Citation: YU Qi, SONG Hua, SONG Hua-lin, WANG Jian, JIANG Nan, LI Feng, CHEN Yan-guang. Effect of reduction temperature on the performance of Ni₂P/Ti-MCM-41 catalyst in hydrodesulfurization[J]. Journal of Fuel Chemistry and Technology, ;2016, 44(08): 970-976. shu

Effect of reduction temperature on the performance of Ni₂P/Ti-MCM-41 catalyst in hydrodesulfurization

YU Qi ¹ ,
SONG Hua ^1,2,, ,
SONG Hua-lin ^3,, ,
WANG Jian ¹ ,
JIANG Nan ¹ ,
LI Feng ^1,2 ,
CHEN Yan-guang ^1,2

1.
1. College of Chemistry & Chemical Engineering, Northeast Petroleum University, Daqing 163318, China;
2.
2. Provincial Key Laboratory of Oil & Gas Chemical Technology, Northeast Petroleum University, Daqing 163318, China;
3.
3. Department of Image School, Mudanjiang Medical University, Mudanjiang 157011, China

Corresponding author: SONG Hua, SONG Hua-lin,
Received Date: 6 February 2016
Available Online: 30 April 2016
Fund Project:

The supported Ni₂P/Ti-MCM-41 catalyst is prepared by temperature-programmed reduction method with nickel chloride (NiCl₂·6H₂O) as the nickel precursor, ammonium hypophosphite (NH₄H₂PO₂) as the phosphorus precursor and Ti-MCM-41 as the support. The Ni₂P/Ti-MCM-41 catalyst was characterized by H₂-TPR, XRD, BET, XPS, and TEM; the effect of reduction temperature on its catalytic performance in hydrodesulfurization (HDS) was investigated by using dibenzothiophene (DBT) as a model compound. The results show that the precursors on the catalyst prepared in this way can be reduced at 318℃, which is at least 200℃ lower than that prepared by traditional methods. Pure Ni₂P phase can be obtained by reduction at 350-500℃; the low reduction temperature is in favor of forming small Ni₂ Pcrystallite size. The Ni₂P/Ti-MCM-41 catalyst obtained at a reduction temperature of 400℃ exhibits the highest surface area, the best dispersion of Ni₂P crystallite size, the lowest surface phosphorus content and the highest HDS activity; under 340℃, 3.0MPa, a H₂/oil ratio of 500 (volume ratio) and a weight hourly space velocity (WHSV) of 2.0h^-1, the conversion of DBT for HDS reaches 99.4%.
- hydrodesulfurization,
- nickel phosphide,
- reduction temperature,
- Ti-MCM-41,
- dibenzothiophene
1. [1]
  [1] TIAN F P,SHEN Q C,FU Z K,WU Y H,JIA C Y.Enhanced adsorption desulfurization performance over hierarchically structured zeolite Y[J].Fuel Process Technol,2014,128:176-182.
2. [2]
  [2] 宋华,代敏,宋华林.Ni₂P加氢脱硫催化剂[J].化学进展,2012,24(5):43-47.(SONG Hua,DAI Min,SONG Hua-lin.Ni₂P catalyst for hydrodesulfurization[J].Prog Chem,2012,24(5):43-47.)
3. [3]
  [3] ZHAO H Y,OYAMA S T,FREUND H J,WLODARCZYK R,SIERKA M.Nature of active sites in Ni₂P hydrotreating catalysts as probed by iron substitution[J].Appl Catal B:Environ,2015,164:204-216.
4. [4]
  [4] SONG H,DAI M,SONG H L,WAN X,XU X W,ZHANG C Y,WANG H Y.Synthesis of a Ni₂P catalyst supported on anatase-TiO₂ whiskers with high hydrodesulfurization activity,based on triphenylphosphine[J].Catal Commun,2014,43:151-154.
5. [5]
  [5] SONG H,WANG J,WANG Z D,SONG H L,LI F,JIN Z S.Effect of titanium content on dibenzothiophene HDS performance over Ni₂P/Ti-MCM-41 catalyst[J].J Catal,2014,311:257-265.
6. [6]
