Citation: Ping Chen, Qi Yu, Xu-hai Xiong, Dong Liu, Zhe Liu, Cai-xia Jia. Surface Modification of High Performance Fibers and Interfacial Properties of Their Reinforced Bismaleimide Resin Matrix Composites[J]. Acta Polymerica Sinica, ;2018, (3): 323-335. doi: 10.11777/j.issn1000-3304.2017.17081 shu

Surface Modification of High Performance Fibers and Interfacial Properties of Their Reinforced Bismaleimide Resin Matrix Composites

Ping Chen ^1,, ,
Qi Yu ² ,
Xu-hai Xiong ² ,
Dong Liu ¹ ,
Zhe Liu ¹ ,
Cai-xia Jia ²

1.
State Key Laboratory of Fine Chemicals & School of Chemical Engineering, Dalian University of Technology, Dalian 116024
2.
Liaoning Key Laboratory of Advanced Polymer Matrix Composites, Shenyang Aerospace University, Shenyang 110136

Corresponding author: Ping Chen, Pchen@dlut.edu.cn
Received Date: 7 April 2017
Revised Date: 6 July 2017

Surface modification of high-performance continuous fibers was carried out by inductively coupled plasma (ICP) and dielectric barrier discharge (DBD) cold plasma, respectively. The effects of treatment time, discharge power and pressure on the chemical composition, morphology and wetting ability of the fiber surface were investigated by X-ray photoelectron spectroscopy (XPS), atomic force microscopy (AFM) and dynamic contact angle analysis (DCA). The relationship between interface structure and interfacial adhesion, and the failure mechanism of the fibers reinforced bismaleimide (BMI) composites were discussed. The results indicated that the treatment of PBO fibers by O₂, Ar and mixed O₂/Ar ICP, respectively, would result in the decomposition of the phenyl rings and oxazole moieties on the fiber surface, along with the formation of some polar groups and active groups, such as ester bonds, amide bonds and free radicals. Sputtering and etching of plasma also brought about a rough morphology for fiber surface. The modification effect by Ar ICP was better than that by O₂ ICP, and O₂/Ar ICP presented the best activation effect on the chemical compositions of PBO surface due to the synergy effect. The optimum ratio of O₂/Ar mixture was 40% -60% of O₂ content. The interlaminar shear strength (ILSS) of PBO/BMI composite treated with O₂/Ar ICP was 61.6 MPa, an increase by 38.1% compared with that of the untreated samples. The DBD plasma also improved the polarity, reactivity and the morphology of the PBO fiber surface. The effect of enhancement in ILSS values of PBO/BMI composites treated by O₂DBD was better in comparison with that treated by air DBD. The ILSS value was increased to 57.1 MPa at 12 s when treated at 30 W/cm³by air DBD plasma, while that of PBO/BMI composites treated by oxy-DBD plasma under the same condition was 62 MPa. Scanning electron microscopy (SEM) micrographs demonstrated that the fracture failure mechanism of PBO/BMI composites treated by ICP or DBD plasma shifted from interface failure to matrix failure. Finally, the relationship between the aging behavior of the fiber surface and the interfacial property of the fiber reinforced BMI composites were also discussed. ILSS values of PBO/BMI composites decreased with storage time for the fibers treated by plasma.
