Citation: WU Yue, LIU Xing-Quan, ZHANG Zheng, ZHAO Hong-Yuan. Preparation and Characterization of M(Ⅱ) and M(Ⅳ) Iso-Molar Co-Doped LiMn_1.9Mg_0.05Ti_0.05O₄ Cathode Materials for Lithium-Ion Batteries[J]. Acta Physico-Chimica Sinica, ;2014, 30(12): 2283-2290. doi: 10.3866/PKU.WHXB201410132 shu

Preparation and Characterization of M(Ⅱ) and M(Ⅳ) Iso-Molar Co-Doped LiMn_1.9Mg_0.05Ti_0.05O₄ Cathode Materials for Lithium-Ion Batteries

1.
State Key Laboratory of Electronic Thin Film and Integrated Devices, School of Microelectronics and Solid State Electronics, University of Electronic Science and Technology of China, Chengdu 610054, P. R. China

Received Date: 9 July 2014
Available Online: 13 October 2014
Fund Project: 国家自然科学基金(21071026) (21071026)电子科技大学杰出人才引进项目(08JC00303)资助 (08JC00303)

An Mg(Ⅱ) and Ti(Ⅳ), iso-molar, co-doped cathode material LiMn_1.9Mg_0.05Ti_0.05O₄ for lithium-ion batteries was successfully synthesized via a sol-gel method, using lithium hydroxide, manganese acetate, magnesium nitrate, and butyl titanate as raw materials, and citric acid as a chelating agent. The as-prepared materials were characterized using thermogravimetric analysis (TGA), X-ray diffraction (XRD), scanning electron microscopy (SEM), transmission electron microscopy (TEM), and electrochemical tests (including cyclic voltammetry (CV) and electrochemical impedance spectroscopy (EIS) measurements). The results demonstrated that the cathode material LiMn_1.9Mg_0.05Ti_0.05O₄, which was obtained after calcination at 780℃ for 12 h, exhibited a fine microstructure and od electrochemical performance. When cycled at 4.35-3.30 V at room temperature, LiMn_1.9Mg_0.05Ti_0.05O₄ delivered a discharge specific capacity of 126.8 mAh·g^-1 at 0.5C rate, and maintained a capacity of 118.5 mAh·g^-1 after 50 cycles; the capacity retention of this material reached 93.5%. This material showed a discharge-specific capacity of 111.9 mAh·g^-1 at 0.5C rate after 30 cycles, when it was cycled at 55℃; under these conditions the capacity retention reached 91.9%, far superior to the capacity retention of undoped LiMn₂O₄. The iso-molar co-doping of LiMn₂O₄ with Mg(Ⅱ) and Ti(Ⅳ) ions led to significant modification of the electronic and ionic conductivity, and increased the rate properties and electrochemical performance of the spinel lithium manganate at elevated temperatures.
- Lithium ion battery,
- Cathode material,
- Spinel lithium manganate,
- Sol-gel method,
- Mg, Ti co-doping
1. [1]
  
