Citation: HAO Cheng-hao, ZHU Sheng-hua, BAI Yong-hui, LI Fan. Effect of CO₂ on pyrolysis behavior of Shengli lignite[J]. Journal of Fuel Chemistry and Technology, ;2017, 45(3): 272-278. shu

Effect of CO₂ on pyrolysis behavior of Shengli lignite

State Key Laboratory Breeding Base of Coal Science and Technology Co-founded by Shanxi Province and the Ministry of Science and Technology, Taiyuan University of Technology, Taiyuan 030024, China

Corresponding author: LI Fan, lifan66@hotmail.com
Received Date: 2 November 2016
Revised Date: 30 December 2016

Figures(9)

The pyrolysis of Shengli lignite (5-8 mm) under CO₂ atmosphere was investigated at the temperature from 400 to 700℃ in a fixed bed reactor, the effect of CO₂ on the distribution of gas, solid and liquid phase in the product was analyzed, and the influence mechanism on the char structure under CO₂ atmosphere was explored. The results indicate that the yields of tar and water from pyrolysis under CO₂ atmosphere are higher than that under N₂ atmosphere, with a decrease in char and gas yield. At 400℃ and 500℃, the surface area and pore volume of the char prepared under CO₂ atmosphere are nearly the same as that under N₂ atmosphere, while at 600 and 700℃, the surface area and pore volume of the char prepared under CO₂ atmosphere are higher than that under N₂ atmosphere. It maybe attributes to that CO₂ can not only promote the release of volatile, but can also react with the active sites in the channels of char. The introduction of CO₂ into pyrolysis can increase the aromaticity of char due to the consumption of 3-5 rings aromatic structures. The yields of H₂ and CH₄ obtained from pyrolysis under CO₂ atmosphere are lower than that obtained under N₂ atmosphere at 600 and 700℃, and the yield of CO is much higher because of the occurrence of the char-CO₂ reaction.
- lignite,
- pyrolysis,
- char property,
- CO₂ atmosphere
1. [1]
  ZHAO Hong, GUO Fei, YANG Jian-guo. Adsorption characteristic of Indonesia Lignite and dewater experiment[J]. J China Coal Soc, 2008,33(7):799-802.
2. [2]
  YU J H, ARASH T, HAN Y N, YIN F K, LI X C. A review on water in low rank coals:The existence, interaction with coal structure and effects on coal utilization[J]. Fuel Process Technol, 2013,106(2):9-20.
3. [3]
  ÖZTAZTA N A, YÜRÜM Y. Pyrolysis of Turkish Zonguldak bituminous coal. Part 1. Effect of mineral matter[J]. Fuel, 2000,79(10):1221-1227. doi: 10.1016/S0016-2361(99)00255-0
4. [4]
  GAN Jian-ping, MA Bao-qi, SHANG Jian-xuan, MA Xiao-xun, YANG Zhan-biao. Formation and development of the coal grading conversion ideas[J]. Coal Chem Ind, 2013,41(1):3-6.
5. [5]
  ZHOU Jun, YANG Zhe, WU Lei, ZHANG Qiu-li, LAN Xin-zhe, SHANG Wen-zhi. Study on microwave pyrolysis of low rank coal under CO₂ atmosphere[J]. J China Coal Soc, 2015,40(10):2465-2471.
6. [6]
  GAO S P, ZHAO J T, WANG Z Q, WANG J F, Fang Y T, HUANG J J. Effect of CO₂ on pyrolysis behaviors of lignite[J]. Thin Solid Films, 2013,41(3):257-264.
7. [7]
  DUAN Lun-bo, ZHAO Chang-sui, ZHOU Wu, QU Cheng-rui, LI Ying-jie, CHEN Xiao-ping. Effect of CO₂ atmosphere on the pyrolysis process of bituminous coal[J]. Proc CSEE, 2010,30(2):62-66.
8. [8]
