Citation: WANG Huan, KONG Jiao, WANG Mei-jun, CHANG Li-ping. Structural evolution of a bituminous coal char related to its synchronized gasification behavior with H₂O and/or CO₂[J]. Journal of Fuel Chemistry and Technology, ;2019, 47(4): 393-401. shu

Structural evolution of a bituminous coal char related to its synchronized gasification behavior with H₂O and/or CO₂

Key Laboratory of Coal Science and Technology, Ministry of Education and Shanxi Province, Taiyuan University of Technology, Taiyuan 030024, China

Corresponding author: WANG Mei-jun, wangmeijun@tyut.edu.cn
Received Date: 25 December 2018
Revised Date: 24 February 2019

Fund Project: The project was supported by the National Natural Science Foundation of China (21406152, U1510111), Shanxi Coal Based Key Scientific and Technological Project (MJH2015-04)the National Natural Science Foundation of China 21406152Shanxi Coal Based Key Scientific and Technological Project MJH2015-04the National Natural Science Foundation of China U1510111

Figures(9)

This work aims to investigate the structural evolution of the char during gasification under a single or mixed atmosphere of H₂O and/or CO₂ with the synchronized investigation of the effect of the varying char structure on the gasification reactivity. The experimental char was prepared from a bituminous coal at 1000℃. The changes of the char structure along with the progress of the carbon conversion during gasification were characterized using N₂ adsorption, SEM, and Raman spectroscopy. The results revealed that H₂O showed a more dramatically change on the char structure than CO₂ and two reactants had different reaction pathways. The different pathways of reactants affected the evolution manners of the char structure and different gasification reactivity of char was related to structural evolution. The specific reaction rate between the char and CO₂ decreased monotonously with increasing carbon conversion. However, the opposite trends are observed when H₂O exist, either H₂O alone or the mixtures of H₂O and CO₂. The char gasification reactivity was under the common effect of physical and chemical structure. In terms of the mixture of H₂O and CO₂, the significant specific surface area caused by H₂O provided more active sites for CO₂. The interactions between H₂O and CO₂ promoted reaction between C and CO₂ (C + CO₂ → CO) in mixtures of H₂O and CO₂, leading to higher amount of CO and higher specific reaction rate than calculated.
- bituminous coal,
- char gasification,
- structural evolution,
- H₂O and CO₂ mixed atmospheres,
- active cooperation
1. [1]
  KEOWN D M, HAYASHI J I, LI C Z. Drastic changes in biomass char structure and reactivity upon contact with steam[J]. Fuel, 2008,87(7):1127-1132. doi: 10.1016/j.fuel.2007.05.057
2. [2]
  LI C Z. Some recent advances in the understanding of the pyrolysis and gasification behaviour of Victorian brown coal[J]. Fuel, 2007,86(12/13):1664-1683.
3. [3]
  ZHANG L, LI T T, QUYN D, DONG L, QIU P H, LI C Z. Structural transformation of nascent char during the fast pyrolysis of mallee wood and low-rank coals[J]. Fuel Process Technol, 2015,138:390-396. doi: 10.1016/j.fuproc.2015.05.003
