Citation: HU Bin, WANG Xiao-bei, BAI Lu, LIANG Cai, YANG Lin-jun. Experimental study on strengthening the electrostatic precipitation removal of PM_2.5 and SO₃ by desulfurization wastewater evaporation[J]. Journal of Fuel Chemistry and Technology, ;2017, 45(7): 889-896. shu

Experimental study on strengthening the electrostatic precipitation removal of PM_2.5 and SO₃ by desulfurization wastewater evaporation

Key Laboratory of Energy Thermal Conversion and Control of Ministry of Education Southeast University, Nanjing 210096, China

Corresponding author: YANG Lin-jun, ylj@seu.edu.cn
Received Date: 6 March 2017
Revised Date: 21 April 2017

Fund Project: the Major State Basic Research Development Program of China 973 programthe Major State Basic Research Development Program of China 2013CB228505

Figures(11)

In order to study the influence of desulfurization wastewater evaporation (DWE) on the ESP and the desulfurization performance, an experimental setup with DWE and the coal-fired thermal system was established. The removal of PM_2.5 and SO₃ from coal combustion with DWE and the evolution of fine particle size and PM_2.5 and SO₃ concentration at ESP outlet were investigated. Also, the mechanism of PM_2.5 and SO₃ removal was analyzed. The results show that DWE can increase the average size of particles from 0.1 μm to 1.1 μm. Compared SEM image before DWE with that after DWE, the particles reuniting and floc formation between particles are clearly observed. The ESP efficiency is increased by 5%; the removal efficiency of PM_2.5 in number concentration is increased by 25% at the ESP outlet; and the removal efficiency of SO₃ by ESP is 60%-80%. The SO₃ concentration in flue gas has an effect on PM_2.5 and SO₃ removal by ESP. However, the DWE has no effect on the desulfurization efficiency and the pH value of the desulfurization slurry.
- desulfurization wastewater evaporation,
- PM_2.5,
- SO₃,
- electrostatic precipitation,
- simultaneous control
1. [1]
  YANG Lin-jun. Pollution Control Technology of Fine Particles from the Combustion Sources[M]. Beijing:Chemical Industry Press, 2011.
2. [2]
  GB13223-2011, Emission standard of air pollutants for thermal power plants[S].
3. [3]
4. [4]
  KIM K, YANG S, EUM H. Analysis of the scale formed in FGD facility[J]. Anal Sci, 2007,17:i1615-i1617.
5. [5]
  LI Wen-yan, WANG Ji-xing, CHE Jian-wei. Wet flue gas desulfurization wet exhaust problem analysis[J]. Proc CSEE, 2007,27(14):36-40. doi: 10.3321/j.issn:0258-8013.2007.14.007
6. [6]
  MA S C, CHAI J, CHEN G D. Research on desulfurization wastewater evaporation:Present and future perspectives[J]. Renew Sust Energy Rev, 2016,58:1143-1151. doi: 10.1016/j.rser.2015.12.252
7. [7]
  ZHANG Zhi-rong. Study on key problems of the thermal power plant FGD waste water with evaporation treatment[D]. Chongqing:Chongqing University, 2011.
8. [8]
  ZHANG Zi-jing, WANG Jian-wen, GAO Yi, WEN Gao, SUN Shi-chang, LANG Lin-mao. Flow field simulation of smoke and gas evaporation characteristics of desulfurization wastewater in coal-fired power plant[J]. J China Coal Soc, 2015,40(3):678-683.
9. [9]
  DENG Jia-jia. Study on optimization of coal combustion power plant WFGD spray scrubber process and zero discharge of WFGD wastewate[D]. Chongqing:Chongqing University, 2015.
10. [10]
  MA Shuang-chen, CHAI Feng, WU Wen-long, YU Wei-jin, CHEN Gong-da. Experimental research on influencing factors of flue evaporation treatment for desulfurization wastewater[J]. Environ Sci Technol, 2015,38(12):297-301.
11. [11]
  Mitsubishi Heavy Industries. Mitsubishi gas-gas heater[Z]. Japan:Mitsubishi Heavy Industries, 1986.
12. [12]
  HONJO S, SHINODA T, NAKAYAMA Y. MHI Wet-FGD waste water treatment technologies[R]. Japan:Mitsubishi Heavy Industries, 1987.
13. [13]
  MIERZEJEWSKI M K. The treatment and disposal of wastewater from flue gas desulphurization plant[J]. IWC, 1991,24(2):125-129.
14. [14]
