Citation: HU Si, ZHANG Qing, XIA Zhi, NG Yan-Jun, XU Jun, DENG Feng, DOU Tao. Catalytic Conversion of Methanol to Propylene over (NH₄)₂SiF₆-Modified Nanosized HZSM-5 Zeolite[J]. Acta Physico-Chimica Sinica, ;2012, 28(11): 2705-2712. doi: 10.3866/PKU.WHXB201207171 shu

Catalytic Conversion of Methanol to Propylene over (NH₄)₂SiF₆-Modified Nanosized HZSM-5 Zeolite

HU Si ¹ ,
ZHANG Qing ¹ ,
XIA Zhi ² ,
NG Yan-Jun ^1, ,
XU Jun ³ ,
DENG Feng ³ ,
DOU Tao ^1,2,

1.
1 The Key Laboratory of Catalysis of CNPC, China University of Petroleum-Beijing, Beijing 102249, P. R. China;
2 Institute of Special Chemicals, Taiyuan University of Technology, Taiyuan 030024, P. R. China;
3 Wuhan Institute of Physics and Mathematics, Chinese Academy of Sciences, Wuhan 430071, P. R. China

Received Date: 25 May 2012
Available Online: 17 July 2012
Fund Project: 国家重点基础研究发展计划(973)项目(2012CB215002) (973)项目(2012CB215002) 国家自然科学基金(10979076, 21176255) (10979076, 21176255) 国际科技合作与交流专项项目(2010DFB40440)资助 (2010DFB40440)

(NH₄)₂SiF₆-modified nanosized HZSM-5 zeolite was prepared and investigated as a catalyst formethanol to propylene conversion. The effects of this modification on the framework, textural propertiesand acidity of both the parent and the modified HZSM-5 zeolite were investigated by powder X-raydiffraction (XRD), ²⁷Al magic angle spinning nuclear magnetic resonance (²⁷Al MAS NMR), X-rayfluorescence (XRF), X-ray photoelectron spectroscopy (XPS), N₂ adsorption, transmission electronmicroscopy (TEM), temperature-programmed desorption of ammonia (NH₃-TPD), and infraredspectroscopy of adsorbed pyridine (Py-IR). The catalytic performance of these materials on the methanolto propylene (MTP) conversion process was tested under operating conditions of T=450℃, p=0.1 MPa(p_MeOH=50 KPa) and WHSV=1 h^-1. The results showed that surface aluminum on the nanosized ZSM-5zeolite could be selectively removed by the (NH₄)₂SiF₆ solution and that the number of acidic sites on theHZSM-5 zeolite gradually decreased with increasing (NH₄)₂SiF₆ concentration. Moreover, after modification with an optimally concentrated (NH₄)₂SiF₆ solution, an obvious increase in specific surface area as well asmesopore volume was observed for the nanosized HZSM-5 with a resulting dramatic improvement in thecatalytic performance of this material for the MTP reaction. Both the propylene selectivity and propylene/ethylene (P/E) mass ratio resulting from use of the modified HZSM-5 increased significantly to 45.1% and8.0, as compared to results of 28.8% and 2.6 obtained with the original material. In addition, the catalyticlifespan of the modified zeolite was double that of the original.
- Nanosized ZSM-5,
- Dealumination,
- Pore structure,
- Acidity,
- Propylene selectivity,
- Catalytic lifetime
1. [1]
  
