Citation: LIU Yide, CHEN Jialian, LI Hongzhou, YANG Songwei, LUO Fubin, CHEN Qinghua. Flame Retardant Properties of Synergistic Flame Retardant Polypropylene[J]. Chinese Journal of Applied Chemistry, ;2019, 36(10): 1165-1171. doi: 10.11944/j.issn.1000-0518.2019.10.190184 shu

Flame Retardant Properties of Synergistic Flame Retardant Polypropylene

LIU Yide ^a,b ,
CHEN Jialian ^a,d ,
LI Hongzhou ^a,, ,
YANG Songwei ^a,b ,
LUO Fubin ^a ,
CHEN Qinghua ^a,b,c

a.
College of Environmental Science and Engineering, Fujian Normal University, Fuzhou 350007, China
b.
Polymer Resources Green Recycling Engineering Research Center of the Ministry of Education, Fuzhou 350007, China
c.
Fuqing Branch of Fujian Normal University, Fuzhou 350300, China
d.
Quangang Petrochemical Research Institute of Fujian Normal University, Quanzhou, Fujian 362000, China

Corresponding author: LI Hongzhou, lihongzhou@fjnu.edu.cn
Received Date: 3 July 2019
Revised Date: 15 August 2019
Accepted Date: 3 September 2019

Fund Project: Supported by the Foundation of Quangang Petrochemical Research Institute, Fujian Normal University(No.2018YJY03)the Foundation of Quangang Petrochemical Research Institute, Fujian Normal University 2018YJY03

Figures(6)