  LIU Yong, YANG Lin-jun, PAN Dan-ping, ZHAO Wen, LIU Rui, HU Bin. Experimental study on amount reduce of PM2[J]. J Southeast Univ:Nat Sci Ed, 2015,45(2):320-327.
15. [15]
  PAN Dan-ping, WU Hao, HUANG Rong-ting, ZHANG Ya-ping, YANG Lin-jun. Removal properties of sulfuric acid mist during limestone-gypsum flue gas desulfurization process[J]. J Southeast Univ:Nat Sci Ed, 2016,46(2):311-316.
16. [16]
  ZHOU Li-xing. Dynamics of Multiphase Turbulent Reacting Fluid Flows[M]. Beijing:National Defence Industry Press, 2002.
17. [17]
  KUO K K. Principles of Combustion[M]. New York:John Wiley and Sons, 1986.
18. [18]
  YUE Yong, CHEN Lei, YAO Qiang, LI Shui-qing. Study on characteristics of particulate matter size distribution and trace elements enrichment in emission from a pulverized coal-fired boiler[J]. Proc CSEE, 2005,25(18):74-79. doi: 10.3321/j.issn:0258-8013.2005.18.013
19. [19]
  CHANG Jing-cai. Experimental study on flexible collection electrode applied in advanced purification for coal fired flue gas following WFGD[D]. Jinan:Shangdong University, 2011.
20. [20]
  QI Li-qiang, YAN Wei-ping, YUAN Yong-tao. Physicochemical characteristics and the mechanism of fly ash escaped from electrostatic precipitator of coal-fired boiler[J]. Proc CSEE, 2007,27(5):45-48.
21. [21]
  MOSER R E. SO₃ impacts on plant O&M:part Ⅰ[J]. Power, 2005,150(8):10-15.
22. [22]
  LOU Qing-gang. Study on the formation mechanism of SO₃ during coal burning[J]. Energy Eng, 2008,6(1):46-49.
23. [23]
  XIAO Gang, JIN Bao-sheng, LIU Ji-chi, ZHONG Zhao-ping, XIAO Rui, HUANG Ya-ji, ZHONG Wen-qi, WANG Xiao-fang, XU Yan. Quantitative analysis of dissolution rate of limestone used in WFGD[J]. J Southeast Univ:Nat Sci Ed, 2008,38(6):1029-1033. doi: 10.3969/j.issn.1001-0505.2008.06.018
24. [24]
  YAN Jin-pei, YANG Lin-jun, BAO Jing-jing. Impact property on fine particles from coal combustion in wet flue gas desulfurization process[J]. J Southeast Univ:Nat Sci Ed, 2011,41(2):387-392.
1. [1]
  Donghui PAN , Yuping XU , Xinyu WANG , Lizhen WANG , Junjie YAN , Dongjian SHI , Min YANG , Mingqing CHEN . Preparation and in vivo tracing of ⁶⁸Ga-labeled PM_2.5 mimetic particles for positron emission tomography imaging. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 669-676. doi: 10.11862/CJIC.20230468
2. [2]
  Cuiwu MO , Gangmin ZHANG , Chao WU , Zhipeng HUANG , Chi ZHANG . A(NH₂SO₃) (A=Li, Na): Two ultraviolet transparent sulfamates exhibiting second harmonic generation response. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1387-1396. doi: 10.11862/CJIC.20240045
3. [3]
  Kun Rong , Cuilian Wen , Jiansen Wen , Xiong Li , Qiugang Liao , Siqing Yan , Chao Xu , Xiaoliang Zhang , Baisheng Sa , Zhimei Sun . 层状MoS₂/Ti₃C₂T_x异质结光热转换材料用于太阳能驱动水蒸发. Acta Physico-Chimica Sinica, 2025, 41(6): 100053-. doi: 10.1016/j.actphy.2025.100053
4. [4]
  Haojie Duan , Hejingying Niu , Lina Gan , Xiaodi Duan , Shuo Shi , Li Li . Reinterpret the heterogeneous reaction of α-Fe₂O₃ and NO₂ with 2D-COS: The role of SDS, UV and SO₂. Chinese Chemical Letters, 2024, 35(6): 109038-. doi: 10.1016/j.cclet.2023.109038
5. [5]
  Wentao Lin , Wenfeng Wang , Yaofeng Yuan , Chunfa Xu . Concerted Nucleophilic Aromatic Substitution Reactions. University Chemistry, 2024, 39(6): 226-230. doi: 10.3866/PKU.DXHX202310095
6. [6]
  . . Chinese Journal of Inorganic Chemistry, 2024, 40(11): 0-0.
7. [7]
  Qianqian Liu , Xing Du , Wanfei Li , Wei-Lin Dai , Bo Liu . Synergistic Effects of Internal Electric and Dipole Fields in SnNb₂O₆/Nitrogen-Enriched C₃N₅ S-Scheme Heterojunction for Boosting Photocatalytic Performance. Acta Physico-Chimica Sinica, 2024, 40(10): 2311016-. doi: 10.3866/PKU.WHXB202311016
8. [8]
  Shihui Shi , Haoyu Li , Shaojie Han , Yifan Yao , Siqi Liu . Regioselectively Synthesis of Halogenated Arenes via Self-Assembly and Synergistic Catalysis Strategy. University Chemistry, 2024, 39(5): 336-344. doi: 10.3866/PKU.DXHX202312002
9. [9]
