Citation: Quanming Ren, Shengpeng Mo, Jie Fan, Zhentao Feng, Mingyuan Zhang, Peirong Chen, Jiajian Gao, Mingli Fu, Limin Chen, Junliang Wu, Daiqi Ye. Enhancing catalytic toluene oxidation over MnO₂@Co₃O₄ by constructing a coupled interface[J]. Chinese Journal of Catalysis, ;2020, 41(12): 1873-1883. doi: 10.1016/S1872-2067(20)63641-5 shu

Enhancing catalytic toluene oxidation over MnO₂@Co₃O₄ by constructing a coupled interface

Quanming Ren ^a, ,
Shengpeng Mo ^a ,
Jie Fan ^a ,
Zhentao Feng ^a ,
Mingyuan Zhang ^a ,
Peirong Chen ^a,b,c ,
Jiajian Gao ^d ,
Mingli Fu ^a,b,c ,
Limin Chen ^a,b,c ,
Junliang Wu ^a,b,c ,
Daiqi Ye ^a,b,c

a School of Environment and Energy, South China University of Technology, Guangzhou 510006, Guangdong, China;
b National Engineering Laboratory for VOCs Pollution Control Technology and Equipment, South China University of Technology, Guangzhou 510006, Guangdong, China;
c Guangdong Provincial Key Laboratory of Atmospheric Environment and Pollution Control, Guangdong Provincial Engineering and Technology Research Centre for Environmental Risk Prevention and Emergency Disposal, South China University of Technology, Guangzhou 510006, Guangdong, China;
d School of Chemical and Biomedical Engineering, Nanyang Technological University, 62 Nanyang Drive, Singapore 637459, Singapore

Received Date: 4 March 2020
Revised Date: 17 April 2020

Fund Project: This work was supported by the National Key Research and Development Project of Research (2017YFC0212805, 2016YFC0204200, 2016YFC0204200, 2016YFC0204200), the National Natural Science Foundation of China (51878292, 51878293, 51678245), the Natural Science Foundation of Guangdong Province, China (2020A1515010929, 2015B020236002, 2014A030310431, 2016A030311003), the Science and Technology Project of Guangzhou City, China (201804020026), and the Science and Technology Program of Guangdong (2017B090901049).

