Citation: WU Da-kai, WANG Xu, GAO Xin-hua, MA Qing-xiang, ZHANG Jian-li, FAN Su-bing, ZHAO Tian-sheng. Preparation of layered K-Fe-Zn-Ti catalyst and its performance in the hydrogenation of carbon dioxide to light olefins[J]. Journal of Fuel Chemistry and Technology, ;2019, 47(8): 949-956. shu

Preparation of layered K-Fe-Zn-Ti catalyst and its performance in the hydrogenation of carbon dioxide to light olefins

State Key Laboratory of High-efficiency Utilization of Coal and Green Chemical Engineering, Ningxia University, Yinchuan 750021

Corresponding author: GAO Xin-hua, gxh@nxu.edu.cn ZHANG Jian-li, zhangjl@nxu.edu.cn
Received Date: 22 March 2019
Revised Date: 9 May 2019

Fund Project: the Key R & D Project of Ningxia 2018BEE03010the Natural Science Foundation of Ningxia 2018AAC02002The project was supported by the National Natural Science Foundation of China (21666030), the Natural Science Foundation of Ningxia (2018AAC02002) and the Key R & D Project of Ningxia (2018BEE03010)the National Natural Science Foundation of China 21666030

Figures(9)

A series of layered K-Fe-Zn-Ti catalysts with different Zn/Fe molar ratios were prepared by high-temperature solid state reaction and characterized by SEM, TEM, XRD, H₂-TPR, CO₂-TPD, XPS, N₂ sorption and TG measurements; the performance of K-Fe-Zn-Ti catalysts in the hydrogenation of CO₂ to light olefins was investigated. The results indicate that the K-Fe-Zn-Ti catalysts have the typical layered structure with K_2.3Fe_2.3Ti_5.7O₁₆ as the main phase. ZnFe₂O₄ appears on the Zn promoted K-Fe-Zn-Ti catalysts, which may reduce the crystallinity, enhance the surface basicity, and promote the adsorption of CO₂. The K-Fe-Zn-Ti catalysts exhibit high selectivity to olefins in CO₂ hydrogenation; the ratio of olefins to paraffins in the products (O/P) is higher than 6.5. The addition of Zn can enhance the formation of C₅⁺ hydrocarbons and especially C₄⁺ linear alpha-olefins (LAOs); the content of LAOs in C₄⁺ hydrocarbons over Zn promoted K-Fe-Zn-Ti reaches 75.2%, in comparison with the value of 54.6% over the Zn-free K-Fe-Ti catalyst. In particular, the 0.8K-1.8Fe-0.6Zn-1.3Ti catalyst displays the highest O/P value (7.8), although the effect of Zn content in the Zn-promoted K-Fe-Zn-Ti catalysts on the yield of heavy hydrocarbons and selectivity to alpha-olefins is less significant. Moreover, the K-Fe-Zn-Ti catalysts display high stability in CO₂ hydrogenation and the LMO structure remains almost intact after a long term reaction test of 100 h.
- layered K-Fe-Zn-Ti catalyst,
- CO₂ hydrogenation,
- light olefins,
- linear α-olefins
1. [1]
  WANG W, WANG S P, MA X B, GONG J L. Recent advances in catalytic hydrogenation of carbon dioxide[J]. Chem Soc Rev, 2011,40(7):3703-3727. doi: 10.1039/c1cs15008a
2. [2]
  WANG J J, YOU Z Y, ZHANG Q H, DENG W P, WANG Y. Synthesis of lower olefins by hydrogenation of carbon dioxide over supported iron catalysts[J]. Catal Today, 2013,215(41):186-193.