  Yajun Hou , Chuanzheng Zhu , Qiang Wang , Xiaomeng Zhao , Kun Luo , Zongshuai Gong , Zhihao Yuan . ~2.5 nm pores in carbon-based cathode promise better zinc-iodine batteries. Chinese Chemical Letters, 2024, 35(5): 108697-. doi: 10.1016/j.cclet.2023.108697
10. [10]
  Xingyang LI , Tianju LIU , Yang GAO , Dandan ZHANG , Yong ZHOU , Meng PAN . A superior methanol-to-propylene catalyst: Construction via synergistic regulation of pore structure and acidic property of high-silica ZSM-5 zeolite. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1279-1289. doi: 10.11862/CJIC.20240026
11. [11]
  Zhengyu Zhou , Huiqin Yao , Youlin Wu , Teng Li , Noritatsu Tsubaki , Zhiliang Jin . Synergistic Effect of Cu-Graphdiyne/Transition Bimetallic Tungstate Formed S-Scheme Heterojunction for Enhanced Photocatalytic Hydrogen Evolution. Acta Physico-Chimica Sinica, 2024, 40(10): 2312010-. doi: 10.3866/PKU.WHXB202312010
12. [12]
  Jing Wang , Pingping Li , Yuehui Wang , Yifan Xiu , Bingqian Zhang , Shuwen Wang , Hongtao Gao . Treatment and Discharge Evaluation of Phosphorus-Containing Wastewater. University Chemistry, 2024, 39(5): 52-62. doi: 10.3866/PKU.DXHX202309097
13. [13]
  Yu-Yu Tan , Lin-Heng He , Wei-Min He . Copper-mediated assembly of SO₂F group via radical fluorine-atom transfer strategy. Chinese Chemical Letters, 2024, 35(9): 109986-. doi: 10.1016/j.cclet.2024.109986
14. [14]
  Zhangshu Wang , Xin Zhang , Jixin Han , Xuebing Fang , Xiufeng Zhao , Zeyu Gu , Jinjun Deng . Exploration and Design of Experimental Teaching on Ultrasonic-Enhanced Synergistic Treatment of Ternary Composite Flooding Produced Water. University Chemistry, 2024, 39(5): 116-124. doi: 10.3866/PKU.DXHX202310056
15. [15]
  Daojuan Cheng , Fang Fang . Exploration and Implementation of Science-Education Integration in Organic Chemistry Teaching for Pharmacy Majors: A Case Study on Nucleophilic Substitution Reactions of Alkyl Halides. University Chemistry, 2024, 39(11): 72-78. doi: 10.12461/PKU.DXHX202403105
16. [16]
  Shuangxi Li , Huijun Yu , Tianwei Lan , Liyi Shi , Danhong Cheng , Lupeng Han , Dengsong Zhang . NO_x reduction against alkali poisoning over Ce(SO₄)₂-V₂O₅/TiO₂ catalysts by constructing the Ce⁴⁺–SO₄²⁻ pair sites. Chinese Chemical Letters, 2024, 35(5): 108240-. doi: 10.1016/j.cclet.2023.108240
17. [17]
  Ping Ye , Lingshuang Qin , Mengyao He , Fangfang Wu , Zengye Chen , Mingxing Liang , Libo Deng . 荷叶衍生多孔碳的零电荷电位调节实现废水中电化学捕集镉离子. Acta Physico-Chimica Sinica, 2025, 41(3): 2311032-. doi: 10.3866/PKU.WHXB202311032
18. [18]
  Yuanpei ZHANG , Jiahong WANG , Jinming HUANG , Zhi HU . Preparation of magnetic mesoporous carbon loaded nano zero-valent iron for removal of Cr(Ⅲ) organic complexes from high-salt wastewater. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1731-1742. doi: 10.11862/CJIC.20240077
19. [19]
  Yan LIU , Jiaxin GUO , Song YANG , Shixian XU , Yanyan YANG , Zhongliang YU , Xiaogang HAO . Exclusionary recovery of phosphate anions with low concentration from wastewater using a CoNi-layered double hydroxide/graphene electronically controlled separation film. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1775-1783. doi: 10.11862/CJIC.20240043
20. [20]
  Chunai Dai , Yongsheng Han , Luting Yan , Zhen Li , Yingze Cao . Preparation of Superhydrophobic Surfaces and Their Application in Oily Wastewater Treatment: Design of a Comprehensive Physical Chemistry Innovation Experiment. University Chemistry, 2024, 39(2): 34-40. doi: 10.3866/PKU.DXHX202307081

Get Citation

PDF

XML

Metrics

PDF Downloads(3)
Abstract views(980)
HTML views(90)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Experimental study on strengthening the electrostatic precipitation removal of PM2.5 and SO3 by desulfurization wastewater evaporation

Metrics

通讯作者: 陈斌, bchen63@163.com

Experimental study on strengthening the electrostatic precipitation removal of PM_2.5 and SO₃ by desulfurization wastewater evaporation