Citation: BIAN Xinchao, FENG Lidong, CHEN Zhiming, CHEN Xuesi. Non-Isothermal Crystallization Behavior of Polylactide[J]. Chinese Journal of Applied Chemistry, ;2016, 33(7): 766-773. doi: 10.11944/j.issn.1000-0518.2016.07.150384 shu

Non-Isothermal Crystallization Behavior of Polylactide

BIAN Xinchao ^a,b ,
FENG Lidong ^a,b,, ,
CHEN Zhiming ^b ,
CHEN Xuesi ^a,b

a.
a. Key Laboratory of Polymer Ecomaterials, Changchun Institute of Applied Chemistry, Chinese Academy of Sciences, Changchun 130022, China;
b.
b. Zhejiang Hisun Biomaterials Limited Corporation, Taizhou, Zhejiang 318000, China

Corresponding author: FENG Lidong,
Received Date: 30 October 2015
Available Online: 15 January 2016
Fund Project:

The non-isothermal crystallization behavior of polylactide(PLA) was investigated by differential scanning calorimetry(DSC), including heating from glass state and cooling from melted state for the PLA polymer. Crystallization kinetic parameters were calculated using Ozawa equation, Mo method, Khanna law and Kissinger method. These methods are all suitable for handling non-isothermal crystallization process of PLA.The crystallization rate coefficient(CRC) proposed by Khanna can easily evaluate the relative crystallization rate of PLA. In contrast to the cooling process from melted state, the heating process of PLA from glass state stimulates crystal nucleus generation, while cooling process is conducive to the growth of crystals. When the heating rate is at 2.0 ℃/min, crystallization enthalpy(ΔH_c) reaches the maximum of 27.1 J/g. When the crystallization starts from the melted state, ΔH_c increases with the decreasing cooling rate. The cooling rate is lowered to 0.25 ℃/min, and ΔH_c is increased to 28.3 J/g. At a lower temperature, the process of crystallization from the glass state, is mainly heterogeneous nucleation of two-dimensional crystal growth pattern. At higher temperature, crystallization from the glass state and melted polymer largely attributes to the homogeneous nucleation for three-dimensional growth pattern. Compared with the heating process, the cooling process is not conducive to the formation of crystal nucleus, so that in the cooling process ΔH_c is much lower, and the diffusion activation energy is a little higher than that in the heating process.
- polylactide,
- non-isothermal crystallization,
- Ozawa equation,
- Khanna method,
- polymeric melted state,
- glass state
1. [1]
  [1] ZHUO Renxi,YIN Chao,WU Yingnan,et al. Synthesis and Degradation Behavior of Poly(DL-lactide) for Ophthalmic Application[J]. Chinese J Appl Chem,1997,14(2):102-104(in Chinese).卓仁禧,尹超,吴颖楠,等. 聚乳酸眼科植入材料的制备及其降解性能[J]. 应用化学,1997,14(2):102-104.
2. [2]
  [2] Eling B,Gogolewski S,Pennings A J. Biodegradable Materials of Poly(L-lactic acid):1.Melt-Spun and Solution-Spun Fibres[J]. Polymer,1982,23(11):1587-1593.
3. [3]
  [3] Pennings J P,Dijkstra H,Pennings A J. Preparation and Properties of Absorbable Fibres from L-lactide Copolymers[J]. Polymer,1993,34(5):942-951.
4. [4]
  [4] LI Xiaohong,YUAN Minglong,HAO Jianyuan,et al. Progress and Prospects on the Academic Research and Industrial Application of Biodegradable Polymers[J]. Polym Bull,2008,52(8):109-122(in Chinese).李孝红,袁明龙,郝建原,等. 生物降解聚合物的研究和产业化进展及展望[J]. 高分子通报,2008,52(8):109-122.
5. [5]
  [5] Garlotta D. A Literature Review of Poly(Lactic Acid)[J]. J Polym Environ,2001,9(2):63-84.
6. [6]
  [6] Tsuji H,Ikada Y. Properties and Morphologies of Poly(L-Lactide):1.Annealing Condition Effects on Properties and Morphologies of Poly(L-Lactide)[J]. Polymer,1995,36(14):2709 2716.
