Citation: YANG Cheng, ZHANG Cheng-hua, XU Jian, WU Bao-Shan, YANG Yong, LI Yong-wang. One-step catalytic conversion of syngas to aromatics over ZrO₂ catalyst[J]. Journal of Fuel Chemistry and Technology, ;2016, 44(7): 837-844. shu

One-step catalytic conversion of syngas to aromatics over ZrO₂ catalyst

YANG Cheng ^1,2 ,
ZHANG Cheng-hua ^1,3,4,*,, ,
XU Jian ^3,4 ,
WU Bao-Shan ^1,3,4 ,
YANG Yong ^1,3,4 ,
LI Yong-wang ^1,3,4

1.
State Key Laboratory of Coal Conversion, Institute of Coal Chemistry, Chinese Academy of Sciences, Taiyuan 030001, China
2.
University of Chinese Academy of Sciences, Beijing 100049, China
3.
National Engineering Laboratory for Indirect Coal Liquefaction, Beijing 101407, China
4.
Synfuels China Technology CO. LTD., Beijing 101407, China

Corresponding author: ZHANG Cheng-hua, zhangchh@sxicc.ac.cn
Received Date: 26 February 2016
Revised Date: 18 April 2016

Fund Project: The project was supported by the National Natural Science Foundation of China 21173249The project was supported by the National Natural Science Foundation of China 91545109

Figures(9)