In this paper, the synergistic flame retardant system with ammonium polyphosphate (APP) as the main flame retardant, aluminum hypophosphite (AHP) and melamine cyanurate (MCA) as auxiliary flame retardants was investigated for the flame retardant performance of polypropylene (PP). The flame retardant properties of the prepared flame retardant samples were analyzed by vertical burning test, limiting oxygen index (LOI) test, thermogravimetric analysis, cone calorimeter test and scanning electron microscopy. The results show that the addition of 30% mass fraction of any flame retardant alone can not achieve good flame retardant properties of PP. When the total mass fraction of additives is kept at 30%, mass ratio APP:AHP:MCA=4:1:1, the ideal flame retardancy is obtained, LOI of the flame retardant PP is 33%, the vertical burning test reaches Ⅴ-0 level, and the peak heat release rate (PHRR) is reduced from 765.7 kW/m² to 122.7 kW/m².
- polypropylene,
- synergistic system,
- cone calorimetry,
- flame retardancy
1. [1]
  AN Fangcheng. Development Status and Market Analysis of Polypropylene Industry[J]. Chem Ind Chem Eng Prog, 2012,31(1):246-251.
2. [2]
  LIAO Kairong, LU Zejian, WANG Jian. Modification of Ammonium Polyphosphate and Flame Retardant Effect on Polypropylene[J]. Polym Mater Sci Eng, 1998,14(4):88-93.
3. [3]
  GUAN Yahui, WANG Xiuli, DENG Cong. Research of Flame Retardant Modification of Polypropylene Wood-Plastic Composites Based on Aluminum Phosphate[J]. Chem Res Appl, 2019,31(1):88-89.
4. [4]
  HUANG Weiguang. Application Status and Prospects of Flame Retardants[N]. Sichuan Economic Daily, 2017-12-06(006)(in Chinese).
5. [5]
  ZHANG Yue. Market Analysis of Flame Retardants at Domestic and Foreign[J]. Fine Spec Chem, 2014,22(8):20-24. doi: 10.3969/j.issn.1008-1100.2014.08.004
6. [6]
  Liang J Z, Zhang Y J. A Study of the Flame-Retardant Properties of Polypropylene/Al(OH)₃/Mg(OH)₂, Composites[J]. Polym Int, 2010,59(4):539-542. doi: 10.1002/pi.2733
7. [7]
  Xu M J, Wang J, Ding Y H. Synergistic Effects of Aluminum Hypophosphite on Intumescent Flame Retardant Polypropylene System[J]. Chinese J Polym Sci, 2015,33(2):318-328. doi: 10.1007/s10118-015-1588-0
8. [8]
  YUAN Yizhong. Synthesis of New Halogen-Free Flame Retardant of Melamine Cyanurate(MCA) Containing Silicone and Application in Polypropylene[J]. Zhejiang Chem Ind, 2013,44(9):27-29. doi: 10.3969/j.issn.1006-4184.2013.09.008
9. [9]
  Horst B, Wolfram S. Reactions of Methyl(phenyl)silylene with CO and PH₃-the Formation of Acid-Base Complexes[J]. J Organomet Chem, 2002,641:156-164. doi: 10.1016/S0022-328X(01)01363-8
10. [10]
  WANG Jing. Effect of Aluminum Hypophosphite on Expanded Flame Retardant Polypropylene System[D]. Northeast Forest University, 2012(in Chinese).
11. [11]
  HE Xiaofang, ZHANG Cong, DAI Xin. Research Progress in Application of Ammonium Polyphosphate Intumescent Flame Retardants for Polymer[J]. Plast Add, 2011(2):14-17. doi: 10.3969/j.issn.1672-6294.2011.02.004
12. [12]
  Du B X, Guo Z H, Fang Z P. Effects of Organo-Clay and Sodium Dodecyl Sulfonate Intercalated Layered Double Hydroxide on Thermal and Flame Behavior of Intumescent Flame Retarded Polypropylene[J]. Polym Degrad Stab, 2009,94:1979-1985. doi: 10.1016/j.polymdegradstab.2009.07.024
1. [1]
  Caiyun Jin , Zexuan Wu , Guopeng Li , Zhan Luo , Nian-Wu Li . Phosphazene-based flame-retardant artificial interphase layer for lithium metal batteries. Acta Physico-Chimica Sinica, 2025, 41(8): 100094-0. doi: 10.1016/j.actphy.2025.100094
2. [2]
  Zijian Zhao , Yanxin Shi , Shicheng Li , Wenhong Ruan , Fang Zhu , Jijun Jiang . A New Exploration of the Preparation of Polyacrylic Acid by Free Radical Polymerization Based on the Concept of Green Chemistry. University Chemistry, 2024, 39(5): 315-324. doi: 10.3866/PKU.DXHX202311094
3. [3]
  Junke LIU , Kungui ZHENG , Wenjing SUN , Gaoyang BAI , Guodong BAI , Zuwei YIN , Yao ZHOU , Juntao LI . Preparation of modified high-nickel layered cathode with LiAlO₂/cyclopolyacrylonitrile dual-functional coating. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1461-1473. doi: 10.11862/CJIC.20240189
4. [4]
  Ruilan Fan , Xiaoling Huang . 磷源的选择及三种含磷阻燃剂的合成与阻燃性. University Chemistry, 2025, 40(8): 181-191. doi: 10.12461/PKU.DXHX202410025
5. [5]
