Citation: SHEN Tian, WANG Yong-gang, CHENG Xiang-long, LIN Xiong-chao. Activation and mechanism of chars from partial gasification of lignite at different steam concentrations[J]. Journal of Fuel Chemistry and Technology, ;2017, 45(5): 513-522. shu

Activation and mechanism of chars from partial gasification of lignite at different steam concentrations

School of Chemical and Environmental Engineering, China University of Mining and Technology (Beijing), Beijing 100083

Corresponding author: WANG Yong-gang, wyg1960@126.com
Received Date: 26 December 2016
Revised Date: 3 March 2017

Fund Project: The project was supported by the National Key Technology Research and Development Program of the Ministry of Science and Technology of China 2012BAA04B02

Figures(10)

The char samples were prepared from the partial gasification of Shengli lignite in a fluidised-bed/fixed-bed reactor, and characterised by BET, Raman, FT-IR, microwave digestion ICP-AES, and TGA. The results indicate that at 800 ℃ and steam atmosphere the decomposition of ether group is made by the inherent char activation, leading to the decrease in the content of short chain or amorphous carbon between aromatic rings to prevent the graphitizing and the enhancement in the degree of defective aromatic structure. With the increasing of steam concentration (10%-25%) the char reactivity is reduced, which is attributed to the weakening of the regeneration of active sites by forming more ether group via the reaction "Ar, R-CO-Ar, R+2H₂O→Ar, R-O-Ar, R+2H₂+CO₂". However, with the continual increasing of steam concentration (25%-40%) the char reactivity is slightly promoted because the content of defective aromatic structure (3-5 rings) is increased due to the enhancement of the reaction (Ar, R-CH=CH₂+H₂O→Ar, R-CO-CH₃+H₂) and the reaction (Ar, R-+H-→Ar, R-H).
- lignite,
- fluidized-bed,
- active site,
- char structure
1. [1]
  XU Xiu-feng, CUI Hong, GU Yong-da, CHEN Song-ying, WU Dong. Influence of charring conditions of coal chars on their gasification reactivity by air[J]. J Fuel Chem Technol, 1996,24(5):404-410.
2. [2]
  XIE Ke-chang, WANG Yong-gang, LING Kai-cheng, LING Da-qi. Kinetics of CO₂ pressurised gasification of DongShan char[J]. J China Coal Soc, 1991,16(2):103-109.
3. [3]
  ZHU Zi-bin, MA Zhi-hua, LIN Shi-ying, Mitsuho Hirato, Masayuki Horio. Characteristics of coal char gasification at high temperature (Ⅱ): The effect of pore structure on coal char gasification[J]. CIESC J, 1994,45(2):155-161.
4. [4]
  RADOVIC L R, STECZKO K, WALKER P L, JENKINS R G. Combined effects of inorganic constituents and pyrolysis conditions on the gasification reactivity of coal chars[J]. Fuel Process Technol, 1985,10(3):311-326. doi: 10.1016/0378-3820(85)90038-4
5. [5]
  LIZZIO A A, JIANG H, RADOVIC L R. On the kinetics of carbon (char) gasification: Reconciling models with experiments[J]. Carbon, 1990,28(1):7-19. doi: 10.1016/0008-6223(90)90087-F
6. [6]
  LI X, HAYASHI J, LI C. Volatilisation and catalytic effects of alkali and alkaline earth metallic species during the pyrolysis and gasification of Victorian brown coal. Part Ⅶ. Raman spectroscopic study on the changes in char structure during the catalytic gasification in air[J]. Fuel, 2006,85(10/11):1509-1517.
7. [7]
