Citation: MAO Qiao-ting, HU Jun-hao, ZHAO Yu-jia, YAN Shu-hang, YANG Hai-ping, CHEN Han-ping. Synergistic effect during biomass and waste plastics co-pyrolysis[J]. Journal of Fuel Chemistry and Technology, ;2020, 48(3): 286-292. shu

Synergistic effect during biomass and waste plastics co-pyrolysis

State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology, Wuhan 430074, China

Corresponding author: YANG Hai-ping, yhping2002@163.com
Received Date: 17 December 2019
Revised Date: 1 March 2020

Fund Project: The project was supported by the National Key Research and Development Program of China 2018YFB1501403the China Postdoctoral Science Foundation 2019M662617The project was supported by the National Key Research and Development Program of China (2018YFB1501403), the National Natural Science Foundation of China (51906082) and the China Postdoctoral Science Foundation (2019M662617)the National Natural Science Foundation of China 51906082

Figures(6)

Polypropylene (PP) and bamboo were selected as typical representatives of waste plastics and biomass. And the biomass and plastic co-pyrolysis weight loss, kinetic mechanism and product distribution were studied by thermogravimetric analyzer and fixed-bed reactor. The synergistic mechanism between biomass and plastic during co-pyrolysis was discussed. As the ratio of plastic increases, the ending temperature of co-pyrolysis decreases from 501 to 471℃, while the main temperature range for co-pyrolysis is shortened. What's more, the total activation energy required for the co-pyrolysis decreases when the plastic ratio is below 0.25 and then increases. Comparing the experimental with theoretical data, it is found that the synergistic effect during biomass and waste plastics co-pyrolysis is obvious. Due to the synergistic effect, the total activation energy for co-pyrolysis is much lower than calculated value. In addition, the synergistic effect can promote the conversion of macromolecular volatiles into small-molecule gas, accelerate the generation of hydrocarbons like aromatics and alkanes, and inhibit the formation of oxygen-containing substances like CO₂, phenol, carboxylic acids, furans and ketones.
- waste solids,
- co-pyrolysis,
- kinetic analysis,
- products component,
- synergistic effect
1. [1]
  ISAHAK W N R W, HISHAM M W M, YARMO M A, HIN T Y. A review on bio-oil production from biomass by using pyrolysis method[J]. Renewable Sustainable Energy Rev, 2012,16(8):5910-5923. doi: 10.1016/j.rser.2012.05.039
2. [2]
  AL-SALEM S M, ANTELAVA A, CONSTANTINOU A, MANOS G, DUTTA A. A review on thermal and catalytic pyrolysis of plastic solid waste (PSW)[J]. J Environ Manage, 2017,197:177-198. doi: 10.1016/j.jenvman.2017.03.084
3. [3]
  ZHOU Li-min, WANG Yi-ping, HUANG Qun-wu, CAI Jun-qing. TG analysis and kinetics of biomass/plastic co-pyrolysis[J]. Acta Energ Sol Sin, 2007,28(9):979-983. doi: 10.3321/j.issn:0254-0096.2007.09.008
4. [4]
  BU Q, CHEN K, XIE W, LIU Y Y, GAO M J, KONG X H, CHU Q L, MAO H P. Hydrocarbon rich bio-oil production, thermal behavior analysis and kinetic study of microwave-assisted co-pyrolysis of microwave-torrefied lignin with low density polyethylene[J]. Bioresour Technol, 2019,291121860. doi: 10.1016/j.biortech.2019.121860
5. [5]
  HASSAN H, LIM J K, HAMEED B H. Catalytic co-pyrolysis of sugarcane bagasse and waste high-density polyethylene over faujasite-type zeolite[J]. Bioresour Technol, 2019,284:406-414. doi: 10.1016/j.biortech.2019.03.137
6. [6]
  HASSAN H, HAMEED B H, LIM J K. Co-pyrolysis of sugarcane bagasse and waste high-density polyethylene:Synergistic effect and product distributions[J]. Energy, 2020,191116545. doi: 10.1016/j.energy.2019.116545
7. [7]
  OZSIN G, PUTUN A E. Insights into pyrolysis and co-pyrolysis of biomass and polystyrene:Thermochemical behaviors, kinetics and evolved gas analysis[J]. Energy Convers Manage, 2017,149:675-685. doi: 10.1016/j.enconman.2017.07.059