Herein, a bottom-down design is presented to successfully fabricate ZIF-derived Co₃O₄, grown in situ on a one-dimensional (1D) α-MnO₂ material, denoted as α-MnO₂@Co₃O₄. The synergistic effect derived from the coupled interface constructed between α-MnO₂ and Co₃O₄ is responsible for the enhanced catalytic activity. The resultant α-MnO₂@Co₃O₄ catalyst exhibits excellent catalytic activity at a T_90% (temperature required to achieve a toluene conversion of 90%) of approximately 229 ℃, which is 47 and 28 ℃ lower than those of the pure α-MnO₂ nanowire and Co₃O₄-b obtained via pyrolysis of ZIF-67, respectively. This activity is attributed to the increase in the number of surface-adsorbed oxygen species, which accelerate the oxygen mobility and enhance the redox pairs of Mn⁴⁺/Mn³⁺ and Co²⁺/Co³⁺. Moreover, the result of in situ diffuse reflectance infrared Fourier transform spectroscopy suggests that the gaseous oxygen could be more easily activated to adsorbed oxygen species on the surface of α-MnO₂@Co₃O₄ than on that of α-MnO₂. The catalytic reaction route of toluene oxidation over the α-MnO₂@Co₃O₄ catalyst is as follows:toluene → benzoate species → alkanes containing oxygen functional group → CO₂ and H₂O. In addition, the α-MnO₂@Co₃O₄ catalyst shows excellent stability and good water resistance for toluene oxidation. Furthermore, the preparation method can be extended to other 1D MnO₂ materials. A new strategy for the development of high-performance catalysts of practical significance is provided.
- MnO₂@Co₃O₄,
- Toluene oxidation,
- Synergistic effect,
- Coupled interface,
- In situ DRIFTS
1. [1]
2. [2]
3. [3]
4. [4]
5. [5]
6. [6]
7. [7]
8. [8]
9. [9]
10. [10]
11. [11]
12. [12]
13. [13]
14. [14]
15. [15]
16. [16]
17. [17]
18. [18]
19. [19]
20. [20]
21. [21]
22. [22]
23. [23]
24. [24]
25. [25]
26. [26]
27. [27]
28. [28]
29. [29]
30. [30]
31. [31]
32. [32]
33. [33]
34. [34]
35. [35]
36. [36]
37. [37]
38. [38]
39. [39]
40. [40]
41. [41]
42. [42]
43. [43]
44. [44]
45. [45]
46. [46]
47. [47]
48. [48]
49. [49]
50. [50]
51. [51]
52. [52]
53. [53]
54. [54]
55. [55]
56. [56]
57. [57]
58. [58]
59. [59]
60. [60]
61. [61]
62. [62]
63. [63]
64. [64]
65. [65]
1. [1]
  Yinjie Xu , Suiqin Li , Lihao Liu , Jiahui He , Kai Li , Mengxin Wang , Shuying Zhao , Chun Li , Zhengbin Zhang , Xing Zhong , Jianguo Wang . Enhanced Electrocatalytic Oxidation of Sterols using the Synergistic Effect of NiFe-MOF and Aminoxyl Radicals. Acta Physico-Chimica Sinica, 2024, 40(3): 2305012-0. doi: 10.3866/PKU.WHXB202305012
2. [2]
  Xue Liu , Lipeng Wang , Luling Li , Kai Wang , Wenju Liu , Biao Hu , Daofan Cao , Fenghao Jiang , Junguo Li , Ke Liu . Research on Cu-Based and Pt-Based Catalysts for Hydrogen Production through Methanol Steam Reforming. Acta Physico-Chimica Sinica, 2025, 41(5): 100049-0. doi: 10.1016/j.actphy.2025.100049
3. [3]
  Yuanqing Wang , Yusong Pan , Hongwu Zhu , Yanlei Xiang , Rong Han , Run Huang , Chao Du , Chengling Pan . Enhanced Catalytic Activity of Bi₂WO₆ for Organic Pollutants Degradation under the Synergism between Advanced Oxidative Processes and Visible Light Irradiation. Acta Physico-Chimica Sinica, 2024, 40(4): 2304050-0. doi: 10.3866/PKU.WHXB202304050
4. [4]
  Shi-Yu Lu , Wenzhao Dou , Jun Zhang , Ling Wang , Chunjie Wu , Huan Yi , Rong Wang , Meng Jin . Amorphous-Crystalline Interfaces Coupling of CrS/CoS₂ Few-Layer Heterojunction with Optimized Crystallinity Boosted for Water-Splitting and Methanol-Assisted Energy-Saving Hydrogen Production. Acta Physico-Chimica Sinica, 2024, 40(8): 2308024-0. doi: 10.3866/PKU.WHXB202308024
5. [5]
  Jingyi Xie , Qianxi Lü , Weizhen Qiao , Chenyu Bu , Yusheng Zhang , Xuejun Zhai , Renqing Lü , Yongming Chai , Bin Dong . Enhancing Cobalt―Oxygen Bond to Stabilize Defective Co₂MnO₄ in Acidic Oxygen Evolution. Acta Physico-Chimica Sinica, 2024, 40(3): 2305021-0. doi: 10.3866/PKU.WHXB202305021
6. [6]
  Xudong Lv , Tao Shao , Junyan Liu , Meng Ye , Shengwei Liu . Paired Electrochemical CO₂ Reduction and HCHO Oxidation for the Cost-Effective Production of Value-Added Chemicals. Acta Physico-Chimica Sinica, 2024, 40(5): 2305028-0. doi: 10.3866/PKU.WHXB202305028
7. [7]
  Yang Wang , Yunpeng Fu , Xiaoji Liu , Guotao Zhang , Guobin Li , Wanqiang Liu , Jinglun Wang . Structural Analysis of Nitrile Solutions Based on Infrared Spectroscopy Probes. University Chemistry, 2025, 40(4): 367-374. doi: 10.12461/PKU.DXHX202406113