  LI X, LI C. Volatilisation and catalytic effects of alkali and alkaline earth metallic species during the pyrolysis and gasification of Victorian brown coal. Part Ⅷ. Catalysis and changes in char structure during gasification in steam[J]. Fuel, 2006,85(10/11):1518-1525.
8. [8]
  LI T, ZHANG L, DONG L, LI C Z. Effects of gasification atmosphere and temperature on char structural evolution during the gasification of Collie sub-bituminous coal[J]. Fuel, 2014,117:1190-1195. doi: 10.1016/j.fuel.2013.08.040
9. [9]
  TAY H L, KAJITANI S, ZHANG S, LI C Z. Effects of gasifying agent on the evolution of char structure during the gasification of Victorian brown coal[J]. Fuel, 2013,103:22-28. doi: 10.1016/j.fuel.2011.02.044
10. [10]
  WANG Yong-gang, SUN Jia-liang, ZHANG Shu. Impacts of the gas atmosphere on the gasification reactivity and char structure of the brown coal[J]. J China Coal Soc, 2014,39(8):1765-1771.
11. [11]
  XU Xiu-Qiang, WANG Yong-gang, CHEN Guo-peng, CHEN Zong-ding, QIN Zhong-yu, DAI Jin-ze, ZHANG Shu, XU De-ping. Effects of steam on the reactivity and microstructure of char from in-situ gasification of brown coal[J]. J Fuel Chem Technol, 2015,43(5):546-553.
12. [12]
  XU Xiu-qiang, WANG Yong-gang, CHEN Zong-ding, BAI Lei, ZHANG Kun-jun, YANG Sa-sha, ZHANG Shu. Influence of cooling treatments on char microstructure and reactivity of Shengli brown coal[J]. J Fuel Chem Technol, 2015,43(1):1-8.
13. [13]
  XIANG Yin-hua, WANG Yang, ZHANG Jian-min, ZHANG Shou-yu, FANG Yi-tian, DONG Zhong-bing. Kinetic on steam gasification of partially gasified char[J]. CIESC J, 2003,54(3):368-373.
14. [14]
  LI C Z. Some recent advances in the understanding of the pyrolysis and gasification behaviour of Victorian brown coal[J]. Fuel, 2007,86(12/13):1664-1683.
15. [15]
  MIN Z, YIMSIRI P, ASADULLAH M, ZHANG S, LI C Z. Catalytic reforming of tar during gasification. Part Ⅱ. Char as a catalyst or as a catalyst support for tar reforming[J]. Fuel, 2011,90(7):2545-2552. doi: 10.1016/j.fuel.2011.03.027
16. [16]
  WU H, QUYN D M, LI C Z. Volatilisation and catalytic effects of alkali and alkaline earth metallic species during the pyrolysis and gasification of Victorian brown coal. Part Ⅲ. The importance of the interactions between volatiles and char at high temperature[J]. Dent Traumatol, 2002,81(8):1033-1039.
17. [17]
  ZHANG L X, HUANG J J, FANG Y T, WANG Y. Gasification reactivity and kinetics of typical chinese anthracite chars with steam and CO₂[J]. Energy Fuels, 2006,20(3):1201-1210. doi: 10.1021/ef050343o
18. [18]
  YE D P, AGNEW J B, ZHANG D K. Gasification of a South Australian low-rank coal with carbon dioxide and steam: Kinetics and reactivity studies[J]. Fuel, 1998,77(11):1209-1219. doi: 10.1016/S0016-2361(98)00014-3
19. [19]
  ZHANG S, HAYASHI J I, LI C Z. Volatilisation and catalytic effects of alkali and alkaline earth metallic species during the pyrolysis and gasification of Victorian brown coal. Part Ⅸ. Effects of volatile-char interactions on char-H₂O and char-O₂ reactivities[J]. Fuel, 2011,90(4):1655-1661. doi: 10.1016/j.fuel.2010.11.008
20. [20]
  CHEN W H, LIN B J. Hydrogen and synthesis gas production from activated carbon and steam via reusing carbon dioxide[J]. Appl Energy, 2013,101(1):551-559.
21. [21]
