Home

Citation: Xu Yong-Xiang, Yan Chuan-Wei, Gao Yan-Min, Cao Chu-Nan. Diffusion and Existing Form of Water Vapour in Organic Coatings[J]. Acta Physico-Chimica Sinica, ;2002, 18(07): 649-652. doi: 10.3866/PKU.WHXB20020717 shu

Diffusion and Existing Form of Water Vapour in Organic Coatings

1.
State Key Laboratory for Corrosion and Protection,Institute of Metal Research,The Chinese Academy of Sciences,Shenyang　110015

Received Date: 2 November 2001
Available Online: 15 July 2002

Absorption and desorption of water vapour in alkyd and polyurethane varnish were studied by quartz crystal microbalance(QCM).The absorption and desorption kinetics curves were Fickian in nature when the relative humidity was higher than 30％,while the solubility followed Henry′s law.The average diffusion coefficient D increases linearly with relative humidity.A residual amount of water(about 10％ of the equilibrium absorption amount under the condition of RH 100％)was found to remain in the coatings after extended exposure to dry air.FTIR analysis showed that the molecular structure of the coatings changed before absorption and after desorption of water vapour.The results showed that the residual water reacted with the coating molecule and H-bond was formed between water molecule and the C=O group.A considerable part of water in the coatings may transport in a chain mode by replacement.The rate of forming H-bond is much faster than that of diffusion.When the relative humidity is higher than 30％,the concentration of the water in the coatings is sufficient to support the reaction; diffusion is the controlling step of the absorption process,so the kinetics is Fickian.When the RH is lower than 30％,the concentration of the water in the coatings is not sufficient to support the reaction; the reaction rate is lowered to the degree that it is comparable to the rate of diffusion,then the kinetics of the whole process begin to deviate from Fick′s law.
- Water vapour;Organic coatings;Diffusion;Quartz crystal microbalance(QCM);Fourier transform infrared spectroscopy(FTIR)
1. [1]
  Siwei Hou , Yaxin Niu , Guanglu Zhang , Yanmei Yang , Xu Wang , Zhenzhen Chen . Application of Solid-Phase Microextraction and Mass Spectrometry in Environmental Detection. University Chemistry, 2026, 41(3): 297-306. doi: 10.12461/PKU.DXHX202504078
2. [2]
  Lihua Jin , Lei Tian , Chaozhan Wang , Jiawei Liu , Quan Bai , Yan Li . Teaching Exploration and Practice of the Instrumental Analysis Experiment “Distinguishing Green Plastic Bags by Attenuated Total Reflectance Fourier Transform Infrared Spectroscopy”. University Chemistry, 2026, 41(2): 360-365. doi: 10.12461/PKU.DXHX202502089
3. [3]
  Tianqi Bai , Kun Huang , Fachen Liu , Ruochen Shi , Wencai Ren , Songfeng Pei , Peng Gao , Zhongfan Liu . Nanoscale Mechanism of Microstructure-Dependent Thermal Diffusivity in Thick Graphene Sheets. Acta Physico-Chimica Sinica, 2025, 41(3): 100025-0. doi: 10.3866/PKU.WHXB202404024
4. [4]
  Yang Wang , Yunpeng Fu , Xiaoji Liu , Guotao Zhang , Guobin Li , Wanqiang Liu , Jinglun Wang . Structural Analysis of Nitrile Solutions Based on Infrared Spectroscopy Probes. University Chemistry, 2025, 40(4): 367-374. doi: 10.12461/PKU.DXHX202406113
5. [5]
  Zhengxuan Chang , Haoyang Jiang , Weiguang Zhao . Development of an AI-powered infrared spectroscopy recognition and teaching assistance system for halogenated n-butane preparation experiment. University Chemistry, 2026, 41(7): 430-440. doi: 10.12461/PKU.DXHX202505070
6. [6]
  Xiaoning TANG , Junnan LIU , Xingfu YANG , Jie LEI , Qiuyang LUO , Shu XIA , An XUE . Effect of sodium alginate-sodium carboxymethylcellulose gel layer on the stability of Zn anodes. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1452-1460. doi: 10.11862/CJIC.20240191
7. [7]
  Zhimin Sun , Wenyu Xue , Shuangshuang Yang , Chaoyang Zhang , Bo Yu , Xingwei Wang , Qiangliang Yu , Feng Zhou , Weimin Liu . 面向海洋应用的多功能涂层：基于氟硅烷包覆CIP实现防腐、吸波与减阻一体化. Acta Physico-Chimica Sinica, 2026, 42(11): 100292-. doi: 10.1016/j.actphy.2026.100292