8. [8]
  Weikang Wang , Yadong Wu , Jianjun Zhang , Kai Meng , Jinhe Li , Lele Wang , Qinqin Liu . Green H₂O₂ synthesis via melamine-foam supported S-scheme Cd_0.5Zn_0.5In₂S₄/S-doped carbon nitride heterojunction: synergistic interfacial charge transfer and local photothermal effect. Acta Physico-Chimica Sinica, 2025, 41(8): 100093-0. doi: 10.1016/j.actphy.2025.100093
9. [9]
  Jingping Li , Suding Yan , Jiaxi Wu , Qiang Cheng , Kai Wang . Improving hydrogen peroxide photosynthesis over inorganic/organic S-scheme photocatalyst with LiFePO₄. Acta Physico-Chimica Sinica, 2025, 41(9): 100104-0. doi: 10.1016/j.actphy.2025.100104
10. [10]
  Yi Yang , Xin Zhou , Miaoli Gu , Bei Cheng , Zhen Wu , Jianjun Zhang . Femtosecond transient absorption spectroscopy investigation on ultrafast electron transfer in S-scheme ZnO/CdIn₂S₄ photocatalyst for H₂O₂ production and benzylamine oxidation. Acta Physico-Chimica Sinica, 2025, 41(6): 100064-0. doi: 10.1016/j.actphy.2025.100064
11. [11]
  Jianyu Qin , Yuejiao An , Yanfeng Zhang . In Situ Assembled ZnWO₄/g-C₃N₄ S-Scheme Heterojunction with Nitrogen Defect for CO₂ Photoreduction. Acta Physico-Chimica Sinica, 2024, 40(12): 2408002-0. doi: 10.3866/PKU.WHXB202408002
12. [12]
  Qi Wu , Changhua Wang , Yingying Li , Xintong Zhang . Enhanced photocatalytic synthesis of H₂O₂ by triplet electron transfer at g-C₃N₄@BN van der Waals heterojunction interface. Acta Physico-Chimica Sinica, 2025, 41(9): 100107-0. doi: 10.1016/j.actphy.2025.100107
13. [13]
  Qingqing SHEN , Xiangbowen DU , Kaicheng QIAN , Zhikang JIN , Zheng FANG , Tong WEI , Renhong LI . Self-supporting Cu/α-FeOOH/foam nickel composite catalyst for efficient hydrogen production by coupling methanol oxidation and water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1953-1964. doi: 10.11862/CJIC.20240028
14. [14]
  Meiran Li , Yingjie Song , Xin Wan , Yang Li , Yiqi Luo , Yeheng He , Bowen Xia , Hua Zhou , Mingfei Shao . Nickel-Vanadium Layered Double Hydroxides for Efficient and Scalable Electrooxidation of 5-Hydroxymethylfurfural Coupled with Hydrogen Generation. Acta Physico-Chimica Sinica, 2024, 40(9): 2306007-0. doi: 10.3866/PKU.WHXB202306007
15. [15]
  Fei ZHOU , Xiaolin JIA . Co₃O₄/TiO₂ composite photocatalyst: Preparation and synergistic degradation performance of toluene. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2232-2240. doi: 10.11862/CJIC.20240236
16. [16]
  Lina Guo , Ruizhe Li , Chuang Sun , Xiaoli Luo , Yiqiu Shi , Hong Yuan , Shuxin Ouyang , Tierui Zhang . Effect of Interlayer Anions in Layered Double Hydroxides on the Photothermocatalytic CO₂ Methanation of Derived Ni-Al₂O₃ Catalysts. Acta Physico-Chimica Sinica, 2025, 41(1): 100002-0. doi: 10.3866/PKU.WHXB202309002
17. [17]
  Ying Liang , Yuheng Deng , Shilv Yu , Jiahao Cheng , Jiawei Song , Jun Yao , Yichen Yang , Wanlei Zhang , Wenjing Zhou , Xin Zhang , Wenjian Shen , Guijie Liang , Bin Li , Yong Peng , Run Hu , Wangnan Li . Machine learning-guided antireflection coatings architectures and interface modification for synergistically optimizing efficient and stable perovskite solar cells. Acta Physico-Chimica Sinica, 2025, 41(9): 100098-0. doi: 10.1016/j.actphy.2025.100098
18. [18]
  Siyu HOU , Weiyao LI , Jiadong LIU , Fei WANG , Wensi LIU , Jing YANG , Ying ZHANG . Preparation and catalytic performance of magnetic nano iron oxide by oxidation co-precipitation method. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1577-1582. doi: 10.11862/CJIC.20230469
19. [19]
  Xiuzheng Deng , Changhai Liu , Xiaotong Yan , Jingshan Fan , Qian Liang , Zhongyu Li . Carbon dots anchored NiAl-LDH@In₂O₃ hierarchical nanotubes for promoting selective CO₂ photoreduction into CH₄. Chinese Chemical Letters, 2024, 35(6): 108942-. doi: 10.1016/j.cclet.2023.108942
20. [20]
  Honghong Zhang , Zhen Wei , Derek Hao , Lin Jing , Yuxi Liu , Hongxing Dai , Weiqin Wei , Jiguang Deng . 非均相催化CO₂与烃类协同催化转化的最新进展. Acta Physico-Chimica Sinica, 2025, 41(7): 100073-0. doi: 10.1016/j.actphy.2025.100073

Get Citation

PDF

XML

Metrics

PDF Downloads(41)
Abstract views(4336)
HTML views(396)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Enhancing catalytic toluene oxidation over MnO2@Co3O4 by constructing a coupled interface

Metrics

通讯作者: 陈斌, bchen63@163.com

Enhancing catalytic toluene oxidation over MnO₂@Co₃O₄ by constructing a coupled interface