3. [3]
  WEI J, GE Q J, YAO R W, WEN Z Y, FANG C Y, GUO L S, XU H Y, SUN J. Directly converting CO₂ into a gasoline fuel[J]. Nat Commun, 2017,815174. doi: 10.1038/ncomms15174
4. [4]
  ROHDE M P, UNRUH D, SCHAUB G. Membrane application in Fischer-Tropsch synthesis to enhance CO₂ Hydrogenation[J]. Ind Eng Chem Res, 2005,44(25):9653-9658. doi: 10.1021/ie050289z
5. [5]
  SONG C. Global challenges and strategies for control, conversion and utilization of CO₂ for sustainable development involving energy, catalysis, adsorption and chemical processing[J]. Catal Today, 2006,115(1):2-32.
6. [6]
  PRASAD P S S, BAE J W, JUN K W, LEE K W. Fischer-Tropsch synthesis by carbon dioxide hydrogenation on Fe-based catalysts[J]. Catal Surv Asia, 2008,12(3):170-183.
7. [7]
  ZHANG Juan, CHEN Jian-gang, CHEN Cong-biao, WANG Zhan-xiu, WANG Jun-gang, SUN Yu-han. Secondary reaction of olefin over Co-based catalyst for Fischer-Tropsch synthesis[J]. Petrochem Technol, 2010,39(8):855-860.
8. [8]
  GUO L S, SUN J, JI X W, WEI J, WEN Z Y, YAO R W, XU H Y, QE Q J. Directly converting carbon dioxide to linearα-olefins on bio-promoted catalysts[J]. Commun Chem, 2018,111. doi: 10.1038/s42004-018-0012-4
9. [9]
  TU Jun-ling, XU Yong-jun, DING Ming-yue, WANG Tie-jun, WANG Long-long, WANG Min-long. Preparation of nano-structured Fe₃O₄ catalysts and their performance in Fischer-Tropsch synthesis[J]. J Fuel Chem Technol, 2015,43(7):839-845. doi: 10.3969/j.issn.0253-2409.2015.07.008
10. [10]
  WANG X, WU D K, ZHANG J L, GAO X H, MA Q X, FAN S B, ZAHO T S. Highly selective conversion of CO₂ to light olefins via Fischer-Tropsch synthesis over stable layered K-Fe-Ti catalysts[J]. Appl Catal A:Gen, 2019,573:32-40. doi: 10.1016/j.apcata.2019.01.005
11. [11]
  CHOI Y H, JANG Y J, PARK H, KIM W Y, LEE Y H, CHOI S H, LEE J S. Carbon dioxide Fischer-Tropsch synthesis:A new path to carbon-neutral fuels[J]. Appl Catal B:Environ, 2017,202:605-610. doi: 10.1016/j.apcatb.2016.09.072
12. [12]
  LI S Z, LI A W, KRISHNAMOORTHY S, IGLESIA E. Effects of Zn, Cu, and K promoters on the structure and on the reduction, carburization, and catalytic behavior of iron-based Fischer-Tropsch synthesis catalysts[J]. Catal Lett, 2001,77(4):197-205.
13. [13]
  WANG H L, YANG Y, XU J, WANG H, DING M Y, LI Y W. Study of bimetallic interactions and promoter effects of FeZn, FeMn and FeCr Fischer-Tropsch synthesis catalysts[J]. J Mol Catal A:Chem, 2010,326(1):29-40.
14. [14]
  LIU X M, LU M, YAN Z F, BELTRAMINI J. Recent advances in catalysts for methanol synthesis via hydrogenation of CO and CO₂[J]. Ind Eng Chem Res, 2003,42(25):6518-6530. doi: 10.1021/ie020979s
15. [15]
  SHIDO T, IWASSAWA Y. Reactant-promoted reaction mechanism for water-gas shift reaction on ZnO, as the genesis of surface catalysis[J]. J Catal, 1991,129(2):343-355.
16. [16]
