Citation: Hongmei Ai, Hongyuan Yang, Qing Liu, Guoming Zhao, Jing Yang, Fangna Gu. ZrO₂-modified Ni/LaAl₁₁O₁₈ catalyst for CO methanation:Effects of catalyst structure on catalytic performance[J]. Chinese Journal of Catalysis, ;2018, 39(2): 297-308. doi: 10.1016/S1872-2067(17)62995-4 shu

ZrO₂-modified Ni/LaAl₁₁O₁₈ catalyst for CO methanation:Effects of catalyst structure on catalytic performance

Hongmei Ai ^a,b, ,
Hongyuan Yang ^a ,
Qing Liu ^a ,
Guoming Zhao ^a ,
Jing Yang ^a ,
Fangna Gu ^c

a Key Laboratory of Low Carbon Energy and Chemical Engineering, College of Chemical and Environmental Engineering, Shandong University of Science and Technology, Qingdao 266590, Shandong, China;
b Assets Management Division, Shandong University of Science and Technology, Qingdao 266590, Shandong, China;
c State Key Laboratory of Multiphase Complex Systems, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, China

Received Date: 26 September 2017
Revised Date: 11 December 2017

Fund Project: This work was supported by the National Natural Science Foundation of China (21606146), Natural Science Foundation of Shandong Province (ZR2016BB17, 2016ZRB01037), Scientific Research Foundation of Shandong University of Science and Technology for Recruited Talents (2016RCJJ005, 2016RCJJ006), Government Sponsored Visiting Scholar Foundation of Shandong University of Science and Technology (2016), Qingdao Postdoctoral Applied Research Project (2015202), and China National Coal Association Science and Technology Research Program (MTKJ2016-266).