  ROMÁN S, GONZÁLEZ J F, GONZÁLEZ-GARCÍA C M, ZAMORA F. Control of pore development during CO₂ and steam activation of olive stones[J]. Fuel Process Technol, 2008,89(8):715-720. doi: 10.1016/j.fuproc.2007.12.015
22. [22]
  XIANG Yin-hua, WANG Yang, ZHANG Jian-min, DONG Zhong-bing, LI Bin. Study on structural properties and their affecting factors during gasificaiton of chars[J]. J Fuel Chem Technol, 2002,30(2):108-112.
23. [23]
  TAY H L, KAJITANI S, ZHANG S, LI C Z. Inhibiting and other effects of hydrogen during gasification: Further insights from FT-Raman spectroscopy[J]. Fuel, 2014,116:1-6. doi: 10.1016/j.fuel.2013.07.066
1. [1]
  Jinglin CHENG , Xiaoming GUO , Tao MENG , Xu HU , Liang LI , Yanzhe WANG , Wenzhu HUANG . NiAlNd catalysts for CO₂ methanation derived from the layered double hydroxide precursor. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1592-1602. doi: 10.11862/CJIC.20240152
2. [2]
  Jiahong WANG , Zekun XU , Tianjiao LU , Jinming HUANG . Performance of N, Mn doped semi-coke activated carbon catalyzed ozone oxidation for the degradation of tetracycline hydrochloride in water. Chinese Journal of Inorganic Chemistry, 2025, 41(12): 2549-2560. doi: 10.11862/CJIC.20250120
3. [3]
  Congqi Zhu , Bo Liu , Ruchun Li . Dual active sites enhancing alkaline H₂-production performance. Acta Physico-Chimica Sinica, 2025, 41(11): 100146-0. doi: 10.1016/j.actphy.2025.100146
4. [4]
  Ping Song , Nan Zhang , Jie Wang , Rui Yan , Zhiqiang Wang , Yingxue Jin . Experimental Teaching Design on Synthesis and Antitumor Activity Study of Cu-Pyropheophorbide-a Methyl Ester. University Chemistry, 2024, 39(6): 278-286. doi: 10.3866/PKU.DXHX202310087
5. [5]
  Hao XU , Ruopeng LI , Peixia YANG , Anmin LIU , Jie BAI . Regulation mechanism of halogen axial coordination atoms on the oxygen reduction activity of Fe-N₄ site: A density functional theory study. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 695-701. doi: 10.11862/CJIC.20240302
6. [6]
  Jianan Hong , Chenyu Xu , Yan Liu , Changqi Li , Menglin Wang , Yanwei Zhang . Decoding the interfacial competition between hydrogen evolution and CO₂ reduction via edge-active-site modulation in photothermal catalysis. Acta Physico-Chimica Sinica, 2025, 41(9): 100099-0. doi: 10.1016/j.actphy.2025.100099
7. [7]
  Shiqian WEI , Xinyu TIAN , Hong LIU , Maoxia CHEN , Fan TANG , Qiang FAN , Weifeng FAN , Yu HU . Oxygen reduction reaction/oxygen evolution reaction catalytic performances of different active sites on nitrogen-doped graphene loaded with iron single atoms. Chinese Journal of Inorganic Chemistry, 2025, 41(9): 1776-1788. doi: 10.11862/CJIC.20250102
8. [8]
  Haitang WANG , Yanni LING , Xiaqing MA , Yuxin CHEN , Rui ZHANG , Keyi WANG , Ying ZHANG , Wenmin WANG . Construction, crystal structures, and biological activities of two Ln^Ⅲ₃ complexes. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1474-1482. doi: 10.11862/CJIC.20240188
9. [9]
  Chengyan XU , Jiangnan YU , Yu LI , Xizhen PAN , Yinlin HOU , Wenmin WANG . Synthesis, structure, and bioactivity of a Ho₄ complex bridged by azide group. Chinese Journal of Inorganic Chemistry, 2026, 42(7): 1453-1462. doi: 10.11862/CJIC.20260033
10. [10]
  Jingjing QING , Fan HE , Zhihui LIU , Shuaipeng HOU , Ya LIU , Yifan JIANG , Mengting TAN , Lifang HE , Fuxing ZHANG , Xiaoming ZHU . Synthesis, structure, and anticancer activity of two complexes of dimethylglyoxime organotin. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1301-1308. doi: 10.11862/CJIC.20240003