  (1) Inagaki, S.; Takechi, K.; Kubota, Y. Chem. Commun. 2010, 46,2662. doi: 10.1039/b925408k
2. [2]
  (2) Schneider, M.; Schmidt, F.; Burgfels, G.; Buchold, H.; Möller,F.W. Process for Preparing Lower Olefins. Eur. Pat. 0448000,1991.
3. [3]
  (3) Koempel, H.; Liebner,W. Lurgi's Methanol to Propylene (MTP)Report on a SuccessfulCommercialisation. In Studies in Surface Science and Catalysis; Noronha, F. B., Schmal, M.,Sousa-Aguiar, E. F. Eds.; Elsevier: Frankfurt, 2007; Vol. 167, pp261-267.
4. [4]
  (4) Zhao, T. S.; Takemoto, T.; Tsubaki, N. Catal. Commun. 2006, 7,647. doi: 10.1016/j.catcom.2005.11.009
5. [5]
  (5) Wu,W. Z.; Guo,W. Y.; Xiao,W. D.; Luo, M. Chem. Eng. Sci.2011, 66, 4722. doi: 10.1016/j.ces.2011.06.036
6. [6]
  (6) Bjørgen, M.; Joensen, F.; Lillerud, K. P.; Olsbye, U.; Svelle, S.Catal. Today 2009, 142, 90. doi: 10.1016/j.cattod.2009.01.015
7. [7]
  (7) Bjørgen, M.; Svelle, S.; Joensen, F.; Nerlov, J.; Kolboe, S.;Bonino, F.; Palumbo, L.; Bordiga, S.;Olsbye, U. J. Catal. 2007,249, 195. doi: 10.1016/j.jcat.2007.04.006
8. [8]
  (8) Lee, K. Y.; Lee, H. K.; Ihm, S. K. Top. Catal. 2010, 53, 247.doi: 10.1007/s11244-009-9412-0
9. [9]
  (9) Mei, C. S.;Wen, P. Y.; Liu, Z. C.; Liu, H. X.;Wang, Y. D.; Yang,W. M.; Xie, Z. K.; Hua,W. M.; Gao, Z. J. Catal. 2008, 258,243. doi: 10.1016/j.jcat.2008.06.019
10. [10]
  (10) Liu, J.; Zhang, C. X.; Shen, Z. H.; Hua,W. M.; Tang, Y.; Shen,W.; Yue, Y. H.; Xu, H. L. Catal. Commun. 2009, 10, 1506. doi: 10.1016/j.catcom.2009.04.004
11. [11]
  (11) Sun, C.; Du, J. M.; Liu, J.; Yang, Y. S.; Ren, N.; Shen,W.; Xu,H. L.; Tang, Y. Chem. Commun.2010, 46, 2671. doi: 10.1039/b925850g
12. [12]
  (12) Kim, J.; Choi, M.; Ryoo, R. J. Catal. 2010, 269, 219. doi: 10.1016/j.jcat.2009.11.009
13. [13]
  (13) Firoozi, M.; Baghalha, M.; Asadi, M. Catal. Commun. 2009, 10,1582. doi: 10.1016/j.catcom.2009.04.021
14. [14]
  (14) Guo, Q. S.; Mao, D. S.; Lao, Y. P.; Lu, G. Z. Chin. J. Catal.2009, 30, 1248. [郭强胜, 毛东森, 劳嫣萍, 卢冠忠. 催化学报, 2009, 30, 1248.]
15. [15]
  (15) Mao, D. S.; Guo, Q. S.; Meng, T. Acta Phys. -Chim. Sin. 2010,26, 338. [毛东森, 郭强胜, 孟涛. 物理化学学报, 2010, 26,338.] doi: 10.3866/PKU.WHXB20100208
16. [16]
  (16) Choi, M.; Na, K.; Kim, J.; Sakamoto, Y.; Terasaki, O.; Ryoo, R.Nature 2009, 461, 246. doi: 10.1038/nature08288
17. [17]
  (17) Min, H. K.; Park, M. B.; Hong, S. B. J. Catal. 2010, 271, 186.doi: 10.1016/j.jcat.2010.01.012
18. [18]
  (18) Triantafillidis, C. S.; Vlessidis, A. G.; Nalbandian, L.;Evmiridis, N. P. Microporous Mesoporous Mat. 2001, 47, 369.doi: 10.1016/S1387-1811(01)00399-7
19. [19]
  (19) Han, S.; Shihabi, D. S.; Chang, C. D. J. Catal. 2000, 196, 375.doi: 10.1006/jcat.2000.3037
20. [20]
  (20) Kumar, S.; Sinha, A. K.; Hegde, S. G.; Sivasanker, S. J. Mol. Catal. A 2000, 154, 115. doi: 10.1016/S1381-1169(99)00360-X
21. [21]
  (21) Zhao, G. L.; Teng, J.W.; Xie, Z. K.; Tang, Y.; Yang,W. M.;Chen, Q. L. Chin. J. Catal. 2005, 26, 1083. [赵国良, 滕加伟,谢在库, 唐颐, 杨为明, 陈庆龄. 催化学报, 2005, 26, 1083.]
22. [22]
  (22) Wu,W.;Wu,W. G.; Li, L. F.; Yang,W.;Wu, G. Acta Petrolei Sinica (Petroleum Processing Section) 2010, 26, 189.[吴伟, 吴维果, 李凌飞, 杨巍, 武光. 石油学报(石油加工), 2010, 26, 189.]