We report Ni/LaHA@ZrO₂ catalysts prepared by a facile modified successive adsorption and reaction method for CO methanation. N₂ adsorption, X-ray diffraction, transmission electron microscopy, scanning electron microscopy, thermogravimetric analysis, H₂ temperature-programmed reduction, H₂ temperature-programmed desorption, X-ray photoelectron spectroscopy, thermogravimetric analysis, and inductively coupled plasma atomic emission spectrometry were used to characterize the samples. The results indicated that the ZrO₂ nanoparticles were distributed over the surface of the Ni/LaHA@ZrO₂ catalyst and even partially covered some Ni particles, resulting in the coating exerting a confinement effect. The excess ZrO₂ had an adverse effect on the enhancement of CO conversion because of the coverage of the surface Ni particles; however, the Ni/LaHA@ZrO₂ catalyst displayed much higher CH₄ selectivity than Ni/LaHA because of the activation of the byproduct CO₂ molecules by ZrO₂ species. Therefore, even though 20Ni/LaHA@ZrO₂-5 exhibited similar CO conversion as 20Ni/LaHA, the use of the former resulted in a higher CH₄ yield than the use of the latter. A 107-h-lifetime test revealed that the Ni/LaHA@ZrO₂ catalyst was highly stable with superior anti-sintering and anti-coking properties because of its coating structure and the promoter effect of ZrO₂.
- Lanthanum hexaaluminate,
- ZrO₂,
- Nickel catalyst,
- Coating structure,
- CO methanation
1. [1]
2. [2]
3. [3]
4. [4]
5. [5]
6. [6]
7. [7]
8. [8]
9. [9]
10. [10]
11. [11]
12. [12]
13. [13]
14. [14]
15. [15]
16. [16]
17. [17]
18. [18]
19. [19]
20. [20]
21. [21]
22. [22]
23. [23]
24. [24]
25. [25]
26. [26]
27. [27]
28. [28]
29. [29]
30. [30]
31. [31]
32. [32]
33. [33]
34. [34]
35. [35]
36. [36]
37. [37]
38. [38]
39. [39]
40. [40]
41. [41]
42. [42]
43. [43]
44. [44]
45. [45]
46. [46]
47. [47]
48. [48]
49. [49]
50. [50]
51. [51]
52. [52]
53. [53]
54. [54]
55. [55]
1. [1]
  Wen YANG , Didi WANG , Ziyi HUANG , Yaping ZHOU , Yanyan FENG . La promoted hydrotalcite derived Ni-based catalysts: In situ preparation and CO₂ methanation performance. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 561-570. doi: 10.11862/CJIC.20230276
2. [2]
  Lina Guo , Ruizhe Li , Chuang Sun , Xiaoli Luo , Yiqiu Shi , Hong Yuan , Shuxin Ouyang , Tierui Zhang . 层状双金属氢氧化物的层间阴离子对衍生的Ni-Al₂O₃催化剂光热催化CO₂甲烷化反应的影响. Acta Physico-Chimica Sinica, 2025, 41(1): 2309002-. doi: 10.3866/PKU.WHXB202309002
3. [3]
  Junke LIU , Kungui ZHENG , Wenjing SUN , Gaoyang BAI , Guodong BAI , Zuwei YIN , Yao ZHOU , Juntao LI . Preparation of modified high-nickel layered cathode with LiAlO₂/cyclopolyacrylonitrile dual-functional coating. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1461-1473. doi: 10.11862/CJIC.20240189
4. [4]
  Kun WANG , Wenrui LIU , Peng JIANG , Yuhang SONG , Lihua CHEN , Zhao DENG . Hierarchical hollow structured BiOBr-Pt catalysts for photocatalytic CO₂ reduction. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1270-1278. doi: 10.11862/CJIC.20240037
5. [5]
  Bo YANG , Gongxuan LÜ , Jiantai MA . Corrosion inhibition of nickel-cobalt-phosphide in water by coating TiO₂ layer. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 365-384. doi: 10.11862/CJIC.20240063
6. [6]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
7. [7]
  Xinpeng LIU , Liuyang ZHAO , Hongyi LI , Yatu CHEN , Aimin WU , Aikui LI , Hao HUANG . Ga₂O₃ coated modification and electrochemical performance of Li_1.2Mn_0.54Ni_0.13Co_0.13O₂ cathode material. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1105-1113. doi: 10.11862/CJIC.20230488
8. [8]
  Fangxuan Liu , Ziyan Liu , Guowei Zhou , Tingting Gao , Wenyu Liu , Bin Sun . Hollow structured photocatalysts. Acta Physico-Chimica Sinica, 2025, 41(7): 100071-. doi: 10.1016/j.actphy.2025.100071
9. [9]
  Yulian Hu , Xin Zhou , Xiaojun Han . A Virtual Simulation Experiment on the Design and Property Analysis of CO₂ Reduction Photocatalyst. University Chemistry, 2025, 40(3): 30-35. doi: 10.12461/PKU.DXHX202403088
10. [10]
  Shiqi Peng , Yongfang Rao , Tan Li , Yufei Zhang , Jun-ji Cao , Shuncheng Lee , Yu Huang . Regulating the electronic structure of Ir single atoms by ZrO₂ nanoparticles for enhanced catalytic oxidation of formaldehyde at room temperature. Chinese Chemical Letters, 2024, 35(7): 109219-. doi: 10.1016/j.cclet.2023.109219
11. [11]
  Ruolin CHENG , Haoran WANG , Jing REN , Yingying MA , Huagen LIANG . Efficient photocatalytic CO₂ cycloaddition over W₁₈O₄₉/NH₂-UiO-66 composite catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 523-532. doi: 10.11862/CJIC.20230349
12. [12]
  Yi YANG , Shuang WANG , Wendan WANG , Limiao CHEN . Photocatalytic CO₂ reduction performance of Z-scheme Ag-Cu₂O/BiVO₄ photocatalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 895-906. doi: 10.11862/CJIC.20230434
13. [13]
  Hongyi LI , Aimin WU , Liuyang ZHAO , Xinpeng LIU , Fengqin CHEN , Aikui LI , Hao HUANG . Effect of Y(PO₃)₃ double-coating modification on the electrochemical properties of Li[Ni_0.8Co_0.15Al_0.05]O₂. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1320-1328. doi: 10.11862/CJIC.20230480
14. [14]
  Zelong LIANG , Shijia QIN , Pengfei GUO , Hang XU , Bin ZHAO . Synthesis and electrocatalytic CO₂ reduction performance of metal-organic framework catalysts loaded with silver particles. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 165-173. doi: 10.11862/CJIC.20240409
15. [15]
  Xue Dong , Xiaofu Sun , Shuaiqiang Jia , Shitao Han , Dawei Zhou , Ting Yao , Min Wang , Minghui Fang , Haihong Wu , Buxing Han . 碳修饰的铜催化剂实现安培级电流电化学还原CO₂制C₂₊产物. Acta Physico-Chimica Sinica, 2025, 41(3): 2404012-. doi: 10.3866/PKU.WHXB202404012
16. [16]
  Zhicheng JU , Wenxuan FU , Baoyan WANG , Ao LUO , Jiangmin JIANG , Yueli SHI , Yongli CUI . MOF-derived nickel-cobalt bimetallic sulfide microspheres coated by carbon: Preparation and long cycling performance for sodium storage. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 661-674. doi: 10.11862/CJIC.20240363
17. [17]
  Kaihui Huang , Dejun Chen , Xin Zhang , Rongchen Shen , Peng Zhang , Difa Xu , Xin Li . Constructing Covalent Triazine Frameworks/N-Doped Carbon-Coated Cu₂O S-Scheme Heterojunctions for Boosting Photocatalytic Hydrogen Production. Acta Physico-Chimica Sinica, 2024, 40(12): 2407020-. doi: 10.3866/PKU.WHXB202407020
18. [18]
  Asif Hassan Raza , Shumail Farhan , Zhixian Yu , Yan Wu . 用于高效制氢的双S型ZnS/ZnO/CdS异质结构光催化剂. Acta Physico-Chimica Sinica, 2024, 40(11): 2406020-. doi: 10.3866/PKU.WHXB202406020
19. [19]
  Zhanggui DUAN , Yi PEI , Shanshan ZHENG , Zhaoyang WANG , Yongguang WANG , Junjie WANG , Yang HU , Chunxin LÜ , Wei ZHONG . Preparation of UiO-66-NH₂ supported copper catalyst and its catalytic activity on alcohol oxidation. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 496-506. doi: 10.11862/CJIC.20230317
20. [20]
  Qingqing SHEN , Xiangbowen DU , Kaicheng QIAN , Zhikang JIN , Zheng FANG , Tong WEI , Renhong LI . Self-supporting Cu/α-FeOOH/foam nickel composite catalyst for efficient hydrogen production by coupling methanol oxidation and water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1953-1964. doi: 10.11862/CJIC.20240028

Get Citation

PDF

XML

Metrics

PDF Downloads(1)
Abstract views(638)
HTML views(43)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

ZrO2-modified Ni/LaAl11O18 catalyst for CO methanation:Effects of catalyst structure on catalytic performance

Metrics

通讯作者: 陈斌, bchen63@163.com

ZrO₂-modified Ni/LaAl₁₁O₁₈ catalyst for CO methanation:Effects of catalyst structure on catalytic performance