Citation: HAN Feng, ZHANG Yan-guo, MENG Ai-hong, LI Qing-hai. Evolution of gaseous products and analysis of methane generation reaction types during pyrolysis of Shuicheng lignite[J]. Journal of Fuel Chemistry and Technology, ;2014, 42(1): 7-12. shu

Evolution of gaseous products and analysis of methane generation reaction types during pyrolysis of Shuicheng lignite

1.
Key Laboratory for Thermal Science and Power Engineering of Ministry of Education, Beijing Key Laboratory for CO₂ Utilization and Reduction Technology, Tsinghua University, Beijing 100084, China

Corresponding author: ZHANG Yan-guo,
Received Date: 10 July 2013
Available Online: 5 September 2013
Fund Project: 国家重点基础研究发展规划(973计划,2011CB201502) (973计划,2011CB201502)云南省科技创新强省计划(2010AD010) (2010AD010)云南省重大科技专项—新能源(2012ZB006)。 (2012ZB006)

The Fourier transform infrared (FT-IR) spectroscopy was applied to investigate the functional groups of Shuicheng lignite, and the simultaneous thermogravimetry-mass spectrometry (TG/MS) at heating rate of 10 ℃/min was used to investigate the pyrolysis behavior of coal. The instantaneous evolution of the gaseous products (H₂, CH₄, H₂O, CO, CO₂) was studied by means of temperature-programmed pyrolysis experiments. The pyrolytic generation characteristics of methane was specially analyzed. Five peaks were fitted and the kinetic parameters were calculated by the fitting of curves. By the kinetic analysis combined with structure analysis, pyrolysis characteristics and the evolution features of other volatiles during pyrolysis, it is found that the lowest temperature peak represents the desorption of adsorbed methane in coal and the other four peaks are the results of methane generation during pyrolysis, which involves four types of reactions.
- functional group,
- pyrolysis,
- mass spectrometry,
- methane,
- Shuicheng lignite
1. [1]
  [1] ÖZTASN A, YÜRÜM Y. Pyrolysis of Turkish Zonguldak bituminous coal. Part 1. Effect of mineral matter[J]. Fuel, 2000, 79(10): 1221-1227.
2. [2]
  [2] PORADA S. The reactions of formation of selected gas products during coal pyrolysis[J]. Fuel, 2004, 83(9): 1191-1196.
3. [3]
  [3] CRAMER B. Methane generation from coal during open system pyrolysis investigated by isotope specific, Gaussian distributed reaction kinetics[J]. Org Geochem, 2004, 35(4): 379-392.
4. [4]
  [4] 朱学栋, 朱子彬. 煤热失重动力学的研究[J]. 高校化学工程学报, 1999, 13(3): 223-228. (ZHU Xue-dong, ZHU Zi-bin. Study of the coal pyrolytic kinetics by thermogrametry[J]. Journal of Chemical Engineering of Chinese Universities, 1999, 13(3): 223-228.)
5. [5]
  [5] 吕太, 张翠珍, 吴超. 粒径和升温速率对煤热分解影响的研究[J]. 煤炭转化, 2005, 28(1): 17-20. (LV Tai, ZHANG Cui-zhen, WU Chao. Study on the effect of coal diameter and heating rate on the coal pyrolysis[J]. Coal Conversion, 2005, 28(1): 17-20.)
6. [6]
  [6] ARENILLAS A, RUBIERA F, PIS J J. Simultaneous thermogravimetric-mass spectrometric study on the pyrolysis behaviour of different rank coals[J]. Analy Appl Pyrolysis, 1999, 50(1): 31-46.
7. [7]
  [7] GEORGAKOPOULOS A. Study of low rank Greek coals using FTIR spectroscopy[J]. Energy Sources, 2003, 25(10): 995-1005.
8. [8]
  [8] BARUAH M K, GOGOI P C. A new form of sulphur in coal: The discovery of an iron-sulphur coordination compound[J]. Fuel, 1998, 77(9): 979-985.
