Citation: WANG Jun-li, ZHAO Qiang, HAO Xiao-gang, HUANG Wei, ZHAO Jian-guo. Low temperature co-pyrolysis of low rank coal with biomass and its influence on pyrolysis-derived products[J]. Journal of Fuel Chemistry and Technology, ;2021, 49(1): 37-46. doi: 10.19906/j.cnki.JFCT.2021003 shu

Low temperature co-pyrolysis of low rank coal with biomass and its influence on pyrolysis-derived products

WANG Jun-li ^1,, ,
ZHAO Qiang ¹ ,
HAO Xiao-gang ^2,, ,
HUANG Wei ^2,3 ,
ZHAO Jian-guo ^1,,

1.
College of Chemistry and Chemical Engineering, Shanxi Datong University, Datong 037009, China
2.
College of Chemistry and Chemical Engineering, Taiyuan University of Technology, Taiyuan 030024, China
3.
Key Laboratory of Coal Science and Technology of Education Ministry and Shanxi Province, Taiyuan University of Technology, Taiyuan 030024, China

Corresponding author: WANG Jun-li, wangjunlitylg@126.com HAO Xiao-gang, xghao@tyut.edu.cn ZHAO Jian-guo, jgzhaoshi@163.com
Received Date: 9 September 2020
Revised Date: 16 October 2020

Fund Project: The project was supported by the National Natural Science Foundation of China (21908135), Shanxi Province Science Foundation for Youths (201901D211435), Shanxi Province Foundation for Returness (2019-20) and Science and Technology Innovation Project for Colleges and Universities in Shanxi Province (201802096)

Figures(7)

