Citation: XIAO Ya-hui, LIU Yong, QIAO Cong-zhen, XU Shao-ping. Hydrogen-rich gas production from catalytic steam gasification of biomass in a decoupled dual loop gasification system[J]. Journal of Fuel Chemistry and Technology, ;2019, 47(12): 1430-1439. shu

Hydrogen-rich gas production from catalytic steam gasification of biomass in a decoupled dual loop gasification system

1.
Henan Engineering Research Center of Resource & Energy Recovery from Waste, College of Chemistry and Chemical Engineering, Henan University, Kaifeng 475004, China
2.
State Key Laboratory of Fine Chemicals, School of Chemical Engineering, Dalian University of Technology, Dalian 116024, China

Corresponding author: XIAO Ya-hui, yahuixiao1987@163.com
Received Date: 9 September 2019
Revised Date: 21 October 2019

Fund Project: The project was supported by the National Natural Science Foundation of China (50776013, 21676072), the Key Scientific Research Projects for Higher Education of Henan Province (20A530002)the National Natural Science Foundation of China 50776013the National Natural Science Foundation of China 21676072the Key Scientific Research Projects for Higher Education of Henan Province 20A530002

Figures(7)

In order to strengthen tar destruction and hydrogen-rich gas production in the biomass gasification, a novel decoupled dual loop gasification (DDLG) system was proposed. The system decouples gasification process into fuel gasification, tar reforming and residual char combustion, which occur in three independent reactors, i.e. gasifier, reformer and combustor. Both the gasifier and the reformer are separately interconnected with the combustor, forming two circulation loops in parallel. With pine sawdust as feedstock, and calcined olivine as both solid heat carriers and in-situ tar destruction catalyst, the performance of biomass gasification was investigated. The results indicate that the reforming after the gasifier and the presence of olivine catalyst greatly improve the tar destruction. Specifically, at the gasifier temperature of 700 ℃, the reformer temperature of 850 ℃ and the steam to carbon mass ratio (S/C) of 1.2, the tar content in product gas decreases to 13.9 g/m³, and the dry gas yield and H₂ concentration reach 1.0 m³/kg, and 38.8%, respectively.
- biomass gasification,
- decouple,
- tar removal,
- hydrogen-rich gas
1. [1]
  WU Chuang-zhi, YIN Xiu-li, LIU Hua-cai, CHEN Yong. Perspective on development of distributed bioenergy utilization[J]. Bull Chin Aca Sci, 2016(2):191-198.
2. [2]
  DOU B, ZHANG H, SONG Y, ZHAO L, JIANG B, HE M, RRAN C, CHEN H, XU Y. Hydrogen production from the thermochemical conversion of biomass:Issues and challenges[J]. Sustainable Energy Fuels, 2019,3:314-342. doi: 10.1039/C8SE00535D
3. [3]
  JIA Shuang, YING Hao, SUN Yun-juan, SUN Ning, XU Wei, XU Yu, NING Si-yun. Research advance in biomass steam gasification for hydrogen-rich syngas and its application[J]. Chem Ind Eng Prog, 2018,37(2):497-504.
4. [4]
  SANSANIWAL S K, PAL K, ROSEN M A, TYAGI S K. Recent advances in the development of biomass gasification technology:A comprehensive review[J]. Renewable Sustainable Energy Rev, 2017,72:363-384. doi: 10.1016/j.rser.2017.01.038
5. [5]
  MA X, ZHAO X, GU J, SHI J. Co-gasification of coal and biomass blends using dolomite and olivine as catalysts[J]. Renewable Energy, 2019,132:509-514. doi: 10.1016/j.renene.2018.07.077
6. [6]