9. [9]
  [9] 庞博, 戴和武. 兴隆庄煤显微组份热解失重及热解反应动力学的研究[J]. 燃料化学学报, 1989, 17(1): 1-7. (PANG Bo, DAI He-wu. Weight loss determination and pyrolytic kinetics study on Xing-long-zhuang Coal macerals[J]. Journal of Fuel Chemistry and Technology, 1989, 17(1): 1-7.)
10. [10]
  [10] 朱学栋, 朱子彬. 煤化程度和升温速率对热分解影响的研究[J]. 煤炭转化, 1999, 22(2): 43-47. (ZHU Xue-dong, ZHU Zi-bin. Study on the effect of coal rank and heating rate on the pyrolysis[J]. Coal Conversion, 1999, 22(2): 43-47.)
11. [11]
  [11] 沈兴. 差热, 热重分析与非等温固相反应动力学[M]. 北京: 冶金工业出版社, 1995: 75-76. (SHEN Xing. DTA, TGA and non-isothermal kinetics of solid-reactions[M]. Beijing: Metallurgical Industry Press, 1995: 75-76.)
12. [12]
  [12] JÜNTGEN H. Review of the kinetics of pyrolysis and hydropyrolysis in relation to the chemical constitution of coal[J]. Fuel, 1984, 63(6): 731-737.
13. [13]
  [13] 李美芬, 曾凡桂, 贾建波, 谢克昌. 三种高变质程度煤热解过程中H₂的逸出特征研究[J]. 燃料化学学报, 2007, 35(2): 237-240. (LI Mei-fen, ZENG Fan-gui, JIA Jian-bo, XIE Ke-chang. TG/MS study on evolution characteristics of hydrogen from pyrolysis of three high rank coals[J]. Journal of Fuel Chemistry and Technology, 2007, 35(2): 237-240.)
14. [14]
  [14] ARENILLAS A, RUBIERA F, PIS J J. Simultaneous thermogravimetric-mass spectrometric study on the pyrolysis behaviour of different rank coals[J]. J Anal Appl Pyrolysis, 1999, 50(1): 31-46.
15. [15]
  [15] 刘生玉, 王宝俊, 谢克昌. 镜煤抽提物热解特性的实验研究[J]. 燃料化学学报, 2003, 31(5): 420-425. (LIU Sheng-yu, WANG Bao-jun, XIE Ke-chang. Experimental study on pyrolysis of extract from vitrain[J]. Journal of Fuel Chemistry and Technology, 2003, 31(5): 420-425.)
16. [16]
  [16] 闫金定, 崔洪, 杨建丽, 刘振宇. 热重质谱联用研究兖州煤的热解行为[J]. 中国矿业大学学报, 2003, 32(3): 311-315. (YAN Jin-ding, CUI Hong, YANG Jian-li, LIU Zhen-yu. Research on pyrolysis behavior of Yanzhou coal using TG/MS[J]. Journal of China University of Mining & Technology, 2003, 32(3): 311-315.)
17. [17]
  [17] VAN HEEK K H, HODEK W. Structure and pyrolysis behaviour of different coals and relevant model substances[J]. Fuel, 1994, 73(6): 886-896.
18. [18]
  [18] 傅献彩, 沈文霞, 姚天扬. 物理化学(下册)[M]. 4版. 北京: 高等教育出版社, 1993: 751-752. (FU Xian-cai, SHEN Wen-xia, YAO Tian-yang. Physical chemistry, volume 2[M]. 4th ed. Beijing: High Education Press, 1993: 751-752.)
19. [19]
  [19] WEISHAUPTOVA Z, MEDEK J, KOVÁĶ L. Bond forms of methane in porous system of coal Ⅱ[J]. Fuel, 2004, 83(13): 1759-1764.
20. [20]
  [20] ALEXEEV A D, ULYANOVA E V, STARIKOV G P, KOVRIGA N N. Latent methane in fossil coals[J]. Fuel, 2004, 83(10): 1407-1411.