  MASAHIRO S, WU J G, KAZUMI T, ISAO T, KAZUHISA M. Effects of ZnO contained in supported Cu-based catalysts on their activities for several reactions[J]. Catal Lett, 2002,83(1/2):1-4. doi: 10.1023/A:1020693226903
17. [17]
  KOOHSARYAN E, ANBIA M. Nanosized and hierarchical zeolites:A short review[J]. Chin J Catal, 2016,37(4):447-467.
18. [18]
  ZHANG Li-li, YANG Juan, ZHANG Wei-guang, LU Lu-de, YANG Xu-jie, WANG Xin. Preparation of ultrafine K₂La₂Ti₃O₁₀ by soft chemistry method at low temperature and its exfoliation behavior[J]. Chin J Appl Chem, 2005,22(1):64-66.
19. [19]
  WU Da-xiong, ZHU Hai-tao, SUN Kai. Exfoliation and photocatalytic activity of layered K-Fe-Ti oxide[J]. New Chem Mater, 2009,37(9):56-57. doi: 10.3969/j.issn.1006-3536.2009.09.018
20. [20]
  WANG S R, ZHANG J X, YANG J D, GAO X L. Spinel ZnFe₂O₄ nanoparticle-decorated rod-like ZnO nanohetero structures for enhanced gas sensing performances[J]. Rsc Adv, 2015,5(13):10048-10057. doi: 10.1039/C4RA14033H
21. [21]
  LU Y E, YAN Q G, HAN J, CAO B B, STREET J, YU F. Fischer-Tropsch synthesis of olefin-rich liquid hydrocarbons from biomass-derived syngas over carbon-encapsulated iron carbide/iron nanoparticles catalyst[J]. Fuel, 2017,193:369-384. doi: 10.1016/j.fuel.2016.12.061
22. [22]
  ZHANG Jian-li, WANG Xu, Ma Li-ping, YU Xu-fei, MA Qing-xiang, FAN Su-bing, ZHAO Tian-sheng. Preparation of layered K/Mg-Fe-Al catalysts and its catalytic performances in CO hydrogenation[J]. J Fuel Chem Technol, 2017,45(12):1489-1498. doi: 10.3969/j.issn.0253-2409.2017.12.011
23. [23]
  LI Z L, WANG J J, QU Y Z, LIU H L. Highly selective conversion of carbon dioxide to lower olefins[J]. ACS Catal, 2017,7:8544-8548. doi: 10.1021/acscatal.7b03251
24. [24]
  ZHANG C H, YANG Y, TENG B T, LI T, ZHENG H, XIANG H, LI Y. Study of an iron-manganese Fischer-Tropsch synthesis catalyst promoted with copper[J]. J Catal, 2006,237(2):405-415.
25. [25]
  LIANG M S, KANG W K, XIE K C. Comparison of reduction behavior of Fe₂O₃, ZnO and ZnFe₂O₄ by TPR technique[J]. J Nat Gas Chem, 2009,18(1):110-113. doi: 10.1016/S1003-9953(08)60073-0
26. [26]
  GUO Wei, GAO Wen-gui, WANG Hua, TIAN Jun-jie, HAN Chong, QIN Zhi-qiang. Effect of Fe addition on Cu/Zn/ZrO₂ catalyst for hydrogenation of carbon dioxide to higher alcohol[J]. Mater Rev, 2013,27(20):44-47.
27. [27]
  MAZAN M O, MARRERO-JEREZ J, SOLDATI A, NÚÑEZ P, LARRONDO S A. Fe-doped ceria nanopowders synthesized by freeze-drying precursor method for electrocatalytic applications[J]. Int J Hydrogen Energy, 2015,40(10):3981-3989. doi: 10.1016/j.ijhydene.2015.01.006
28. [28]
  MA Li-ping, ZHANG Jian-li, MA Qing-xiang, FAN Su-bing, ZHAO Tian-sheng. Direct synthesis of light olefins from CO hydrogenation over K/MgFeZn-HTLcs catalysts[J]. J Fuel Chem Technol, 2016,44(4):449-456. doi: 10.3969/j.issn.0253-2409.2016.04.009
29. [29]
  DING M Y, YANG Y, LI Y W, WANG T J, MA L L, WU C Z. Impact of H₂/CO ratios on phase and performance of Mn-modified Fe-based Fischer-Tropsch synthesis catalyst[J]. Appl Energy, 2013,112(4):1241-1246.