4. [4]
  LU L M, KONG C H, SAHAJWALLA V, HARRIS D. Char structural ordering during pyrolysis and combustion and its influence on char reactivity[J]. Fuel, 2002,81(9):1215-1225.
5. [5]
  MARQUES M, SUAREZ-RUIZ I, FLORES D, GUEDES A, RODRIGUES S. Correlation between optical, chemical and micro-structural parameters of high-rank coals and graphite[J]. Int J Coal Geol, 2009,77(3/4):377-382.
6. [6]
  FENG B, BHATIA S K. Variation of the pore structure of coal chars during gasification[J]. Carbon, 2003,41(3):507-523. doi: 10.1016/S0008-6223(02)00357-3
7. [7]
  WU H W, YIP K V, TIAN F J, XIE Z L, LI C Z. Evolution of char structure during the steam gasification of biochars produced from the pyrolysis of various mallee biomass components[J]. Ind Eng Chem Res, 2009,48(23):10431-10438. doi: 10.1021/ie901025d
8. [8]
  IRFAN M F, USMAN M R, KUSAKABE K. Coal gasification in CO₂ atmosphere and its kinetics since 1948:A brief review[J]. Energy, 2011,36(1):12-40. doi: 10.1016/j.energy.2010.10.034
9. [9]
  MITSUOKA K, HAYASHI S, AMANO H, KAYAHARA K, SASAOAKA E, UDDIN M A. Gasification of woody biomass char with CO₂:The catalytic effects of K and Ca species on char gasification reactivity[J]. Fuel Process Technol, 2011,92(1):26-31.
10. [10]
  FUSHIMI C, WADA T, TSUTSUMI A. Inhibition of steam gasification of biomass char by hydrogen and tar[J]. Biomass Bioenergy, 2011,35(1):179-185.
11. [11]
  BAI Y H, WANG Y L, ZHU S H, YAN L J, LI F, XIE K C. Synergistic effect between CO₂ and H₂O on reactivity during coal chars gasification[J]. Fuel, 2014,126(15):1-7.
12. [12]
  GUIZANI C, ESCUDERO-SANZ F J, SALVADOR S. The gasification reactivity of high-heating-rate chars in single and mixed atmospheres of H₂O and CO₂[J]. Fuel, 2013,108:812-823.
13. [13]
  EVERSON , R C, NEOMAGUS H W J P, KASAINI H, NJAPHA D. Reaction kinetics of pulverized coal-chars derived from inertinite-rich coal discards:Gasification with carbon dioxide and steam[J]. Fuel, 2006,85(7/8):1076-1082.
14. [14]
  HUANG Z M, ZHANG J S, ZHAO Y, ZHANG H, YUE G X, SUDA T, NARUKAWA M. Kinetic studies of char gasification by steam and CO₂ in the presence of H₂ and CO[J]. Fuel Process Technol, 2010,91(8):843-847.
15. [15]
  BUTTERMAN H C, CASTALDI M J. Influence of CO₂ injection on biomass gasification[J]. Ind Eng Chem Res, 2007,46(26):8875-8886.
16. [16]
  ROBERTS D G, HARRIS D J. Char gasification in mixtures of CO₂ and H₂O:Competition and inhibition[J]. Fuel, 2007,86(17/18):2672-2678.
17. [17]
  CHEN C, ZHANG S, XU K, LUO G Q, YAO H. Experimental and modeling study of char gasification with mixtures of CO₂ and H₂O[J]. Energy Fuels, 2016,30(3):1628-1635. doi: 10.1021/acs.energyfuels.5b02294
18. [18]
  UMEMOTE S, KAJITANI S, HARA S. Modeling of coal char gasification in coexistence of CO₂ and H₂O considering sharing of active sites[J]. Fuel, 2013,103(1):14-21.
19. [19]
  FUSHIMI C, GOTO M, TSUTSUMI A, HAYASHI J I, CHIBA T. Steam gasification characteristics of coal with rapid heating[J]. J Anal Appl Pyrolysis, 2003,70(2):185-197. doi: 10.1016/S0165-2370(02)00131-6
20. [20]