A series of ZrO₂ nanoparticles with different particle sizes and different crystalline phases were prepared using coprecipitation and hydrothermal methods. Their physico-chemical properties were characterized by N₂ physisorption, XRD, TEM, Raman spectroscopy, XPS, and NH₃-TPD techniques. The catalytic performances for syngas conversion were tested at 400 ℃, 3 MPa, gas hourly space velocity (GHSV) of 500 mL/(g_cat·h), and H₂/CO/Ar (volume ratio)=5:5:1. It was found that syngas can be directly converted into hydrocarbons over ZrO₂ nanoparticles. The hydrocarbon products are mainly composed of isomerized olefins, cyclenes, and aromatics. The selectivity of C₅₊ hydrocarbons is up to 48%. Moreover, the aromatic concentration in C₅₊ ranges from 30% to 53% depending on ZrO₂ structures. It is also found that the monoclinic ZrO₂ shows higher activity than the tetragonal one. Monoclinic ZrO₂ with larger specific surface area and acid amount show highest CO conversion as well as the yield of target products, but the monoclinic ZrO₂ with lager particle size has the higher acid surface density and results in the higher aromatic selectivity. Consequently, acidity is the key factor for CO conversion. And high acid surface density promotes the formation of aromatics but acid amount affects the activity.
- zirconia,
- isosynthesis,
- syngas,
- one-step,
- aromatics
1. [1]
  SARTIPI S, MAKKEE M, KAPTEIJN F, GASCON J. Catalysis engineering of bifunctional solids for the one-step synthesis of liquid fuels from syngas: A review[J]. Catal Sci Technol, 2014,4(4):893-907. doi: 10.1039/c3cy01021j
2. [2]
  SARTIPI S, ALBERTS M, SANTOS V P, NASALEVICH M, GASCON J, KAPTEIJN F. Insights into the catalytic performance of mesoporous H-ZSM-5-supported cobalt in Fischer-Tropsch synthesis[J]. ChemCatChem, 2014,6(1):142-151. doi: 10.1002/cctc.v6.1
3. [3]
  DE SMIT E, WECKHUYSEN B M. The renaissance of iron-based Fischer-Tropsch synthesis: on the multifaceted catalyst deactivation behaviour[J]. Chem Soc Rev, 2008,37(12):2758-2781. doi: 10.1039/b805427d
4. [4]
  DRY M E. Fischer-Tropsch reactions and the environment[J]. Appl Catal A: Gen, 1999,189(2):185-190. doi: 10.1016/S0926-860X(99)00275-6
5. [5]
  ANDERSON R B. Catalysts for the Fischer-Tropsch synthesis[C]. New York: Van Nostrand Reinhold, 1956.
6. [6]
  UDAYA V, RAO S, GORMLEY R J. Bifunctional catalysis in syngas conversions[J]. Catal Today, 1990,6(3):207-234. doi: 10.1016/0920-5861(90)85003-7
7. [7]
  VAN Der LAAN G P, BEENACKERS A. Kinetics and selectivity of the Fischer-Tropsch synthesis: A literature review[J]. Catal Rev, 1999,41(3/4):255-318.
8. [8]
  XIANG Hong-wei, YANG Yong, LI Yong-wang. Indirect coal liquefaction: from base to industrialization[J]. Sci China Chem, 2014,12:1876-1892.
9. [9]
  SUN B, QIAO M H, FAN K N A, ULRICH J, TAO F. Fischer-Tropsch synthesis over molecular sieve supported catalysts[J]. ChemCatChem, 2011,3(3):542-550. doi: 10.1002/cctc.v3.3
10. [10]
  TOEMEN S, ABU BAKAR W A W, ALI R. Investigation of Ru/Mn/Ce/Al₂O₃ catalyst for carbon dioxide methanation: Catalytic optimization, physicochemical studies and RSM[J]. J Taiwan Inst Chem E, 2014,45(5):2370-2378. doi: 10.1016/j.jtice.2014.07.009
11. [11]
  FAN J, WENG D, WU X D, RAN R. Modification of CeO₂-ZrO₂ mixed oxides by coprecipitated/impregnated Sr: Effect on the microstructure and oxygen storage capacity[J]. J Catal, 2008,258(1):177-186. doi: 10.1016/j.jcat.2008.06.009
12. [12]
  GE S, HE D, LI Z. A mesoporous Ce_0.5Zr_0.5O₂ solid solution catalyst for CO hydrogenation to iso-C₄ hydrocarbons[J]. Catal Lett, 2008,126(1/2):193-199.
13. [13]
  ZHU Z, HE D. CO hydrogenation to iso-C₄ hydrocarbons over CeO₂-TiO₂ catalysts[J]. Fuel, 2008,87(10/11):2229-2235.
14. [14]
  PICHLER H, ZIESECKE K H. Isosynthesis by reduced oxide catalysts[J]. Brennst Chem, 1949,30:13-80.
15. [15]
  MAEHASHI T, MARUYA K, DOMEN K, AIKA K, ONISHI T. Selective formation of iso-butene from carbon-monoxide and hydrogen over zirconium-oxide catalyst[J]. Chem Lett, 1984,5:747-748.
16. [16]
  MARUYA K, MAEHASHI T, HARAOKA T, NARUI S, ASAKAWA Y, DOMEN K, ONISHI T. The CO-H₂ reaction over ZrO₂ to form isobutene selectively[J]. Bull Chem Soc Jpn, 1988,61(3):667-671. doi: 10.1246/bcsj.61.667
17. [17]