7. [7]
  [7] Hernández-Sáncehz F,Molina-Mateo J,Romero Colomer F J,et al. Influence of Low-Temperature Nucleation on the Crystallization Process of Poly(L-lactide)[J]. Biomacromolecules,2005,6(6):3283-3290.
8. [8]
  [8] REN Jie,YANG Jun,REN Tianbin. Review of the Crystallization Behavior of Biodegradable PLA[J]. Polym Bull,2006,12:51-56(in Chinese).任杰,杨军,任天斌. 生物可降解材料聚乳酸结晶行为研究进展[J]. 高分子通报,2006,12:51-56.
9. [9]
  [9] HE Yong,GAO Zhaofen,XIN Yan,et al. Crystallization Behavior of Poly(L-lactide)[J]. Chem Res Chinese Univ,2006,27(4):745-748(in Chinese). 何勇,高兆芬,辛燕,等. 左旋聚乳酸的结晶行为研究[J]. 高等学校化学学报,2006,27(4):745-748.
10. [10]
  [10] Pluta M,Galeski A. Crystalline and Supermolecular Structure of Poly Lactide in Relation to the Crystallization Method[J]. Appl Polym Sci,2002,86(6):1386-1395.
11. [11]
  [11] Li L B,Zhong Z Y,de Jeu W H,et al. Crystal Structure and Morphology of Poly(L-lactide-b-L-lactide) Diblock Copolymers[J]. Macromolecules,2004,37(23):8641-8646.
12. [12]
  [12] Abe H,Harigaya M,Kikkawa Y,et al. Crystal Growth and Solid-State Structure of Poly(lactide) Stereocopolymers[J]. Biomacromolecules,2005,6(1):457-467.
13. [13]
  [13] Huang J,Melissa S L,Runt J. Crystallization and Microstructure of Poly(L-lactide-co-meso-lactide) Copolymers[J]. Macromolecules,1998,31(8): 2593-2599.
14. [14]
  [14] LI Xungang. Influence of Two Nucleating Agent on Crystallization Properties of Poly(lactic acid)[J]. Polym Addit,2014,3:6-12(in Chinese).李训刚. 两种成核剂对聚乳酸结晶性能的影响[J]. 聚合物与助剂,2014,3:6-12.
15. [15]
  [15] HUANG Weijiang,QIN Shuhao,ZHANG Kai,et al. Research Progress on Improvement of Polylactic Acid Crystallization Behavior by Nucleating Agent[J]. China Plast Ind,2013,41(1):12-17(in Chinese).黄伟江,秦舒浩,张凯,等. 成核剂改善聚乳酸结晶行为的研究进展[J]. 塑料工业,2013,41(1):12-17.
16. [16]
  [16] XU Yang,SUN Zhidan,CHEN Xiaolang,et al. Effect of Crystallization Temperature on Crystal Modifications and Crystallization Morphology of Poly(L-lactic Acid)[J]. J Funct Mater,2012,43(16):2138-2141(in Chinese).徐阳,孙志丹,陈晓浪,等. 结晶温度对左旋聚乳酸的晶体改性和晶体形貌的影响[J]. 功能材料,2012,43(16):2138-2141.
17. [17]
  [17] CHENG Haibo,CHEN Xuesi,XIAO Haihua,et al. Promotion of Crystallization in Linear Polylactide by Multiarm-polylactide[J]. Chinese J Appl Chem,2010,27(7):754-758(in Chinese).程海波,陈学思,肖海华,等. 多臂聚乳酸对线型聚乳酸结晶的促进作用[J]. 应用化学,2010,27(7):754-758.
18. [18]
  [18] CHEN Xiaolang,XU Yang,SUN Zhidan,et al. Effect of Drawing Temperature on Structure and Properties of α'-Phase of Poly(lactic acid)[J]. Acta Chim Sin,2012,70(6):775-782(in Chinese).陈晓浪,徐阳,孙志丹,等. 拉伸温度对α'-型聚乳酸结构与性能的影响[J]. 化学学报,2012,70(6):775-782.
19. [19]
  [19] Nijenhuis A J,Grijpma D W,Pennings A J. Lewis Acid-Catalyzed Polymerization of L-Lactide-Kinetics and Mechanism of the Bulk-Polymerization[J]. Macromolecules,1992,25(24):6419-6424.