  ZHANG R, WANG Q H, LUO Z Y, FANG M X, CEN K F. Competition and inhibition effects during coal char gasification in the mixture of H₂O and CO₂[J]. Energy Fuels, 2013,27(9):5107-5115.
21. [21]
  TAY H L, KAJITANI S, ZHANG S, LI C Z. Effects of gasifying agent on the evolution of char structure during the gasification of Victorian brown coal[J]. Fuel, 2013,103:22-28. doi: 10.1016/j.fuel.2011.02.044
22. [22]
  WANG M J, ROBERTS D G, KOCHANEK M A, HARRIS D J, CHANG L P, LI C Z. Raman spectroscopic investigations into links between intrinsic reactivity and char chemical structure[J]. Energy Fuels, 2014,28(1):285-290. doi: 10.1021/ef401281h
23. [23]
  ROBERTS D G, HARRISA D J. Char gasification in mixtures of CO₂ and H₂O:Competition and inhibition[J]. Fuel, 2007,86(17/18):2672-2678.
24. [24]
  LI X J, HAYASHI J I, LI C Z. FT-Raman spectroscopic study of the evolution of char structure during the pyrolysis of a Victorian brown coal[J]. Fuel, 2006,85(12/13):1700-1707.
25. [25]
  SEKINE Y, ISHIKAWA K, KIKUCHI E, MATSUKATA M, AKIMOTO A. Reactivity and structural change of coal char during steam gasification[J]. Fuel, 2006,85(2):122-126. doi: 10.1016/j.fuel.2005.05.025
26. [26]
  WANG M J, TIAN J L, ROBERTS D G, CHANG L P, XIE K C. Interactions between corncob and lignite during temperature-programmed co-pyrolysis[J]. Fuel, 2015,142(15):102-108.
27. [27]
  LIU X H, ZHENG Y, LIU Z H, DING H R, HUANG X H, ZHENG C G. Study on the evolution of the char structure during hydrogasification process using Raman spectroscopy[J]. Fuel, 2015,157(1):97-106.
28. [28]
  LIVNEH T, BAR-ZIV E, SENNECA Q, SALATINO P. Evolution of reactivity of highly porous chars from Raman microscopy[J]. Combust Sci Technol, 2000,153(1):65-82. doi: 10.1080/00102200008947251
29. [29]
  ESPINAL J F, MONDRAGON F, TRUONG T N. Thermodynamic evaluation of steam gasification mechanisms of carbonaceous materials[J]. Carbon, 2009,47(13):3010-3018. doi: 10.1016/j.carbon.2009.06.048
30. [30]
  JING X L, WANG Z Q, ZHANG Q, YU Z L, LI C Y, HUANG J J, FANG Y T. Evaluation of CO₂ gasification reactivity of different coal rank chars by physicochemical properties[J]. Energy Fuels, 2013,27(12):7287-7293. doi: 10.1021/ef401639v
31. [31]
  MALEKSHAHIAN M, HILL J M. Effect of pyrolysis and CO₂ gasification pressure on the surface area and pore size distribution of petroleum coke[J]. Energy Fuels, 2011,25(11):5250-5256. doi: 10.1021/ef201231w
32. [32]
  DING L, ZHANG Y Q, WANG Z Q, HUANG J J, FANG Y T. Interaction and its induced inhibiting or synergistic effects during co-gasification of coal char and biomass char[J]. Bioresour Technol, 2014,173:11-20. doi: 10.1016/j.biortech.2014.09.007
33. [33]
  WU X J, ZHANG Z X, PIAO G L, HE X, CHEN Y S, KOBAYASHI N, MORI S, ITAYA Y. Behavior of mineral matters in chinese coal ash melting during char-CO₂/H₂O gasification reaction[J]. Energy Fuels, 2009,23(5):2420-2428. doi: 10.1021/ef801002n
34. [34]
  KLOSE W, WOLKI M. On the intrinsic reaction rate of biomass char gasification with carbon dioxide and steam[J]. Fuel, 2005,84(7/8):885-892.
1. [1]
  Li Li , Fanpeng Chen , Bohang Zhao , Yifu Yu . Understanding of the structural evolution of catalysts and identification of active species during CO₂ conversion. Chinese Chemical Letters, 2024, 35(4): 109240-. doi: 10.1016/j.cclet.2023.109240