  GUIZANI C, SANZ F J E, SALVADOR S. Effects of CO₂ on biomass fast pyrolysis:Reaction rate, gas yields and char reactive properties[J]. Fuel, 2014,116:310-320. doi: 10.1016/j.fuel.2013.07.101
9. [9]
  JAMIL K, HAYASHI J I, LI C Z. Pyrolysis of a Victorian brown coal and gasification of nascent char in CO₂ atmosphere in a wire-mesh reactor[J]. Fuel, 2004,83(7/8):833-843.
10. [10]
  WANG P F, JIN L J, LIU J H, ZHU S W, HU H Q. Analysis of coal tar derived from pyrolysis at different atmospheres[J]. Fuel, 2013,104(2):14-21.
11. [11]
  LI X J, HAYASHI J I, LI C Z. FT-Raman spectroscopic study of the evolution of char structure during the pyrolysis of a Victorian brown coal[J]. Fuel, 2006,85(12):1700-1707.
12. [12]
  LI X J, HAYASHI J I, LI C Z. Volatilisation and catalytic effects of alkali and alkaline earth metallic species during the pyrolysis and gasification of Victorian brown coal. Part Ⅶ. Raman spectroscopic study on the changes in char structure during the catalytic gasification in air[J]. Fuel, 2006,85(10/11):1509-1517.
13. [13]
  ZHANG S, MIN Z H, TAY H L, ASADULLAH M, LI C Z. Effects of volatile-char interactions on the evolution of char structure during the gasification of Victorian brown coal in steam[J]. Fuel, 2011,90(4):1529-1535. doi: 10.1016/j.fuel.2010.11.010
14. [14]
  NAREDI P, PISUPATI S. Effect of CO₂ during coal pyrolysis and char burnout in oxy-coal combustion[J]. Energy Fuels, 2011,25(6):2452-2459. doi: 10.1021/ef200197w
15. [15]
  CAI H Y, MEGARITIS A, MESSENBÖCK R, DIX M, DUGGWELL D R, KANDIYOTI R. Pyrolysis of coal maceral concentrates under pf-combustion conditions (Ⅰ):Changes in volatile release and char combustibility as a function of rank[J]. Fuel, 1998,77(12):1273-1282. doi: 10.1016/S0016-2361(98)00039-8
16. [16]
  LIU Yuan, HE Xin-fu, YANG Fu-sheng, ZHANG Ya-gang, REN Xiu-bin, ZHOU An-ning. Impacts of pyrolysis temperature and atmosphere on product distribution of Shenfu coal pyrolysis[J]. J China Coal Soc, 2015,40(S2):497-504.
17. [17]
  QIU Ji-hua. Variation of surface area and pore structure of pulverized coal during pyrolysis[J]. J Fuel Chem Technol, 1994,22(3):316-320.
18. [18]
  LORENZ H, CARREA E, TAMURA M, HAAS J. The role of char surface structure development in pulverized fuel combustion[J]. Fuel, 2000,79(10):1161-1172. doi: 10.1016/S0016-2361(99)00259-8
19. [19]
  ZHOU Yi, DUAN Yu-feng, CHEN Xiao-ping, ZHAO Chang-sui, WU Xin. Influential factors on pore structure of coal-char[J]. Boiler Technol, 2005,36(4):34-38.
20. [20]
  BAI Yong-hui. Influence mechanism of CO₂ on char-steam gasification[D]. Taiyuan:Taiyuan University of Technology, 2014.
21. [21]
  ASADULLAH M, ZHANG S, MIN Z H, YIMSIRI P, LI C Z. Effects of biomass char structure on its gasification reactivity[J]. Bioresour Technol, 2010,101(20):7935-43. doi: 10.1016/j.biortech.2010.05.048
22. [22]
  SHEN Jun, WANG Zhi-zhong. Study on variation of micro-pores ( < 100 nm) and volatile components of different rank coals during carbonization[J]. J China Coal Soc, 2007,32(6):626-629.
23. [23]
  LIU Xiao-fei, YOU Jing-lin, WANG Yuan-yuan, LU Li-ming, XIE Ying-fang, YU Li-wang, FU Qing. Raman spectroscopic study on the pyrolysis of Australian bituminous coal[J]. J Fuel Chem Technol, 2014,42(3):270-276. doi: 10.1016/S1872-5813(14)60019-0