  NANCY B, JACKSON J G E. The surface characteristics required for isosynthesis over zirconium dioxide and modified zirconium dioxide[J]. J Catal, 1990,126(1):31-45. doi: 10.1016/0021-9517(90)90044-K
18. [18]
  SU C L, HE D H, LI J R, CHEN Z X, ZHU Q M. Synthesis of isobutene from synthesis gas over nanosize zirconia catalysts[J]. Appl Catal A: Gen, 2000,202(1):81-89. doi: 10.1016/S0926-860X(00)00461-0
19. [19]
  LI Y W, HE D H, YUAN Y B, CHEN Z X, ZHU Q M. Selective formation of isobutene from CO hydrogenation over zirconium dioxide based catalysts[J]. Energy Fuels, 2001,15(6):1434-1440. doi: 10.1021/ef010064a
20. [20]
  LI Y W, HE D H, CHENG Z X, SU C L, LI R J, ZHU Q M. Effect of calcium salts on isosynthesis over ZrO₂ catalysts[J]. J Mol Catal A: Chem, 2001,175(1/2):267-275.
21. [21]
  LI Y W, HE D H, ZHU Q M, ZHANG X, XU B Q. Effects of redox properties and acid-base properties on isosynthesis over ZrO₂-based catalysts[J]. J Catal, 2004,221(2):584-593. doi: 10.1016/j.jcat.2003.09.023
22. [22]
  ZHANG R J, HE D H. Effect of alcohol solvents treated ZrO (OH)₂ hydrogel on properties of ZrO₂ and its catalytic performance in isosynthesis[J]. J Nat Gas Chem, 2012,21(1):1-6. doi: 10.1016/S1003-9953(11)60324-1
23. [23]
  MARUYA K, KOMIYA T, HAYAKAWA T, LU L H, YASHIMA M. Active sites on ZrO₂ for the formation of isobutene from CO and H₂[J]. J Mol Catal A: Chem, 2000,159(1):97-102. doi: 10.1016/S1381-1169(00)00176-X
24. [24]
  ZHANG R, LIU H, HE D. Pure monoclinic ZrO₂ prepared by hydrothermal method for isosynthesis[J]. Catal Commun, 2012,26:244-247. doi: 10.1016/j.catcom.2012.06.005
25. [25]
  CHANG C D, LANG W H, SILÜESTRI A J. Synthesis gas conversion to aromatic-hydrocarbon[J]. J Catal, 1979,56(2):268-273. doi: 10.1016/0021-9517(79)90113-1
26. [26]
  LI W Z, HUANG H, LI H J, ZHANG W, LIU H C. Facile synthesis of pure monoclinic and tetragonal zirconia nanoparticles and their phase effects on the behavior of supported molybdena catalysts for methanol-selective oxidation[J]. Langmuir, 2008,24(15):8358-8366. doi: 10.1021/la800370r
27. [27]
  LI Wei-zhen, LIU Hai-chao. Solvent effects on the solvothermal synthesis of pure monoclinic and tetragonal zirconia nanoparticles[J]. Acta Phys-Chim Sin, 2008,24(12):2172-2178.
28. [28]
  LI Mei-jun, FENG Zhao-chi, ZHANG Jing, YING Pin-liang, XIN qin, LI Can. Study of influence of calcination atmosphere on phase transformation of zirconia by UV raman spectroscopy[J]. Chin J Catal, 2003,11:861-866.
29. [29]
  ZHANG W, TAN Y Y, GAO Y L, WU J X, TANG B. Ultrafine nano zirconia as electrochemical pseudocapacitor material[J]. Ceram Int, 2015,41(2):2626-2630. doi: 10.1016/j.ceramint.2014.10.047
30. [30]
  ARDIZZONE S, BIANCHI C L. XPS characterization of sulphated zirconia catalysts: The role of iron[J]. Surf Interface Anal, 2000,30(1):77-80. doi: 10.1002/(ISSN)1096-9918
1. [1]
  Bingliang Li , Yuying Han , Dianyang Li , Dandan Liu , Wenbin Shang . One-Step Synthesis of Benorilate Guided by Green Chemistry Principles and in vivo Dynamic Evaluation. University Chemistry, 2024, 39(6): 342-349. doi: 10.3866/PKU.DXHX202311070
2. [2]
  Cheng Zheng , Shiying Zheng , Yanping Zhang , Shoutian Zheng , Qiaohua Wei . Synthesis, Copper Content Analysis, and Luminescent Performance Study of Binuclear Copper (I) Complexes with Isomeric Luminescence Shift: A Comprehensive Chemical Experiment Recommendation. University Chemistry, 2024, 39(7): 322-329. doi: 10.3866/PKU.DXHX202310131
3. [3]
  Shihui Shi , Haoyu Li , Shaojie Han , Yifan Yao , Siqi Liu . Regioselectively Synthesis of Halogenated Arenes via Self-Assembly and Synergistic Catalysis Strategy. University Chemistry, 2024, 39(5): 336-344. doi: 10.3866/PKU.DXHX202312002
4. [4]
  Geyang Song , Dong Xue , Gang Li . Recent Advances in Transition Metal-Catalyzed Synthesis of Anilines from Aryl Halides. University Chemistry, 2024, 39(2): 321-329. doi: 10.3866/PKU.DXHX202308030
5. [5]
  Yufang GAO , Nan HOU , Yaning LIANG , Ning LI , Yanting ZHANG , Zelong LI , Xiaofeng LI . Nano-thin layer MCM-22 zeolite: Synthesis and catalytic properties of trimethylbenzene isomerization reaction. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1079-1087. doi: 10.11862/CJIC.20240036
6. [6]
  Wenjie SHI , Fan LU , Mengwei CHEN , Jin WANG , Yingfeng HAN . Synthesis and host-guest properties of imidazolium-functionalized zirconium metal-organic cage. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 105-113. doi: 10.11862/CJIC.20240360