2. [2]
  Mengjun Zhao , Yuhao Guo , Na Li , Tingjiang Yan . Deciphering the structural evolution and real active ingredients of iron oxides in photocatalytic CO2 hydrogenation. Chinese Journal of Structural Chemistry, 2024, 43(8): 100348-100348. doi: 10.1016/j.cjsc.2024.100348
3. [3]
  Bin Dong , Ning Yu , Qiu-Yue Wang , Jing-Ke Ren , Xin-Yu Zhang , Zhi-Jie Zhang , Ruo-Yao Fan , Da-Peng Liu , Yong-Ming Chai . Double active sites promoting hydrogen evolution activity and stability of CoRuOH/Co₂P by rapid hydrolysis. Chinese Chemical Letters, 2024, 35(7): 109221-. doi: 10.1016/j.cclet.2023.109221
4. [4]
  Yijia Jiao , Yuzhu Li , Yuting Zhou , Peipei Cen , Yi Ding , Yan Guo , Xiangyu Liu . Structural evolution and zero-field SMM behaviour in ferromagnetically-coupled disk-type Co₇ clusters bearing exclusively end-on azido bridges. Chinese Chemical Letters, 2024, 35(8): 109082-. doi: 10.1016/j.cclet.2023.109082
5. [5]
  Yubang Li , Xixi Hu , Daiqian Xie . The microscopic formation mechanism of O + H2 products from photodissociation of H2O. Chinese Journal of Structural Chemistry, 2024, 43(5): 100274-100274. doi: 10.1016/j.cjsc.2024.100274
6. [6]
  Xingyan Liu , Chaogang Jia , Guangmei Jiang , Chenghua Zhang , Mingzuo Chen , Xiaofei Zhao , Xiaocheng Zhang , Min Fu , Siqi Li , Jie Wu , Yiming Jia , Youzhou He . Single-atom Pd anchored in the porphyrin-center of ultrathin 2D-MOFs as the active center to enhance photocatalytic hydrogen-evolution and NO-removal. Chinese Chemical Letters, 2024, 35(9): 109455-. doi: 10.1016/j.cclet.2023.109455
7. [7]
  Hongyu Tang , Dongming Liu , Jinfu Huang , Liang Zhang , Yang Tang , Bin Huang , Yanwei Li , Shunhua Xiao , Yiling Sun , Renheng Wang . Excellent structural stability and electrochemical properties of LiNi_0.9Co_0.05Mn_0.05O₂ material by surface Ni²⁺ anchoring and Cs⁺ doping. Chinese Chemical Letters, 2025, 36(6): 109987-. doi: 10.1016/j.cclet.2024.109987
8. [8]
  Xiaoxu Duan , Junli Xu , Jiwei Li , Congcong Du , Kai Chen , Teng Xu , Yifei Sun , Haifeng Xiong . Enhancing CO₂ reduction efficiency with axial oxygen coordinated Ni-N₄ active sites on hierarchical pore N-doped carbon. Chinese Chemical Letters, 2025, 36(7): 110340-. doi: 10.1016/j.cclet.2024.110340
9. [9]
  Yongjian Li , Xinyu Zhu , Chenxi Wei , Youyou Fang , Xinyu Wang , Yizhi Zhai , Wenlong Kang , Lai Chen , Duanyun Cao , Meng Wang , Yun Lu , Qing Huang , Yuefeng Su , Hong Yuan , Ning Li , Feng Wu . Unraveling the chemical and structural evolution of novel Li-rich layered/rocksalt intergrown cathode for Li-ion batteries. Chinese Chemical Letters, 2024, 35(12): 109536-. doi: 10.1016/j.cclet.2024.109536
10. [10]
  Weiping Xiao , Yuhang Chen , Qin Zhao , Danil Bukhvalov , Caiqin Wang , Xiaofei Yang . Constructing the synergistic active sites of nickel bicarbonate supported Pt hierarchical nanostructure for efficient hydrogen evolution reaction. Chinese Chemical Letters, 2024, 35(12): 110176-. doi: 10.1016/j.cclet.2024.110176
11. [11]
