Citation: MA Ya-shi, HU Xiao-fei, LIU Xia, GUO Qing-hua, YU Guang-suo. Study on ash fusion and viscosity temperature characteristics modification of Shanxi typical high aluminum coal[J]. Journal of Fuel Chemistry and Technology, ;2017, 45(11): 1303-1309. shu

Study on ash fusion and viscosity temperature characteristics modification of Shanxi typical high aluminum coal

Key Laboratory of Coal Gasification and Energy Chemical Engineering of Ministry of Education, East China University of Science & Technology, Shanghai 200237, China

Corresponding author: LIU Xia, gsyu@ecust.edu.cn YU Guang-suo, lxia@ecust.edu.cn
Received Date: 28 July 2017
Revised Date: 29 August 2017

Fund Project: the National Natural Science Foundation of China 21676091The project was supported by the National Natural Science Foundation of China (21676091)

Figures(8)

In this work, the influences of two industrial fluxes (i.e. limestone and clay) and their composite flux on ash fusion and viscosity temperature characteristics of Shanxi typical high-alumina coals were explored, respectively. The results indicated that flow temperature of coal ash decreased with increasing additive amount of flux. Moreover, limestone exhibited a better flux effect than clay, among which the flux effect of composite flux was more obvious than that of the single fluxes. It was also found that limestone could significantly reduce the t_cv of coal ash slag and clay could promote the slag type transformation towards glassy slag. Compared with single fluxes, composite flux exhibited synergistic effect on both the significant reduction of t_cv and the promotion of slag type transformation. For Shanxi typical high-alumina Liangdu coal, when total amount of composite flux was 4% (2% limestone+2% clay), not only the slag transformed into glassy slag, but also t_cv of the slag decreased 133 and 222 ℃ compared with single flux limestone(2%) and clay (6%), respectively. Minerals analysis results confirmed the fluxing principle of different fluxes. After the addition of composite flux, Shanxi high-alumina coals could meet the requirements of industrial entrained-flow gasifier.
- high-aluminum coal,
- composite flux,
- ash fusion characteristics,
- viscosity temperature characteristics
1. [1]
  SAFRONOV D, FÖRSTER T, SCHWITALLA D, NIKRITYUK P, GUHL S, RICHTER A, MEYER B. Numerical study on entrained-flow gasification performance using combined slag model and experimental characterization of slag properties[J]. Fuel Process Technol, 2017,161:62-75. doi: 10.1016/j.fuproc.2017.03.007
2. [2]
  YU Guang-suo, NIU Miao-ren, WANG Yi-fei, LIANG Qin-feng, YU Zun-hong. Application status and development tendency of coal entrained-bed gasification[J]. Mod Chem Ind, 2004,24(5):23-26.
3. [3]
  BAI Jin, KONG Ling-xue, LI Huai-zhu, GUO Zhen-xing, BAI Zong-qing, WEI Chi-wei, LI Wen. Adjustment in high temperature flow property of ash from Shanxi typical anthracite[J]. J Fuel Chem Technol, 2013,41(7):805-813.
4. [4]
  NINOMIYA Y, SATO A. Ash melting behavior under coal gasification conditions[J]. Energy Convers Manage, 1997,38(10):1405-1412.
5. [5]
  KONDRATIEV A, JAK E. Predicting coal ash slag flow characteristics (viscosity model for the Al₂O₃-CaO-'FeO'-SiO₂ system)[J]. Fuel, 2001,80(14):1989-2000. doi: 10.1016/S0016-2361(01)00083-7
6. [6]
  JING N J, WANG Q H, YANG Y K, CHENG L M, LUO Z Y, CEN K F. Influence of ash composition on the sintering behavior during pressurized combustion and gasification process[J]. J Zhejiang Univ-Sci A, 2012,13(3):230-238. doi: 10.1631/jzus.A1100206
7. [7]
  HURST H J, NOVAK F, PATTERSON J H. Phase diagram approach to the fluxing effect of additions of CaCO₃ on Australian coal ashes[J]. Energy Fuels, 1996,10(6):1215-1219. doi: 10.1021/ef950264k
8. [8]
  YAO Xing-yi. Relationship of coal ash fusibility to chemical composition[J]. J Fuel Chem Technol, 1965,6(2):151-161.
9. [9]
  DAI Ting-kui. Study on improving ash fusibility and fluxing mechanism of high alumina coal[D]. Huainan:Anhui Univ Sci Technol, 2016.