  (1) Wang, Z. P.; Sun, F. C. Transaction of Beijing Institute of Technology 2004, 24 (12), 1053. [王震坡, 孙逢春. 北京理工大学学报, 2004, 24 (12), 1053.]
2. [2]
  (2) Dunn, B.; Kamath, H.; Tarascon, J. Science 2011, 334 (6058), 928. doi: 10.1126/science.1212741
3. [3]
  (3) Saft, M.; Chagnon, G.; Faugeras, T.; Sarre, G.; Morhet, P. J. Power Sources 1999, 80 (1-2), 180.
4. [4]
  (4) Tarascon, J. M.; Armand, M. Nature 2001, 414 (6861), 359. doi: 10.1038/35104644
5. [5]
  (5) Mukherjee, R.; Krishnan, R.; Lu, T. M.; Koratkar, N. Nano Energy 2012, 1 (4), 518. doi: 10.1016/j.nanoen.2012.04.001
6. [6]
  (6) Park, O. K.; Cho, Y.; Lee, S.; Yoo, H.; Song, H.; Cho, J. Energy Environ. Sci. 2011, 4 (5), 1621. doi: 10.1039/c0ee00559b
7. [7]
  (7) Patey, T. J.; Büchel, R.; Ng, S. H.; Krumeich, F.; Pratsinis, S. E.; Novák. P. J. Power Sources 2009, 189, 149. doi: 10.1016/j.jpowsour.2008.10.002
8. [8]
  (8) Shi, Z. C.; Li, C.; Yang, Y. Electrochemistry 2003, 9 (1), 9. [施志聪, 李晨, 杨勇. 电化学, 2003, 9 (1), 9.]
9. [9]
  (9) Fedorkorva, A.; Nacher-Alejos, A.; mez-Romero, P. Electrochim. Acta 2010, 55, 943. doi: 10.1016/j.electacta.2009.09.060
10. [10]
  (10) Yi, T. F.; Yue, C. B.; Zhu, Y. R.; Zhu, R. S.; Hu, X. G. Rare Metal Materials and Engineering 2009, 38 (9), 1687. [伊廷锋, 岳彩波, 朱彦荣, 诸荣孙, 胡信国. 稀有金属材料与工程, 2009, 38 (9), 1687.]
11. [11]
  (11) Wang, Z. X.; Xing, Z. J.; Li, X. H.; Guo, H. J.; Peng,W. J. Acta Phys. -Chim. Sin. 2004, 20 (8), 790. [王志兴, 邢志军, 李新海, 郭华军, 彭文杰. 物理化学学报, 2004, 20 (8), 790.] doi: 10.3866/PKU.WHXB20040802
12. [12]
  (12) Xu, C. Q.; Tian, Y.W.; Zhai, Y. C. Journal of Materials and Metallurgy 2002, 1 (4), 243. [徐茶青, 田彦文, 翟玉春. 材料与冶金学报, 2002, 1 (4), 243.]
13. [13]
  (13) Amatucci, M.; Tarascon, J. M. J. Electrochem. Soc. 2002, 149 (12), K31.
14. [14]
  (14) Amatucci, G. G.; Pereira, N.; Zheng, T.; Tarascon, J. M. J. Electrochem. Soc. 2001, 148 (2), A171.
15. [15]
  (15) Hong, Y. S.; Han, C. H.; Kim, K.; Kwon, C.W.; Campet, G.; Choy, J. H. Solid State Ionics 2001, 139 (1-2), 75. doi: 10.1016/S0167-2738(00)00821-3
16. [16]
  (16) Fey, G. T. K.; Lu, C. Z.; Kumar, T. P. J. Power Sources 2003, 115, 332. doi: 10.1016/S0378-7753(03)00010-7
17. [17]
  (17) Liu, Q. S.; Yu, L. H.;Wang, H. H. J. Alloy. Compd. 2009, 486, 886. doi: 10.1016/j.jallcom.2009.07.087
18. [18]
  (18) Kou, D.; Liu, X. Q.; Zhang, Z.; Liu, H. J.;Wang, C. Science & Technology in Chemical Industry 2012, 20 (6), 1. [寇丹, 刘兴泉, 张峥, 刘宏基, 王超. 化工科技, 2012, 20 (6), 1.]
19. [19]
  (19) Kang, K.; Dai, S. H.;Wan, Y. H. J. Funct. Mater. 2000, 31 (3), 283. [康慨, 戴受惠, 万玉华. 功能材料, 2000, 31 (3), 283.]
20. [20]
  (20) Du, R. B.; Liu, T.; Kong, X. J. Chin. J. Rare Metals 2009, 33 (4), 553. [杜荣斌, 刘涛, 孔学军. 稀有金属, 2009, 33 (4), 553.]
21. [21]
  (21) Wang, Y. M.; Bao, F. Y.; Hou, X. G.; Zhou, J. China Powder Science and Technology 2009, 15 (4), 49. [王玉棉, 包飞燕, 侯新刚, 邹杰. 中国粉体技术, 2009, 15 (4), 49.]