21. [21]
  [21] SAVAGE P E. Mechanisms and kinetics models for hydrocarbon pyrolysis[J]. J Anal Appl Pyrolysis, 2000, 54(1): 109-126.
22. [22]
  [22] 曾凡桂, 贾建波. 霍林河褐煤热解甲烷生成反应类型及动力学的热重-质谱实验与量子化学计算[J]. 物理化学学报, 2009, 25(6): 1117-1124. (ZENG Fan-gui, JIA Jian-bo. Reaction types and kinetics of methane generation from Huolinhe lignite pyrolysis by TG/MS experiment and quantum chemical calculations[J]. Acta Physico-Chimica Sinica, 2009, 25(6): 1117-1124.)
23. [23]
  [23] PORADA S. The reactions of formation of selected gas products during coal pyrolysis[J]. Fuel, 2004, 83(9): 1191-1196.
1. [1]
  Wei Shao , Wanqun Zhang , Pingping Zhu , Wanqun Hu , Qiang Zhou , Weiwei Li , Kaiping Yang , Xisheng Wang . Design and Practice of Ideological and Political Cases in the Course of Instrument Analysis Experiment: Taking the GC-MS Experiment as an Example. University Chemistry, 2024, 39(2): 147-154. doi: 10.3866/PKU.DXHX202309048
2. [2]
  Feifei Yang , Wei Zhou , Chaoran Yang , Tianyu Zhang , Yanqiang Huang . Enhanced Methanol Selectivity in CO₂ Hydrogenation by Decoration of K on MoS₂ Catalyst. Acta Physico-Chimica Sinica, 2024, 40(7): 2308017-0. doi: 10.3866/PKU.WHXB202308017
3. [3]
  Xinyu Zhu , Meili Pang . Application of Functional Group Addition Strategy in Organic Synthesis. University Chemistry, 2024, 39(3): 218-230. doi: 10.3866/PKU.DXHX202308106
4. [4]
  Wen Jiang , Jieli Lin , Zhongshu Li . 低配位含磷官能团的研究进展. University Chemistry, 2025, 40(8): 138-151. doi: 10.12461/PKU.DXHX202409144
5. [5]
  Yuanyuan Ping , Wangqing Kong . 光催化碳氢键官能团化合成1-苯基-1,2-乙二醇. University Chemistry, 2025, 40(6): 238-247. doi: 10.12461/PKU.DXHX202408092
6. [6]
  Danqing Wu , Jiajun Liu , Tianyu Li , Dazhen Xu , Zhiwei Miao . Research Progress on the Simultaneous Construction of C—O and C—X Bonds via 1,2-Difunctionalization of Olefins through Radical Pathways. University Chemistry, 2024, 39(11): 146-157. doi: 10.12461/PKU.DXHX202403087
7. [7]
  Jie ZHAO , Huili ZHANG , Xiaoqing LU , Zhaojie WANG . Theoretical calculations of CO₂ capture and separation by functional groups modified 2D covalent organic framework. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 275-283. doi: 10.11862/CJIC.20240213
8. [8]
  Zian Lin , Yingxue Jin . Matrix-Assisted Laser Desorption/Ionization Mass Spectrometry (MALDI-MS) for Disease Marker Screening and Identification: A Comprehensive Experiment Teaching Reform in Instrumental Analysis. University Chemistry, 2024, 39(11): 327-334. doi: 10.12461/PKU.DXHX202403066
9. [9]
  Wen YANG , Didi WANG , Ziyi HUANG , Yaping ZHOU , Yanyan FENG . La promoted hydrotalcite derived Ni-based catalysts: In situ preparation and CO₂ methanation performance. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 561-570. doi: 10.11862/CJIC.20230276
10. [10]
  Wenlong Wang , Wentao Hao , Lang He , Jia Qiao , Ning Li , Chaoqiu Chen , Yong Qin . Bandgap and adsorption engineering of carbon dots/TiO₂ S-scheme heterojunctions for enhanced photocatalytic CO₂ methanation. Acta Physico-Chimica Sinica, 2025, 41(9): 100116-0. doi: 10.1016/j.actphy.2025.100116
