Citation: Tian GAO, Ri-hong XIAO, Xing CHUAI, Zhuo XIONG, Geng WEI, Tie LI, Kai YANG, Guo LI, Yong-chun ZHAO, Jun-ying ZHANG. Study on mercury emission characteristics of circulating fluidized bed boiler and pulverized coal boiler[J]. Journal of Fuel Chemistry and Technology, ;2022, 50(3): 275-282. doi: 10.19906/j.cnki.JFCT.2021075 shu

Study on mercury emission characteristics of circulating fluidized bed boiler and pulverized coal boiler

Tian GAO ^1, ,
Ri-hong XIAO ¹ ,
Xing CHUAI ¹ ,
Zhuo XIONG ¹ ,
Geng WEI ² ,
Tie LI ² ,
Kai YANG ² ,
Guo LI ² ,
Yong-chun ZHAO ^1,, ,
Jun-ying ZHANG ¹

1.
State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology, Wuhan 430074, China
2.
Key Laboratory for Clean Combustion and Flue Gas Purification of Sichuan Province (Dongfang Boiler Co., Ltd., Dongfang Electric Group), Zigong 643099, China

Corresponding author: Yong-chun ZHAO, yczhao@hust.edu.cn
Received Date: 8 July 2021
Revised Date: 1 August 2021

Figures(9)