22. [22]
  (22) Liu, X. M.; Huang, Z. D.; Oh, S.; Ma, P. C. J. Power Sources 2010, 195 (13), 4290. doi: 10.1016/j.jpowsour.2010.01.068
23. [23]
  (23) Michalska, M.; Lipinska, L.; Mirkowska, M.; Aksieniongek, M.; Diduszko, R.;Wasiucionek, M. Solid State Ionics 2011, 188 (1), 160. doi: 10.1016/j.ssi.2010.12.003
24. [24]
  (24) Chen, K.; Donahoe, A. C.; Noh, Y. D.; Li, K.; Komarneni, S.; Xue, D. Ceram. Int. 2014, 40 (2), 3155. doi: 10.1016/j.ceramint.2013.09.128
25. [25]
  (25) Son, J. T.; Kim, H. G.; Park, Y. Electrochim. Acta 2004, 50, 453.
26. [26]
  (26) Shen, P.; Huang, Y.; Liu, L.; Jia, D. J. Solid State Electr. 2006, 10 (11), 929. doi: 10.1007/s10008-005-0039-1
27. [27]
  (27) Prabu, M.; Reddy, M. V.; Selvasekarapandian, S.; Subba Rao, G. V.; Chowdari, B. V. R. Electrochim. Acta 2013, 88, 745. doi: 10.1016/j.electacta.2012.10.011
28. [28]
  (28) Lee, D. K.; Han, S. C.; Ahn, D.; Singh, S. P.; Sohn, K. S.; Pyo, M. ACS Appl. Mater. Inter. 2012, 4 (12), 6841.
29. [29]
  (29) Hu, G. J.; Ouyang, C. Y. Acta Phys. Sin. 2010, 59 (8), 5864. [胡国进, 欧阳楚英. 物理学报, 2010, 59 (8), 5864.]
30. [30]
  (30) Huang, B.; Li, X.;Wang, Z.; Guo, H.; Xiong, X.;Wang, J. J. Alloy. Compd. 2014, 583, 313. doi: 10.1016/j.jallcom.2013.08.157
31. [31]
  (31) Wang, Z. P.; Liu,W.;Wang, Y.; Zhao, C. S.; Zhang, S. P.; Chen, J. T.; Zhou, H. H.; Zhang, X. X. Acta Phys. -Chim. Sin. 2012, 28 (9), 2084. [王震坡, 刘文, 王悦, 赵春松, 张淑萍, 陈继涛, 周恒辉, 张新祥. 物理化学学报, 2012, 28 (9), 2084.] doi: 10.3866/PKU.WHXB201207043
32. [32]
  (32) Xiao, L.; Guo, Y.; Qu, D.; Deng, B.; Liu, H.; Tang, D. J. Power Sources 2013, 225, 286. doi: 10.1016/j.jpowsour.2012.10.070
33. [33]
  (33) Singh, S.; Mitra, S. Electrochim. Acta 2014, 123, 378. doi: 10.1016/j.electacta.2014.01.045
34. [34]
  (34) Ohzuku, T.; Kitagawa, M.; Hirai, T. J. Electrochem. Soc. 1990, 137 (3), 769. doi: 10.1149/1.2086552
35. [35]
  (35) Zhuang, Q. C.;Wei, T.;Wei, G. Z.; Dong, Q. F.; Sun, S. G. Acta Chim. Sin. 2009, 67 (19), 2184. [庄全超, 魏涛, 魏国祯,董全峰, 孙世刚. 化学学报, 2009, 67 (19), 2184.]
36. [36]
  (36) Xia, Y. Y.; Sakai, T.; Fujieda, T.; Yang, X. Q. J. Electrochem. Soc. 2001, 148 (7), A723.
37. [37]
  (37) Xiong, L.; Xu, Y.; Tao, T.; odenough, J. B. J. Power Sources 2012, 199, 214. doi: 10.1016/j.jpowsour.2011.09.062
1. [1]
  Qingtang ZHANG , Xiaoyu WU , Zheng WANG , Xiaomei WANG . Performance of nano Li₂FeSiO₄/C cathode material co-doped by potassium and chlorine ions. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1689-1696. doi: 10.11862/CJIC.20240115
2. [2]
  Liangliang Song , Haoyan Liang , Shunqing Li , Bao Qiu , Zhaoping Liu . Challenges and strategies on high-manganese Li-rich layered oxide cathodes for ultrahigh-energy-density batteries. Acta Physico-Chimica Sinica, 2025, 41(8): 100085-0. doi: 10.1016/j.actphy.2025.100085