- Continuous fibers,
- Plasma treatment technology,
- Composite interface,
- Fiber surface modification,
- Interface structure and properties
1. [1]
  Stenzenberger H D.Adv Polym Sci, 1994, 117:166-220
2. [2]
  Mijovic J, Andjelic S.Macromolecules, 1996, 29 (1):239-246 doi: 10.1021/ma950550v
3. [3]
  Phelan J C, Sung C S P.Macromolecules, 1997, 30 (22):6845-6851 doi: 10.1021/ma961887f
4. [4]
  Hu X, Meng J R.J Polym Sci, Part A:Polym Chem, 2005, 43:994-1006
5. [5]
  Xiong X H, Chen P, Zhang J X, Yu Q, Wang B C.Thermochim Acta, 2011, 514:44-50 doi: 10.1016/j.tca.2010.12.001
6. [6]
  Xiong X H, Ren R, Chen P, Yu Q, Wang J, Jia C X.J Appl Polym Sci, 2013, 130:1084-1091 doi: 10.1002/app.39269
7. [7]
  Chen Ping, Xiong Xuhai, Xia Lian, Zhang Liying, Yu Qi, Liu Siyang.Acta Polymerica Sinica, 2017, (3):399-410
8. [8]
  Yao Y, Zhao T, Yu Y Z.J Appl Polym Sci, 2005, 97:443-448 doi: 10.1002/(ISSN)1097-4628
9. [9]
  Zhang L Y, Na L Y, Xia L L, Xiong X H, Fan S D, Chen P.High Perform Polym, 2016, 28(2):215-224 doi: 10.1177/0954008315577672
10. [10]
  Kumar K S S, Nair C P R, Sadhana R, Ninan K N.Eur Polym J, 2007, 43:5084-5096 doi: 10.1016/j.eurpolymj.2007.09.012
11. [11]
  Matsui J.Crit Rev Surf Chem, 1990, 1:71-80
12. [12]
  Severini F, Formaro L, Mario P, Luca P.Carbon, 2002, 40(5):735-741 doi: 10.1016/S0008-6223(01)00180-4
13. [13]
  Kaushik V K.Polym Test, 2000, 19(1):17-25 doi: 10.1016/S0142-9418(98)00068-3
14. [14]
  Wu J, Cheng X H.J Appl Polym Sci, 2006, 102:4165-4170 doi: 10.1002/(ISSN)1097-4628
15. [15]
  Wu G M, Hung C H, You J H, Liu S J.J Polym Res, 2004, 11:31-36 doi: 10.1023/B:JPOL.0000021734.69852.5b
16. [16]
  Yue Z R, Jiang W, Wang L, Gardner S D, Pittman C U.Carbon, 1999, 37(11):1785-1796 doi: 10.1016/S0008-6223(99)00047-0
17. [17]
  Ryu S K, Park B J, Park S J.J Colloid Interf Sci, 1999, 215(1):167-169 doi: 10.1006/jcis.1999.6240
18. [18]
  Fukunaga A, Ueda S.Compos Sci Technol, 2000, 60(2):249-252 doi: 10.1016/S0266-3538(99)00118-9
19. [19]
  Lindsay B, Abel M L, Watts J F.Carbon, 2007, 45(12):2433-2444 doi: 10.1016/j.carbon.2007.04.017
20. [20]
  Yang Y, Lu C X, Su X L.Mater Lett, 2007, 61(17):3601-3604 doi: 10.1016/j.matlet.2006.11.121
21. [21]
  Dilsiz N, Wightman J P.Carbon, 1999, 37(7):1105-1114 doi: 10.1016/S0008-6223(98)00300-5
22. [22]
  Kim J, Mai Y W.J Mater Sci, 1991, 26:4702-4720 doi: 10.1007/BF00612409
23. [23]
  Huang Y D, Liu L, Qiu J H, Shao L.Compos Sci Technol, 2002, 62(16):2153-2159 doi: 10.1016/S0266-3538(02)00148-3
24. [24]
  Liu L, Huang Y D, Zhang Z Q, Jiang B, Nin J.J Appl Polym Sci, 2001, 81:2764-2768 doi: 10.1002/(ISSN)1097-4628
25. [25]
  Zhang Y H, Huang Y D, Liu L, Cai K L.Appl Surf Sci, 2008, 254:3153-3161 doi: 10.1016/j.apsusc.2007.10.081
26. [26]
27. [27]
28. [28]
  Liu D, Chen P, Mu J J, Yu Q, Lu C.Appl Surf Sci, 2011, 257(15):6935-6940 doi: 10.1016/j.apsusc.2011.03.035
29. [29]
  Liu D, Chen P, Mu J J, Yu Q, Lu C.Appl Surf Sci, 2011, 257(23):10239-10245 doi: 10.1016/j.apsusc.2011.07.029
30. [30]
  Liu D, Chen P, Chen M X.Mat Sci Eng A, 2012, 532:78-83 doi: 10.1016/j.msea.2011.10.065
31. [31]
  Liu D, Chen P, Chen M X, Liu Z.Surf Coat Technol, 2012, 206:3534-3541 doi: 10.1016/j.surfcoat.2012.02.033
32. [32]
  Chen M X, Chen P, Liu D, Liu Z.Surf Coat Technol, 2012, 207(1):221-226
33. [33]
  Liu D, Chen P, Yu Q, Ma K M, Ding Z F.Surf Coat Technol, 2014, 305:630-637
34. [34]
