Citation: NIU Zengyuan, LUO Xin, YE Xiwen, XIU Xiaoli, ZHANG Li, WANG Xin, CHEN Jing. Rapid screening and identification of 22 allergenic disperse dyes in ecological textiles by high performance liquid chromatography- linear ion trap/orbitrap mass spectrometry[J]. Chinese Journal of Chromatography, ;2015, 33(10): 1104-1109. doi: 10.3724/SP.J.1123.2015.04048 shu

Rapid screening and identification of 22 allergenic disperse dyes in ecological textiles by high performance liquid chromatography- linear ion trap/orbitrap mass spectrometry

NIU Zengyuan ^1,, ,
LUO Xin ¹ ,
YE Xiwen ¹ ,
XIU Xiaoli ^1,2 ,
ZHANG Li ^1,3 ,
WANG Xin ¹ ,
CHEN Jing ¹

1.
1. Technical Center for Inspection and Quarantine of Shandong Entry-Exit Inspection and Quarantine Bureau, Qingdao 266002, China;

Corresponding author: NIU Zengyuan,
Received Date: 28 April 2015

Fund Project: 质检公益性行业科研专项(201310062) (201310062)国家质检总局科技项目(2013IK015) (2013IK015)山东出入境检验检疫局科技项目(SK200994). (SK200994)