8. [8]
  CHEN W, LI K X, XIA M W, YANG H P, CHEN Y Q, CHEN X, CHE Q F, CHEN H P. Catalytic deoxygenation co-pyrolysis of bamboo wastes and microalgae with biochar catalyst[J]. Energy, 2018,157:472-482. doi: 10.1016/j.energy.2018.05.149
9. [9]
  WU Hong-xiang, LI Hai-bin, ZHAO Zeng-li. Thermogravimetric analysis and pyrolytic kinetic study on coal/biomas s blends[J]. J Fuel Chem Technol, 2009,37(5):538-545. doi: 10.3969/j.issn.0253-2409.2009.05.005
10. [10]
  LI X Y, LI J, ZHOU G Q, FENG Y, WANG Y J, YU G, DENG S B, HUANG J, WANG B. Enhancing the production of renewable petrochemicals by co-feeding of biomass with plastics in catalytic fast pyrolysis with ZSM-5 zeolites[J]. Appl Catal A:Gen, 2014,481:173-182. doi: 10.1016/j.apcata.2014.05.015
11. [11]
  JAKAB E, VARHEGYI G, FAIX O. Thermal decomposition of polypropylene in the presence of wood-derived materials[J]. J Anal Appl Pyrolysis, 2000,56(2):273-285. doi: 10.1016/S0165-2370(00)00101-7
12. [12]
  PENG Jin-xing, SHAO Qian-jun, CHEN Feng-nong, CHEN Fen-xue, YUAN Bo-zeng. Experimental study on co-liquefaction of bamboo and PE in supercritical ethanol[J]. Acta Energ Sol Sin, 2009,30(8):1139-1144. doi: 10.3321/j.issn:0254-0096.2009.08.027
13. [13]
  BLOCK C, EPHRAIM A, HORTALA W E, MINH D P, VANDECASTEELE C A N. Co-pyrogasification of plastics and biomass, a review[J]. Waste Biomass Valorization, 2019,10(3):483-509. doi: 10.1007/s12649-018-0219-8
14. [14]
  BURRA K G, GUPTA A K. Kinetics of synergistic effects in co-pyrolysis of biomass with plastic wastes[J]. Appl Energy, 2018,220:408-418. doi: 10.1016/j.apenergy.2018.03.117
15. [15]
  XIANG Z P, LIANG J H, HERVAN Z, LIU Y Y, MAO H P, BU Q. Thermal behavior and kinetic study for co-pyrolysis of lignocellulosic biomass with polyethylene over cobalt modified ZSM-5 catalyst by thermogravimetric analysis[J]. Bioresour Technol, 2018,247:804-811. doi: 10.1016/j.biortech.2017.09.178
16. [16]
  BURRA K G, GUPTA A K. Synergistic effects in steam gasification of combined biomass and plastic waste mixtures[J]. Appl Energy, 2018,211:230-236. doi: 10.1016/j.apenergy.2017.10.130
1. [1]
  Yinjie Xu , Suiqin Li , Lihao Liu , Jiahui He , Kai Li , Mengxin Wang , Shuying Zhao , Chun Li , Zhengbin Zhang , Xing Zhong , Jianguo Wang . Enhanced Electrocatalytic Oxidation of Sterols using the Synergistic Effect of NiFe-MOF and Aminoxyl Radicals. Acta Physico-Chimica Sinica, 2024, 40(3): 2305012-0. doi: 10.3866/PKU.WHXB202305012
2. [2]
  Xue Liu , Lipeng Wang , Luling Li , Kai Wang , Wenju Liu , Biao Hu , Daofan Cao , Fenghao Jiang , Junguo Li , Ke Liu . Research on Cu-Based and Pt-Based Catalysts for Hydrogen Production through Methanol Steam Reforming. Acta Physico-Chimica Sinica, 2025, 41(5): 100049-0. doi: 10.1016/j.actphy.2025.100049
3. [3]
  Zhaohu Li , Weidong Wang , Yuhao Liu , Mingzhe Han , Lingling Wei , Huan Jiao . Research on the Safety Management and Disposal of Chemical Laboratory Waste. University Chemistry, 2024, 39(10): 128-136. doi: 10.3866/PKU.DXHX202312090
4. [4]
  Minglei Sun , Zhong-Yong Yuan . Valorization strategies for electrodegradation of nitrogenous wastes in sewage. Acta Physico-Chimica Sinica, 2025, 41(9): 100108-0. doi: 10.1016/j.actphy.2025.100108
5. [5]
  Shuyong Zhang , Yaxian Zhu , Wenqing Zhang , Yuzhi Wang , Jing Lu . Ideological and Political Design of Combustion Heat Measurement Experiment: Determination of Heat Value of Agricultural and Forestry Wastes. University Chemistry, 2024, 39(2): 1-6. doi: 10.3866/PKU.DXHX202303026
6. [6]
  Yaling Chen . Basic Theory and Competitive Exam Analysis of Dynamic Isotope Effect. University Chemistry, 2024, 39(8): 403-410. doi: 10.3866/PKU.DXHX202311093
7. [7]
