Citation: Hao-ge Cheng, Xu Zhu, Dong Fu, Xin-yue Zhang, Hao Wei, Ning Ma. One-step Fabrication of 2D Micro-hemispheres through the Improved Breath Figure Method[J]. Acta Polymerica Sinica, ;2019, 50(4): 393-401. doi: 10.11777/j.issn1000-3304.2018.18226 shu

One-step Fabrication of 2D Micro-hemispheres through the Improved Breath Figure Method

College of Material Science and Chemical Engineering, Harbin Engineering University, Harbin 150001

Corresponding author: Xin-yue Zhang, xinyue@hrbeu.edu.cn Ning Ma, nma@hrbeu.edu.cn
Received Date: 29 October 2018
Revised Date: 26 November 2018
Available Online: 28 December 2018

Traditional breath figure method was improved via the introduction of polymer pre-phase separation. The morphology and size distribution of microsturctures prepared could be finely tuned by pre-phase separation time, PEG molecular weight, the ratio between different PEG molecules, and blending with small PS molecules. Specifically, compared with 20 and 30 min, the pre-phase separation time of 10 min could yield the most uniform structures; PEG2000 stood out from all PEG molecules tested with molecular weight from 2000 to 10000 and afforded microstructures of the highest compactness and homogeneity; introducing PEG200 the even smaller molecule would enhance the phase separation degree between PS and PEG. Furthermore, ratio variation between PEG200 and PEG2000 suggested that the maximal micro-convexes could be obtained at ratio of 2:8, while a honeycomb morphology was observed at 3:7. Among all the factors investigated, PS molecular weight played a dominant role on topography regulation. PS with lower molecular weight could reduce the molecular chain twisting for all polymer components, which conduced to the polymer phase separation. Addition of PS18000 rather than PS260000 could increase micro-convex amount as well as improve the uniformity of as-prepared structures dramatically. The honeycomb micro-hemisphere arrays were ultimately achieved through one-step breath figure method under the optimized conditions of pre-phase separation time as 10 min, PEG200:PEG2000 ratio as 3:7, and PS18000 participation; in the meantime, three structures including holes, half-holes, and convexes appeared on the substrate. Scrutinize of the underlying mechanism indicated that distribution and assembly of PEG molecules inside or on the surface of water droplets functioned decisively towards the topography of structures formed. This study provides novel insight into highly efficent fabrication of micro-hemispheres arrays.
- Breath figure,
- Polymer phase separation,
- 2D Micro-hemisphere
1. [1]
  Baker R R, Sadovy Y. Nature, 1978, 276: 818 − 821 doi: 10.1038/276818a0
2. [2]
  Brunner R, Sandfuchs O, Pacholski C, Morhard C, Spatz J. Laser Photonics Rev, 2012, 6(5): 641 − 659 doi: 10.1002/lpor.201100011
3. [3]
  Jeong K-H, Kim J, Lee L P. Science, 2006, 312(5773): 557 − 561 doi: 10.1126/science.1123053
4. [4]
  Wu L, He J Q, Shang W, Deng T, Gu J, Su H, Liu Q, Zhang W, Zhang D. Adv Opt Mater, 2016, 4(2): 195 − 224 doi: 10.1002/adom.201500428
5. [5]
  Deng Z, Chen F, Yang Q, Bian H, Du G, Yong J, Shan C, Hou X. Adv Funct Mater, 2016, 26(12): 1995 − 2001 doi: 10.1002/adfm.201504941
6. [6]
  Lee G J, Choi C, Kim D H, Song Y M. Adv Funct Mater, 2018, 28(24): 1705202 doi: 10.1002/adfm.v28.24
7. [7]
  Huo Y, Fesenmaier C C, Catrysse P B. Opt Express, 2010, 18(6): 5861 − 5872 doi: 10.1364/OE.18.005861
8. [8]
  Chang C, Yang S, Huang L, Chang J. Infrared Phys Technol, 2005, 48(2): 163 − 173
9. [9]
  Kunnavakkam M V, Houlihan F M, Schlax M, Liddle J A, Kolodner P, Nalamasu O, Rogers J A. Appl Phys Lett, 2003, 82(8): 1152 − 1154 doi: 10.1063/1.1555694