23. [23]
  (23) Song, M. J.; Zou, C. L.; Niu, G. X.; Zhao, D. Y. Chin. J. Catal.2012, 33, 140. [宋明娟, 邹成龙,牛国兴, 赵东元. 催化学报,2012, 33, 140.] doi: 10.1016/S1872-2067(10)60283-5
24. [24]
  (24) van Grieken, R.; Sotelo, J. L.; Menéndez, J. M.; Melero, J. A.Microporous Mesoporous Mat. 2000, 39, 135. doi: 10.1016/S1387-1811(00)00190-6
25. [25]
  (25) Qin, Z. X.; Shen, B. J.; Gao, X. H.; Lin, F.;Wang, B. J.; Xu, C.M. J. Catal. 2011, 278, 266. doi: 10.1016/j.jcat.2010.12.013
26. [26]
  (26) Svelle, S.; Joensen, F.; Nerlov, J.; Olsbye, U.; Lillerud, K. P.;Kolboe, S.; Bjørgen, M. J. Am. Chem. Soc. 2006, 128, 14770.doi: 10.1021/ja065810a
1. [1]
  Jia Wang , Qing Qin , Zhe Wang , Xuhao Zhao , Yunfei Chen , Liqiang Hou , Shangguo Liu , Xien Liu . P-Doped Carbon-Supported Zn_xP_yO_z for Efficient Ammonia Electrosynthesis under Ambient Conditions. Acta Physico-Chimica Sinica, 2024, 40(3): 2304044-0. doi: 10.3866/PKU.WHXB202304044
2. [2]
  Yi RU , Tao MENG , Zhaoteng XUE , Dongsen MAO . Synergistic catalysis of Al distribution and pore structure in ZSM-5 zeolite for bioethanol-to-propylene. Chinese Journal of Inorganic Chemistry, 2026, 42(2): 247-262. doi: 10.11862/CJIC.20250255
3. [3]
  Xingyang LI , Tianju LIU , Yang GAO , Dandan ZHANG , Yong ZHOU , Meng PAN . A superior methanol-to-propylene catalyst: Construction via synergistic regulation of pore structure and acidic property of high-silica ZSM-5 zeolite. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1279-1289. doi: 10.11862/CJIC.20240026
4. [4]
  Peng YUE , Liyao SHI , Jinglei CUI , Huirong ZHANG , Yanxia GUO . Effects of Ce and Mn promoters on the selective oxidation of ammonia over V₂O₅/TiO₂ catalyst. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 293-307. doi: 10.11862/CJIC.20240210
5. [5]
  Ze Luo , Yukun Zhu , Yadan Luo , Guangmin Ren , Yonghong Wang , Hua Tang . Photocatalytic selective oxidation of 5-hydroxymethylfurfural coupled with H₂ evolution over In₂O₃/ZnIn₂S₄ S-scheme heterojunction. Acta Physico-Chimica Sinica, 2026, 42(3): 100166-0. doi: 10.1016/j.actphy.2025.100166
6. [6]
  Dingwen CHEN , Siheng YANG , Haiyan FU , Hua CHEN , Xueli ZHENG , Weichao XUE , Jiaqi XU , Ruixiang LI . NiOOH-mediated synthesis of gold nanoaggregates for electrocatalytic performance for selective oxidation of glycerol to glycolate. Chinese Journal of Inorganic Chemistry, 2025, 41(11): 2317-2326. doi: 10.11862/CJIC.20250053
7. [7]
  Lijun Yue , Siya Liu , Peng Liu . 不同晶相纳米MnO₂的制备及其对生物乙醇选择性氧化催化性能的测试——一个科研转化的综合化学实验. University Chemistry, 2025, 40(8): 225-232. doi: 10.12461/PKU.DXHX202410005
8. [8]
  Shihui Shi , Haoyu Li , Shaojie Han , Yifan Yao , Siqi Liu . Regioselectively Synthesis of Halogenated Arenes via Self-Assembly and Synergistic Catalysis Strategy. University Chemistry, 2024, 39(5): 336-344. doi: 10.3866/PKU.DXHX202312002
9. [9]
  .
  CCS Chemistry | 超分子活化底物为自由基促进高效选择性光催化氧化
  . CCS Chemistry, 2025, 7(10.31635/ccschem.025.202405229): -.
10. [10]
  Feifei Yang , Wei Zhou , Chaoran Yang , Tianyu Zhang , Yanqiang Huang . Enhanced Methanol Selectivity in CO₂ Hydrogenation by Decoration of K on MoS₂ Catalyst. Acta Physico-Chimica Sinica, 2024, 40(7): 2308017-0. doi: 10.3866/PKU.WHXB202308017