  Yu Xiong , Li-Jun Hu , Jian-Guo Song , Di Zhang , Yi-Shuang Peng , Xiao-Jun Huang , Jian Hong , Bin Zhu , Wen-Cai Ye , Ying Wang . Structure elucidation of plumerubradins A–C: Correlations between ¹H NMR signal patterns and structural information of [2+2]-type cyclobutane derivatives. Chinese Chemical Letters, 2025, 36(5): 110149-. doi: 10.1016/j.cclet.2024.110149
12. [12]
  Yan-Jiang Li , Shu-Lei Chou , Yao Xiao . Detecting dynamic structural evolution based on in-situ high-energy X-ray diffraction technology for sodium layered oxide cathodes. Chinese Chemical Letters, 2025, 36(2): 110389-. doi: 10.1016/j.cclet.2024.110389
13. [13]
  Yaping ZHANG , Tongchen WU , Yun ZHENG , Bizhou LIN . Z-scheme heterojunction β-Bi₂O₃ pillared CoAl layered double hydroxide nanohybrid: Fabrication and photocatalytic degradation property. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 531-539. doi: 10.11862/CJIC.20240256
14. [14]
  Xinyu Yin , Haiyang Shi , Yu Wang , Xuefei Wang , Ping Wang , Huogen Yu . Spontaneously Improved Adsorption of H₂O and Its Intermediates on Electron-Deficient Mn^(3+δ)+ for Efficient Photocatalytic H₂O₂ Production. Acta Physico-Chimica Sinica, 2024, 40(10): 2312007-0. doi: 10.3866/PKU.WHXB202312007
15. [15]
  Bicheng Zhu , Jingsan Xu . S-scheme heterojunction photocatalyst for H2 evolution coupled with organic oxidation. Chinese Journal of Structural Chemistry, 2024, 43(8): 100327-100327. doi: 10.1016/j.cjsc.2024.100327
16. [16]
  Weichen WANG , Chunhua GONG , Junyong ZHANG , Yanfeng BI , Hao XU , Jingli XIE . Construction of two metal-organic frameworks by rigid bis(triazole) and carboxylate mixed-ligands and their catalytic properties for CO₂ cycloaddition reaction. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1377-1386. doi: 10.11862/CJIC.20230415
17. [17]
  Zuyou Song , Yong Jiang , Qiao Gou , Yini Mao , Yimin Jiang , Wei Shen , Ming Li , Rongxing He . Promoting the generation of active sites through "Co-O-Ru" electron transport bridges for efficient water splitting. Chinese Chemical Letters, 2025, 36(4): 109793-. doi: 10.1016/j.cclet.2024.109793
18. [18]
  Yu-Yao Li , Xiao-Hui Li , Zhi-Xuan An , Yang Chu , Xiu-Li Wang . Room-temperature olefin epoxidation reaction by two 2D cobalt metal-organic complexes under O₂ atmosphere: Coordination and structural regulation. Chinese Chemical Letters, 2025, 36(4): 109716-. doi: 10.1016/j.cclet.2024.109716
19. [19]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
20. [20]
  Yongheng Ren , Yang Chen , Hongwei Chen , Lu Zhang , Jiangfeng Yang , Qi Shi , Lin-Bing Sun , Jinping Li , Libo Li . Electrostatically driven kinetic Inverse CO2/C2H2 separation in LTA-type zeolites. Chinese Journal of Structural Chemistry, 2024, 43(10): 100394-100394. doi: 10.1016/j.cjsc.2024.100394

Get Citation

PDF

XML

Metrics

PDF Downloads(5)
Abstract views(761)
HTML views(47)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Structural evolution of a bituminous coal char related to its synchronized gasification behavior with H2O and/or CO2

Metrics

通讯作者: 陈斌, bchen63@163.com

Structural evolution of a bituminous coal char related to its synchronized gasification behavior with H₂O and/or CO₂