Citation: NIU Zengyuan, LUO Xin, YE Xiwen, XIU Xiaoli, ZHANG Li, WANG Xin, CHEN Jing. Rapid screening and identification of 22 allergenic disperse dyes in ecological textiles by high performance liquid chromatography- linear ion trap/orbitrap mass spectrometry[J]. Chinese Journal of Chromatography, ;2015, 33(10): 1104-1109. doi: 10.3724/SP.J.1123.2015.04048 shu

Rapid screening and identification of 22 allergenic disperse dyes in ecological textiles by high performance liquid chromatography- linear ion trap/orbitrap mass spectrometry

NIU Zengyuan ^1,, ,
LUO Xin ¹ ,
YE Xiwen ¹ ,
XIU Xiaoli ^1,2 ,
ZHANG Li ^1,3 ,
WANG Xin ¹ ,
CHEN Jing ¹

1.
1. Technical Center for Inspection and Quarantine of Shandong Entry-Exit Inspection and Quarantine Bureau, Qingdao 266002, China;

Corresponding author: NIU Zengyuan,
Received Date: 28 April 2015

Fund Project: 质检公益性行业科研专项(201310062) (201310062)国家质检总局科技项目(2013IK015) (2013IK015)山东出入境检验检疫局科技项目(SK200994). (SK200994)