11. [11]
  Zhengjie Miao , Chuanqiang Zhou , Yuanyuan Ren , Xiangping Xu , Ju Xie , Jie Han . Hierarchical chiral nanoribbons of achiral oligoaniline: temperature induced helicity inversion and enantioselective crystallization application. Acta Physico-Chimica Sinica, 2026, 42(10): 100256-0. doi: 10.1016/j.actphy.2026.100256
12. [12]
  Xinyu Xu , Jiale Lu , Bo Su , Jiayi Chen , Xiong Chen , Sibo Wang . Steering charge dynamics and surface reactivity for photocatalytic selective methane oxidation to ethane over Au/Ti-CeO₂. Acta Physico-Chimica Sinica, 2025, 41(11): 100153-0. doi: 10.1016/j.actphy.2025.100153
13. [13]
  Shuhong Xiang , Lv Yang , Yingsheng Xu , Guoxin Cao , Hongjian Zhou . Selective electrosorption of Cs(Ⅰ) from high-salinity radioactive wastewater using CNT-interspersed potassium zinc ferrocyanide electrodes. Acta Physico-Chimica Sinica, 2025, 41(9): 100097-0. doi: 10.1016/j.actphy.2025.100097
14. [14]
  Baitong Wei , Jinxin Guo , Xigong Liu , Rongxiu Zhu , Lei Liu . Theoretical Study on the Structure, Stability of Hydrocarbon Free Radicals and Selectivity of Alkane Chlorination Reaction. University Chemistry, 2025, 40(3): 402-407. doi: 10.12461/PKU.DXHX202406003
15. [15]
  Jingkun Yu , Xue Yong , Ang Cao , Siyu Lu . Bi-Layer Single Atom Catalysts Boosted Nitrate-to-Ammonia Electroreduction with High Activity and Selectivity. Acta Physico-Chimica Sinica, 2024, 40(6): 2307015-0. doi: 10.3866/PKU.WHXB202307015
16. [16]
  Zhen Li , Sujuan Zhang , Zhongliao Wang , Jinfeng Zhang , Gaoli Chen , Shifu Chen . Rational design of S-scheme CdS/MnO₂ heterojunctions for high-value photothermal synergistic catalytic oxidation of toluene. Acta Physico-Chimica Sinica, 2026, 42(4): 100179-0. doi: 10.1016/j.actphy.2025.100179
17. [17]
  Jun Huang , Pengfei Nie , Yongchao Lu , Jiayang Li , Yiwen Wang , Jianyun Liu . 丝光沸石负载自支撑氮掺杂多孔碳纳米纤维电容器及高效选择性去除硬度离子. Acta Physico-Chimica Sinica, 2025, 41(7): 100066-0. doi: 10.1016/j.actphy.2025.100066
18. [18]
  Xinyu You , Xin Zhang , Shican Jiang , Yiru Ye , Lin Gu , Hexun Zhou , Pandong Ma , Jamal Ftouni , Abhishek Dutta Chowdhury . Efficacy of Ca/ZSM-5 zeolites derived from precipitated calcium carbonate in the methanol-to-olefin process. Chinese Journal of Structural Chemistry, 2024, 43(4): 100265-100265. doi: 10.1016/j.cjsc.2024.100265
19. [19]
  Zhi Chai , Huashan Huang , Xukai Shi , Yujing Lan , Zhentao Yuan , Hong Yan . Wittig反应的立体选择性. University Chemistry, 2025, 40(8): 192-201. doi: 10.12461/PKU.DXHX202410046
20. [20]
  Yu Wang , Haiyang Shi , Zihan Chen , Feng Chen , Ping Wang , Xuefei Wang . 具有富电子Pt^δ−壳层的空心AgPt@Pt核壳催化剂：提升光催化H₂O₂生成选择性与活性. Acta Physico-Chimica Sinica, 2025, 41(7): 100081-0. doi: 10.1016/j.actphy.2025.100081

Get Citation

PDF

XML

Metrics

PDF Downloads(831)
Abstract views(2969)
HTML views(70)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Catalytic Conversion of Methanol to Propylene over (NH4)2SiF6-Modified Nanosized HZSM-5 Zeolite

Metrics

通讯作者: 陈斌, bchen63@163.com

Catalytic Conversion of Methanol to Propylene over (NH₄)₂SiF₆-Modified Nanosized HZSM-5 Zeolite