离子交换固相萃取-气相色谱-质谱联用法测定方便面皮复合包装袋中2,4-二氨基甲苯的迁移量

引用本文: 芦智远, 王冰, 田娜, 张耀武, 张新宇, 刘佳, 吕岩. 离子交换固相萃取-气相色谱-质谱联用法测定方便面皮复合包装袋中2,4-二氨基甲苯的迁移量[J]. 色谱, 2019, 37(10): 1053-1058. doi: 10.3724/SP.J.1123.2019.01024 shu

Citation: LU Zhiyuan, WANG Bing, TIAN Na, ZHANG Yaowu, ZHANG Xinyu, LIU Jia, LÜ Yan. Determination of 2,4-diaminotoluene in Mianpi composite packaging film bags by ion-exchange solid-phase extraction-gas chromatography-mass spectrometry[J]. Chinese Journal of Chromatography, 2019, 37(10): 1053-1058. doi: 10.3724/SP.J.1123.2019.01024 shu

离子交换固相萃取-气相色谱-质谱联用法测定方便面皮复合包装袋中2,4-二氨基甲苯的迁移量

芦智远 ^1, ,
王冰 ^2, ,
田娜 ^1, ,
张耀武 ^1, ,
张新宇 ^1, ,
刘佳 ^1, ,
吕岩 ^1,

1.
西安市产品质量监督检验院, 陕西西安 710065;
2.
西安计量技术研究院, 陕西西安 710086
基金项目:
国家粮食局行业标准项目（国粮办发[2017]177号）.

摘要: 建立了方便面皮复合包装袋中2，4-二氨基甲苯迁移量的离子交换固相萃取-气相色谱-质谱联用检测方法。样品用4%（v/v）乙酸溶液浸泡，然后采用MCX混合型阳离子交换柱富集净化，以5.0 mL水淋洗小柱，用3.0 mL 5%（v/v）氨化甲醇洗脱样品，洗脱液经过溶剂交换，七氟丁酸酐衍生后，用气相色谱-质谱联用仪对目标物进行检测，外标法定量。2，4-二氨基甲苯在1~50 μg/L范围内，线性相关系数（r）为0.9991，检出限（S/N=3）为0.2 μg/L，定量限（S/N=10）为0.6 μg/L，回收率在89.0%~94.2%之间，相对标准偏差为1.9%~3.6%。该方法的前处理过程无需调节提取液的pH值，也不需要液液萃取，大幅简化了前处理过程，降低了有机溶剂的消耗，具有操作便捷、结果准确的优点，适用于方便面皮复合包装袋中2，4-二氨基甲苯迁移量的检测。

关键词:

English

Determination of 2,4-diaminotoluene in Mianpi composite packaging film bags by ion-exchange solid-phase extraction-gas chromatography-mass spectrometry

1.
Xi'an Supervision & Inspection Institute of Product Quality, Xi'an 710065, China;
2.
Xi'an Institute of Measurement and Testing Technology, Xi'an 710086, China
Received Date: 02 February 2019
Fund Project:
Industry Standard Project of State Administration of Grain (Office[2017]177).

Abstract: A method for the determination of 2,4-diaminotoluene in Mianpi composite packaging film bags was established based on ion-exchange solid-phase extraction-gas chromatography-mass spectrometry (GC-MS). The samples were immersed in 4% (v/v) acetic acid solution. 2,4-Diaminotoluene was enriched from a 50.0 mL soak solution with an activated and balanced MCX solid-phase extraction column. The MCX column was washed with 5.0 mL water and eluted with 3.0 mL ammoniated methanol. 2,4-Diaminotoluene was detected quantitatively by GC-MS after derivatization with heptafluorobutyric acid anhydride. In the mass concentration range of 1-50 μg/L, the linear correlation coefficient (r) was 0.9991. The limit of detection (LOD, S/N=3) was 0.2 μg/L, and the limit of quantification (LOQ, S/N=10) was 0.6 μg/L. The recovery of 2,4-diaminotoluene was in the range of 89.0%-94.2%. The relative standard deviations (RSDs) were 1.9%-3.6%. This method requires neither pH adjustment of the soak solution in the pre-processing step nor liquid-liquid extraction. With this method, the pre-processing step is greatly simplified and there is minimal consumption of organic solvents. Further, the method is simple, convenient, and accurate, and it is suitable for the determination of 2,4-diaminotoluene in Mianpi composite packaging film bags.