  [6] SONG H,DAI M,GUO Y T,ZHANG Y J.Preparation of composite TiO₂-Al₂O₃ supported nickel phosphide hydrotreating catalysts and catalytic activity for hydrodesulfurization of dibenzothiophene[J].Fuel Process Technol,2012,96:228-236.
7. [7]
  [7] SONG L M,ZHANG S J,WEI Q W.A new route for synthesizing nickel phosphide catalysts with high hydrodesulfurization activity based on sodium dihydrogenphosphite[J].Catal Commun,2011,12:1157-1160.
8. [8]
  [8] MELENDEZ-ORTIZ H I,GARCIA-CERDA L A,OLIVARES-MALDONADO Y,CASTRUITA G,MERCADO-SILVA J A,PERERA-MERCADO Y A.Preparation of spherical MCM-41 molecular sieve at room temperature:Influence of the synthesis conditions in the structural properties[J].Ceram Int,2012,38(8):6353-6358.
9. [9]
  [9] 宋华,张福勇,徐晓伟,宋华林,李峰.镨和铈对低温还原法制备的Ni₂P催化剂加氢脱硫活性的影响[J].燃料化学学报,2015,43(9):1128-1133.(SONG Hua,ZHANG Fu-yong,XU Xiao-wei,SONG Hua-lin,LI Feng.Effect of Pr and Ce on the activity of Ni₂P catalyst prepared by low temperature reduction in hydrodesulphurization[J].J Fuel Chem Technol,2015,43(9):1128-1133.)
10. [10]
  [10] 宋华,王紫东,代敏,宋华林,万霞,李锋.Ni₂P催化剂的低温还原法合成及其HDS性能[J].燃料化学学报,2014,42(6):733-737.(SONG Hua,WANG Zi-dong,DAI Min,SONG Hua-lin,WAN Xia,LI Feng.Preparation of Ni₂P catalysts at low reduction temperature and its HDS performance[J].J Fuel Chem Technol,2014,42(6):733-737.)
11. [11]
  [11] WANG X,CLARK P,OYAMA S T.Synthesis,characterization,and hydrotreating activity of several iron group transition metal phosphides[J].J Catal,2002,208(2):321-331.
12. [12]
  [12] OYAMA S T,WANG X Q,LEE Y K,CHUN W J.Active phase of Ni₂P/SiO₂ in hydroprocessing reactions[J].J Catal,2004,221(2):263-273.
13. [13]
  [13] KOSSLICK H,LISCHKE G,LANDMESSER H,PARLITZ B,STOREK W,FRICKE R.Acidity and catalytic behavior of substituted MCM-48[J].J Catal,1998,176:102-114.
14. [14]
  [14] CHEN T,YANG B L,LI S S,WANG K L,JIANG X D,ZHANG Y,HE G W.Ni₂P catalysts supported on titania-modified alumina for the hydrodesulfurization of dibenzothiophene[J].Ind Eng Chem Res,2011,50:11043-11048.
15. [15]
  [15] ELICHE-QUESADA D,MERIDA-ROBLES J,MAIRELES-TORRES P,RODRIGUEZ-CASTELLON E,BUSCA G,FINOCCHIO E,JIMENEZ-LOPEZ A.Effects of preparation method and sulfur poisoning on the hydrogenation and ring opening of tetralin on NiW/zirconium-doped mesoporous silica catalysts[J].J Catal,2003,220(2):457-467.
16. [16]
  [16] KUHN J N,LAKSHMINARAYANAN N,OZKAN U S.Effect of hydrogen sulfide on the catalytic activity of Ni-YSZ cermets[J].J Mol Catal A:Chem,2008,282(1/2):9-21.
17. [17]
  [17] KORANYI T I.Phosphorus promotion of Ni (Co)-containing Mo-free catalysts in thiophene hydrodesulfurization[J].Appl Catal A:Gen,2003,239(1/2):253-267.
18. [18]
  [18] CECILIA J A,INFANTES-MOLINA A,RODRIGUEZ-CASTELLON E,JIMENEZ-LOPEZ A.A novel method for preparing an active nickel phosphide catalyst for HDS of dibenzothiophene[J].J Catal,2009,263(1):4-15.
19. [19]
  [19] LAYMAN K A,BUSSEL M E.Infrared spectroscopic investigation of CO adsorption on silica-supported nickel phosphide catalysts[J].J Phys Chem B,2004,108:10930-10941.
20. [20]
  [20] OYAMA S T,WANG X,LEE Y K,BANDO K,REQUEJO F G.Effect of phosphorus content in nickel phosphide catalysts studied by XAFS and other techniques[J].J Catal,2002,210(1):207-217.