30. [30]
  SUO H Y, WANG S G, ZHANG C H, XU J, WU B, YANG Y, XIANG H W, LI Y W. Chemical and structural effects of silica in iron-based Fischer-Tropsch synthesis catalysts[J]. J Catal, 2012,286(2):111-123.
1. [1]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
2. [2]
  Feifei Yang , Wei Zhou , Chaoran Yang , Tianyu Zhang , Yanqiang Huang . Enhanced Methanol Selectivity in CO₂ Hydrogenation by Decoration of K on MoS₂ Catalyst. Acta Physico-Chimica Sinica, 2024, 40(7): 2308017-0. doi: 10.3866/PKU.WHXB202308017
3. [3]
  Qinhui Guan , Yuhao Guo , Na Li , Jing Li , Tingjiang Yan . Molecular sieve-mediated indium oxide catalysts for enhancing photocatalytic CO₂ hydrogenation. Acta Physico-Chimica Sinica, 2025, 41(11): 100133-0. doi: 10.1016/j.actphy.2025.100133
4. [4]
  Liuyun Chen , Wenju Wang , Tairong Lu , Xuan Luo , Xinling Xie , Kelin Huang , Shanli Qin , Tongming Su , Zuzeng Qin , Hongbing Ji . Soft template-induced deep pore structure of Cu/Al₂O₃ for promoting plasma-catalyzed CO₂ hydrogenation to DME. Acta Physico-Chimica Sinica, 2025, 41(6): 100054-0. doi: 10.1016/j.actphy.2025.100054
5. [5]
  Yongqing Xu , Yuyao Yang , Mengna Wu , Xiaoxiao Yang , Xuan Bie , Shiyu Zhang , Qinghai Li , Yanguo Zhang , Chenwei Zhang , Robert E. Przekop , Bogna Sztorch , Dariusz Brzakalski , Hui Zhou . Review on Using Molybdenum Carbides for the Thermal Catalysis of CO₂ Hydrogenation to Produce High-Value-Added Chemicals and Fuels. Acta Physico-Chimica Sinica, 2024, 40(4): 2304003-0. doi: 10.3866/PKU.WHXB202304003
6. [6]
  Xiaorui Chen , Xuan Luo , Tongming Su , Xinling Xie , Liuyun Chen , Yuejing Bin , Zuzeng Qin , Hongbing Ji . Ga-doped Cu/γ-Al₂O₃ bifunctional interface sites promote the direct hydrogenation of CO₂ to DME. Acta Physico-Chimica Sinica, 2025, 41(10): 100126-0. doi: 10.1016/j.actphy.2025.100126
7. [7]
  Huihua GONG , Tianhua CUI , Li JI , Liyuan ZHANG , Xueli ZHENG , Haiyan FU , Hua CHEN , Jiawei MAO , Ruixiang LI . Efficient hydrogenation of CO₂ realized by Ru-NNN complex. Chinese Journal of Inorganic Chemistry, 2026, 42(5): 1085-1095. doi: 10.11862/CJIC.20250321
8. [8]
  Huihua GONG , Tianhua CUI , Li JI , Jichuan ZHANG , Liyuan ZHANG , Yan CHEN , Zhenye WANG , Jiaqi XU , Ruixiang LI . Hydrogenation of CO₂ to formate catalyzed by N-heterocyclic carbene-nitrogen-phosphine chelated iridium(Ⅰ) complexes. Chinese Journal of Inorganic Chemistry, 2025, 41(12): 2609-2620. doi: 10.11862/CJIC.20250170
9. [9]
  Wenwen Ma , Lian Kong , Jinyang Chu , Li Ma , Ziqing Ma , Heyu Cheng , Xinyuan Li , Zhan Yu , Zhen Zhao . Digitalization-Driven Olefin Production: Digital Design of Catalysts for CO₂-Assisted Oxidation Dehydrogenation of Ethane to Ethylene. University Chemistry, 2026, 41(1): 363-372. doi: 10.12461/PKU.DXHX202506055
10. [10]
  Zhipeng Bao , Yilin Wang , Yu Chen , Beirui Jia , Congcong Wang , Zean Xie , Xuehua Yu , Zhen Zhao . Digital and Intelligent Integration under the “Dual Carbon” Strategy: Plasma Reaction-Separation Coupling for CO₂ Hydrogenation to Methanol. University Chemistry, 2026, 41(1): 29-40. doi: 10.12461/PKU.DXHX202506009