  GUAN G, KAEWPANHA M, HAO X, ABUDULA A. Catalytic steam reforming of biomass tar:Prospects and challenges[J]. Renewable Sustainable Energy Rev, 2016,58:450-461. doi: 10.1016/j.rser.2015.12.316
7. [7]
  KIRNBAUER F, HOFBAUER H. Investigations on bed material changes in a dual fluidized bed steam gasification plant in Güssing, Austria[J]. Energy Fuels, 2011,25:3793-3798. doi: 10.1021/ef200746c
8. [8]
  NAQVI M, YAN J, DANISH M, FAROOQ U, LU S G. An experimental study on hydrogen enriched gas with reduced tar formation using pre-treated olivine in dual bed steam gasification of mixed biomass compost[J]. Int J Hydrogen Energy, 2016,41(25):10608-10618. doi: 10.1016/j.ijhydene.2016.04.206
9. [9]
  XIAO Y, XU S, TURSUN Y, WANG C, WANG G. Catalytic steam gasification of lignite for hydrogen-rich gas production in a decoupled triple bed reaction system[J]. Fuel, 2017,189:57-65. doi: 10.1016/j.fuel.2016.10.078
10. [10]
  XIAO Ya-hui. Decoupled catalytic gasification of biomass and coal for hydrogen-rich gas production[D]. Dalian: Dalian University of Technology, 2017.
11. [11]
  XU Guang-wen, DONG Li, LIU Xin-hua, WANG Yin, WANG Bao-qun, GAO Shi-qiu. Decoupling thermochemical conversion: Method, technique and research status[C]//Proceedings of 6^th annual conference of China society of particuology cum symposium on particle technology across Taiwan straits. Shanghai, 2008: 949-952.
12. [12]
  ZHANG J, WANG Y, DONG L, GAO S, XU G. Decoupling gasification:Approach principle and technology justification[J]. Energy Fuels, 2010,24:6223-6232. doi: 10.1021/ef101036c
13. [13]
  ZHANG J, WU R, ZHANG G, YU J, YAO C, WANG Y, GAO S, XU G. Technical review on thermochemical conversion based on decoupling for solid carbonaceous fuels[J]. Energy Fuels, 2013,27(4):1951-1966. doi: 10.1021/ef400118b
14. [14]
  LI C Z, XU G W. Decoupled thermochemical conversion-Preface[J]. Fuel, 2013,112:607-608. doi: 10.1016/j.fuel.2013.06.027
15. [15]
  WANG Xiao-ming, XIAO Xian-bin, LIU Ji, CHEN Xu-jiao, QIN Wu, DONG Chang-qing, LI Wen-yan. Research progress of dual fluidized bed biomass gasifier[J]. Chem Ind Eng Prog, 2015,34(1):26-31.
16. [16]
  SUN Yan-lin, ZENG Xi, WANG Fang, CUI Yan-bin, XU Guang-wen. Pilot test of low-rank crushed coal gasification in two-stage fluidized bed reactor[J]. J China Coal Soc, 2017,42(5):1297-1303.
17. [17]
  ZENG Ji-min, XIAO Rui, HENG Li-jun, ZENG De-wang, SHAO Shan-shan. Chemical looping gasification of biomass for high H₂/CO-ratio syngas[J]. J Combust Sci Technol, 2016,22(3):229-235.
18. [18]
  GUO Wan-jun, GE Hui-jun, SHEN Lai-hong, SONG Tao, GU Hai-ming, JIANG Shou-xi. Experimental study on chemical looping gasification of biomass with hematite base on 25 kW_th fluidized beds[J]. J Therm Sci Technol, 2017,16(1):78-86.
19. [19]
  ZHANG Z, PANG S. Experimental investigation of tar formation and producer gas composition in biomass steam gasification in a 100kW dual fluidised bed gasifier[J]. Renewable Energy, 2018,132:416-424.
20. [20]
  MAUERHOFER A M, FUCHS J, MÜLLER S, BENEDIKT F, SCHMID J C, HOFBAUER H. CO₂ gasification in a dual fluidized bed reactor system:Impact on the product gas composition[J]. Fuel, 2019,253:1605-1616. doi: 10.1016/j.fuel.2019.04.168
21. [21]
  XIAO Y, XU S, SONG Y, WANG C, OUYANG S. Gasification of low-rank coal for hydrogen-rich gas production in a dual loop gasification system[J]. Fuel Process Technol, 2018,171:110-116. doi: 10.1016/j.fuproc.2017.11.014
22. [22]