A rapid screening method based on high performance liquid chromatography-linear ion trap/orbitrap high-resolution mass spectrometry (HPLC-LTQ/Orbitrap MS) for 22 disperse dyes in ecological textiles has been established. The target compounds were extracted by pyridine/water (1:1, v/v) by shaking extraction in 90 ℃ water bath. The extracts were then separated by a CAPCELL PAK C₁₈ column (100 mm×2.0 mm, 5 μm) using gradient elution with acetonitrile-5 mmol/L ammonium acetate containing 0.01% (v/v) formic acid as mobile phases, and finally analyzed by HPLC-LTQ/Orbitrap in positive and negative ESI modes. The retention time and accurate mass of parent ion were used for fast screening of 22 disperse dyes, while the confirmatory analysis was obtained by fragments generated by collision-induced dissociation (CID) MS/MS. Target analysis exhibited high mass accuracy (< 5×10^-6). Each target showed a good linearity in its own concentration range and the correlation coefficient was higher than 0.99. The LOQs were 0.125-2.5 mg/kg. Except for Disperse Yellow 49, the average recoveries of most disperse dyes at three spiked levels were 65%-120%, and the relative standard deviations (n=6) were less than 15%. The method was applied for screening 40 different kinds of textiles, and Disperse Orange 37/76 was detected in one of them. With high selectivity and strong anti-jamming ability, this method is simple, rapid, accurate, and it can be used for the inspection of disperse dyes in textiles.
1. [1]
  [1] Oeko-Tex^®-International Association for Research and Testing in the Field of Textile Ecology. Oeko-Tex Standard 100. (2014-12-24). https://www.oeko-tex.com/en/manufactur- ers/manufacturers.xhtml
2. [2]
  [2] European Communities. Commission Decision of 9 July 2009 Establishing the Ecological Criteria for the Award of the Community Eco-label for Textile Products (2009/567/EC). (2009-07-09). http://eur-lex.europa.eu/search.html?qid=1435755118480&text=2009/567/EC&scope=EURLEX&type=quick&lang=en
3. [3]
  [3] BS EN 71-10: 2005
4. [4]
  [4] GB/T 20383-2006
5. [5]
  [5] García-Lavandeira J, Blanco E, Salgado C, et al. Talanta, 2010, 82: 261
6. [6]
  [6] Fang H W, Chen X, Lu Y P, et al. Journal of Instrumental Analysis (方慧文, 陈曦, 卢跃鹏, 等. 分析测试学报), 2010, 29(12): 1178
7. [7]
  [7] Zhao S H, Wu G, Wu J J, et al. Textile Standard and Quality (赵珊红, 吴刚, 吴俭俭, 等. 纺织标准与质量), 2010(2): 37
8. [8]
  [8] Yang C, Zhao J H, Wang J, et al. J Chromatogr A, 2013, 1300: 38
9. [9]
  [9] DeArmond P D, DiGoregorio A L. J Chromatogr A, 2013, 1305: 154
10. [10]
  [10] Schuhmann K, Herzog R, Schwudke D, et al. Anal Chem, 2011, 83: 5480
11. [11]
  [11] Guo C C, Shi F, Jiang S, et al. J Chromatogr B, 2014, 967: 174
12. [12]
  [12] Jia W, Chu X G, Ling Y, et al. J Chromatogr A, 2014, 1336: 67
13. [13]
  [13] Jia W, Chu X G, Ling Y, et al. J Chromatogr A, 2014, 1347: 122
14. [14]
  [14] Lehner S M, Neumann N K N, Sulyok M, et al. Food Addit Contam, 2011, 28: 1457
15. [15]
  [15] Quifer-Rada P, Vallverdú-Queralt A, Martínez-Huélamo M, et al. Food Chem, 2015, 169: 336
16. [16]
  [16] Zhang L, Luo X, Niu Z Y, et al. J Chromatogr A, 2015, 1386: 22
17. [17]
  [17] Xiu X L, Luo X, Niu Z Y, et al. Chinese Journal of Chromatography (修晓丽, 罗忻, 牛增元, 等. 色谱), 2013, 31(10): 961
18. [18]
  [18] Ye X W, Peng Y, Niu Z Y, et al. Chinese Journal of Chromatography (叶曦雯, 彭燕, 牛增元, 等. 色谱), 2014, 32(9): 1005
19. [19]
  [19] Peng Y, Ye X W, Niu Z Y, et al. Chinese Journal of Chromatography (彭燕, 叶曦雯, 牛增元, 等. 色谱), 2015, 33(4): 377
20. [20]
  [20] ISO 16373-2-2014
21. [21]
  [21] European Communities. Commission Decision of 12 August 2002 Implementing Council Directive 96/23/EC Concerning the Performance of Analytical Methods and the Interpretation of Results. Official Journal of the European Communities. 2002/657/EC. (2002-08-12). http://eur-lex.europa.eu/legal-content/EN/ALL/?uri=CELEX:32002D0657
22. [22]
  [22] Domènech A, Francisco N C, Palacios O, et al. J Chromatogr A, 2014, 1328: 16
23. [23]
  [23] Choi J H, Lamshöft M, Zühlke S, et al. Biomed Chromatogr, 2014, 28: 751
1. [1]
  Yanhui Zhong , Ran Wang , Zian Lin . Analysis of Halogenated Quinone Compounds in Environmental Water by Dispersive Solid-Phase Extraction with Liquid Chromatography-Triple Quadrupole Mass Spectrometry. University Chemistry, 2024, 39(11): 296-303. doi: 10.12461/PKU.DXHX202402017
2. [2]
  Zian Lin , Yingxue Jin . Matrix-Assisted Laser Desorption/Ionization Mass Spectrometry (MALDI-MS) for Disease Marker Screening and Identification: A Comprehensive Experiment Teaching Reform in Instrumental Analysis. University Chemistry, 2024, 39(11): 327-334. doi: 10.12461/PKU.DXHX202403066
3. [3]
  Zunxiang Zeng , Yuling Hu , Yufei Hu , Hua Xiao . Analysis of Plant Essential Oils by Supercritical CO₂Extraction with Gas Chromatography-Mass Spectrometry: An Instrumental Analysis Comprehensive Experiment Teaching Reform. University Chemistry, 2024, 39(3): 274-282. doi: 10.3866/PKU.DXHX202309069