The co-pyrolysis behavior of two low rank coals (Inner Mongolia Xinghe coal, Xiaolongtan coal) and three common biomasses (straw, sunflower, apple tree branches) was investigated by non-isothermal thermogravimetric analysis and fixed bed experiments. The results show that whether the co-pyrolysis of biomass and coal has synergistic effects is closely related to the type and the adding amount of biomass. The synergistic effect during the co-pyrolysis of Inner Mongolia Xinghe coal and apple tree branches at the mixing proportion 2∶1 is found to be the most obvious, which is further proved by an analysis of co-pyrolysis products in a fixed bed. The analysis results of tar component show that the content of oxygenated compounds in tar increases, but the amount of hydrocarbons decreases. The co-pyrolysis can increase the yield of tar but it cannot improve the quality of tar.
- low rank coal,
- biomass,
- co-pyrolysis,
- tar
1. [1]
  CHEN Ying-ying. Experimental study on co-pyrolysis of biomass and coal[D]. Baoding: North China Electric Power University, 2007.
2. [2]
  KUPPENS T, CORNELISSEN T, CARLEER R, YPERMAN J, SCHREURS S, JANS M, THEWYS T. Economic assessment of flash co-pyrolysis of short rotation coppice and biopolymer waste streams[J]. J Environ Manage,2010,91(12):2736−2747. doi: 10.1016/j.jenvman.2010.07.022
3. [3]
  CHENG Dan-yan, YONG Qi-run, GONG Ben-gen, ZHAO Yong-chun, ZHANG Jun-ying. Carbothermal interaction between Cu-based oxygen carrier and ash minerals in the chemical-looping gasification of coal and biomass[J]. J Fuel Chem Technol,2020,48(1):18−27.
4. [4]
  LI Xiao-ming, ZHANG Hong, LIU Meng-jie, ZHI Li-fei, BAI Jin, BAI Zong-qing, LI Wen. Investigation of coal-biomass interaction during co-pyrolysis by char separation and its effect on coal char structure and gasification reactivity with CO₂[J]. J Fuel Chem Technol,2020,48(8):897−907. doi: 10.1016/S1872-5813(20)30062-1
5. [5]
  FERMOSO J, ARIAS B, PLAZA M G, PEVIDA C, RUBIERA F, PIS J J, GARCÍA-PEÑA F, CASERO P. High-pressure co-gasification of coal with biomass and petroleum coke[J]. Fuel Process Technol,2009,90(7):926−932.
6. [6]
  NIKKHAH K, BAKHSHI N N, MACDONALD D G. Co-pyrolysis of various biomass materials and coals in a quartz semi-batch reactor[J]. Energy Bio Wastes,1993,16:857−857.
7. [7]
  ZHOU Shi-xue, NIE Xi-wen, WANG Rong-chun, LIU Ze-chang. Study on co-pyrolysis of high sulfur and strongly caking coal with biomass[J]. J Fuel Chem Technol,2000,28(4):294−297. doi: 10.3969/j.issn.0253-2409.2000.04.002
8. [8]
  ZHANG Li. Research on co-pyrolysis of biomass and coal in a free fall reactor[D]. Dalian: Dalian University of Technology, 2006.
9. [9]
  LI Shi-guang, XU Shao-ping. Copyrolysis of coal and biomass[J]. Coal Convers,2002,25(1):7−12. doi: 10.3969/j.issn.1004-4248.2002.01.002
10. [10]
  LI Wen, LI Bao-qing, SUN Cheng-gong, YU Chi-wei, CAO Bian-ying. Study on pyrolysis and hydropyrolysis of biomasss and copyrolysis between biomass and coal[J]. J Fuel Chem Technol,1996,24(4):341−347.
11. [11]
  STORM C, RUDIGER H, SPLIETHOFF H, HEIN K. Co-pyrolysis of coal/biomass and coal/sewage sludge mixtures[J]. J Eng Gas Turb Power,1999,121(1):55−63. doi: 10.1115/1.2816312
12. [12]
  WANG Jun-li. Kinetics of low rank coal pyrolysis and co-pyrolysis with biomass and deep processing of pyrolysis-derived products[D]. Taiyuan: Taiyuan University of Technology, 2017.
13. [13]
  XIE Ke-chang. Coal Structure and Its Reactivity[M]. Beijing: Science Press, 2002.
14. [14]
  YANG H, YAN R, CHEN H, LEE D H, ZHENG C. Characteristics of hemicellulose, cellulose and lignin pyrolysis[J]. Fuel,2007,86(12):1781−1788.
15. [15]
  ZHAO Chao-chao, DU Guan-ben. Study on the effect of operating conditions on biomass pyrolysis[J]. For Mach Woodwork Equip,2009,37(5):7−10. doi: 10.3969/j.issn.2095-2953.2009.05.002
16. [16]
  SONG Yu-yao. Experimental research on the characteristics of coal and biomass pyrolysis in the fix-bed reactor[D]. Anshan: University of Science and Technology Liaoning, 2015.
17. [17]
  HU Hai-tao, LI Yun-chao, WANG Xian-hua, ZHANG Shuai, YANG Hai-ping, CHEN Han-ping. A review of biomass pretreatment technologies and their influence on pyrolysis product[J]. Biomass Chem Eng,2014,48(1):44−50. doi: 10.3969/j.issn.1673-5854.2014.01.008