A 600 MW circulating fluidized bed boiler power plant and a 1000 MW pulverized coal boiler power plant were selected to study mercury migration, transformation and emission characteristics. The mercury concentration in flue gas was sampled by EPA 30B method, and the solid and liquid samples such as furnace-incoming coal, fly ash, bottom slag, limestone, process water, desulfurization gypsum and desulfurization wastewater were collected for analysis. The synergetic effect of existing pollutant control devices on mercury removal in two power plants was studied, and the migration and transformation law of mercury was discussed. After the flue gas of the two power plants passes through APCDs, the total mercury removal rate reaches over 88%, and the final mercury concentrations of the flue gas are 1.85 and 1.10 μg/m³, which are far lower than the national requirements. Under the existing equipment conditions, the ultra-low mercury emission can be realized.
- coal-fired power plant,
- mercury,
- circulating fluidized bed,
- pulverized coal boiler,
- migration and transformation
1. [1]
  XIN Feng, WEI Shu-zhou, ZHANG Jun-feng, MA Si-ming, ZHAO Yong-chun, ZHANG Jun-ying. Research progress on the removal of mercury from coal-fired flue gas by using non-carbon-based adsorbents[J]. J Fuel Chem Technol,2020,48(12):1409−1420. doi: 10.3969/j.issn.0253-2409.2020.12.002
2. [2]
  TIAN H Z, ZHU C Y, GAO J J, CHENG K, НAO J M, WANG K, HUA S B, WANG Y, ZHOU J R. Quantitative assessment of atmospheric emissions of toxic heavy metals from anthropogenic sources in China: historical trend, spatial distribution, uncertainties, and control policies[J]. Atmos Chem Phys,2015,15(8):12107−12166.
3. [3]
  WU Q, WANG S, LIU K, HAO J. Emission-limit-oriented strategy to control atmospheric mercury emissions in coal-fired power plants toward the implementation of the minamata convention[J]. Environ Sci Technol,2018,52(19):11087−11093. doi: 10.1021/acs.est.8b02250
4. [4]
  NIU Li-li, XU Chao, LIU Wei-ping. Overviews of mercury emission from coal combustion in China and technology of mercury-removing by activated carbon[J]. Environ Sci Technol,2012,35(9):45−55. doi: 10.3969/j.issn.1003-6504.2012.09.011
5. [5]
  XU Li-meimei, LI Cai-ting, Xazadam·Ablikin, GAO Zhao. Development of mercury pollution control of flue gas with existing treatment eouipments and technioues in coal-fired power plant[J]. Environ Eng,2010,28(3):77−80.
6. [6]
  LIU Fei, QIAO Shao-hua, YAN Nai-qiang, QU Zan, JIA Jin-ping. Progress of elemental mercury control from coal-fired flue gas[J]. Environ Sci Technol,2012,35(6):58−63. doi: 10.3969/j.issn.1003-6504.2012.06.014
7. [7]
  LIU Xuan, SU Yin-jiao, ZHAO Yuan-cai, TENG Yang, ZHANG Kai, ZHANG Yong-hong. Distribution and enrichment characteristics of arsenic in feed-coal and by-products of coal-fired power plants[J]. J Fuel Chem Technol,2020,48(12):1513−1519. doi: 10.3969/j.issn.0253-2409.2020.12.013
8. [8]
  TANG Nian, PAN Si-wei. Study on mercury emission and migration from large-scale pulverized coal-fired boiler[J]. J Fuel Chem Technol,2013,41(4):484−490. doi: 10.3969/j.issn.0253-2409.2013.04.015
9. [9]
  CAO Y, GAO Z, ZHU J, WANG Q, HUANG Y, CHIU C, PARKER B, CHU P, PAN W. Impacts of halogen additions on mercury oxidation, in a slipstream selective catalyst reduction (SCR), reactor when burning sub-bituminous coal[J]. Environ Sci Technol,2008,42(1):256−261. doi: 10.1021/es071281e
10. [10]
  WANG Zheng, XUE Jian-ming, XU Yue-yang, WANG Hong-liang, LIU Jun. Research on influencing factors of SCR's cooperative control in mercury emissions from coal-fired flue[J]. Proc CSEE,2013,33(14):32−37.
11. [11]
  XU Yue-yang, XUE Jian-ming, WANG Hong-laing, LI Bing, GUAN Yi-ming, LIU Jun. Research on mercury collaborative control by conventional pollutants purification facilities of coal-fired power plants[J]. Proc CSEE,2014,34(23):3924−3931.
12. [12]
  LEE C W, SRIVASTAVA R K, GHORISHI S B HASTINGS T W, STEVENS F M. Investigation of selective catalytic reduction impact on mercury speciation under simulated NO_x emission control conditions[J]. J Air Waste Manage,2004,54(12):1560−1566. doi: 10.1080/10473289.2004.10471009
13. [13]
  CHEN Lei, DUAN Yu-feng, ZHAO Shi-lin, LI Ya-ning. Mercury Co-removal by the air pollutant control devices in a 350 MW ultra-low emission coal-fired power plant[J]. J Eng Therm Energy Power,2020,35(2):187−193.
14. [14]