7. [7]
  Renxiao Liang , Zhe Zhong , Zhangling Jin , Lijuan Shi , Yixia Jia . A Palladium/Chiral Phosphoric Acid Relay Catalysis for the One-Pot Three-Step Synthesis of Chiral Tetrahydroquinoline. University Chemistry, 2024, 39(5): 209-217. doi: 10.3866/PKU.DXHX202311024
8. [8]
  Minna Ma , Yujin Ouyang , Yuan Wu , Mingwei Yuan , Lijuan Yang . Green Synthesis of Medical Chemiluminescence Reagents by Photocatalytic Oxidation. University Chemistry, 2024, 39(5): 134-143. doi: 10.3866/PKU.DXHX202310093
9. [9]
  Yu Wang , Shoulei Zhang , Tianming Lv , Yan Su , Xianyu Liu , Fuping Tian , Changgong Meng . Introduce a Comprehensive Inorganic Synthesis Experiment: Synthesis of Nano Zinc Oxide via Microemulsion Using Waste Soybean Oil. University Chemistry, 2024, 39(7): 316-321. doi: 10.3866/PKU.DXHX202311035
10. [10]
  Zhen Yao , Bing Lin , Youping Tian , Tao Li , Wenhui Zhang , Xiongwei Liu , Wude Yang . Visible-Light-Mediated One-Pot Synthesis of Secondary Amines and Mechanistic Exploration. University Chemistry, 2024, 39(5): 201-208. doi: 10.3866/PKU.DXHX202311033
11. [11]
  Jiaojiao Yu , Bo Sun , Na Li , Cong Wen , Wei Li . Improvement of Classical Organic Experiment Based on the “Reverse-Step Optimization Method”: Taking Synthesis of Ethyl Acetate as an Example. University Chemistry, 2025, 40(3): 333-341. doi: 10.12461/PKU.DXHX202405177
12. [12]
  Zhuoyan Lv , Yangming Ding , Leilei Kang , Lin Li , Xiao Yan Liu , Aiqin Wang , Tao Zhang . Light-Enhanced Direct Epoxidation of Propylene by Molecular Oxygen over CuO_x/TiO₂ Catalyst. Acta Physico-Chimica Sinica, 2025, 41(4): 100038-. doi: 10.3866/PKU.WHXB202408015
13. [13]
  Yongqing Kuang , Jie Liu , Jianjun Feng , Wen Yang , Shuanglian Cai , Ling Shi . Experimental Design for the Two-Step Synthesis of Paracetamol from 4-Hydroxyacetophenone. University Chemistry, 2024, 39(8): 331-337. doi: 10.12461/PKU.DXHX202403012
14. [14]
  Yuan Zheng , Quan Lan , Zhenggen Zha , Lingling Li , Jun Jiang , Pingping Zhu . Teaching Reform of Organic Synthesis Experiments by Introducing Reverse Thinking and Design Concepts: Taking the Synthesis of Cinnamic Acid Based on Retrosynthetic Analysis as an Example. University Chemistry, 2024, 39(6): 207-213. doi: 10.3866/PKU.DXHX202310065
15. [15]
  Yongpo Zhang , Xinfeng Li , Yafei Song , Mengyao Sun , Congcong Yin , Chunyan Gao , Jinzhong Zhao . Synthesis of Chlorine-Bridged Binuclear Cu(I) Complexes Based on Conjugation-Driven Cu(II) Oxidized Secondary Amines. University Chemistry, 2024, 39(5): 44-51. doi: 10.3866/PKU.DXHX202309092
16. [16]
  Zhuoya WANG , Le HE , Zhiquan LIN , Yingxi WANG , Ling LI . Multifunctional nanozyme Prussian blue modified copper peroxide: Synthesis and photothermal enhanced catalytic therapy of self-provided hydrogen peroxide. Chinese Journal of Inorganic Chemistry, 2024, 40(12): 2445-2454. doi: 10.11862/CJIC.20240194
17. [17]
  Yinwu Su , Xuanwen Zheng , Jianghui Du , Boda Li , Tao Wang , Zhiyan Huang . Green Synthesis of 1,3-Dibromoacetone Using Halogen Exchange Method: Recommending a Basic Organic Synthesis Teaching Experiment. University Chemistry, 2024, 39(5): 307-314. doi: 10.3866/PKU.DXHX202311092
18. [18]
  Zhuo Wang , Xue Bai , Kexin Zhang , Hongzhi Wang , Jiabao Dong , Yuan Gao , Bin Zhao . MOF模板法合成氮掺杂碳材料用于增强电化学钠离子储存和去除. Acta Physico-Chimica Sinica, 2025, 41(3): 2405002-. doi: 10.3866/PKU.WHXB202405002
19. [19]
  Caixia Lin , Zhaojiang Shi , Yi Yu , Jianfeng Yan , Keyin Ye , Yaofeng Yuan . Ideological and Political Design for the Electrochemical Synthesis of Benzoxathiazine Dioxide Experiment. University Chemistry, 2024, 39(2): 61-66. doi: 10.3866/PKU.DXHX202309005
20. [20]
  Xiaojun Wu , Kai Hu , Faqiong Zhao . Laying the Groundwork for General Chemistry Experiment Teaching: Exploration and Summary of Assisting Experiment Preparatory Work through Online and Offline Integration. University Chemistry, 2024, 39(8): 23-27. doi: 10.3866/PKU.DXHX202312052

Get Citation

PDF

XML

Metrics

PDF Downloads(4)
Abstract views(2318)
HTML views(538)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

One-step catalytic conversion of syngas to aromatics over ZrO2 catalyst

Metrics

通讯作者: 陈斌, bchen63@163.com

One-step catalytic conversion of syngas to aromatics over ZrO₂ catalyst