11. [11]
  Beibei Gao , Lipeng Zhou , Dexin Yang . Integrating the “Dual Carbon” Concept into Teaching Reform of Physical Chemistry: A Case of CO₂ Hydrogenation to CH₃OH. University Chemistry, 2026, 41(3): 248-253. doi: 10.12461/PKU.DXHX202504011
12. [12]
  Xue Dong , Xiaofu Sun , Shuaiqiang Jia , Shitao Han , Dawei Zhou , Ting Yao , Min Wang , Minghui Fang , Haihong Wu , Buxing Han . Electrochemical CO₂ Reduction to C₂₊ Products with Ampere-Level Current on Carbon-Modified Copper Catalysts. Acta Physico-Chimica Sinica, 2025, 41(3): 100024-0. doi: 10.3866/PKU.WHXB202404012
13. [13]
  Jilei LIANG , Mengmeng WU , Lü QI , Yunqi LIU , Chenguang LIU . In-situ preparation of mesoporous carbon-encapsulated NiMoS hydrodesulfurization catalyst. Chinese Journal of Inorganic Chemistry, 2026, 42(10): 2127-2137. doi: 10.11862/CJIC.20260127
14. [14]
  Ruikang Su , Muyan Bai , Zhiqing Liu , Fang Fang , Yuena Yu . Wittig反应与可见光氧化还原催化融合构建烯烃. University Chemistry, 2026, 41(8): 370-379. doi: 10.12461/PKU.DXHX202507075
15. [15]
  Kun WANG , Wenrui LIU , Peng JIANG , Yuhang SONG , Lihua CHEN , Zhao DENG . Hierarchical hollow structured BiOBr-Pt catalysts for photocatalytic CO₂ reduction. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1270-1278. doi: 10.11862/CJIC.20240037
16. [16]
  Xueting Feng , Ziang Shang , Rong Qin , Yunhu Han . Advances in Single-Atom Catalysts for Electrocatalytic CO₂ Reduction. Acta Physico-Chimica Sinica, 2024, 40(4): 2305005-0. doi: 10.3866/PKU.WHXB202305005
17. [17]
  Lina Guo , Ruizhe Li , Chuang Sun , Xiaoli Luo , Yiqiu Shi , Hong Yuan , Shuxin Ouyang , Tierui Zhang . Effect of Interlayer Anions in Layered Double Hydroxides on the Photothermocatalytic CO₂ Methanation of Derived Ni-Al₂O₃ Catalysts. Acta Physico-Chimica Sinica, 2025, 41(1): 100002-0. doi: 10.3866/PKU.WHXB202309002
18. [18]
  Dong Xiang , Kunzhen Li , Kanghua Miao , Ran Long , Yujie Xiong , Xiongwu Kang . Amine-Functionalized Copper Catalysts: Hydrogen Bonding Mediated Electrochemical CO₂ Reduction to C₂ Products and Superior Rechargeable Zn-CO₂ Battery Performance. Acta Physico-Chimica Sinica, 2024, 40(8): 2308027-0. doi: 10.3866/PKU.WHXB202308027
19. [19]
  Fangfang Tan , Lele Zhang , Penghua Jing , Pengju Zhao , Yang Li . 烯烃光催化氧化制备二苯甲酮——介绍一个绿色合成综合实验. University Chemistry, 2026, 41(8): 380-388. doi: 10.12461/PKU.DXHX202507049
20. [20]
  Wenlong Wang , Wentao Hao , Lang He , Jia Qiao , Ning Li , Chaoqiu Chen , Yong Qin . Bandgap and adsorption engineering of carbon dots/TiO₂ S-scheme heterojunctions for enhanced photocatalytic CO₂ methanation. Acta Physico-Chimica Sinica, 2025, 41(9): 100116-0. doi: 10.1016/j.actphy.2025.100116

Get Citation

PDF

XML

Metrics

PDF Downloads(15)
Abstract views(1758)
HTML views(205)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142