  LI H, LI Y, WU C, ZHANG J. Oxidation and capture of elemental mercury over SiO₂-TiO₂-V₂O₅ catalysts in simulated low-rank coal combustion flue gas[J]. Chem Eng J,2011,169(1/3):186−193. doi: 10.1016/j.cej.2011.03.003
15. [15]
  SUI Hui, ZHANG Meng-ze, DONG Yong, WANG Peng. Research progress of adsorption and oxidation mechanism of elemental mercury from coal-fired flue gas[J]. Chem Ind Eng Prog,2014,33(6):1582−1588.
16. [16]
  WANG Chen-ping, DUAN Yu-feng, ZHAO Shi-lin, LI Ya-ning, ZHU Chun, SHE Min, LIU Meng, WEI Hong-qi, WANG Shuang-qun. Effects of coal combustion temperature on mercury emission and speciation[J]. Chem Ind Eng Prog,2017,36(5):1899−1905.
17. [17]
  ZHOU Y, YANG J, DONG L, GAO T, LI Z, JI Y, ZHAO Y, PAN S, ZHANG J, ZHENG C. Removal of elemental mercury from flue gas by recyclable CuCl₂ modified magnetospheres from fly ash. Part 5. Industrial scale studies at a 50MWth coal-fired power plant[J]. Fuel,2020,266:1−8.
18. [18]
  PUDASAINEE D, KIM J, YOON Y, SEO YC. Oxidation, reemission and mass distribution of mercury in bituminous coal-fired power plants with SCR, CS-ESP and wet FGD[J]. Fuel,2012,93(1):312−318.
19. [19]
  LIU H, CHEN Y, GAO T, YANG G, ZHANG J. Elemental mercury removal from flue gas using modified tonstein: Performance of adsorbent injection at an entrained flow reactor system and 50-MW coal-fired power plant in China[J]. J Clean Prod,2020,287:124998.
20. [20]
  WANG Yun-jun, DUAN Yu-feng, YANG Li-guo, JIANG Yi-man, WU Cheng-jun, WANG Qian, YANG Xiang-hua. Comparison of mercury removal characteristic between fabric filter and electrostatic precipitators of coal-fired power plants[J]. J Fuel Chem Technol,2008,36(1):23−29. doi: 10.3969/j.issn.0253-2409.2008.01.005
21. [21]
  YOKOYAMA T, ASAKURA K, MATSUDA H, ITO S, NODA N. Mercury emissions from a coal-fired power plant in Japan[J]. Sci Total Environ,2000,259(1/3):97−103. doi: 10.1016/S0048-9697(00)00552-0
22. [22]
  FTHENAKIS V M, LIPFERT F W, MOSKOWITZ P D. An assessment of mercury emissions and health risks from a coal-fired power plant[J]. J Hazard Mater,1995,44(2/3):267−283. doi: 10.1016/0304-3894(95)00058-3
23. [23]
  YANG Hong-min, KUN-LEI LIU, YAN CAO, PAN Wei-ping. Demercurization property of flue gas desulfurization installations in power plants[J]. J Chin Soc Power Eng,2006,(4):554−557.
24. [24]
  HU Chang-xing, ZHOU Jin-song, HE Sheng, ZHANG Le ZHENG Jian-ming, LUO Zhong-yang, CEN Ke-fa. Influence and control of electrostatic precipitators and wet flue gas desulfurization systems on the speciation of mercury in flue gas[J]. J Chin Soc Power Eng,2009,29(4):400−404.
25. [25]
  LI Zhi-chao, DUAN Yu-feng, WANG Yun-jun, HUANG Zhi-jun, MENG Su-li, SHEN Jie-zhong. Mercury removal by ESP and WFGD in a 300 MW coal-fired power plant[J]. J Fuel Chem Technol,2013,41(4):491−498. doi: 10.3969/j.issn.0253-2409.2013.04.016
1. [1]
  Gaihua Li , Donglian Liu , Xiuge Wang , Shuang Liu , Ning Zhang , Xuerui Tian . Teaching Design of Elemental Chemistry under the Concept of “Curriculum Ideology and Politics”: a Case of Mercury. University Chemistry, 2026, 41(2): 45-53. doi: 10.12461/PKU.DXHX202502025
2. [2]
  Haobin Zhou , Shuai Du , Xuesong Guo , Yue Wang , Qin Zhong , Tong Wang , Yuzhi Wang , Shuangyan Huan , Hailong Yan , Kun Li . 阳极溶出伏安法测定水中微量镉的无汞化改进. University Chemistry, 2026, 41(5): 275-284. doi: 10.12461/PKU.DXHX202511142
3. [3]
  Han Ren , Xingrui He , Xiangfeng Zeng , Zeyi Long , Guifeng Wang , Qixin Zhang , Xiaochuan Zou . From Ancient Alchemical Furnaces to Contemporary Technological Wonders. University Chemistry, 2026, 41(2): 328-334. doi: 10.12461/PKU.DXHX202503111
4. [4]
  Wan Li , Mei Shi , Yanping Ren , Faqiong Zhao , Min Hu , Xiuyun Wang , Juanjuan Song , Yongxian Fan , Dongcheng Liu , Xiuqiong Zeng , Wenwei Zhang , Weihong Li , Xiaohang Qiu , Yong Fan , Jianrong Zhang , Shuyong Zhang . Suggestions on Heating and Heating Instruments (Part V): Solid-State Synthesis and High-Temperature Heating Using Muffle and Tube Furnaces. University Chemistry, 2026, 41(3): 182-190. doi: 10.12461/PKU.DXHX202507046
5. [5]
  Dongqi Cai , Fuping Tian , Zerui Zhao , Yanjuan Zhang , Yue Dai , Feifei Huang , Yu Wang . Exploration of Factors Influencing the Determination of Ion Migration Number by Hittorf Method. University Chemistry, 2024, 39(4): 94-99. doi: 10.3866/PKU.DXHX202310031
6. [6]
  Jiayu Tang , Jichuan Pang , Shaohua Xiao , Xinhua Xu , Meifen Wu . Improvement for Measuring Transference Numbers of Ions by Moving-Boundary Method. University Chemistry, 2024, 39(5): 193-200. doi: 10.3866/PKU.DXHX202311021