21. [21]
  [21] SONG H,DAI M,SONG H L,WAN X,XU X W.A novel synthesis of Ni₂P/MCM-41 catalysts by reducing a precursor of ammonium hypophosphite and nickel chloride at low temperature[J].Appl Catal A:Gen,2013,462-463:247-255.
22. [22]
  [22] SAWHILL S J,LAYMAN K A,VAN WYK D R,ENGELHARD M H,WANG C,BUSSELL M E.Thiophene hydrodesulfurization over nickel phosphide catalysts:Effect of the precursor composition and support[J].J Catal,2005,231(2):300-313.
1. [1]
  Bo YANG , Gongxuan LÜ , Jiantai MA . Nickel phosphide modified phosphorus doped gallium oxide for visible light photocatalytic water splitting to hydrogen. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 736-750. doi: 10.11862/CJIC.20230346
2. [2]
  Bo YANG , Gongxuan LÜ , Jiantai MA . Corrosion inhibition of nickel-cobalt-phosphide in water by coating TiO₂ layer. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 365-384. doi: 10.11862/CJIC.20240063
3. [3]
  Caixia Lin , Zhaojiang Shi , Yi Yu , Jianfeng Yan , Keyin Ye , Yaofeng Yuan . Ideological and Political Design for the Electrochemical Synthesis of Benzoxathiazine Dioxide Experiment. University Chemistry, 2024, 39(2): 61-66. doi: 10.3866/PKU.DXHX202309005
4. [4]
  Yanglin Jiang , Mingqing Chen , Min Liang , Yige Yao , Yan Zhang , Peng Wang , Jianping Zhang . Experimental and Theoretical Investigations of Solvent Polarity Effect on ESIPT Mechanism in 4′-N,N-diethylamino-3-hydroxybenzoflavone. Acta Physico-Chimica Sinica, 2025, 41(2): 100012-. doi: 10.3866/PKU.WHXB202309027
5. [5]
  Hailian Tang , Siyuan Chen , Qiaoyun Liu , Guoyi Bai , Botao Qiao , Fei Liu . Stabilized Rh/hydroxyapatite Catalyst for Furfuryl Alcohol Hydrogenation: Application of Oxidative Strong Metal-Support Interactions in Reducing Conditions. Acta Physico-Chimica Sinica, 2025, 41(4): 100036-. doi: 10.3866/PKU.WHXB202408004
6. [6]
  Liuyun Chen , Wenju Wang , Tairong Lu , Xuan Luo , Xinling Xie , Kelin Huang , Shanli Qin , Tongming Su , Zuzeng Qin , Hongbing Ji . Soft template-induced deep pore structure of Cu/Al₂O₃ for promoting plasma-catalyzed CO₂ hydrogenation to DME. Acta Physico-Chimica Sinica, 2025, 41(6): 100054-. doi: 10.1016/j.actphy.2025.100054
7. [7]
  Runhua Chen , Qiong Wu , Jingchen Luo , Xiaolong Zu , Shan Zhu , Yongfu Sun . 缺陷态二维超薄材料用于光/电催化CO₂还原的基础与展望. Acta Physico-Chimica Sinica, 2025, 41(3): 2308052-. doi: 10.3866/PKU.WHXB202308052
8. [8]
  Tong Zhou , Xue Liu , Liang Zhao , Mingtao Qiao , Wanying Lei . Efficient Photocatalytic H₂O₂ Production and Cr(VI) Reduction over a Hierarchical Ti₃C₂/In₄SnS₈ Schottky Junction. Acta Physico-Chimica Sinica, 2024, 40(10): 2309020-. doi: 10.3866/PKU.WHXB202309020
9. [9]
  Qianlang Wang , Jijun Sun , Qian Chen , Quanqin Zhao , Baojuan Xi . The Appeal of Organophosphorus Compounds: Clearing Their Name. University Chemistry, 2025, 40(4): 299-306. doi: 10.12461/PKU.DXHX202405205
10. [10]
  Liangzhen Hu , Li Ni , Ziyi Liu , Xiaohui Zhang , Bo Qin , Yan Xiong . A Green Chemistry Experiment on Electrochemical Synthesis of Benzophenone. University Chemistry, 2024, 39(6): 350-356. doi: 10.3866/PKU.DXHX202312001
11. [11]