3. [3]
  Mengxue WANG , Shan FAN , Wei DONG , Yichen REN , Yong ZHANG . Preparation and performance of Mo-doped MnO₂ cathode materials for zinc-ion batteries. Chinese Journal of Inorganic Chemistry, 2026, 42(9): 2033-2040. doi: 10.11862/CJIC.20260111
4. [4]
  Qiang Huang , Yue Wang , Xuejie Wang , Lyubov G. Bulusheva , Tao Liu . La-Ce双掺杂调控电子结构及离子传输增强Na₄Fe₃(PO₄)₂P₂O₇正极的超快储钠性能. Acta Physico-Chimica Sinica, 2026, 42(11): 100339-. doi: 10.1016/j.actphy.2026.100339
5. [5]
  Yuyao Wang , Zhitao Cao , Zeyu Du , Xinxin Cao , Shuquan Liang . Research Progress of Iron-based Polyanionic Cathode Materials for Sodium-Ion Batteries. Acta Physico-Chimica Sinica, 2025, 41(4): 100035-0. doi: 10.3866/PKU.WHXB202406014
6. [6]
  Wang Shuang , Fu Xiaoqi , Yao Shanshan . Synergistic optimization of ion migration and electron transfer in sodium-ion battery cathode materials. Acta Physico-Chimica Sinica, 2026, 42(5): 100206-. doi: 10.1016/j.actphy.2025.100206
7. [7]
  Li Peicai , Wang Xubin , Zhang Qinghua , Wang Bowen , Rong Xiaohui , Hu Yong-Sheng , Li Zhongtao . High-rate and long-cycling P2-type cathode material for sodium-ion batteries. Acta Physico-Chimica Sinica, 2026, 42(5): 100214-. doi: 10.1016/j.actphy.2025.100214
8. [8]
  Xiangyu CAO , Jiaying ZHANG , Yun FENG , Linkun SHEN , Xiuling ZHANG , Juanzhi YAN . Synthesis and electrochemical properties of bimetallic-doped porous carbon cathode material. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 509-520. doi: 10.11862/CJIC.20240270
9. [9]
  Pengyang FAN , Shan FAN , Qinjin DAI , Xiaoying ZHENG , Wei DONG , Mengxue WANG , Xiaoxiao HUANG , Yong ZHANG . Preparation and performance of rich 1T-MoS₂ nanosheets for high-performance aqueous zinc ion battery cathode materials. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 675-682. doi: 10.11862/CJIC.20240339
10. [10]
  Jianbao Mei , Bei Li , Shu Zhang , Dongdong Xiao , Pu Hu , Geng Zhang . Enhanced Performance of Ternary NASICON-Type Na_3.5−xMn_0.5V_1.5−xZr_x (PO₄)₃/C Cathodes for Sodium-Ion Batteries. Acta Physico-Chimica Sinica, 2024, 40(12): 2407023-0. doi: 10.3866/PKU.WHXB202407023
11. [11]
  Lingbang Qiu , Jiangmin Jiang , Libo Wang , Lang Bai , Fei Zhou , Gaoyu Zhou , Quanchao Zhuang , Yanhua Cui . In Situ Electrochemical Impedance Spectroscopy Monitoring of the High-Temperature Double-Discharge Mechanism of Nb₁₂WO₃₃ Cathode Material for Long-Life Thermal Batteries. Acta Physico-Chimica Sinica, 2025, 41(5): 100040-0. doi: 10.1016/j.actphy.2024.100040
12. [12]
  Ziying YUAN , Zhen DUAN , Dan LIU , Jingrui NIU , Feiyan LAI , Xiaohui ZHANG , Guangchang YANG . Modification of O3-type Na_0.86Ni_1/3Fe_1/3Mn_1/3O₂ cathode material via Ti⁴⁺/P⁵⁺ dual-site co-doping. Chinese Journal of Inorganic Chemistry, 2026, 42(8): 1647-1657. doi: 10.11862/CJIC.20260041
13. [13]