11. [11]
  Changqing MIAO , Fengjiao CHEN , Wenyu LI , Shujie WEI , Yuqing YAO , Keyi WANG , Ni WANG , Xiaoyan XIN , Ming FANG . Crystal structures, DNA action, and antibacterial activities of three tetranuclear lanthanide-based complexes. Chinese Journal of Inorganic Chemistry, 2024, 40(12): 2455-2465. doi: 10.11862/CJIC.20240192
12. [12]
  Jing WU , Puzhen HUI , Huilin ZHENG , Pingchuan YUAN , Chunfei WANG , Hui WANG , Xiaoxia GU . Synthesis, crystal structures, and antitumor activities of transition metal complexes incorporating a naphthol-aldehyde Schiff base ligand. Chinese Journal of Inorganic Chemistry, 2024, 40(12): 2422-2428. doi: 10.11862/CJIC.20240278
13. [13]
  Jia JI , Tengqi YAO , Wenqian DENG , Wenjing SHI , Xuan LÜ , Lin TIAN , Xiaoyan XIN , Yinling HOU . Structures, antibacterial activities, and interactions with DNA of two nickel complexes. Chinese Journal of Inorganic Chemistry, 2026, 42(1): 78-86. doi: 10.11862/CJIC.20250141
14. [14]
  Yunbo ZHU , Linxiang ZHOU , Chaoyang SHI , Jie YU , Danyang WEI , Mingli XU . Stable Fe—P structure catalysts: Enabled by a strong coordination strategy and high-efficiency oxygen electrocatalysis performance. Chinese Journal of Inorganic Chemistry, 2026, 42(9): 2021-2032. doi: 10.11862/CJIC.20260080
15. [15]
  Xin MA , Ya SUN , Na SUN , Qian KANG , Jiajia ZHANG , Ruitao ZHU , Xiaoli GAO . A Tb₂ complex based on polydentate Schiff base: Crystal structure, fluorescence properties, and biological activity. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1347-1356. doi: 10.11862/CJIC.20230357
16. [16]
  Xinting XIONG , Zhiqiang XIONG , Panlei XIAO , Xuliang NIE , Xiuying SONG , Xiuguang YI . Synthesis, crystal structures, Hirshfeld surface analysis, and antifungal activity of two complexes Na(Ⅰ)/Cd(Ⅱ) assembled by 5-bromo-2-hydroxybenzoic acid ligands. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1661-1670. doi: 10.11862/CJIC.20240145
17. [17]
  Hui Wang , Abdelkader Labidi , Menghan Ren , Feroz Shaik , Chuanyi Wang . Recent Progress of Microstructure-Regulated g-C₃N₄ in Photocatalytic NO Conversion: The Pivotal Roles of Adsorption/Activation Sites. Acta Physico-Chimica Sinica, 2025, 41(5): 100039-0. doi: 10.1016/j.actphy.2024.100039
18. [18]
  Lifang HE , Wenjie TANG , Yaoze LUO , Mingsheng LIANG , Jianxin TANG , Yuxuan WU , Fuxing ZHANG , Xiaoming ZHU . Synthesis, structure, and anticancer activity of two dialkyltin complexes constructed based on 2, 2′-bipyridin-6, 6′-dicarboxylic acid. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1601-1609. doi: 10.11862/CJIC.20250012
19. [19]
  Haiyu Zhu , Zhuoqun Wen , Wen Xiong , Xingzhan Wei , Zhi Wang . 二维半金属/硅异质结中肖特基势垒高度的准确高效预测. Acta Physico-Chimica Sinica, 2025, 41(7): 100078-0. doi: 10.1016/j.actphy.2025.100078
20. [20]
  Pan He , Junlin Yan , Zhigang Chen , Enming Dai , Xin Zhao , Ruijuan Wang . Design of Digital Experiment for Field Emission Scanning Electron Microscopy Based on Semi-Physical Simulation. University Chemistry, 2026, 41(1): 114-121. doi: 10.12461/PKU.DXHX202505104

Get Citation

PDF

XML

Metrics

PDF Downloads(4)
Abstract views(1660)
HTML views(186)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142