  Bing WEI , Jianfan ZHANG , Zhe CHEN . Research progress in fine tuning of bimetallic nanocatalysts for electrocatalytic carbon dioxide reduction. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 425-439. doi: 10.11862/CJIC.20240201
12. [12]
  Wanchun Zhu , Yongmei Liu , Li Wang , Yunshan Bai , Shu'e Song , Xiaokui Wang , Zhongyun Wu , Hong Yuan , Yunchao Li , Fuping Tian , Yuan Chun , Jianrong Zhang , Shuyong Zhang . Suggestions on Operating Specifications of Physical Chemistry Experiment: Measurement and Control of Temperature. University Chemistry, 2025, 40(5): 128-136. doi: 10.12461/PKU.DXHX202503028
13. [13]
  Xiaoling LUO , Pintian ZOU , Xiaoyan WANG , Zheng LIU , Xiangfei KONG , Qun TANG , Sheng WANG . Synthesis, crystal structures, and properties of lanthanide metal-organic frameworks based on 2, 5-dibromoterephthalic acid ligand. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1143-1150. doi: 10.11862/CJIC.20230271
14. [14]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
15. [15]
  Weihan Zhang , Menglu Wang , Ankang Jia , Wei Deng , Shuxing Bai . 表面硫物种对钯-硫纳米片加氢性能的影响. Acta Physico-Chimica Sinica, 2024, 40(11): 2309043-. doi: 10.3866/PKU.WHXB202309043
16. [16]
  Qiaoqiao BAI , Anqi ZHOU , Xiaowei LI , Tang LIU , Song LIU . Construction of pressure-temperature dual-functional flexible sensors and applications in biomedicine. Chinese Journal of Inorganic Chemistry, 2024, 40(12): 2259-2274. doi: 10.11862/CJIC.20240128
17. [17]
  Mingxin LU , Liyang ZHOU , Xiaoyu XU , Xiaoying FENG , Hui WANG , Bin YAN , Jie XU , Chao CHEN , Hui MEI , Feng GAO . Preparation of La-doped lead-based piezoelectric ceramics with both high electrical strain and Curie temperature. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 329-338. doi: 10.11862/CJIC.20240206
18. [18]
  Guang Huang , Lei Li , Dingyi Zhang , Xingze Wang , Yugai Huang , Wenhui Liang , Zhifen Guo , Wenmei Jiao . Cobalt’s Valor, Nickel’s Foe: A Comprehensive Chemical Experiment Utilizing a Cobalt-based Imidazolate Framework for Nickel Ion Removal. University Chemistry, 2024, 39(8): 174-183. doi: 10.3866/PKU.DXHX202311051
19. [19]
  Yonghui ZHOU , Rujun HUANG , Dongchao YAO , Aiwei ZHANG , Yuhang SUN , Zhujun CHEN , Baisong ZHU , Youxuan ZHENG . Synthesis and photoelectric properties of fluorescence materials with electron donor-acceptor structures based on quinoxaline and pyridinopyrazine, carbazole, and diphenylamine derivatives. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 701-712. doi: 10.11862/CJIC.20230373
20. [20]
  Yihao Zhao , Jitian Rao , Jie Han . Synthesis and Photochromic Properties of 3,3-Diphenyl-3H-Naphthopyran: Design and Teaching Practice of a Comprehensive Organic Experiment. University Chemistry, 2024, 39(10): 149-155. doi: 10.3866/PKU.DXHX202402050

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(591)
HTML views(43)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Effect of reduction temperature on the performance of Ni2P/Ti-MCM-41 catalyst in hydrodesulfurization

Metrics

通讯作者: 陈斌, bchen63@163.com

Effect of reduction temperature on the performance of Ni₂P/Ti-MCM-41 catalyst in hydrodesulfurization