10. [10]
  XIAO H X, LI F H, LIU Q R, JI S H, FAN S H, FAN H L, XU M L, GUO Q Q, MA M J, MA X W. Modification of ash fusion behavior of coal with high ash fusion temperature by red mud addition[J]. Fuel, 2017,192:121-127. doi: 10.1016/j.fuel.2016.12.012
11. [11]
  LI Wen, BAI Jin. Chemistry of Ash from Coal[M]. Beijing:Science Press, 2013.
12. [12]
  HUANG Qian-jun. The product of base/acid and silica/alumina of ash in steal coal-An index to ash slagging tendency[J]. Power Eng, 2004,24(3):340-344.
13. [13]
  SONG W J, TANG L H, ZHU X D, WU Y Q, ZHU Z B, KOYAMA S. Effect of coal ash composition on ash fusion temperatures[J]. Energy Fuels, 2009,24(1):182-189.
14. [14]
  XU Jie, LIU Xia, ZHANG Qing, ZHAO Feng, GUO Qing-hua, WANG Fu-chen. Research on ash fusibility and viscosity-temperature characteristic of high-calcium Shanxin coal ash[J]. Proc CSEE, 2013, 33(20):46-51.
15. [15]
  LIU X, YU G, XU J, LIANG Q, LIU H. Viscosity fluctuation behaviors of coal ash slags with high content of calcium and low content of silicon[J]. Fuel Process Technol, 2017,158:115-122. doi: 10.1016/j.fuproc.2016.12.013
16. [16]
  LIU Xia, LIANG Qin-feng, LIU Hai-feng, YU Guang-suo, GONG Xin. Measurement condition of coal ash viscosity-temperature characteristics[J]. J East China Univ Sci Technol:Nat Sci Ed, 2015,1004.
17. [17]
  DING Jia-hai. Coal adaptability experience in SE pulverized coal gasification[J]. Large Scale Nitrogenous Fertilizer Ind, 2016,39(6):361-365.
18. [18]
  TSURUDA A, ARMA L H, TAKEBE H. Viscosity measurement and prediction of gasified and synthesized coal slag melts[J]. Fuel, 2017,200:521-528. doi: 10.1016/j.fuel.2017.03.094
19. [19]
  ILYUSHECHKIN A Y, HLA S S. Viscosity of high-iron slags from Australian coals[J]. Energy Fuels, 2013,27(7):3736-3742. doi: 10.1021/ef400593k
20. [20]
  WU G, YAZHENSKIKH E, HACK K, WOSCH E, MVLLER M. Viscosity model for oxide melts relevant to fuel slags. Part 1:Pure oxides and binary systems in the system SiO₂-Al₂O₃-CaO-MgO-Na₂O-K₂O[J]. Fuel Process Technol, 2015,137:93-103. doi: 10.1016/j.fuproc.2015.03.025
21. [21]
  DAI Bai-qian, WU Xiao-jiang, CHEN Yu-shuang, ZHANG Zhong-xiao. Experimental study and quantum chemistry calculation on coal ash fusion behavior and related mineral evolution mechanism[J]. J Chin Soc Power Eng, 2014,34(1):70-76.
1. [1]
  Xin XIONG , Qian CHEN , Quan XIE . First principles study of the photoelectric properties and magnetism of La and Yb doped AlN. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1519-1527. doi: 10.11862/CJIC.20240064
2. [2]
  Xueyu Lin , Ruiqi Wang , Wujie Dong , Fuqiang Huang . Rational Design of Bimetallic Oxide Anodes for Superior Li⁺ Storage. Acta Physico-Chimica Sinica, 2025, 41(3): 100021-0. doi: 10.3866/PKU.WHXB202311005
3. [3]
  Lizhu SUN , Jinyun WANG , Zhongning CHEN , Ping DUAN , Qianchong ZHANG . Modulation of charge transport in platinum(Ⅱ) bis(acetylide) complexes by coordination configuration. Chinese Journal of Inorganic Chemistry, 2026, 42(11): 2381-2388. doi: 10.11862/CJIC.20260207
4. [4]
  Yuting Bai , Cenqi Yan , Zhen Li , Jiaqiang Qin , Pei Cheng . Preparation of High-Strength Polyimide Porous Films with Thermally Closed Pore Property by In Situ Pore Formation Method. Acta Physico-Chimica Sinica, 2024, 40(9): 2306010-0. doi: 10.3866/PKU.WHXB202306010
5. [5]
  Xuyu WANG , Xinran XIE , Dengke CAO . Photoreaction characteristics and luminescence modulation in phosphine-anthracene-based Au(Ⅰ) and Ir(Ⅲ) complexes. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1513-1522. doi: 10.11862/CJIC.20250113
6. [6]
  Gang ZHANG , Jian ZHANG , Haiyang CHU , Chongxin QIAN , Lai WEI . Chlorobenzene additive-assisted regulation of (PMA)₂PbBr₄ crystal growth and photoelectric properties. Chinese Journal of Inorganic Chemistry, 2026, 42(4): 713-721. doi: 10.11862/CJIC.20250318
7. [7]
  Yanbo LIU , Jiadong LIU , Qing XIONG , Wutong ZHANG , Zhaosheng ZHANG . First-principles study on the optoelectronic properties and defect characteristics of CeBN₃ (B=Ta, Nb). Chinese Journal of Inorganic Chemistry, 2026, 42(6): 1155-1163. doi: 10.11862/CJIC.20260018