  Yuanchao LI , Weifeng HUANG , Pengchao LIANG , Zifang ZHAO , Baoyan XING , Dongliang YAN , Li YANG , Songlin WANG . Effect of heterogeneous dual carbon sources on electrochemical properties of LiMn_0.8Fe_0.2PO₄/C composites. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 751-760. doi: 10.11862/CJIC.20230252
14. [14]
  Xiaoning TANG , Shu XIA , Jie LEI , Xingfu YANG , Qiuyang LUO , Junnan LIU , An XUE . Fluorine-doped MnO₂ with oxygen vacancy for stabilizing Zn-ion batteries. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1671-1678. doi: 10.11862/CJIC.20240149
15. [15]
  Xiaokang JIANG , Junliang MA , Yan ZHAO , Feng GAO , Changli LIU , Xingshen ZHAO , Hengwei ZHOU . Preparation and luminescent properties of Sm³⁺-doped La₂MgZrO₆ phosphors. Chinese Journal of Inorganic Chemistry, 2026, 42(2): 263-270. doi: 10.11862/CJIC.20250236
16. [16]
  Yan ZHAO , Jiaxu WANG , Zhonghu LI , Changli LIU , Xingsheng ZHAO , Hengwei ZHOU , Xiaokang JIANG . Gd³⁺-doped Sc₂W3O₁₂: Eu³⁺ red phosphor: Preparation and luminescence performance. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 461-468. doi: 10.11862/CJIC.20240316
17. [17]
  Siyu Zhang , Kunhong Gu , Bing'an Lu , Junwei Han , Jiang Zhou . Hydrometallurgical Processes on Recycling of Spent Lithium-lon Battery Cathode: Advances and Applications in Sustainable Technologies. Acta Physico-Chimica Sinica, 2024, 40(10): 2309028-0. doi: 10.3866/PKU.WHXB202309028
18. [18]
  Qi Li , Pingan Li , Zetong Liu , Jiahui Zhang , Hao Zhang , Weilai Yu , Xianluo Hu . Fabricating Micro/Nanostructured Separators and Electrode Materials by Coaxial Electrospinning for Lithium-Ion Batteries: From Fundamentals to Applications. Acta Physico-Chimica Sinica, 2024, 40(10): 2311030-0. doi: 10.3866/PKU.WHXB202311030
19. [19]
  Rongrong Wang , Chen Li , Xiang Ren , Keliang Zhang , Yu Sun , Xianzhong Sun , Kai Wang , Xiong Zhang , Yanwei Ma . Recent advances and challenges of eco-friendly Ni-rich cathode slurry systems in lithium-ion batteries. Acta Physico-Chimica Sinica, 2026, 42(4): 100222-0. doi: 10.1016/j.actphy.2025.100222
20. [20]
  Ying Li , Yushen Zhao , Kai Chen , Xu Liu , Tingfeng Yi , Li-Feng Chen . Rational Design of Cross-Linked N-Doped C-Sn Nanofibers as Free-Standing Electrodes towards High-Performance Li-Ion Battery Anodes. Acta Physico-Chimica Sinica, 2024, 40(3): 2305007-0. doi: 10.3866/PKU.WHXB202305007

Get Citation

PDF

XML

Metrics

PDF Downloads(307)
Abstract views(1302)
HTML views(69)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Preparation and Characterization of M(Ⅱ) and M(Ⅳ) Iso-Molar Co-Doped LiMn1.9Mg0.05Ti0.05O4 Cathode Materials for Lithium-Ion Batteries

Metrics

通讯作者: 陈斌, bchen63@163.com

Preparation and Characterization of M(Ⅱ) and M(Ⅳ) Iso-Molar Co-Doped LiMn_1.9Mg_0.05Ti_0.05O₄ Cathode Materials for Lithium-Ion Batteries