18. [18]
  GUAN Ren-gui, LI Wen, LI Bao-qing. Effects of Ca-based additives on pyrolysis of Datong coal[J]. J China Univ Min Technol,2002,31(4):396−401. doi: 10.3321/j.issn:1000-1964.2002.04.016
19. [19]
  LIU Z, GUO X, SHI L, HE W, WU J, LIU Q, LIU J. Reaction of volatiles-A crucial step in pyrolysis of coals[J]. Fuel,2015,154:361−369. doi: 10.1016/j.fuel.2015.04.006
20. [20]
  LU Q, ZHANG Z F, DONG C Q, ZHU X. Catalytic upgrading of biomass fast pyrolysis vapors with nano metal oxides: An analytical Py-GC/MS study[J]. Energies,2010,3(11):1805−1820. doi: 10.3390/en3111805
21. [21]
  LU Q, ZHANG Y, TANG Z, LI W, ZHU X. Catalytic upgrading of biomass fast pyrolysis vapors with titania and zirconia/titania based catalysts[J]. Fuel,2010,89(8):2096−2103. doi: 10.1016/j.fuel.2010.02.030
22. [22]
  PATTIYA A, TITILOYE J O, BRIDGWATER A V. Fast pyrolysis of cassava rhizome in the presence of catalysts[J]. J Anal Appl Pyrolysis,2008,81(1):72−79. doi: 10.1016/j.jaap.2007.09.002
23. [23]
  SONG Y, TAHMASEBI A, YU J. Co-pyrolysis of pine sawdust and lignite in a thermogravimetric analyzer and a fixed-bed reactor[J]. Bioresour Technol,2014,174:204−211. doi: 10.1016/j.biortech.2014.10.027
24. [24]
  PARK D K, KIM S D, LEE S H, LEE J G. Co-pyrolysis characteristics of sawdust and coal blend in TGA and a fixed bed reactor[J]. Bioresour Technol,2010,101(15):6151−6156. doi: 10.1016/j.biortech.2010.02.087
25. [25]
  OASMAA A, CZERNIK S. Fuel oil quality of biomass pyrolysis oils state of the art for the end users[J]. Energy Fuels,1999,13(4):914−921. doi: 10.1021/ef980272b
26. [26]
  SCHOLZE B, MEIER D. Characterization of the water-insoluble fraction from pyrolysis oil (pyrolytic lignin). Part I. PY-GC/MS, FTIR, and functional groups[J]. J Anal Appl Pyrolysis,2001,60(1):41−54. doi: 10.1016/S0165-2370(00)00110-8
27. [27]
  LU Q, LI W, ZHANG D, ZHU F. Analytical pyrolysis–gas chromatography/mass spectrometry (Py-GC/MS) of sawdust with Al/SBA-15 catalysts[J]. J Anal Appl Pyrolysis,2009,84(2):131−138. doi: 10.1016/j.jaap.2009.01.002
28. [28]
  VAN DE VELDEN M, BAEYENS J, BREMS A, JANSSENS B, DEWIL R. Fundamentals, kinetics and endothermicity of the biomass pyrolysis reaction[J]. Renew Energy,2010,35(1):232−242. doi: 10.1016/j.renene.2009.04.019
29. [29]
  CARLSON T R, CHENG Y T, JAE J, HUBER G W. Production of green aromatics and olefins by catalytic fast pyrolysis of wood sawdust[J]. Energy Environ Sci,2011,4(1):145−161. doi: 10.1039/C0EE00341G
30. [30]
  MOCHIZUKI T, CHEN S Y, TOBA M, YOSHIMURA Y. Pyrolyzer-GC/MS system-based analysis of the effects of zeolite catalysts on the fast pyrolysis of Jatropha husk[J]. Appl Catal A: Gen,2013,456:174−181. doi: 10.1016/j.apcata.2013.02.022
1. [1]
  Zhonghan Xu , Yuejia Li , Kin Shing Chan . 碳中和新旅程. University Chemistry, 2025, 40(6): 167-171. doi: 10.12461/PKU.DXHX202407075
2. [2]
  Qianqian ZHU , Lihui XU , Hong PAN , Chengjian YAO , Hong ZHAO , Nan MA , Xiaolin SHI , Zihan SHEN , Weijun ZHANG , Zhongjian WANG . Waste cotton fabric-ased porous carbon materials: Preparation and wave-absorbing properties. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1555-1564. doi: 10.11862/CJIC.20250040
3. [3]
  Kuaibing Wang , Feifei Mao , Weihua Zhang , Bo Lv . Design and Practice of a Comprehensive Teaching Experiment for Preparing Biomass Carbon Dots from Rice Husk. University Chemistry, 2025, 40(5): 342-350. doi: 10.12461/PKU.DXHX202407042
4. [4]
  Lu Zhuoran , Li Shengkai , Lu Yuxuan , Wang Shuangyin , Zou Yuqin . Cleavage of C―C Bonds for Biomass Upgrading on Transition Metal Electrocatalysts. Acta Physico-Chimica Sinica, 2024, 40(4): 2306003-0. doi: 10.3866/PKU.WHXB202306003
5. [5]
  Yang ZHOU , Lili YAN , Wenjuan ZHANG , Pinhua RAO . Thermal regeneration of biogas residue biochar and the ammonia nitrogen adsorption properties. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1574-1588. doi: 10.11862/CJIC.20250032
6. [6]
  Xinlong XU , Chunxue JING , Yuzhen CHEN . Bimetallic MOF-74 and derivatives: Fabrication and efficient electrocatalytic biomass conversion. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1545-1554. doi: 10.11862/CJIC.20250046