20. [20]
  [20] FENG Lidong,GAO Zhantuan,BIAN Xinchao,et al. Isothermal Crystallization Kinetics of Polylactic Acid from Different Initial States[J]. J Funct Polym,2009,22(2):144-147(in Chinese).冯立栋,高战团,边新超,等. 不同初始条件下聚乳酸的等温结晶动力学[J]. 功能高分子学报,2009,22(2):144-147.
21. [21]
  [21] TIAN Yi,QIAN Xin. Nonisothermal Crystallization Kinetics of Poly(Lactide) Plasticized with Poly(ethylene glycol)[J]. Polyester Ind,2007,20(2):15-18(in Chinese).田怡,钱欣. 聚乙二醇增塑聚乳酸的非等温结晶动力学研究[J]. 聚酯工业,2007,20(2):15-18.
22. [22]
  [22] LIU Jieping,MO Zhishen,QI Yuchen,et al. Kinetics of Non-Isothermal Crystallization of PEO/PBHE Blends[J]. Acta Polym Sin,1993,1:1-6(in Chinese).刘结平,莫志深,綦玉臣,等. 聚氧化乙烯(PEO)/聚双酚A羟基醚(PBHE)共混体系的非等温结晶动力学[J]. 高分子学报,1993,1:1-6.
23. [23]
  [23] MO Zhishen. A Method for the Non-Isothermal Crystallization Kinetics of Polymers[J]. Acta Polym Sin,2008,7:656-661(in Chinese).莫志深. 一种研究聚合物非等温结晶动力学的方法[J]. 高分子学报,2008,7:656-661.
1. [1]
  Gengjia Chen , Junjie Ou . Application of the van Deemter Equation in Instrumental Analysis Teaching: A Case of Organic Polymer Monolithic Columns. University Chemistry, 2025, 40(11): 362-368. doi: 10.12461/PKU.DXHX202502003
2. [2]
  Fengmei Wang , Xin Zhang , Hong Yan , Xiangyu Xu , Guirong Wang . Inverted 'Π' Graphic Memory Method for Thermodynamic Basic Equations and the Application in Teaching Practice. University Chemistry, 2025, 40(11): 369-375. doi: 10.12461/PKU.DXHX202412087
3. [3]
  Hanmei Lü , Xin Chen , Qifu Sun , Ning Zhao , Xiangxin Guo . Uniform Garnet Nanoparticle Dispersion in Composite Polymer Electrolytes. Acta Physico-Chimica Sinica, 2024, 40(3): 2305016-0. doi: 10.3866/PKU.WHXB202305016
4. [4]
  Yuxia Luo , Xiaoyu Xie , Fangfang Chen . 药物递送魔法师——分子印迹聚合物. University Chemistry, 2025, 40(8): 202-210. doi: 10.12461/PKU.DXHX202409129
5. [5]
  Zhongxin YU , Wei SONG , Yang LIU , Yuxue DING , Fanhao MENG , Shuju WANG , Lixin YOU . Fluorescence sensing on chlortetracycline of a Zn-coordination polymer based on mixed ligands. Chinese Journal of Inorganic Chemistry, 2024, 40(12): 2415-2421. doi: 10.11862/CJIC.20240304
6. [6]
  Kaimin WANG , Na HE , Shiyi LI , Xuling BAI , Weiqing SUN , Yanqing YE , Yulu MA . Synthesis, Hirshfeld surface analysis and properties of two Zn(Ⅱ)/Ni(Ⅱ) coordination polymers. Chinese Journal of Inorganic Chemistry, 2026, 42(1): 55-64. doi: 10.11862/CJIC.20250178
7. [7]
  Qingjun PAN , Zhongliang GONG , Yuwu ZHONG . Advances in modulation of the excited states of photofunctional iron complexes. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 45-58. doi: 10.11862/CJIC.20240365
8. [8]
  Bao Jia , Yunzhe Ke , Shiyue Sun , Dongxue Yu , Ying Liu , Shuaishuai Ding . Innovative Experimental Teaching for the Preparation and Modification of Conductive Organic Polymer Thin Films in Undergraduate Courses. University Chemistry, 2024, 39(10): 271-282. doi: 10.12461/PKU.DXHX202404121
9. [9]
  Xiao SANG , Qi LIU , Jianping LANG . Synthesis, structure, and fluorescence properties of Zn(Ⅱ) coordination polymers containing tetra-alkenylpyridine ligands. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2124-2132. doi: 10.11862/CJIC.20240158
10. [10]