A rapid screening method based on high performance liquid chromatography-linear ion trap/orbitrap high-resolution mass spectrometry (HPLC-LTQ/Orbitrap MS) for 22 disperse dyes in ecological textiles has been established. The target compounds were extracted by pyridine/water (1:1, v/v) by shaking extraction in 90 ℃ water bath. The extracts were then separated by a CAPCELL PAK C₁₈ column (100 mm×2.0 mm, 5 μm) using gradient elution with acetonitrile-5 mmol/L ammonium acetate containing 0.01% (v/v) formic acid as mobile phases, and finally analyzed by HPLC-LTQ/Orbitrap in positive and negative ESI modes. The retention time and accurate mass of parent ion were used for fast screening of 22 disperse dyes, while the confirmatory analysis was obtained by fragments generated by collision-induced dissociation (CID) MS/MS. Target analysis exhibited high mass accuracy (< 5×10^-6). Each target showed a good linearity in its own concentration range and the correlation coefficient was higher than 0.99. The LOQs were 0.125-2.5 mg/kg. Except for Disperse Yellow 49, the average recoveries of most disperse dyes at three spiked levels were 65%-120%, and the relative standard deviations (n=6) were less than 15%. The method was applied for screening 40 different kinds of textiles, and Disperse Orange 37/76 was detected in one of them. With high selectivity and strong anti-jamming ability, this method is simple, rapid, accurate, and it can be used for the inspection of disperse dyes in textiles.
1. [1]
  [1] Oeko-Tex^®-International Association for Research and Testing in the Field of Textile Ecology. Oeko-Tex Standard 100. (2014-12-24). https://www.oeko-tex.com/en/manufactur- ers/manufacturers.xhtml
2. [2]
  [2] European Communities. Commission Decision of 9 July 2009 Establishing the Ecological Criteria for the Award of the Community Eco-label for Textile Products (2009/567/EC). (2009-07-09). http://eur-lex.europa.eu/search.html?qid=1435755118480&text=2009/567/EC&scope=EURLEX&type=quick&lang=en
3. [3]
  [3] BS EN 71-10: 2005
4. [4]
  [4] GB/T 20383-2006
5. [5]
  [5] García-Lavandeira J, Blanco E, Salgado C, et al. Talanta, 2010, 82: 261
6. [6]
  [6] Fang H W, Chen X, Lu Y P, et al. Journal of Instrumental Analysis (方慧文, 陈曦, 卢跃鹏, 等. 分析测试学报), 2010, 29(12): 1178
7. [7]
  [7] Zhao S H, Wu G, Wu J J, et al. Textile Standard and Quality (赵珊红, 吴刚, 吴俭俭, 等. 纺织标准与质量), 2010(2): 37
8. [8]
  [8] Yang C, Zhao J H, Wang J, et al. J Chromatogr A, 2013, 1300: 38
9. [9]
  [9] DeArmond P D, DiGoregorio A L. J Chromatogr A, 2013, 1305: 154
10. [10]
  [10] Schuhmann K, Herzog R, Schwudke D, et al. Anal Chem, 2011, 83: 5480
11. [11]
  [11] Guo C C, Shi F, Jiang S, et al. J Chromatogr B, 2014, 967: 174
12. [12]
  [12] Jia W, Chu X G, Ling Y, et al. J Chromatogr A, 2014, 1336: 67
13. [13]
  [13] Jia W, Chu X G, Ling Y, et al. J Chromatogr A, 2014, 1347: 122
14. [14]
  [14] Lehner S M, Neumann N K N, Sulyok M, et al. Food Addit Contam, 2011, 28: 1457
15. [15]
  [15] Quifer-Rada P, Vallverdú-Queralt A, Martínez-Huélamo M, et al. Food Chem, 2015, 169: 336
16. [16]
  [16] Zhang L, Luo X, Niu Z Y, et al. J Chromatogr A, 2015, 1386: 22
17. [17]
  [17] Xiu X L, Luo X, Niu Z Y, et al. Chinese Journal of Chromatography (修晓丽, 罗忻, 牛增元, 等. 色谱), 2013, 31(10): 961
18. [18]
  [18] Ye X W, Peng Y, Niu Z Y, et al. Chinese Journal of Chromatography (叶曦雯, 彭燕, 牛增元, 等. 色谱), 2014, 32(9): 1005
19. [19]
  [19] Peng Y, Ye X W, Niu Z Y, et al. Chinese Journal of Chromatography (彭燕, 叶曦雯, 牛增元, 等. 色谱), 2015, 33(4): 377
20. [20]
  [20] ISO 16373-2-2014
21. [21]
  [21] European Communities. Commission Decision of 12 August 2002 Implementing Council Directive 96/23/EC Concerning the Performance of Analytical Methods and the Interpretation of Results. Official Journal of the European Communities. 2002/657/EC. (2002-08-12). http://eur-lex.europa.eu/legal-content/EN/ALL/?uri=CELEX:32002D0657
22. [22]
  [22] Domènech A, Francisco N C, Palacios O, et al. J Chromatogr A, 2014, 1328: 16
23. [23]
  [23] Choi J H, Lamshöft M, Zühlke S, et al. Biomed Chromatogr, 2014, 28: 751
1. [1]
  Hanmei Lü , Xin Chen , Qifu Sun , Ning Zhao , Xiangxin Guo . Uniform Garnet Nanoparticle Dispersion in Composite Polymer Electrolytes. Acta Physico-Chimica Sinica, 2024, 40(3): 2305016-0. doi: 10.3866/PKU.WHXB202305016
2. [2]
  Yanhui Zhong , Ran Wang , Zian Lin . Analysis of Halogenated Quinone Compounds in Environmental Water by Dispersive Solid-Phase Extraction with Liquid Chromatography-Triple Quadrupole Mass Spectrometry. University Chemistry, 2024, 39(11): 296-303. doi: 10.12461/PKU.DXHX202402017
3. [3]
  Zian Lin , Yingxue Jin . Matrix-Assisted Laser Desorption/Ionization Mass Spectrometry (MALDI-MS) for Disease Marker Screening and Identification: A Comprehensive Experiment Teaching Reform in Instrumental Analysis. University Chemistry, 2024, 39(11): 327-334. doi: 10.12461/PKU.DXHX202403066