  Liu Z, Chen P, Han D B, Lu F, Yu Q, Ding Z F.Vacuum, 2013, 92:13-19 doi: 10.1016/j.vacuum.2012.11.002
35. [35]
  Liu Z, Chen P, Zhang X L, Yu Q, Ma K M, Ding Z F.Appl Surf Sci, 2013, 283:38-45 doi: 10.1016/j.apsusc.2013.05.137
36. [36]
  Liu Z, Chen P, Zhang X L, Yu Q.RSC Adv, 2014, 4(8):3893-3899 doi: 10.1039/C3RA46192K
37. [37]
  Liu Z, Tang C, Chen P, Yu Q, Li W K.RSC Adv, 2014, 4:26881-26886 doi: 10.1039/c4ra01835d
38. [38]
  Liu Z, Zeng Q, Chen P, Yu Q, Ding Z F.Vacuum, 2015, 121:152-58 doi: 10.1016/j.vacuum.2015.08.012
39. [39]
  Zhang C S, Chen P, Sun B L, Wang J.Appl Surf Sci, 2008, 254:5776-5780 doi: 10.1016/j.apsusc.2008.03.082
40. [40]
  Ronning C, Feldermann H, Merk R, Hofsss H, Reinke P, Thiele J U.Phys Rev B, 1998, 58(4):2207-2215. doi: 10.1103/PhysRevB.58.2207
41. [41]
  Wiertz V B, Bertrand P, In:Pireaux J J, Delhalle J, Rudolf P, eds.ICPSI-2, Polymer-Solid Interfaces:From Model to Real Systems.Namur:Presses Universitaires de Namur, 1998.485-499
42. [42]
  Wang C, Chen J R.Appl Surf Sci, 2007, 253:4599-4606 doi: 10.1016/j.apsusc.2006.10.014
43. [43]
  Packham D E.Int J Adhes Adhes, 2003, 23:437-448 doi: 10.1016/S0143-7496(03)00068-X
44. [44]
1. [1]
  Tieping CAO , Yuejun LI , Dawei SUN . Surface plasmon resonance effect enhanced photocatalytic CO₂ reduction performance of S-scheme Bi₂S₃/TiO₂ heterojunction. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 903-912. doi: 10.11862/CJIC.20240366
2. [2]
  Xiaotian ZHU , Fangding HUANG , Wenchang ZHU , Jianqing ZHAO . Layered oxide cathode for sodium-ion batteries: Surface and interface modification and suppressed gas generation effect. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 254-266. doi: 10.11862/CJIC.20240260
3. [3]
  Lisha LEI , Wei YONG , Yiting CHENG , Yibo WANG , Wenchao HUANG , Junhuan ZHAO , Zhongjie ZHAI , Yangbin DING . Application of regenerated cellulose and reduced graphene oxide film in synergistic power generation from moisture electricity generation and Mg-air batteries. Chinese Journal of Inorganic Chemistry, 2025, 41(6): 1151-1161. doi: 10.11862/CJIC.20240202
4. [4]
  Yihan Xue , Xue Han , Jie Zhang , Xiaoru Wen . NCQDs修饰FeOOH基复合材料的制备及其电容脱盐性能. Acta Physico-Chimica Sinica, 2025, 41(7): 100072-. doi: 10.1016/j.actphy.2025.100072
5. [5]
  Kexin Dong , Chuqi Shen , Ruyu Yan , Yanping Liu , Chunqiang Zhuang , Shijie Li . Integration of Plasmonic Effect and S-Scheme Heterojunction into Ag/Ag₃PO₄/C₃N₅ Photocatalyst for Boosted Photocatalytic Levofloxacin Degradation. Acta Physico-Chimica Sinica, 2024, 40(10): 2310013-. doi: 10.3866/PKU.WHXB202310013
6. [6]
  Bowen Yang , Rui Wang , Benjian Xin , Lili Liu , Zhiqiang Niu . C-SnO₂/MWCNTs Composite with Stable Conductive Network for Lithium-based Semi-Solid Flow Batteries. Acta Physico-Chimica Sinica, 2025, 41(2): 100015-. doi: 10.3866/PKU.WHXB202310024
7. [7]
  Jiahong ZHENG , Jiajun SHEN , Xin BAI . Preparation and electrochemical properties of nickel foam loaded NiMoO₄/NiMoS₄ composites. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 581-590. doi: 10.11862/CJIC.20230253
8. [8]
  Fangfang WANG , Jiaqi CHEN , Weiyin SUN . CuBi@Cu-MOF composite catalysts for electrocatalytic CO₂ reduction to HCOOH. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 97-104. doi: 10.11862/CJIC.20240350
9. [9]