7. [7]
  Rui Li , Huan Liu , Yinan Jiao , Shengjian Qin , Jie Meng , Jiayu Song , Rongrong Yan , Hang Su , Hengbin Chen , Zixuan Shang , Jinjin Zhao . Emerging Irreversible and Reversible Ion Migrations in Perovskites. Acta Physico-Chimica Sinica, 2024, 40(11): 2311011-0. doi: 10.3866/PKU.WHXB202311011
8. [8]
  Wang Shuang , Fu Xiaoqi , Yao Shanshan . Synergistic optimization of ion migration and electron transfer in sodium-ion battery cathode materials. Acta Physico-Chimica Sinica, 2026, 42(5): 100206-. doi: 10.1016/j.actphy.2025.100206
9. [9]
  Yan ZHAO , Xiaokang JIANG , Zhonghui LI , Jiaxu WANG , Hengwei ZHOU , Hai GUO . Preparation and fluorescence properties of Eu³⁺-doped CaLaGaO₄ red-emitting phosphors. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1861-1868. doi: 10.11862/CJIC.20240242
10. [10]
  Jinmei Zhou , Huamin Li , Yiru Wang , Wenwei Zhang , Xiuqiong Zeng , Juanjuan Song , Yongxian Fan , Dongcheng Liu , Yanping Ren , Faqiong Zhao , Mei Shi , Min Hu , Wan Li , Xiuyun Wang , Weihong Li , Xiaohang Qiu , Yong Fan , Jianrong Zhang , Shuyong Zhang . Suggestions on Operational Standards for Heating and Heating Instruments (Part IV): Microwave Heating and the Use of Microwave Ovens, Microwave Reactor and Microwave Digester. University Chemistry, 2026, 41(3): 172-181. doi: 10.12461/PKU.DXHX202507043
11. [11]
  Han ZHANG , Jianfeng SUN , Jinsheng LIANG . Hydrothermal synthesis and luminescent properties of broadband near-infrared Na₃CrF₆ phosphor. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 349-356. doi: 10.11862/CJIC.20240098
12. [12]
  Xiaokang JIANG , Junliang MA , Yan ZHAO , Feng GAO , Changli LIU , Xingshen ZHAO , Hengwei ZHOU . Preparation and luminescent properties of Sm³⁺-doped La₂MgZrO₆ phosphors. Chinese Journal of Inorganic Chemistry, 2026, 42(2): 263-270. doi: 10.11862/CJIC.20250236
13. [13]
  Yutong Liu , Xuemin Jing . Research Progress on the Catalytic Conversion of Methane in the Context of the “Dual Carbon” Goals. University Chemistry, 2025, 40(10): 101-113. doi: 10.12461/PKU.DXHX202412018
14. [14]
  Ronghao Zhao , Yifan Liang , Mengyao Shi , Rongxiu Zhu , Dongju Zhang . Investigation into the Mechanism and Migratory Aptitude of Typical Pinacol Rearrangement Reactions: A Research-Oriented Computational Chemistry Experiment. University Chemistry, 2024, 39(4): 305-313. doi: 10.3866/PKU.DXHX202309101
15. [15]
  Shanghua Li , Malin Li , Xiwen Chi , Xin Yin , Zhaodi Luo , Jihong Yu . High-Stable Aqueous Zinc Metal Anodes Enabled by an Oriented ZnQ Zeolite Protective Layer with Facile Ion Migration Kinetics. Acta Physico-Chimica Sinica, 2025, 41(1): 100003-0. doi: 10.3866/PKU.WHXB202309003
16. [16]
  Wenwei Zhang , Chanzi Ruan , Yiru Wang , Xiuqiong Zeng , Juanjuan Song , Yongxian Fan , Dongcheng Liu , Yanping Ren , Faqiong Zhao , Mei Shi , Min Hu , Wan Li , Xiuyun Wang , Weihong Li , Xiaohang Qiu , Yong Fan , Jianrong Zhang , Shuyong Zhang . Suggestions on Heating and Heating Instruments (Part II): Direct Heating and the Use of Electric Furnace, Hot Plates, Ceramic Hot Plates, Electromagnetic Heating Stirrers and Heating Mantles. University Chemistry, 2026, 41(3): 154-162. doi: 10.12461/PKU.DXHX202507035
17. [17]
  Xuewei BA , Cheng CHENG , Huaikang ZHANG , Deqing ZHANG , Shuhua LI . Preparation and luminescent performance of Sr_1-xZrSi₂O₇∶xDy³⁺ phosphor with high thermal stability. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 357-364. doi: 10.11862/CJIC.20240096
18. [18]
  Yan ZHAO , Jiaxu WANG , Zhonghu LI , Changli LIU , Xingsheng ZHAO , Hengwei ZHOU , Xiaokang JIANG . Gd³⁺-doped Sc₂W3O₁₂: Eu³⁺ red phosphor: Preparation and luminescence performance. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 461-468. doi: 10.11862/CJIC.20240316
19. [19]
  Hanmei Lü , Xin Chen , Qifu Sun , Ning Zhao , Xiangxin Guo . Uniform Garnet Nanoparticle Dispersion in Composite Polymer Electrolytes. Acta Physico-Chimica Sinica, 2024, 40(3): 2305016-0. doi: 10.3866/PKU.WHXB202305016
20. [20]
  Cuiping HE , Zhuxuan LI , Yuqing SUN , Jie LIU , Shicheng XU , Zhanchao WU . Ca²⁺ doping induced crystal phase transition and spectral regulation of Ba₃P₄O₁₃: Eu²⁺ phosphor. Chinese Journal of Inorganic Chemistry, 2025, 41(11): 2299-2306. doi: 10.11862/CJIC.20250074

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(3819)
HTML views(630)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142