  Ling Zhang , Jing Kang . Turn Waste into Valuable: Preparation of High-Strength Water-Based Adhesives from Polymethylmethacrylate Wastes: a Comprehensive Chemical Experiments. University Chemistry, 2024, 39(2): 221-226. doi: 10.3866/PKU.DXHX202306075
8. [8]
  Shule Liu . Application of SPC/E Water Model in Molecular Dynamics Teaching Experiments. University Chemistry, 2024, 39(4): 338-342. doi: 10.3866/PKU.DXHX202310029
9. [9]
  Jiayu Gu , Siqi Wang , Jun Ling . Kinetics of Living Copolymerization: A Brief Discussion. University Chemistry, 2025, 40(4): 100-107. doi: 10.12461/PKU.DXHX202406012
10. [10]
  Jinfu Ma , Hui Lu , Jiandong Wu , Zhongli Zou . Teaching Design of Electrochemical Principles Course Based on “Cognitive Laws”: Kinetics of Electron Transfer Steps. University Chemistry, 2024, 39(3): 174-177. doi: 10.3866/PKU.DXHX202309052
11. [11]
  Yeyun Zhang , Ling Fan , Yanmei Wang , Zhenfeng Shang . Development and Application of Kinetic Reaction Flasks in Physical Chemistry Experimental Teaching. University Chemistry, 2024, 39(4): 100-106. doi: 10.3866/PKU.DXHX202308044
12. [12]
  Jiageng Li , Putrama . 数值积分耦合非线性最小二乘法一步确定反应动力学参数. University Chemistry, 2025, 40(6): 364-370. doi: 10.12461/PKU.DXHX202407098
13. [13]
  Xuzhen Wang , Xinkui Wang , Dongxu Tian , Wei Liu . Enhancing the Comprehensive Quality and Innovation Abilities of Graduate Students through a “Student-Centered, Dual Integration and Dual Drive” Teaching Model: A Case Study in the Course of Chemical Reaction Kinetics. University Chemistry, 2024, 39(6): 160-165. doi: 10.3866/PKU.DXHX202401074
14. [14]
  Dexin Tan , Limin Liang , Baoyi Lv , Huiwen Guan , Haicheng Chen , Yanli Wang . Exploring Reverse Teaching Practices in Physical Chemistry Experiment Courses: A Case Study on Chemical Reaction Kinetics. University Chemistry, 2024, 39(11): 79-86. doi: 10.12461/PKU.DXHX202403048
15. [15]
  Jiajie Cai , Chang Cheng , Bowen Liu , Jianjun Zhang , Chuanjia Jiang , Bei Cheng . CdS/DBTSO-BDTO S-scheme photocatalyst for H₂ production and its charge transfer dynamics. Acta Physico-Chimica Sinica, 2025, 41(8): 100084-0. doi: 10.1016/j.actphy.2025.100084
16. [16]
  Shanghua Li , Malin Li , Xiwen Chi , Xin Yin , Zhaodi Luo , Jihong Yu . High-Stable Aqueous Zinc Metal Anodes Enabled by an Oriented ZnQ Zeolite Protective Layer with Facile Ion Migration Kinetics. Acta Physico-Chimica Sinica, 2025, 41(1): 100003-0. doi: 10.3866/PKU.WHXB202309003
17. [17]
  Jichao XU , Ming HU , Xichang CHEN , Chunhui WANG , Leichen WANG , Lingyi ZHOU , Xing HE , Xiamin CHENG , Su JING . Construction and hydrogen peroxide-activated chemodynamic activity of ferrocene?benzoselenadiazole conjugate. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1495-1504. doi: 10.11862/CJIC.20250144
18. [18]
  Zhening Lou , Quanxing Mao , Xiaogeng Feng , Lei Zhang , Xu Xu , Yuyang Zhang , Xueyan Liu , Hongling Kang , Dongyang Feng , Yongku Li . Practice of Implementing Blended Teaching in Shared Analytical Chemistry Course. University Chemistry, 2024, 39(2): 263-269. doi: 10.3866/PKU.DXHX202308089
19. [19]
  Yuanqing Wang , Yusong Pan , Hongwu Zhu , Yanlei Xiang , Rong Han , Run Huang , Chao Du , Chengling Pan . Enhanced Catalytic Activity of Bi₂WO₆ for Organic Pollutants Degradation under the Synergism between Advanced Oxidative Processes and Visible Light Irradiation. Acta Physico-Chimica Sinica, 2024, 40(4): 2304050-0. doi: 10.3866/PKU.WHXB202304050
20. [20]
  Yiying Yang , Dongju Zhang . Elucidating the Concepts of Thermodynamic Control and Kinetic Control in Chemical Reactions through Theoretical Chemistry Calculations: A Computational Chemistry Experiment on the Diels-Alder Reaction. University Chemistry, 2024, 39(3): 327-335. doi: 10.3866/PKU.DXHX202309074

Get Citation

PDF

XML

Metrics

PDF Downloads(13)
Abstract views(1101)
HTML views(278)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142