24. [24]
  ZHAO Li-hong, GUO Hui-qing, MA Qing-lan. Study on gaseous products distributions during coal pyrolysis[J]. Coal Convers, 2007,30(1):5-9.
25. [25]
  ARENILLAS A, RUBIERA F, PIS J J. Simultaneous thermogravimetric-mass spectrometric study on the pyrolysis behaviour of different rank coals[J]. J Anal Appl Pyrolysis, 1999,50(1):31-46. doi: 10.1016/S0165-2370(99)00024-8
26. [26]
  HE Xuan-ming. Coal Chemistry[M]. Version 2. Beijing:Metallurgical Industry Press, 2010.
27. [27]
  ZHU Xue-dong, ZHU Zi-bin, TANG Li-hua, ZHANG Cheng-fang. Fundamental study on the pyrolysis of coals[J]. J East China Univ Sci Technol, 1998,24(1):37-41.
1. [1]
  Zhaohong Zuo , Wenhao Qiu , Kehan Peng , Haowen Luo , Yihan Wang , Yunren Shi . 聚乙烯热解的AI辅助ReaxFF动力学虚拟仿真实验. University Chemistry, 2026, 41(10): 296-308. doi: 10.12461/PKU.DXHX202510010
2. [2]
  Yongqing Xu , Yuyao Yang , Mengna Wu , Xiaoxiao Yang , Xuan Bie , Shiyu Zhang , Qinghai Li , Yanguo Zhang , Chenwei Zhang , Robert E. Przekop , Bogna Sztorch , Dariusz Brzakalski , Hui Zhou . Review on Using Molybdenum Carbides for the Thermal Catalysis of CO₂ Hydrogenation to Produce High-Value-Added Chemicals and Fuels. Acta Physico-Chimica Sinica, 2024, 40(4): 2304003-0. doi: 10.3866/PKU.WHXB202304003
3. [3]
  Yulian Hu , Xin Zhou , Xiaojun Han . A Virtual Simulation Experiment on the Design and Property Analysis of CO₂ Reduction Photocatalyst. University Chemistry, 2025, 40(3): 30-35. doi: 10.12461/PKU.DXHX202403088
4. [4]
  Jiahong WANG , Zekun XU , Tianjiao LU , Jinming HUANG . Performance of N, Mn doped semi-coke activated carbon catalyzed ozone oxidation for the degradation of tetracycline hydrochloride in water. Chinese Journal of Inorganic Chemistry, 2025, 41(12): 2549-2560. doi: 10.11862/CJIC.20250120
5. [5]
  Yang ZHOU , Lili YAN , Wenjuan ZHANG , Pinhua RAO . Thermal regeneration of biogas residue biochar and the ammonia nitrogen adsorption properties. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1574-1588. doi: 10.11862/CJIC.20250032
6. [6]
  Zhuo WANG , Junshan ZHANG , Shaoyan YANG , Lingyan ZHOU , Yedi LI , Yuanpei LAN . Preparation and photocatalytic performance of CeO₂-reduced graphene oxide by thermal decomposition. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1708-1718. doi: 10.11862/CJIC.20240067
7. [7]
  Hong Dong , Feng-Ming Zhang . Covalent organic frameworks for artificial photosynthetic diluted CO2 reduction. Chinese Journal of Structural Chemistry, 2024, 43(7): 100307-100307. doi: 10.1016/j.cjsc.2024.100307
8. [8]
  Ping Wang , Tianbao Zhang , Zhenxing Li . Reconstruction mechanism of Cu surface in CO2 reduction process. Chinese Journal of Structural Chemistry, 2024, 43(8): 100328-100328. doi: 10.1016/j.cjsc.2024.100328
9. [9]
  Muhammad Humayun , Mohamed Bououdina , Abbas Khan , Sajjad Ali , Chundong Wang . Designing single atom catalysts for exceptional electrochemical CO2 reduction. Chinese Journal of Structural Chemistry, 2024, 43(1): 100193-100193. doi: 10.1016/j.cjsc.2023.100193
10. [10]