  Peng XU , Shasha WANG , Nannan CHEN , Ao WANG , Dongmei YU . Preparation of three-layer magnetic composite Fe₃O₄@polyacrylic acid@ZiF-8 for efficient removal of malachite green in water. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 544-554. doi: 10.11862/CJIC.20230239
6. [6]
  Zehua Zhao , Xiaoyan An , Jinrong Xu , Ling Yang , Hao Zhao , Zhongyun Wu . Independent Development and Application of Calorimetric Experiment Data Acquisition and Processing Software. University Chemistry, 2025, 40(11): 402-408. doi: 10.12461/PKU.DXHX202505045
7. [7]
  Lancanghong Chen , Xingtai Yu , Tianlei Zhao , Qizhi Yao . Exploration of Abnormal Phenomena in Iodometric Copper Quantitation Experiment. University Chemistry, 2025, 40(7): 315-320. doi: 10.12461/PKU.DXHX202408089
8. [8]
  Guojie Xu , Fang Yu , Yunxia Wang , Meng Sun . Introduction to Metal-Catalyzed β-Carbon Elimination Reaction of Cyclopropenones. University Chemistry, 2024, 39(8): 169-173. doi: 10.3866/PKU.DXHX202401060
9. [9]
  Zhuoyan Lv , Yangming Ding , Leilei Kang , Lin Li , Xiao Yan Liu , Aiqin Wang , Tao Zhang . Light-Enhanced Direct Epoxidation of Propylene by Molecular Oxygen over CuO_x/TiO₂ Catalyst. Acta Physico-Chimica Sinica, 2025, 41(4): 100038-0. doi: 10.3866/PKU.WHXB202408015
10. [10]
  Xingyang LI , Tianju LIU , Yang GAO , Dandan ZHANG , Yong ZHOU , Meng PAN . A superior methanol-to-propylene catalyst: Construction via synergistic regulation of pore structure and acidic property of high-silica ZSM-5 zeolite. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1279-1289. doi: 10.11862/CJIC.20240026
11. [11]
  Jinglun Wang , Hu Zhou , Baishu Zheng , Guobin Li , Ming Yue , Zhihua Zhou . Exploration and Practice of “Four Cooperations and Four Integrations” to Cultivate Innovative Talents in Chemical Materials in Local Colleges. University Chemistry, 2024, 39(7): 93-98. doi: 10.12461/PKU.DXHX202405013
12. [12]
  Zongpei Zhang , Yanyang Li , Yanan Si , Kai Li , Shuangquan Zang . Developing a Chemistry Experiment Center Employing a Multifaceted Approach to Serve High-Quality Laboratory Education. University Chemistry, 2024, 39(7): 13-19. doi: 10.12461/PKU.DXHX202404041
13. [13]
  Xue-Peng Zhang , Yuchi Long , Yushu Pan , Jiding Wang , Baoyu Bai , Rui Ding . 定量构效关系方法学习探索：以钴卟啉活化氧气为例. University Chemistry, 2025, 40(8): 345-359. doi: 10.12461/PKU.DXHX202410107
14. [14]
  Ping LI , Geng TAN , Xin HUANG , Fuxing SUN , Jiangtao JIA , Guangshan ZHU , Jia LIU , Jiyang LI . Green synthesis of metal-organic frameworks with open metal sites for efficient ammonia capture. Chinese Journal of Inorganic Chemistry, 2025, 41(10): 2063-2068. doi: 10.11862/CJIC.20250020
15. [15]
  Shunü Peng , Huamin Li , Zhaobin Chen , Yiru Wang . Simultaneous Application of Multiple Quantitative Analysis Methods in Gas Chromatography for the Determination of Active Ingredients in Traditional Chinese Medicine Preparations. University Chemistry, 2025, 40(10): 243-249. doi: 10.12461/PKU.DXHX202412043
16. [16]
  Geshan Zhang , Haodong Tang , Zongjian Liu , Feng Feng . Application of the BOPPPS Effective Teaching Model in Bilingual Physical Chemistry Instruction: A Case on Colligative Properties of Dilute Solutions. University Chemistry, 2025, 40(11): 376-381. doi: 10.12461/PKU.DXHX202412127
17. [17]
  Zhou Fang , Zhihao Zhang , Weihan Jiang , Kin Shing Chan . Warfarin: From Poison to Cure, the Remarkable Journey of a Molecule. University Chemistry, 2025, 40(4): 326-330. doi: 10.12461/PKU.DXHX202406038
18. [18]
  Xiaowu Zhang , Pai Liu , Qishen Huang , Shufeng Pang , Zhiming Gao , Yunhong Zhang . Acid-Base Dissociation Equilibrium in Multiphase System: Effect of Gas. University Chemistry, 2024, 39(4): 387-394. doi: 10.3866/PKU.DXHX202310021
19. [19]
  Zhuo WANG , Junshan ZHANG , Shaoyan YANG , Lingyan ZHOU , Yedi LI , Yuanpei LAN . Preparation and photocatalytic performance of CeO₂-reduced graphene oxide by thermal decomposition. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1708-1718. doi: 10.11862/CJIC.20240067
20. [20]
  Yang Lv , Yingping Jia , Yanhua Li , Hexiang Zhong , Xinping Wang . Integrating the Ideological Elements with the “Chemical Reaction Heat” Teaching. University Chemistry, 2024, 39(11): 44-51. doi: 10.12461/PKU.DXHX202402059

Get Citation

PDF

XML

Metrics

PDF Downloads(15)
Abstract views(1783)
HTML views(458)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142