PKU.DXHX202405185
10. [10]
  Chuanming GUO , Kaiyang ZHANG , Yun WU , Rui YAO , Qiang ZHAO , Jinping LI , Guang LIU . Performance of MnO₂-0.39IrO_x composite oxides for water oxidation reaction in acidic media. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1135-1142. doi: 10.11862/CJIC.20230459
11. [11]
  Liu Lin , Zemin Sun , Huatian Chen , Lian Zhao , Mingyue Sun , Yitao Yang , Zhensheng Liao , Xinyu Wu , Xinxin Li , Cheng Tang . Recent Advances in Electrocatalytic Two-Electron Water Oxidation for Green H₂O₂ Production. Acta Physico-Chimica Sinica, 2024, 40(4): 2305019-0. doi: 10.3866/PKU.WHXB202305019
12. [12]
  Ji-Quan Liu , Huilin Guo , Ying Yang , Xiaohui Guo . Calculation and Discussion of Electrode Potentials in Redox Reactions of Water. University Chemistry, 2024, 39(8): 351-358. doi: 10.3866/PKU.DXHX202401031
13. [13]
  Yue Zhang , Bao Li , Lixin Wu . GO-Assisted Supramolecular Framework Membrane for High-Performance Separation of Nanosized Oil-in-Water Emulsions. Acta Physico-Chimica Sinica, 2024, 40(5): 2305038-0. doi: 10.3866/PKU.WHXB202305038
14. [14]
  Yongmei Liu , Lisen Sun , Zhen Huang , Tao Tu . Curriculum-Based Ideological and Political Design for the Experiment of Methanol Oxidation to Formaldehyde Catalyzed by Electrolytic Silver. University Chemistry, 2024, 39(2): 67-71. doi: 10.3866/PKU.DXHX202308020
15. [15]
  Shi-Yu Lu , Wenzhao Dou , Jun Zhang , Ling Wang , Chunjie Wu , Huan Yi , Rong Wang , Meng Jin . Amorphous-Crystalline Interfaces Coupling of CrS/CoS₂ Few-Layer Heterojunction with Optimized Crystallinity Boosted for Water-Splitting and Methanol-Assisted Energy-Saving Hydrogen Production. Acta Physico-Chimica Sinica, 2024, 40(8): 2308024-0. doi: 10.3866/PKU.WHXB202308024
16. [16]
  Wentao Xu , Xuyan Mo , Yang Zhou , Zuxian Weng , Kunling Mo , Yanhua Wu , Xinlin Jiang , Dan Li , Tangqi Lan , Huan Wen , Fuqin Zheng , Youjun Fan , Wei Chen . Bimetal Leaching Induced Reconstruction of Water Oxidation Electrocatalyst for Enhanced Activity and Stability. Acta Physico-Chimica Sinica, 2024, 40(8): 2308003-0. doi: 10.3866/PKU.WHXB202308003
17. [17]
  Jiaxin Su , Jiaqi Zhang , Shuming Chai , Yankun Wang , Sibo Wang , Yuanxing Fang . Optimizing Poly(heptazine imide) Photoanodes Using Binary Molten Salt Synthesis for Water Oxidation Reaction. Acta Physico-Chimica Sinica, 2024, 40(12): 2408012-0. doi: 10.3866/PKU.WHXB202408012
18. [18]
  Yuena Yang , Xufang Hu , Yushan Liu , Yaya Kuang , Jian Ling , Qiue Cao , Chuanhua Zhou . The Realm of Smart Hydrogels. University Chemistry, 2024, 39(5): 172-183. doi: 10.3866/PKU.DXHX202310125
19. [19]
  Yuan GAO , Yiming LIU , Chunhui WANG , Zhe HAN , Chaoyue FAN , Jie QIU . A hexanuclear cerium oxo cluster stabilized by furoate: Synthesis, structure, and remarkable ability to scavenge hydroxyl radicals. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 491-498. doi: 10.11862/CJIC.20240271
20. [20]
  Wen YANG , Didi WANG , Ziyi HUANG , Yaping ZHOU , Yanyan FENG . La promoted hydrotalcite derived Ni-based catalysts: In situ preparation and CO₂ methanation performance. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 561-570. doi: 10.11862/CJIC.20230276

Get Citation

PDF

XML

Metrics

PDF Downloads(8)
Abstract views(1445)
HTML views(322)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142