  Xuefei Leng , Yanshai Wang , Hai Wang , Shengyang Tao . The In-Depth integration of “Industry-University-Research” in the Exploration and Practice of “Comprehensive Training in Polymer Engineering”. University Chemistry, 2025, 40(4): 66-71. doi: 10.12461/PKU.DXHX202405105
11. [11]
  Ruiying WANG , Hui WANG , Fenglan CHAI , Zhinan ZUO , Benlai WU . Three-dimensional homochiral Eu(Ⅲ) coordination polymer and its amino acid configuration recognition. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 877-884. doi: 10.11862/CJIC.20250052
12. [12]
  Ke Qiu , Fengmei Wang , Mochou Liao , Kerun Zhu , Jiawei Chen , Wei Zhang , Yongyao Xia , Xiaoli Dong , Fei Wang . A Fumed SiO₂-based Composite Hydrogel Polymer Electrolyte for Near-Neutral Zinc-Air Batteries. Acta Physico-Chimica Sinica, 2024, 40(3): 2304036-0. doi: 10.3866/PKU.WHXB202304036
13. [13]
  Minghui Wu , Markus Mühlinghaus , Xuechao Li , Chaojie Xu , Qiang Chen , Haiming Zhang , Klaus Müllen , Lifeng Chi . On-Surface Synthesis of Chevron-Shaped Conjugated Ladder Polymers Consisting of Benzo[a]azulene Units. Acta Physico-Chimica Sinica, 2024, 40(8): 2307024-0. doi: 10.3866/PKU.WHXB202307024
14. [14]
  Chunyuan Kang , Xiaoyu Li , Fan Yang , Bai Yang . Ionic-bond crosslinked carbonized polymer dots for tunable and enhanced room temperature phosphorescence. Acta Physico-Chimica Sinica, 2026, 42(1): 100156-0. doi: 10.1016/j.actphy.2025.100156
15. [15]
  Heng Zhang , Ying Ma , Shiling Yuan . Machine Learning-based Prediction of Antifouling Performance in Polymer Materials: An Integrated Molecular Simulation Experiment. University Chemistry, 2026, 41(1): 346-353. doi: 10.12461/PKU.DXHX202506015
16. [16]
  Tianhao GE , Sirong LU , Zhiyin XIAO , Wei ZHONG . Synthesis of porphyrin-based ionic polymeric materials for catalytic application in CO₂ conversion. Chinese Journal of Inorganic Chemistry, 2026, 42(4): 722-736. doi: 10.11862/CJIC.20250312
17. [17]
  Huafeng SHI . Construction of MnCoNi layered double hydroxide@Co-Ni-S amorphous hollow polyhedron composite with excellent electrocatalytic oxygen evolution performance. Chinese Journal of Inorganic Chemistry, 2025, 41(7): 1380-1386. doi: 10.11862/CJIC.20240378
18. [18]
  Shi-Yu Lu , Wenzhao Dou , Jun Zhang , Ling Wang , Chunjie Wu , Huan Yi , Rong Wang , Meng Jin . Amorphous-Crystalline Interfaces Coupling of CrS/CoS₂ Few-Layer Heterojunction with Optimized Crystallinity Boosted for Water-Splitting and Methanol-Assisted Energy-Saving Hydrogen Production. Acta Physico-Chimica Sinica, 2024, 40(8): 2308024-0. doi: 10.3866/PKU.WHXB202308024
19. [19]
  Junjie Zhang , Yue Wang , Qiuhan Wu , Ruquan Shen , Han Liu , Xinhua Duan . Preparation and Selective Separation of Lightweight Magnetic Molecularly Imprinted Polymers for Trace Tetracycline Detection in Milk. University Chemistry, 2024, 39(5): 251-257. doi: 10.3866/PKU.DXHX202311084
20. [20]
  Fanpeng Meng , Fei Zhao , Jingkai Lin , Jinsheng Zhao , Huayang Zhang , Shaobin Wang . Optimizing interfacial electric fields in carbon nitride nanosheet/spherical conjugated polymer S-scheme heterojunction for hydrogen evolution. Acta Physico-Chimica Sinica, 2025, 41(8): 100095-0. doi: 10.1016/j.actphy.2025.100095

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(796)
HTML views(50)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142