11. [11]
  Yinuo Wang , Siran Wang , Yilong Zhao , Dazhen Xu . Selective Synthesis of Diarylmethyl Anilines and Triarylmethanes via Multicomponent Reactions: Introduce a Comprehensive Experiment of Organic Chemistry. University Chemistry, 2024, 39(8): 324-330. doi: 10.3866/PKU.DXHX202401063
12. [12]
  Lina Guo , Ruizhe Li , Chuang Sun , Xiaoli Luo , Yiqiu Shi , Hong Yuan , Shuxin Ouyang , Tierui Zhang . Effect of Interlayer Anions in Layered Double Hydroxides on the Photothermocatalytic CO₂ Methanation of Derived Ni-Al₂O₃ Catalysts. Acta Physico-Chimica Sinica, 2025, 41(1): 100002-0. doi: 10.3866/PKU.WHXB202309002
13. [13]
  Hao Wu , Zhen Liu , Dachang Bai . ¹H NMR Spectrum of Amide Compounds. University Chemistry, 2024, 39(3): 231-238. doi: 10.3866/PKU.DXHX202309020
14. [14]
  Kexin Yan , Zhaoqi Ye , Lingtao Kong , He Li , Xue Yang , Yahong Zhang , Hongbin Zhang , Yi Tang . Seed-Induced Synthesis of Disc-Cluster Zeolite L Mesocrystals with Ultrashort c-Axis: Morphology Control, Decoupled Mechanism, and Enhanced Adsorption. Acta Physico-Chimica Sinica, 2024, 40(9): 2308019-0. doi: 10.3866/PKU.WHXB202308019
15. [15]
  Zhuo WANG , Junshan ZHANG , Shaoyan YANG , Lingyan ZHOU , Yedi LI , Yuanpei LAN . Preparation and photocatalytic performance of CeO₂-reduced graphene oxide by thermal decomposition. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1708-1718. doi: 10.11862/CJIC.20240067
16. [16]
  Yang Lv , Yingping Jia , Yanhua Li , Hexiang Zhong , Xinping Wang . Integrating the Ideological Elements with the “Chemical Reaction Heat” Teaching. University Chemistry, 2024, 39(11): 44-51. doi: 10.12461/PKU.DXHX202402059
17. [17]
  Yang ZHOU , Lili YAN , Wenjuan ZHANG , Pinhua RAO . Thermal regeneration of biogas residue biochar and the ammonia nitrogen adsorption properties. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1574-1588. doi: 10.11862/CJIC.20250032
18. [18]
  Yue-Zhou Zhu , Kun Wang , Shi-Sheng Zheng , Hong-Jia Wang , Jin-Chao Dong , Jian-Feng Li . Application and Development of Electrochemical Spectroscopy Methods. Acta Physico-Chimica Sinica, 2024, 40(3): 2304040-0. doi: 10.3866/PKU.WHXB202304040
19. [19]
  Limei CHEN , Mengfei ZHAO , Lin CHEN , Ding LI , Wei LI , Weiye HAN , Hongbin WANG . Preparation and performance of paraffin/alkali modified diatomite/expanded graphite composite phase change thermal storage material. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 533-543. doi: 10.11862/CJIC.20230312
20. [20]
  Yuting Bai , Cenqi Yan , Zhen Li , Jiaqiang Qin , Pei Cheng . Preparation of High-Strength Polyimide Porous Films with Thermally Closed Pore Property by In Situ Pore Formation Method. Acta Physico-Chimica Sinica, 2024, 40(9): 2306010-0. doi: 10.3866/PKU.WHXB202306010

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(601)
HTML views(40)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142