  XIAO Y, XU S, SONG Y, SHAN Y, WANG C, WANG G. Biomass steam gasification for hydrogen-rich gas production in a decoupled dual loop gasification system[J]. Fuel Process Technol, 2017,165:54-61. doi: 10.1016/j.fuproc.2017.05.013
23. [23]
  DEVI L, PTASINSKI K J, JANSSEN F J J G. Pretreated olivine as tar removal catalyst for biomass gasifiers:Investigation using naphthalene as model biomass tar[J]. Fuel Process Technol, 2005,86(6):707-730. doi: 10.1016/j.fuproc.2004.07.001
24. [24]
  VIRGINIE M, ADÁNEZ J, COURSON C, DE DIEGO L F, GARCIA-LABIANO F, NIZNANSKY D, KIENNEMANN A, GAYÁN P, ABAD A. Effect of Fe-olivine on the tar content during biomass gasification in a dual fluidized bed[J]. Appl Catal B:Environ, 2012,121/122:214-222.
25. [25]
  LANCEE R J, DUGULAN A I, THÜNE P C, VERINGA H J, NIEMANTSVERDRIET J W, FREDRIKSSON H O A. Chemical looping capabilities of olivine, used as a catalyst in indirect biomass gasification[J]. Appl Catal B:Environ, 2014,145:216-222. doi: 10.1016/j.apcatb.2013.01.041
26. [26]
  WOLFESBERGER U, AIGNER I, HOFBAUER H. Tar content and composition in producer gas of fluidized bed gasification of wood-Influence of temperature and pressure[J]. Environ Prog Sustainable Energy, 2009,28:372-379. doi: 10.1002/ep.10387
27. [27]
  DEVI L, PTASINSKI K J, JANSSEN F J J G, VAN PAASEN S V B, BERGMAN P C A, KIEL J H A. Catalytic decomposition of biomass tars:use of dolomite and untreated olivine[J]. Renewable Energy, 2005,30(4):565-587. doi: 10.1016/j.renene.2004.07.014
28. [28]
  ISRAELSSON M, THUNMAN H. Gasification reaction pathways of condensable hydrocarbons[J]. Energy Fuels, 2016,30:4951-4959. doi: 10.1021/acs.energyfuels.6b00515
29. [29]
  KOPPATZ S, PFEIFER C, HOFBAUER H. Comparison of the performance behaviour of silica sand and olivine in a dual fluidized bed reactor system for steam gasification of biomass at pilot plant scale[J]. Chem Eng J, 2011,175:468-483. doi: 10.1016/j.cej.2011.09.071
1. [1]
  Kuaibing Wang , Feifei Mao , Weihua Zhang , Bo Lv . Design and Practice of a Comprehensive Teaching Experiment for Preparing Biomass Carbon Dots from Rice Husk. University Chemistry, 2025, 40(5): 342-350. doi: 10.12461/PKU.DXHX202407042
2. [2]
  Hao GUO , Tong WEI , Qingqing SHEN , Anqi HONG , Zeting DENG , Zheng FANG , Jichao SHI , Renhong LI . Electrocatalytic decoupling of urea solution for hydrogen production by nickel foam-supported Co₉S₈/Ni₃S₂ heterojunction. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2141-2154. doi: 10.11862/CJIC.20240085
3. [3]
  Fang Niu , Rong Li , Qiaolan Zhang . Analysis of Gas-Solid Adsorption Behavior in Resistive Gas Sensing Process. University Chemistry, 2024, 39(8): 142-148. doi: 10.3866/PKU.DXHX202311102
4. [4]
  Jiali CHEN , Guoxiang ZHAO , Yayu YAN , Wanting XIA , Qiaohong LI , Jian ZHANG . Machine learning exploring the adsorption of electronic gases on zeolite molecular sieves. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 155-164. doi: 10.11862/CJIC.20240408
5. [5]
  Yuhang Jiang , Weijie Liu , Jiaqi Cai , Jiayue Chen , Yanping Ren , Pingping Wu , Liulin Yang . A Journey into the Science and Art of Sugar: “Dispersion of Light and Optical Rotation of Matter” Science Popularization Experiment. University Chemistry, 2024, 39(9): 288-294. doi: 10.12461/PKU.DXHX202401054
6. [6]
  Qingyang Cui , Feng Yu , Zirun Wang , Bangkun Jin , Wanqun Hu , Wan Li . From Jelly to Soft Matter: Preparation and Properties-Exploring of Different Kinds of Hydrogels. University Chemistry, 2024, 39(9): 338-348. doi: 10.3866/PKU.DXHX202309046