10. [10]
  Gissibl T, Thiele S, Herkommer A, Giessen H. Nat Photon, 2016, 10(8): 554 − 560 doi: 10.1038/nphoton.2016.121
11. [11]
  Kuang M, Wang L, Song Y. Adv Mater, 2014, 26(40): 6950 − 6958 doi: 10.1002/adma.v26.40
12. [12]
  Srinivasarao M, Collings D, Philips A, Patel S. Science, 2001, 292(5514): 79 − 83 doi: 10.1126/science.1057887
13. [13]
  Bai H, Du C, Zhang A, Li L. Angew Chem Int Ed, 2013, 52(47): 12240 − 12255 doi: 10.1002/anie.201303594
14. [14]
15. [15]
  Wang C, Mao Y, Wang D, Qu Q, Yang G, Hu X. J Mater Chem, 2008, 18(6): 683 − 690 doi: 10.1039/b715520d
16. [16]
  Wang W, Du C, Wang X, He X, Lin Ji, Li L, Lin S. Angew Chem Int Ed, 2014, 53(45): 12116 − 12119 doi: 10.1002/anie.201407230
17. [17]
  Galeotti F, Mroz W, Scavia G, Botta C. Org Electron, 2012, 14(1): 212 − 218
18. [18]
  Gong J, Xu B, Tao X. ACS Appl Mater Interfaces, 2017, 9(5): 4988 − 4997 doi: 10.1021/acsami.6b14729
19. [19]
  Daly Ronan, Sader J E, Boland J J. ACS Nano, 2016, 10(3): 3087 − 3092 doi: 10.1021/acsnano.5b06082
20. [20]
  Thong A Z, Lim D S W, Ahsan A, Goh G T W, Xu J, Chin J M. Chem Sci, 2014, 5(4): 1375 − 1382 doi: 10.1039/C3SC52258J
21. [21]
  Heng L, Li J, Li M, Tian D, Fan L Z, Jiang L, Tang B Z. Adv Funct Mater, 2014, 24(46): 7241 − 7248 doi: 10.1002/adfm.v24.46
22. [22]
  Okaji R, Sakashita S, Tazumi K, Taki K, Nagamine S, Ohshima M. J Mater Sci, 2013, 48(5): 2038 − 2045 doi: 10.1007/s10853-012-6973-2
23. [23]
  Kim J K, Taki K, Nagamine S, Ohshima M. J Appl Polym Sci, 2009, 111(5): 2518 − 2526 doi: 10.1002/app.v111:5
24. [24]
  Kim J K, Taki K, Nagamine S, Ohshima M. Langmuir, 2008, 24(16): 8898 − 8903 doi: 10.1021/la8000398
25. [25]
  Guo X, Liu L, Zhuang Z, Chen X, Ni M, Li Y, Cui Y, Zhan P, Yuan C, Ge H, Wang Z, Chen Y. Sci Rep, 2016, 5: 15947
1. [1]
  You Wu , Chang Cheng , Kezhen Qi , Bei Cheng , Jianjun Zhang , Jiaguo Yu , Liuyang Zhang . ZnO/D-A共轭聚合物S型异质结高效光催化产H₂O₂及其电荷转移动力学研究. Acta Physico-Chimica Sinica, 2024, 40(11): 2406027-. doi: 10.3866/PKU.WHXB202406027
2. [2]
  Junjie Zhang , Yue Wang , Qiuhan Wu , Ruquan Shen , Han Liu , Xinhua Duan . Preparation and Selective Separation of Lightweight Magnetic Molecularly Imprinted Polymers for Trace Tetracycline Detection in Milk. University Chemistry, 2024, 39(5): 251-257. doi: 10.3866/PKU.DXHX202311084
3. [3]
  Liyong Ding , Zhenhua Pan , Qian Wang . 2D photocatalysts for hydrogen peroxide synthesis. Chinese Chemical Letters, 2024, 35(12): 110125-. doi: 10.1016/j.cclet.2024.110125
4. [4]
  Liqiang Huang , Peng Lin . 数-图分析法解释仪器分析实验课程教学中的难点. University Chemistry, 2025, 40(6): 353-359. doi: 10.12461/PKU.DXHX202407074
5. [5]
  Zhongxin YU , Wei SONG , Yang LIU , Yuxue DING , Fanhao MENG , Shuju WANG , Lixin YOU . Fluorescence sensing on chlortetracycline of a Zn-coordination polymer based on mixed ligands. Chinese Journal of Inorganic Chemistry, 2024, 40(12): 2415-2421. doi: 10.11862/CJIC.20240304
6. [6]
  Li Li , Xue Ke , Shan Wang , Zhuo Jiang , Yuzheng Guo , Chunguang Kuai . Antioxidative strategies of 2D MXenes in aqueous energy storage system. Chinese Chemical Letters, 2025, 36(5): 110423-. doi: 10.1016/j.cclet.2024.110423
7. [7]
  Bao Jia , Yunzhe Ke , Shiyue Sun , Dongxue Yu , Ying Liu , Shuaishuai Ding . Innovative Experimental Teaching for the Preparation and Modification of Conductive Organic Polymer Thin Films in Undergraduate Courses. University Chemistry, 2024, 39(10): 271-282. doi: 10.12461/PKU.DXHX202404121
8. [8]
  Xiao SANG , Qi LIU , Jianping LANG . Synthesis, structure, and fluorescence properties of Zn(Ⅱ) coordination polymers containing tetra-alkenylpyridine ligands. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2124-2132. doi: 10.11862/CJIC.20240158