4. [4]
  Zunxiang Zeng , Yuling Hu , Yufei Hu , Hua Xiao . Analysis of Plant Essential Oils by Supercritical CO₂Extraction with Gas Chromatography-Mass Spectrometry: An Instrumental Analysis Comprehensive Experiment Teaching Reform. University Chemistry, 2024, 39(3): 274-282. doi: 10.3866/PKU.DXHX202309069
5. [5]
  Mingyang Men , Jinghua Wu , Gaozhan Liu , Jing Zhang , Nini Zhang , Xiayin Yao . Sulfide Solid Electrolyte Synthesized by Liquid Phase Approach and Application in All-Solid-State Lithium Batteries. Acta Physico-Chimica Sinica, 2025, 41(1): 100004-0. doi: 10.3866/PKU.WHXB202309019
6. [6]
  Yan Long , Wenbo Zhao , Qing Cao , Xiangyu Li , Fukui Li , Yanwei Hu , Shiyu Song , Kaikai Liu . Phosphorescent carbon nanodot inks for scalable and high-resolution invisible printing. Acta Physico-Chimica Sinica, 2026, 42(3): 100198-0. doi: 10.1016/j.actphy.2025.100198
7. [7]
  Yanan Liu , Yufei He , Dianqing Li . Preparation of Highly Dispersed LDHs-based Catalysts and Testing of Nitro Compound Reduction Performance: A Comprehensive Chemical Experiment for Research Transformation. University Chemistry, 2024, 39(8): 306-313. doi: 10.3866/PKU.DXHX202401081
8. [8]
  Chongjing Liu , Yujian Xia , Pengjun Zhang , Shiqiang Wei , Dengfeng Cao , Beibei Sheng , Yongheng Chu , Shuangming Chen , Li Song , Xiaosong Liu . Understanding Solid-Gas and Solid-Liquid Interfaces through Near Ambient Pressure X-Ray Photoelectron Spectroscopy. Acta Physico-Chimica Sinica, 2025, 41(2): 100013-0. doi: 10.3866/PKU.WHXB202309036
9. [9]
  Hao Wu , Zhen Liu , Dachang Bai . ¹H NMR Spectrum of Amide Compounds. University Chemistry, 2024, 39(3): 231-238. doi: 10.3866/PKU.DXHX202309020
10. [10]
  Ke Qiu , Fengmei Wang , Mochou Liao , Kerun Zhu , Jiawei Chen , Wei Zhang , Yongyao Xia , Xiaoli Dong , Fei Wang . A Fumed SiO₂-based Composite Hydrogel Polymer Electrolyte for Near-Neutral Zinc-Air Batteries. Acta Physico-Chimica Sinica, 2024, 40(3): 2304036-0. doi: 10.3866/PKU.WHXB202304036
11. [11]
  Zhaoxuan ZHU , Lixin WANG , Xiaoning TANG , Long LI , Yan SHI , Jiaojing SHAO . Application of poly(vinyl alcohol) conductive hydrogel electrolytes in zinc ion batteries. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 893-902. doi: 10.11862/CJIC.20240368
12. [12]
  Zhi Dou , Huiyu Duan , Yixi Lin , Yinghui Xia , Mingbo Zheng , Zhenming Xu . High-Throughput Screening Lithium Alloy Phases and Investigation of Ion Transport for Solid Electrolyte Interphase Layer. Acta Physico-Chimica Sinica, 2024, 40(3): 2305039-0. doi: 10.3866/PKU.WHXB202305039
13. [13]
  Yifan Xie , Liyun Yao , Ruolin Yang , Yuxing Cai , Yujie Jin , Ning Li . Exploration and Practice of Online and Offline Hybrid Teaching Mode in High-Performance Liquid Chromatography Experiment. University Chemistry, 2025, 40(11): 100-107. doi: 10.12461/PKU.DXHX202412133
14. [14]
  Yu Peng , Jiawei Chen , Yue Yin , Yongjie Cao , Mochou Liao , Congxiao Wang , Xiaoli Dong , Yongyao Xia . Tailored cathode electrolyte interphase via ethylene carbonate-free electrolytes enabling stable and wide-temperature operation of high-voltage LiCoO₂. Acta Physico-Chimica Sinica, 2025, 41(8): 100087-0. doi: 10.1016/j.actphy.2025.100087
15. [15]
  Yue-Zhou Zhu , Kun Wang , Shi-Sheng Zheng , Hong-Jia Wang , Jin-Chao Dong , Jian-Feng Li . Application and Development of Electrochemical Spectroscopy Methods. Acta Physico-Chimica Sinica, 2024, 40(3): 2304040-0. doi: 10.3866/PKU.WHXB202304040
16. [16]
  Zhike Yang , Jinfan Xu , Junhao Chen , Zheng Yang , Fei Ding , Neil Qiang Su . AI NMR Assistant: A DP5-Based Intelligent System for NMR Spectral Interpretation. University Chemistry, 2026, 41(1): 20-28. doi: 10.12461/PKU.DXHX202506013
17. [17]
  Ningyuan Chen , Qingyi Zeng , Zhiqiang Kuang , Peicong Tian , Dazhi Yan , Weiliang Jin , Deming Kong . Digital-Assisted Experimental Study on Dye Adsorption by Porous Materials. University Chemistry, 2026, 41(1): 321-331. doi: 10.12461/PKU.DXHX202504072
18. [18]
  Xianyong Lu , Tao Hu . Developing an Innovative Inorganic Chemistry Teaching Model Based on Aerospace Specialty Characteristics. University Chemistry, 2025, 40(7): 127-131. doi: 10.12461/PKU.DXHX202409037
19. [19]
  Xinran Zhang , Siqi Liu , Yichi Chen , Qingli Zou , Qinghong Xu , Yaqin Huang . From Protein to Energy Storage Materials: Edible Gelatin Jelly Electrolyte. University Chemistry, 2025, 40(7): 255-266. doi: 10.12461/PKU.DXHX202408104
20. [20]
  Yan Zhang , Xiaoyan Cao , Yiming Li , Shuwei Xia , Mutai Bao . Comparison of Electrolyte Solutions Section in Physical Chemistry Textbooks at Home and Abroad. University Chemistry, 2025, 40(9): 303-309. doi: 10.12461/PKU.DXHX202502027

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(567)
HTML views(100)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142