  Mingming Zhang , Ting Xu , Ruonan Yin , Xueqiu Chen , Zheng-Jun Wang , Jun Li , Xin Wang , Huile Jin , Haibo Ke , Shun Wang , Jing-Jing Lv . Anode engineering for electrocatalytic CO₂ reduction reaction. Chinese Chemical Letters, 2026, 37(3): 110665-. doi: 10.1016/j.cclet.2024.110665
11. [11]
  Huihua GONG , Tianhua CUI , Li JI , Liyuan ZHANG , Xueli ZHENG , Haiyan FU , Hua CHEN , Jiawei MAO , Ruixiang LI . Efficient hydrogenation of CO₂ realized by Ru-NNN complex. Chinese Journal of Inorganic Chemistry, 2026, 42(5): 1085-1095. doi: 10.11862/CJIC.20250321
12. [12]
  Zixuan Zhu , Xianjin Shi , Yongfang Rao , Yu Huang . Recent progress of MgO-based materials in CO₂ adsorption and conversion: Modification methods, reaction condition, and CO₂ hydrogenation. Chinese Chemical Letters, 2024, 35(5): 108954-. doi: 10.1016/j.cclet.2023.108954
13. [13]
  Hui Bian , Xinyi Yuan , Nan Zhang , Zhuo Xu , Juhong Lian , Ruibin Jiang , Junqing Yan , Deng Li , Shengzhong (Frank) Liu . Correlating vacancy-defect density with CO₂ activation for promoted CO₂ methanation over CsPbBr₃ photocatalyst. Chinese Chemical Letters, 2025, 36(7): 111034-. doi: 10.1016/j.cclet.2025.111034
14. [14]
  Chong GAO , Tianyun LIU , Zhiyuan XING , Wenjun YANG , Yang PENG . Covalent organic frameworks enhancing CO₂ mass transfer for high-rate CO₂ electroreduction. Chinese Journal of Inorganic Chemistry, 2026, 42(9): 1997-2007. doi: 10.11862/CJIC.20260109
15. [15]
  Xiaofan ZHANG , Yu DUAN , Meijie SHI , Nan LU , Renhong LI , Xiaoqing YAN . Z-scheme Co₃O₄/BiOBr heterojunction for efficient photoreduction CO₂ reduction. Chinese Journal of Inorganic Chemistry, 2025, 41(9): 1878-1888. doi: 10.11862/CJIC.20250079
16. [16]
  Pu ZHANG , Youzhu YU , Yuhua GUO , Zhongyuan ZHOU . Syntheses and photocatalytic CO₂ reduction properties of heterometallic Ni/Sn and Co/Sn oxo clusters. Chinese Journal of Inorganic Chemistry, 2026, 42(5): 1039-1047. doi: 10.11862/CJIC.20250353
17. [17]
  Muzi Li , Xin Zhang , Xiang-Jing Kong , Qiancheng Chen , Xuefeng Bai , Tao He , Jian-Rong Li . Ion exchange for enhancing MOF adsorbents performance in humid C₂H₂/CO₂ separation. Chinese Chemical Letters, 2026, 37(3): 110709-. doi: 10.1016/j.cclet.2024.110709
18. [18]
  Lingxiang Bao , Jing-Hong Li , Rui-Biao Lin , Jianyuan Wu , Zhenhong Tan , Wu Xie , Wenhai Ji , Dong Zhang , Anucha Koedtruad , Jingjing Ma , Wang Hay Kan , Feng Pan , Toru Ishigaki , Takashi Kamiyama , Ping Miao . Elucidation of the CO₂ adsorption mechanism of [Zn₂(mtz)₂(ox)] using neutron powder diffraction. Chinese Chemical Letters, 2026, 37(5): 110864-. doi: 10.1016/j.cclet.2025.110864
19. [19]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
20. [20]
  Linlu Bai , Wensen Li , Xiaoyu Chu , Haochun Yin , Yang Qu , Ekaterina Kozlova , Zhao-Di Yang , Liqiang Jing . Effects of nanosized Au on the interface of zinc phthalocyanine/TiO₂ for CO₂ photoreduction. Chinese Chemical Letters, 2025, 36(2): 109931-. doi: 10.1016/j.cclet.2024.109931

Get Citation

PDF

XML

Metrics

PDF Downloads(6)
Abstract views(2310)
HTML views(319)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Effect of CO2 on pyrolysis behavior of Shengli lignite

Metrics

通讯作者: 陈斌, bchen63@163.com

Effect of CO₂ on pyrolysis behavior of Shengli lignite