Key words:

ion exchange solid phase extraction
/ gas chromatography-mass spectrometry (GC-MS)
/ 2,4-diaminotoluene
/ Mianpi composite packaging film bag

1. [1] Li Y, Zhu X C. For China Food Industry, 2006, 21(6):34 李勇, 朱兴成. 中国食品工业, 2006, 21(6):34
2. [2] Chen X M, Li T. Packaging Engineering, 2016, 37(15):102 陈旭明, 李婷. 包装工程, 2016, 37(15):102
3. [3] GB/T 5009.119-2003
4. [4] GB 31604.23-2016
5. [5] Li X J, Zhou C M. Chinese Journal of Health Laboratory Technology, 2006, 16(7):794 李小娟, 周长美. 中国卫生检验杂志, 2006, 16(7):794
6. [6] Dong S P, Hu J R. Chinese Journal of Health Laboratory Technology, 2012, 22(7):1719 董四平, 胡静荣. 中国卫生检验杂志, 2012, 22(7):1719
7. [7] Jiang S K. Chinese Journal of Spectroscopy Laboratory, 2013, 30(2):854 蒋受坤. 光谱实验室, 2013, 30(2):854
8. [8] Lu C M, Wang M T, Li A J, et al. For China Food Industry, 2007, 22(9):63 芦春梅, 王明泰, 李爱军, 等. 中国食品工业, 2007, 22(9):63
9. [9] Huo X M, Zhang J B, Jiang J, et al. Guangxi Journal of Light Industry, 2008(5):10 霍晓敏, 张敬波, 姜俊, 等. 广西轻工业, 2008(5):10
10. [10] Li S X, Huang W X, Lv F, et al. Food Science, 2013, 34(8):240 李少霞, 黄伟雄, 吕芬, 等. 食品科学, 2013, 34(8):240
11. [11] Hu J, Wang S T, Wang M, et al. Journal of Analytical Science, 2015, 31(6):883 胡建, 汪仕韬, 王敏, 等. 分析科学学报, 2015, 31(6):883
12. [12] Jiang F, Xiang Z C, Yang W W. Chinese Journal of Health Laboratory Technology, 2017, 27(3):341 蒋芳, 向仲朝, 杨文婉. 中国卫生检验杂志, 2017, 27(3):341
13. [13] Zhang J Z. China Printing and Packaging Study, 2010, 2(1):58 张居舟. 中国印刷与包装研究, 2010, 2(1):58
14. [14] Zhao X R, Xu W, Mou M R, et al. Fujian Analysis & Testing, 2010, 19(4):46 赵雪蓉, 徐伟, 牟明仁, 等. 福建分析测试, 2010, 19(4):46
15. [15] Ma M, Zhou Y Y, Zhou Y, et al. Chinese Journal of Analysis Laboratory, 2013, 32(6):50 马明, 周宇艳, 周韵, 等. 分析试验室, 2013, 32(6):50
16. [16] Nan Y, Wang Z H. Physical Testing and Chemical Analysis(Part B:Chemical Analysis), 2016, 52(2):211 南洋, 王振华. 理化检验(化学分册), 2016, 52(2):211
17. [17] Xie W X, Sun Z S, Li J, et al. Chinese Journal of Analysis Laboratory, 2008, 27(z2):95 解伟欣, 孙忠松, 李杰, 等. 分析试验室, 2008, 27(z2):95
18. [18] GB 9683-88

扫一扫看文章

计量

PDF下载量: 3
文章访问数: 504
HTML全文浏览量: 46

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

离子交换固相萃取-气相色谱-质谱联用法测定方便面皮复合包装袋中2,4-二氨基甲苯的迁移量

English

Determination of 2,4-diaminotoluene in Mianpi composite packaging film bags by ion-exchange solid-phase extraction-gas chromatography-mass spectrometry

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

离子交换固相萃取-气相色谱-质谱联用法测定方便面皮复合包装袋中2,4-二氨基甲苯的迁移量

English

Determination of 2,4-diaminotoluene in Mianpi composite packaging film bags by ion-exchange solid-phase extraction-gas chromatography-mass spectrometry

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南： 你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

文章相关

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs