Citation: SUN Caiying, REN Biaobiao, DONG Tianhe, DAI Qiubo, XIAO Bo. Optimal Activation Temperature of γ-Al₂O₃ for Catalytic Synthesis of Poly(oxy-1, 2-ethanediyl) methylphosphonate[J]. Chinese Journal of Applied Chemistry, ;2020, 37(3): 307-313. doi: 10.11944/j.issn.1000-0518.2020.03.190233 shu

Optimal Activation Temperature of γ-Al₂O₃ for Catalytic Synthesis of Poly(oxy-1, 2-ethanediyl) methylphosphonate

a.
Heilongjiang Key Laboratory of Molecular Design and Preparation of Flame Retarded Materials, College of Chemistry, Chemical Engineering and Resource Utilization/Northeast Forestry University, Harbin 150040, China
b.
School of Landscape Architecture; Northeast Forestry University, Harbin 150040, China
c.
Chifeng Product Quality and Mearurement Inspect Institute, Chifeng, Inner Mongolia 024000, China

Corresponding author: DONG Tianhe, 694130920@qq.com
Received Date: 3 September 2019
Revised Date: 25 November 2019
Accepted Date: 13 December 2019

Fund Project: the Fundamental Research Funds for the Central Universities 2572018BK04Supported by the Fundamental Research Funds for the Central Universities(No.2572018BK04)1

Figures(10)

Poly(oxy-1, 2-ethanediyl) methylphosphonate(PEMP) as a good flame retardant has lots of benefits such as non-toxic, low smoke, high phosphorus content and better flame retardant effects. γ-Al₂O₃ is a good catalyst for the condensation of ethylene glycol (EG) and dimethyl phosphate (DMMP) to produce PEMP. However, since γ-Al₂O₃ is easy to absorb CO₂ and water to reduce its catalytic activity, activation is needed before use. The activation temperature affects the catalytic activity of γ-Al₂O₃. In this paper, γ-Al₂O₃ was activated at different temperatures from 300, 400, 500, 600, 700 and 800℃. γ-Al₂O₃ crystal form was analyzed by X-ray difraction (XRD) and its specific surface area, pore diameter and pore volume were measured by Brunauer-Emmett-Teller (BET) method. The change of infrared absorption was analyzed by Fourier transfer infrared (FTIR). The relative contents of Brønsted acid and Lewis acid sites in γ-Al₂O₃ were determined by pyridine adsorption-FTIR. The purity and viscosity of PEMP catalyzed by γ-Al₂O₃ were compared, and the optimal activation temperature of γ-Al₂O₃ was found to be 400, 500 and 600℃. At this time, γ-Al₂O₃ is a typical γ-Al₂O₃ with large specific surface area and small pore diameter, and the obtained PEMP product has the highest purity.
- poly(oxy-1, 2-ethanediyl)methylphosphonate,
- γ-Al₂O₃,
- activation temperature,
- catalyzed activity
1. [1]
  Xie W, Chen J. Heterogeneous Interesterification of Triacylglycerols Catalyzed by Using Potassium-Doped Alumina as a Solid Catalyst[J]. J Agric Food Chem, 2014,62(43):10414-10421. doi: 10.1021/jf503726a
2. [2]
  Samanta P N, Leszczynski J. High-temperature Thermoelectric Transport Behavior of the Al/γ-Al₂O₃ Interface:Impact of Electron and Phonon Scattering at Nanoscale Metal-Ceramic Contacts[J]. Phys Chem Chem Phys, 2018,20:14513-14524. doi: 10.1039/C8CP01374H
3. [3]
  Shi D, Wang H M, Libor K. WO_x, Supported on γ-Al₂O₃, with Different Morphologies as Model Catalysts for Alkanol Dehydration[J]. J Catal, 2018,363:1-8. doi: 10.1016/j.jcat.2018.04.004
4. [4]
  ZHANG Ye, YU Chunhong, YANG Jinfei. Synthesis of Low-polymeric Organic Phosphonate Flame Retardant[J]. J Nanjing Norm Univ(Eng Technol Ed), 2008(2):56-58. doi: 10.3969/j.issn.1672-1292.2008.02.013
5. [5]
  DING Siyue, YAO Yuewei, FANG Jikun. Synthesis and Application of Reactive Oligomer Organic Phosphonate Flame Retardant[J]. Polyurethane Ind, 2012,27(6):17-20. doi: 10.3969/j.issn.1005-1902.2012.06.005
6. [6]
  CHENG Chao, SUN Caiying. Synthesis of Poly(oxy-1, 2-ethanediyl)methylphosphonate Catalyzed by[Bmim]BF₄/p-TSA[J]. Fine Chem, 2013,30(10):1155-1159, 1176.
7. [7]
  WU Qiang, LU Qianwen, YU Yuanhao. The Catalytic Synthesis and End-capping of Poly(oxy-1, 2-ethanediyl) methylphosphonate[J]. Chem Adhes, 2015(4):278-281.
8. [8]
  LI Bo, SHAO Lingling. Appraisal of Alumina and Aluminium Hydroxide by XRD[J]. Inorg Chem Ind, 2008(2):54-57. doi: 10.3969/j.issn.1006-4990.2008.02.019
9. [9]
  Jasper , Joseph J. The Surface Tension of Pure Liquid Compounds[J]. J Phys Chem Ref Data, 1972,1(4)841. doi: 10.1063/1.3253106
10. [10]
  Mallakpour S, Khadem E. Recent Development in the Synthesis of Polymer Nanocomposites Based on Nano-alumina[J]. Prog Polym Sci, 2015,51:74-93. doi: 10.1016/j.progpolymsci.2015.07.004
11. [11]
  Parry E P. An Infrared Study of Pyridine Adsorbed on Acidic Solids. Characterization of Surface Acidity[J]. J Catal, 1963,2(5):371-379. doi: 10.1016/0021-9517(63)90102-7
12. [12]
  Hughes T R, White H M, White R J. Brønsted and Lewis Acid Site Concentrations in Fluorided Alumina from the Infrared Spectra of Adsorbed Pyridine Species[J]. J Catal, 1969,13(1):58-64. doi: 10.1016/0021-9517(69)90370-4
1. [1]
  Liuyun Chen , Wenju Wang , Tairong Lu , Xuan Luo , Xinling Xie , Kelin Huang , Shanli Qin , Tongming Su , Zuzeng Qin , Hongbing Ji . Soft template-induced deep pore structure of Cu/Al₂O₃ for promoting plasma-catalyzed CO₂ hydrogenation to DME. Acta Physico-Chimica Sinica, 2025, 41(6): 100054-0. doi: 10.1016/j.actphy.2025.100054
2. [2]
  Xiaorui Chen , Xuan Luo , Tongming Su , Xinling Xie , Liuyun Chen , Yuejing Bin , Zuzeng Qin , Hongbing Ji . Ga-doped Cu/γ-Al₂O₃ bifunctional interface sites promote the direct hydrogenation of CO₂ to DME. Acta Physico-Chimica Sinica, 2025, 41(10): 100126-0. doi: 10.1016/j.actphy.2025.100126
3. [3]
  Ziyang Long , Quanzheng Li , Chengliang Zhang , Haifeng Shi . BiVO₄/WO_3-x S-scheme heterojunctions with amplified internal electric field for boosting photothermal-catalytic activity. Acta Physico-Chimica Sinica, 2025, 41(10): 100122-0. doi: 10.1016/j.actphy.2025.100122
4. [4]
  Xueqi Yang , Juntao Zhao , Jiawei Ye , Desen Zhou , Tingmin Di , Jun Zhang . 调节NNU-55(Fe)的d带中心以增强CO₂吸附和光催化活性. Acta Physico-Chimica Sinica, 2025, 41(7): 100074-0. doi: 10.1016/j.actphy.2025.100074
5. [5]
  Shiyi Chen , Jialong Fu , Jianping Qiu , Guoju Chang , Shiyou Hao . Waste medical mask-derived carbon quantum dots enhance the photocatalytic degradation of polyethylene terephthalate (PET) over BiOBr/g-C₃N₄ S-scheme heterojunction. Acta Physico-Chimica Sinica, 2026, 42(1): 100135-0. doi: 10.1016/j.actphy.2025.100135
6. [6]
  Yuanqing Wang , Yusong Pan , Hongwu Zhu , Yanlei Xiang , Rong Han , Run Huang , Chao Du , Chengling Pan . Enhanced Catalytic Activity of Bi₂WO₆ for Organic Pollutants Degradation under the Synergism between Advanced Oxidative Processes and Visible Light Irradiation. Acta Physico-Chimica Sinica, 2024, 40(4): 2304050-0. doi: 10.3866/PKU.WHXB202304050
7. [7]
  Yajin Li , Huimin Liu , Lan Ma , Jiaxiong Liu , Dehua He . Photothermal Synthesis of Glycerol Carbonate via Glycerol Carbonylation with CO₂ over Au/Co₃O₄-ZnO Catalyst. Acta Physico-Chimica Sinica, 2024, 40(9): 2308005-0. doi: 10.3866/PKU.WHXB202308005
8. [8]
  Haotian Zhang , Shengfa Feng , Mufan Cao , Xiong Xiong Liu , Pengcheng Yuan , Yaping Wang , Min Gao , Long Pan , Zhengming Sun . Al₂O₃ coated polyimide porous films enable thin yet strong polymer-in-salt solid-state electrolytes for dendrite-free lithium metal batteries. Chinese Chemical Letters, 2025, 36(8): 111096-. doi: 10.1016/j.cclet.2025.111096
9. [9]
  Jianjun LI , Mingjie REN , Lili ZHANG , Lingling ZENG , Huiling WANG , Xiangwu MENG . UV-assisted degradation of tetracycline hydrochloride by MnFe₂O₄@activated carbon activated persulfate. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1869-1880. doi: 10.11862/CJIC.20240187
10. [10]
  Ran Yu , Chen Hu , Ruili Guo , Ruonan Liu , Lixing Xia , Cenyu Yang , Jianglan Shui . Catalytic Effect of H₃PW₁₂O₄₀ on Hydrogen Storage of MgH₂. Acta Physico-Chimica Sinica, 2025, 41(1): 100001-0. doi: 10.3866/PKU.WHXB202308032
11. [11]
  Yuanyuan Ping , Wangqing Kong . 光催化碳氢键官能团化合成1-苯基-1,2-乙二醇. University Chemistry, 2025, 40(6): 238-247. doi: 10.12461/PKU.DXHX202408092
12. [12]
  Lina Guo , Ruizhe Li , Chuang Sun , Xiaoli Luo , Yiqiu Shi , Hong Yuan , Shuxin Ouyang , Tierui Zhang . Effect of Interlayer Anions in Layered Double Hydroxides on the Photothermocatalytic CO₂ Methanation of Derived Ni-Al₂O₃ Catalysts. Acta Physico-Chimica Sinica, 2025, 41(1): 100002-0. doi: 10.3866/PKU.WHXB202309002
13. [13]
  Mengyang LI , Hao XU , Zhonghao NIU , Chunhua GONG , Weihui ZHONG , Jingli XIE . Highly effective catalytic synthesis of β-amino alcohols by using viologen-polyoxometalate hybrid materials. Chinese Journal of Inorganic Chemistry, 2025, 41(7): 1294-1300. doi: 10.11862/CJIC.20250080
14. [14]
  Yifeng TAN , Ping CAO , Kai MA , Jingtong LI , Yuheng WANG . Synthesis of pentaerythritol tetra(2-ethylthylhexoate) catalyzed by h-MoO₃/SiO₂. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2155-2162. doi: 10.11862/CJIC.20240147
15. [15]
  Linjie ZHU , Xufeng LIU . Synthesis, characterization and electrocatalytic hydrogen evolution of two di-iron complexes containing a phosphine ligand with a pendant amine. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 939-947. doi: 10.11862/CJIC.20240416
16. [16]
  Xinxin YU , Yongxing LIU , Xiaohong YI , Miao CHANG , Fei WANG , Peng WANG , Chongchen WANG . Photocatalytic peroxydisulfate activation for degrading organic pollutants over the zero-valent iron recovered from subway tunnels. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 864-876. doi: 10.11862/CJIC.20240438
17. [17]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
18. [18]
  Yadan Luo , Hao Zheng , Xin Li , Fengmin Li , Hua Tang , Xilin She . Modulating reactive oxygen species in O, S co-doped C₃N₄ to enhance photocatalytic degradation of microplastics. Acta Physico-Chimica Sinica, 2025, 41(6): 100052-0. doi: 10.1016/j.actphy.2025.100052
19. [19]
  Hui Wang , Abdelkader Labidi , Menghan Ren , Feroz Shaik , Chuanyi Wang . Recent Progress of Microstructure-Regulated g-C₃N₄ in Photocatalytic NO Conversion: The Pivotal Roles of Adsorption/Activation Sites. Acta Physico-Chimica Sinica, 2025, 41(5): 100039-0. doi: 10.1016/j.actphy.2024.100039
20. [20]
  Yongxin LIU , Xingchen LI , Hongjia LIU , Danni LI , Tao ZHANG , Xi CHEN . Enhancement effect of Fe₃O₄ conversion to MIL-100(Fe) on activation of persulfate for degradation of antibiotic. Chinese Journal of Inorganic Chemistry, 2025, 41(12): 2503-2513. doi: 10.11862/CJIC.20250169

Get Citation

PDF

XML

Metrics

PDF Downloads(8)
Abstract views(2545)
HTML views(450)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Optimal Activation Temperature of γ-Al2O3 for Catalytic Synthesis of Poly(oxy-1, 2-ethanediyl) methylphosphonate

Metrics

通讯作者: 陈斌, bchen63@163.com

Optimal Activation Temperature of γ-Al₂O₃ for Catalytic Synthesis of Poly(oxy-1, 2-ethanediyl) methylphosphonate