8. [8]
  Jie WU , Zhihong LUO , Xiaoli CHEN , Fangfang XIONG , Li CHEN , Biao ZHANG , Bin SHI , Quansheng OUYANG , Jiaojing SHAO . Critical roles of AlPO₄ coating in enhancing cycling stability and rate capability of high voltage LiNi_0.5Mn_1.5O₄ cathode materials. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 948-958. doi: 10.11862/CJIC.20240400
9. [9]
  Yufan ZHAO , Jinglin YOU , Shixiang WANG , Guopeng LIU , Xiang XIA , Yingfang XIE , Meiqin SHENG , Feiyan XU , Kai TANG , Liming LU . Raman spectroscopic quantitative study of the melt microstructure in binary Li₂O-GeO₂ functional crystals. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1533-1544. doi: 10.11862/CJIC.20250063
10. [10]
  Siqi Sun , Cheng Zhao , Zhaohuan Zhang , Ding Wang , Xinru Yin , Jingting Han , Jinlei Wei , Yong Zhao , Yongheng Zhu . Highly selective QCM sensor based on functionalized hierarchical hollow TiO₂ nanospheres for detecting ppb-level 3-hydroxy-2-butanone biomarker at room temperature. Chinese Chemical Letters, 2025, 36(5): 109939-. doi: 10.1016/j.cclet.2024.109939
11. [11]
  Jiarui Wu , Gengxin Wu , Yan Wang , Yingwei Yang . Crystal Engineering Based on Leaning Towerarenes. University Chemistry, 2024, 39(3): 58-62. doi: 10.3866/PKU.DXHX202304014
12. [12]
  Jin Tong , Shuyan Yu . Crystal Engineering for Supramolecular Chirality. University Chemistry, 2024, 39(3): 86-93. doi: 10.3866/PKU.DXHX202308113
13. [13]
  Xiuqiong Zeng , Jiqing Cai , Chen Chen , Yanping Ren , Wan Li , Yongxian Fan , Faqiong Zhao , Wenwei Zhang , Mei Shi , Min Hu , Kai Hu , Xiuyun Wang , Weihong Li , Yong Fan , Xiaohang Qiu , Juanjuan Song , Dongcheng Liu , Jianrong Zhang , Shuyong Zhang . Suggestions on Dissolution, Crystallization and Crystal Cultivation. University Chemistry, 2026, 41(3): 191-199. doi: 10.12461/PKU.DXHX202507045
14. [14]
  Gaofeng Zeng , Shuyu Liu , Manle Jiang , Yu Wang , Ping Xu , Lei Wang . Micro/Nanorobots for Pollution Detection and Toxic Removal. University Chemistry, 2024, 39(9): 229-234. doi: 10.12461/PKU.DXHX202311055
15. [15]
  Xue Wu , Yupeng Liu , Bingzhe Wang , Lingyun Li , Zhenjian Li , Qingcheng Wang , Quansheng Cheng , Guichuan Xing , Songnan Qu . Rationally assembling different surface functionalized carbon dots for enhanced near-infrared tumor photothermal therapy. Acta Physico-Chimica Sinica, 2025, 41(9): 100109-0. doi: 10.1016/j.actphy.2025.100109
16. [16]
  Haitang WANG , Yanni LING , Xiaqing MA , Yuxin CHEN , Rui ZHANG , Keyi WANG , Ying ZHANG , Wenmin WANG . Construction, crystal structures, and biological activities of two Ln^Ⅲ₃ complexes. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1474-1482. doi: 10.11862/CJIC.20240188
17. [17]
  Yan Liu , Yuexiang Zhu , Luhua Lai . Introduction to Blended and Small-Class Teaching in Structural Chemistry: Exploring the Structure and Properties of Crystals. University Chemistry, 2024, 39(3): 1-4. doi: 10.3866/PKU.DXHX202306084
18. [18]
  Hongwei Ma , Fang Zhang , Hui Ai , Niu Zhang , Shaochun Peng , Hui Li . Integrated Crystallographic Teaching with X-ray,TEM and STM. University Chemistry, 2024, 39(3): 5-17. doi: 10.3866/PKU.DXHX202308107
19. [19]
  Dongju Zhang . Exploring the Descriptions and Connotations of Basic Concepts of Teaching Crystal Structures. University Chemistry, 2024, 39(3): 18-22. doi: 10.3866/PKU.DXHX202304003
20. [20]
  Weina Wang , Fengyi Liu , Wenliang Wang . “Extracting Commonality, Delving into Typicals, Deriving Individuality”: Constructing a Knowledge Graph of Crystal Structures. University Chemistry, 2024, 39(3): 36-42. doi: 10.3866/PKU.DXHX202308029

Get Citation

PDF

XML

Metrics

PDF Downloads(2667)
Abstract views(3473)
HTML views(55)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Address：Zhongguancun North First Street 2,100190 Beijing, PR China Tel: +86-010-82449177-888

DownLoad: Full-Size Img PowerPoint

Return