4. [4]
  Mingyang Men , Jinghua Wu , Gaozhan Liu , Jing Zhang , Nini Zhang , Xiayin Yao . 液相法制备硫化物固体电解质及其在全固态锂电池中的应用. Acta Physico-Chimica Sinica, 2025, 41(1): 2309019-. doi: 10.3866/PKU.WHXB202309019
5. [5]
  Chongjing Liu , Yujian Xia , Pengjun Zhang , Shiqiang Wei , Dengfeng Cao , Beibei Sheng , Yongheng Chu , Shuangming Chen , Li Song , Xiaosong Liu . Understanding Solid-Gas and Solid-Liquid Interfaces through Near Ambient Pressure X-Ray Photoelectron Spectroscopy. Acta Physico-Chimica Sinica, 2025, 41(2): 100013-. doi: 10.3866/PKU.WHXB202309036
6. [6]
  Yanan Liu , Yufei He , Dianqing Li . Preparation of Highly Dispersed LDHs-based Catalysts and Testing of Nitro Compound Reduction Performance: A Comprehensive Chemical Experiment for Research Transformation. University Chemistry, 2024, 39(8): 306-313. doi: 10.3866/PKU.DXHX202401081
7. [7]
  Zhaoxuan ZHU , Lixin WANG , Xiaoning TANG , Long LI , Yan SHI , Jiaojing SHAO . Application of poly(vinyl alcohol) conductive hydrogel electrolytes in zinc ion batteries. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 893-902. doi: 10.11862/CJIC.20240368
8. [8]
  Hao Wu , Zhen Liu , Dachang Bai . ¹H NMR Spectrum of Amide Compounds. University Chemistry, 2024, 39(3): 231-238. doi: 10.3866/PKU.DXHX202309020
9. [9]
  Jiandong Liu , Zhijia Zhang , Mikhail Kamenskii , Filipp Volkov , Svetlana Eliseeva , Jianmin Ma . Research Progress on Cathode Electrolyte Interphase in High-Voltage Lithium Batteries. Acta Physico-Chimica Sinica, 2025, 41(2): 100011-. doi: 10.3866/PKU.WHXB202308048
10. [10]
  Tao Jiang , Yuting Wang , Lüjin Gao , Yi Zou , Bowen Zhu , Li Chen , Xianzeng Li . Experimental Design for the Preparation of Composite Solid Electrolytes for Application in All-Solid-State Batteries: Exploration of Comprehensive Chemistry Laboratory Teaching. University Chemistry, 2024, 39(2): 371-378. doi: 10.3866/PKU.DXHX202308057
11. [11]
  Zhuoming Liang , Ming Chen , Zhiwen Zheng , Kai Chen . Multidimensional Studies on Ketone-Enol Tautomerism of 1,3-Diketones By ¹H NMR. University Chemistry, 2024, 39(7): 361-367. doi: 10.3866/PKU.DXHX202311029
12. [12]
  Lingbang Qiu , Jiangmin Jiang , Libo Wang , Lang Bai , Fei Zhou , Gaoyu Zhou , Quanchao Zhuang , Yanhua Cui . 原位电化学阻抗谱监测长寿命热电池Nb₁₂WO₃₃正极材料的高温双放电机制. Acta Physico-Chimica Sinica, 2025, 41(5): 100040-. doi: 10.1016/j.actphy.2024.100040
13. [13]
  Zongyuan Chen , ChunSheng Shi , Yiwen Li , Ganlin Zu , Qiang Jin , Haishan Wang , Fujun Wang , Dekun Yan , Zhijun Guo , Wangsuo Wu . Measurement of Uranium Isotopes in Environmental Water Samples by Alpha-Spectroscopy: Design of an Undergraduate Radiochemistry Experiment. University Chemistry, 2025, 40(4): 353-358. doi: 10.12461/PKU.DXHX202406103
14. [14]
  Simin Fang , Wei Huang , Guanghua Yu , Cong Wei , Mingli Gao , Guangshui Li , Hongjun Tian , Wan Li . Integrating Science and Education in a Comprehensive Chemistry Design Experiment: The Preparation of Copper(I) Oxide Nanoparticles and Its Application in Dye Water Remediation. University Chemistry, 2024, 39(8): 282-289. doi: 10.3866/PKU.DXHX202401023
15. [15]
  Qi Li , Pingan Li , Zetong Liu , Jiahui Zhang , Hao Zhang , Weilai Yu , Xianluo Hu . Fabricating Micro/Nanostructured Separators and Electrode Materials by Coaxial Electrospinning for Lithium-Ion Batteries: From Fundamentals to Applications. Acta Physico-Chimica Sinica, 2024, 40(10): 2311030-. doi: 10.3866/PKU.WHXB202311030
16. [16]
  Feiya Cao , Qixin Wang , Pu Li , Zhirong Xing , Ziyu Song , Heng Zhang , Zhibin Zhou , Wenfang Feng . Magnesium-Ion Conducting Electrolyte Based on Grignard Reaction: Synthesis and Properties. University Chemistry, 2024, 39(3): 359-368. doi: 10.3866/PKU.DXHX202308094
17. [17]
  Wen-Bing Hu . Systematic Introduction of Polymer Chain Structures. University Chemistry, 2025, 40(4): 15-19. doi: 10.3866/PKU.DXHX202401014
18. [18]
  Yuhui Yang , Jintian Luo , Biao Zuo . A Teaching Approach to Polymer Surface and Interface in Undergraduate Polymer Physics Courses. University Chemistry, 2025, 40(4): 126-130. doi: 10.12461/PKU.DXHX202408056
19. [19]
  Laiying Zhang , Yinghuan Wu , Yazi Yu , Yecheng Xu , Haojie Zhang , Weitai Wu . Innovation and Practice of Polymer Chemistry Experiment Teaching for Non-Polymer Major Students of Chemistry: Taking the Synthesis, Solution Property, Optical Performance and Application of Thermo-Sensitive Polymers as an Example. University Chemistry, 2024, 39(4): 213-220. doi: 10.3866/PKU.DXHX202310126
20. [20]
  Wenbing Hu , Jin Zhu . Flipped Classroom Approach in Teaching Professional English Reading and Writing to Polymer Graduates. University Chemistry, 2024, 39(6): 128-131. doi: 10.3866/PKU.DXHX202310015

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(279)
HTML views(73)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142