  Limei CHEN , Mengfei ZHAO , Lin CHEN , Ding LI , Wei LI , Weiye HAN , Hongbin WANG . Preparation and performance of paraffin/alkali modified diatomite/expanded graphite composite phase change thermal storage material. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 533-543. doi: 10.11862/CJIC.20230312
10. [10]
  Juan WANG , Zhongqiu WANG , Qin SHANG , Guohong WANG , Jinmao LI . NiS and Pt as dual co-catalysts for the enhanced photocatalytic H₂ production activity of BaTiO₃ nanofibers. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1719-1730. doi: 10.11862/CJIC.20240102
11. [11]
  Yuhui Yang , Jintian Luo , Biao Zuo . A Teaching Approach to Polymer Surface and Interface in Undergraduate Polymer Physics Courses. University Chemistry, 2025, 40(4): 126-130. doi: 10.12461/PKU.DXHX202408056
12. [12]
  Yuanchao LI , Weifeng HUANG , Pengchao LIANG , Zifang ZHAO , Baoyan XING , Dongliang YAN , Li YANG , Songlin WANG . Effect of heterogeneous dual carbon sources on electrochemical properties of LiMn_0.8Fe_0.2PO₄/C composites. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 751-760. doi: 10.11862/CJIC.20230252
13. [13]
  Min LI , Xianfeng MENG . Preparation and microwave absorption properties of ZIF-67 derived Co@C/MoS₂ nanocomposites. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1932-1942. doi: 10.11862/CJIC.20240065
14. [14]
  Xin Zhou , Zhi Zhang , Yun Yang , Shuijin Yang . A Study on the Enhancement of Photocatalytic Performance in C/Bi/Bi₂MoO₆ Composites by Ferroelectric Polarization: A Recommended Comprehensive Chemical Experiment. University Chemistry, 2024, 39(4): 296-304. doi: 10.3866/PKU.DXHX202310008
15. [15]
  Congying Lu , Fei Zhong , Zhenyu Yuan , Shuaibing Li , Jiayao Li , Jiewen Liu , Xianyang Hu , Liqun Sun , Rui Li , Meijuan Hu . Experimental Improvement of Surfactant Interface Chemistry: An Integrated Design for the Fusion of Experiment and Simulation. University Chemistry, 2024, 39(3): 283-293. doi: 10.3866/PKU.DXHX202308097
16. [16]
  Shijie Li , Ke Rong , Xiaoqin Wang , Chuqi Shen , Fang Yang , Qinghong Zhang . Design of Carbon Quantum Dots/CdS/Ta₃N₅ S-Scheme Heterojunction Nanofibers for Efficient Photocatalytic Antibiotic Removal. Acta Physico-Chimica Sinica, 2024, 40(12): 2403005-. doi: 10.3866/PKU.WHXB202403005
17. [17]
  Jun Huang , Pengfei Nie , Yongchao Lu , Jiayang Li , Yiwen Wang , Jianyun Liu . 丝光沸石负载自支撑氮掺杂多孔碳纳米纤维电容器及高效选择性去除硬度离子. Acta Physico-Chimica Sinica, 2025, 41(7): 100066-. doi: 10.1016/j.actphy.2025.100066
18. [18]
  Peng XU , Shasha WANG , Nannan CHEN , Ao WANG , Dongmei YU . Preparation of three-layer magnetic composite Fe₃O₄@polyacrylic acid@ZiF-8 for efficient removal of malachite green in water. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 544-554. doi: 10.11862/CJIC.20230239
19. [19]
  Meng Lin , Hanrui Chen , Congcong Xu . Preparation and Study of Photo-Enhanced Electrocatalytic Oxygen Evolution Performance of ZIF-67/Copper(I) Oxide Composite: A Recommended Comprehensive Physical Chemistry Experiment. University Chemistry, 2024, 39(4): 163-168. doi: 10.3866/PKU.DXHX202308117
20. [20]
  Yaping ZHANG , Tongchen WU , Yun ZHENG , Bizhou LIN . Z-scheme heterojunction β-Bi₂O₃ pillared CoAl layered double hydroxide nanohybrid: Fabrication and photocatalytic degradation property. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 531-539. doi: 10.11862/CJIC.20240256

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(95)
HTML views(5)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142