9. [9]
  Xuefei Leng , Yanshai Wang , Hai Wang , Shengyang Tao . The In-Depth integration of “Industry-University-Research” in the Exploration and Practice of “Comprehensive Training in Polymer Engineering”. University Chemistry, 2025, 40(4): 66-71. doi: 10.12461/PKU.DXHX202405105
10. [10]
  Ruiying WANG , Hui WANG , Fenglan CHAI , Zhinan ZUO , Benlai WU . Three-dimensional homochiral Eu(Ⅲ) coordination polymer and its amino acid configuration recognition. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 877-884. doi: 10.11862/CJIC.20250052
11. [11]
  Yuan Teng , Zichun Zhou , Jinghua Chen , Siying Huang , Hongyan Chen , Daibin Kuang . Dual atom-bridge effect promoting interfacial charge transfer in 2D/2D Cs₃Bi₂Br₉/BiOBr epitaxial heterojunction for efficient photocatalysis. Chinese Chemical Letters, 2025, 36(2): 110430-. doi: 10.1016/j.cclet.2024.110430
12. [12]
  Xingchao Zhao , Xiaoming Li , Ming Liu , Zijin Zhao , Kaixuan Yang , Pengtian Liu , Haolan Zhang , Jintai Li , Xiaoling Ma , Qi Yao , Yanming Sun , Fujun Zhang . 倍增型全聚合物光电探测器及其在光电容积描记传感器上的应用. Acta Physico-Chimica Sinica, 2025, 41(1): 2311021-. doi: 10.3866/PKU.WHXB202311021
13. [13]
  Fanpeng Meng , Fei Zhao , Jingkai Lin , Jinsheng Zhao , Huayang Zhang , Shaobin Wang . 优化氮化碳纳米片/球形共轭聚合物S型异质结界面电场以促进析氢反应. Acta Physico-Chimica Sinica, 2025, 41(8): 100095-. doi: 10.1016/j.actphy.2025.100095
14. [14]
  Chaozheng He , Jia Wang , Ling Fu , Wei Wei . Nitric oxide assists nitrogen reduction reaction on 2D MBene: A theoretical study. Chinese Chemical Letters, 2024, 35(5): 109037-. doi: 10.1016/j.cclet.2023.109037
15. [15]
  Jaeyong Ahn , Zhenping Li , Zhiwei Wang , Ke Gao , Huagui Zhuo , Wanuk Choi , Gang Chang , Xiaobo Shang , Joon Hak Oh . Surface doping effect on the optoelectronic performance of 2D organic crystals based on cyano-substituted perylene diimides. Chinese Chemical Letters, 2024, 35(9): 109777-. doi: 10.1016/j.cclet.2024.109777
16. [16]
  Lili Wang , Ya Yan , Rulin Li , Xujie Han , Jiahui Li , Ting Ran , Jialu Li , Baichuan Xiong , Xiaorong Song , Zhaohui Yin , Hong Wang , Qingjun Zhu , Bowen Cheng , Zhen Yin . Interface engineering of 2D NiFe LDH/NiFeS heterostructure for highly efficient 5-hydroxymethylfurfural electrooxidation. Chinese Chemical Letters, 2024, 35(9): 110011-. doi: 10.1016/j.cclet.2024.110011
17. [17]
  Jinwei Zhang , Lipiao Bao , Xing Lu . Synthesis methodologies of conductive 2D conjugated metal-organic frameworks. Chinese Journal of Structural Chemistry, 2025, 44(4): 100459-100459. doi: 10.1016/j.cjsc.2024.100459
18. [18]
  Dongdong Yao , JunweiGu , Yi Yan , Junliang Zhang , Yaping Zheng . Teaching Phase Separation Mechanism in Polymer Blends Using Process Representation Teaching Method: A Teaching Design for Challenging Theoretical Concepts in “Polymer Structure and Properties” Course. University Chemistry, 2025, 40(4): 131-137. doi: 10.12461/PKU.DXHX202408125
19. [19]
  Changjun You , Chunchun Wang , Mingjie Cai , Yanping Liu , Baikang Zhu , Shijie Li . 引入内建电场强化BiOBr/C₃N₅ S型异质结中光载流子分离以实现高效催化降解微污染物. Acta Physico-Chimica Sinica, 2024, 40(11): 2407014-. doi: 10.3866/PKU.WHXB202407014
20. [20]
  .
  南开大学师唯/华北电力大学（保定）刘景维：二维配位聚合物中有序的亲锂冠醚位点用于无枝晶锂沉积
  . CCS Chemistry, 2025, 7(0): -.

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(165)
HTML views(9)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

One-step Fabrication of 2D Micro-hemispheres through the Improved Breath Figure Method

南开大学师唯/华北电力大学（保定）刘景维：二维配位聚合物中有序的亲锂冠醚位点用于无枝晶锂沉积

Metrics

通讯作者: 陈斌, bchen63@163.com