7. [7]
  Chi Zhang , Yi Xu , Xiaopeng Guo , Zian Jie , Ling Li . 五彩斑斓的秘密——物质显色机理. University Chemistry, 2025, 40(6): 266-275. doi: 10.12461/PKU.DXHX202407061
8. [8]
  Yuhang Jiang , Weijie Liu , Jiaqi Cai , Jiayue Chen , Yanping Ren , Pingping Wu , Liulin Yang . A Journey into the Science and Art of Sugar: “Dispersion of Light and Optical Rotation of Matter” Science Popularization Experiment. University Chemistry, 2024, 39(9): 288-294. doi: 10.12461/PKU.DXHX202401054
9. [9]
  Qingyang Cui , Feng Yu , Zirun Wang , Bangkun Jin , Wanqun Hu , Wan Li . From Jelly to Soft Matter: Preparation and Properties-Exploring of Different Kinds of Hydrogels. University Chemistry, 2024, 39(9): 338-348. doi: 10.3866/PKU.DXHX202309046
10. [10]
  Zhifang SU , Zongjie GUAN , Yu FANG . Process of electrocatalytic synthesis of small molecule substances by porous framework materials. Chinese Journal of Inorganic Chemistry, 2024, 40(12): 2373-2395. doi: 10.11862/CJIC.20240290
11. [11]
  Tianyang Yu , Hao Wei . “Illness Enters through the Mouth”: A Brief Overview of Toxic Chemical Substances in Common Foods. University Chemistry, 2025, 40(7): 225-231. doi: 10.12461/PKU.DXHX202409083
12. [12]
  Rohit Kumar , Anita Sudhaik , Aftab Asalam Pawaz Khan , Van Huy Neguyen , Archana Singh , Pardeep Singh , Sourbh Thakur , Pankaj Raizada . Designing tandem S-scheme photo-catalytic systems: Mechanistic insights, characterization techniques, and applications. Acta Physico-Chimica Sinica, 2025, 41(11): 100150-0. doi: 10.1016/j.actphy.2025.100150
13. [13]
  Faqiong Zhao , Xiuqiong Zeng , Kai Hu , Haiyan Liu , Yanping Ren , Wan Li , Wenwei Zhang , Juanjuan Song , Yongxian Fan , Dongcheng Liu , Mei Shi , Min Hu , Xiuyun Wang , Weihong Li , Xiaohang Qiu , Yong Fan , Jianrong Zhang , Shuyong Zhang . Suggestions on Operation Specifications for Drying of Chemical Substances and Use of Air-Blast Drying Ovens, Vacuum Drying Ovens and Freeze Dryers. University Chemistry, 2026, 41(3): 110-121. doi: 10.12461/PKU.DXHX202507033
14. [14]
  . . Chinese Journal of Inorganic Chemistry, 2024, 40(12): 0-0.
15. [15]
  Min Hu , Yinghuan Li , Yanhong Bai , Yanping Ren , Juanjuan Song , Yongxian Fan , Dongcheng Liu , Xiuqiong Zeng , Faqiong Zhao , Wenwei Zhang , Mei Shi , Wan Li , Xiuyun Wang , Weihong Li , Xiaohang Qiu , Yong Fan , Jianrong Zhang , Shuyong Zhang . Suggestions on the Method of Hydrothermal-Solventthermal Synthesis and Their Operation Standards. University Chemistry, 2026, 41(3): 208-215. doi: 10.12461/PKU.DXHX202507034
16. [16]
  Yi Fan , Zhuoqi Jiang , Zhipeng Li , Xuan Zhou , Jingan Lin , Laiying Zhang , Xu Hou . 偶极诱导液体门控可视化物质检测——化学“101计划”表界面性质应用实验新设计. University Chemistry, 2025, 40(8): 265-271. doi: 10.12461/PKU.DXHX202410061
17. [17]
  Shipeng WANG , Shangyu XIE , Luxian LIANG , Xuehong WANG , Jie WEI , Deqiang WANG . Piezoelectric effect of Mn, Bi co-doped sodium niobate for promoting cell proliferation and bacteriostasis. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1919-1931. doi: 10.11862/CJIC.20240094
18. [18]
  Kexin Yan , Zhaoqi Ye , Lingtao Kong , He Li , Xue Yang , Yahong Zhang , Hongbin Zhang , Yi Tang . Seed-Induced Synthesis of Disc-Cluster Zeolite L Mesocrystals with Ultrashort c-Axis: Morphology Control, Decoupled Mechanism, and Enhanced Adsorption. Acta Physico-Chimica Sinica, 2024, 40(9): 2308019-0. doi: 10.3866/PKU.WHXB202308019
19. [19]
  Qingtang ZHANG , Xiaoyu WU , Zheng WANG , Xiaomei WANG . Performance of nano Li₂FeSiO₄/C cathode material co-doped by potassium and chlorine ions. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1689-1696. doi: 10.11862/CJIC.20240115
20. [20]
  Hailang JIA , Yujie LU , Pengcheng JI . Preparation and properties of nitrogen and phosphorus co-doped graphene carbon aerogel supported ruthenium electrocatalyst for hydrogen evolution reaction. Chinese Journal of Inorganic Chemistry, 2025, 41(11): 2327-2336. doi: 10.11862/CJIC.20250021

Get Citation

PDF

XML

Metrics

PDF Downloads(17)
Abstract views(4592)
HTML views(769)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142