8. [8]
  Zehao Zhang , Zheng Wang , Haibo Li . Preparation of 2D V₂O₃@Pourous Carbon Nanosheets Derived from V₂CF_x MXene for Capacitive Desalination. Acta Physico-Chimica Sinica, 2024, 40(8): 2308020-0. doi: 10.3866/PKU.WHXB202308020
9. [9]
  Yu Peng , Jiawei Chen , Yue Yin , Yongjie Cao , Mochou Liao , Congxiao Wang , Xiaoli Dong , Yongyao Xia . Tailored cathode electrolyte interphase via ethylene carbonate-free electrolytes enabling stable and wide-temperature operation of high-voltage LiCoO₂. Acta Physico-Chimica Sinica, 2025, 41(8): 100087-0. doi: 10.1016/j.actphy.2025.100087
10. [10]
  Junke LIU , Kungui ZHENG , Wenjing SUN , Gaoyang BAI , Guodong BAI , Zuwei YIN , Yao ZHOU , Juntao LI . Preparation of modified high-nickel layered cathode with LiAlO₂/cyclopolyacrylonitrile dual-functional coating. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1461-1473. doi: 10.11862/CJIC.20240189
11. [11]
  Yuqiong Li , Bing Lan , Bin Guan , Chunlong Dai , Fan Zhang , Zifeng Lin . Molten Salt Derived Mo₂CT_x MXene with Excellent Catalytic Performance for Hydrogen Evolution Reaction. Acta Physico-Chimica Sinica, 2024, 40(9): 2306031-0. doi: 10.3866/PKU.WHXB202306031
12. [12]
  Qiang Wu , Wenhua Hou . Teaching Classical Contents Newly: Taking Temperature–Entropy Diagram as an Example. University Chemistry, 2025, 40(4): 399-407. doi: 10.12461/PKU.DXHX202407102
13. [13]
  Guoqiang Chen , Zixuan Zheng , Wei Zhong , Guohong Wang , Xinhe Wu . Molten Intermediate Transportation-Oriented Synthesis of Amino-Rich g-C₃N₄ Nanosheets for Efficient Photocatalytic H₂O₂ Production. Acta Physico-Chimica Sinica, 2024, 40(11): 2406021-0. doi: 10.3866/PKU.WHXB202406021
14. [14]
  Qiang Zhou , Yu Huang , Jiahe Li , Wei Shao , Wanqun Hu , Pingping Zhu . Design and Practice of Ideological and Political Cases in the Course of Polymer Physics Experiments: Taking “3D Printing Based on Fused Deposition Modeling/Photocuring Molding” as an Example. University Chemistry, 2026, 41(2): 393-399. doi: 10.12461/PKU.DXHX202502104
15. [15]
  Jiahe Peng , Dongxiao Wen , Jizhou Jiang . Sustainable production of aviation fuel cycloalkanes from plastic waste under ambient-pressure conditions. Acta Physico-Chimica Sinica, 2026, 42(9): 100341-0. doi: 10.1016/j.actphy.2026.100341
16. [16]
  Ping ZHANG , Chenchen ZHAO , Xiaoyun CUI , Bing XIE , Yihan LIU , Haiyu LIN , Jiale ZHANG , Yu'nan CHEN . Preparation and adsorption-photocatalytic performance of ZnAl@layered double oxides. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1965-1974. doi: 10.11862/CJIC.20240014
17. [17]
  Xiaojing Tian , Zhichun Huang , Qingsong Zhang , Xu Wang , Ning Yang , Nanping Deng . PNIPAm Thermo-Responsive Nanofibers Mats: Morphological Stability and Response Behavior under Cross-Linking. Acta Physico-Chimica Sinica, 2024, 40(4): 2304037-0. doi: 10.3866/PKU.WHXB202304037
18. [18]
  Juan WANG , Zhongqiu WANG , Qin SHANG , Guohong WANG , Jinmao LI . NiS and Pt as dual co-catalysts for the enhanced photocatalytic H₂ production activity of BaTiO₃ nanofibers. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1719-1730. doi: 10.11862/CJIC.20240102
19. [19]
  Xunzhang Fan , Yuanjin Zhao , Shufang Luo , Aihua He . Karl Ziegler: A Pioneer in the Polyolefin Industry – Commemorating the 50th Anniversary of the German Chemist’s Passing. University Chemistry, 2024, 39(8): 389-394. doi: 10.3866/PKU.DXHX202312065
20. [20]
  Sumiya Akter Dristy , Md Ahasan Habib , Shusen Lin , Mehedi Hasan Joni , Rutuja Mandavkar , Young-Uk Chung , Md Najibullah , Jihoon Lee . Exploring Zn doped NiBP microspheres as efficient and stable electrocatalyst for industrial-scale water splitting. Acta Physico-Chimica Sinica, 2025, 41(7): 100079-0. doi: 10.1016/j.actphy.2025.100079

Get Citation

PDF

XML

Metrics

PDF Downloads(2)
Abstract views(2155)
HTML views(417)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142