7. [7]
  Zhifang SU , Zongjie GUAN , Yu FANG . Process of electrocatalytic synthesis of small molecule substances by porous framework materials. Chinese Journal of Inorganic Chemistry, 2024, 40(12): 2373-2395. doi: 10.11862/CJIC.20240290
8. [8]
  . . Chinese Journal of Inorganic Chemistry, 2024, 40(12): 0-0.
9. [9]
  Qinjin DAI , Shan FAN , Pengyang FAN , Xiaoying ZHENG , Wei DONG , Mengxue WANG , Yong ZHANG . Performance of oxygen vacancy-rich V-doped MnO₂ for high-performance aqueous zinc ion battery. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 453-460. doi: 10.11862/CJIC.20240326
10. [10]
  Jing SU , Bingrong LI , Yiyan BAI , Wenjuan JI , Haiying YANG , Zhefeng Fan . Highly sensitive electrochemical dopamine sensor based on a highly stable In-based metal-organic framework with amino-enriched pores. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1337-1346. doi: 10.11862/CJIC.20230414
11. [11]
  Guoqiang Chen , Zixuan Zheng , Wei Zhong , Guohong Wang , Xinhe Wu . 熔融中间体运输导向合成富氨基g-C₃N₄纳米片用于高效光催化产H₂O₂. Acta Physico-Chimica Sinica, 2024, 40(11): 2406021-. doi: 10.3866/PKU.WHXB202406021
12. [12]
  Pengyang FAN , Shan FAN , Qinjin DAI , Xiaoying ZHENG , Wei DONG , Mengxue WANG , Xiaoxiao HUANG , Yong ZHANG . Preparation and performance of rich 1T-MoS₂ nanosheets for high-performance aqueous zinc ion battery cathode materials. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 675-682. doi: 10.11862/CJIC.20240339
13. [13]
  Liangliang Song , Haoyan Liang , Shunqing Li , Bao Qiu , Zhaoping Liu . 超高比能电池高锰富锂层状氧化物正极材料面临的挑战与解决策略. Acta Physico-Chimica Sinica, 2025, 41(8): 100085-. doi: 10.1016/j.actphy.2025.100085
14. [14]
  Haitang WANG , Yanni LING , Xiaqing MA , Yuxin CHEN , Rui ZHANG , Keyi WANG , Ying ZHANG , Wenmin WANG . Construction, crystal structures, and biological activities of two Ln^Ⅲ₃ complexes. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1474-1482. doi: 10.11862/CJIC.20240188
15. [15]
  Xiaowei TANG , Shiquan XIAO , Jingwen SUN , Yu ZHU , Xiaoting CHEN , Haiyan ZHANG . A zinc complex for the detection of anthrax biomarker. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1850-1860. doi: 10.11862/CJIC.20240173
16. [16]
  Jianfeng Yan , Yating Xiao , Xin Zuo , Caixia Lin , Yaofeng Yuan . Comprehensive Chemistry Experimental Design of Ferrocenylphenyl Derivatives. University Chemistry, 2024, 39(4): 329-337. doi: 10.3866/PKU.DXHX202310005
17. [17]
  Zhibei Qu , Changxin Wang , Lei Li , Jiaze Li , Jun Zhang . Organoid-on-a-Chip for Drug Screening and the Inherent Biochemistry Principles. University Chemistry, 2024, 39(7): 278-286. doi: 10.3866/PKU.DXHX202311039
18. [18]
  Dan Li , Hui Xin , Xiaofeng Yi . Comprehensive Experimental Design on Ni-based Catalyst for Biofuel Production. University Chemistry, 2024, 39(8): 204-211. doi: 10.3866/PKU.DXHX202312046
19. [19]
  Yang Liu , Peng Chen , Lei Liu . Chemistry “101 Plan”: Design and Construction of Chemical Biology Textbook. University Chemistry, 2024, 39(10): 45-51. doi: 10.12461/PKU.DXHX202407085
20. [20]
  Tianyu Feng , Guifang Jia , Peng Zou , Jun Huang , Zhanxia Lü , Zhen Gao , Chu Wang . Construction of the Chemistry Biology Experiment Course in the Chemistry “101 Program”. University Chemistry, 2024, 39(10): 69-77. doi: 10.12461/PKU.DXHX202409002

Get Citation

PDF

XML

Metrics

PDF Downloads(9)
Abstract views(892)
HTML views(125)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142