Citation: HU Mei-Chen, HUANG Jin-Wen, HUANG Lei-Lei, XIE Da, ZHU Yang-Bin, WANG Lin, WANG Tian-Xing, WU Fan-Hong. Simultaneous Determination of Twelve Kinds of Residual Solvents in A New Drug CBT108 By Headspace Gas Chromatography[J]. Chinese Journal of Analytical Chemistry, ;2018, 46(5): 710-715. doi: 10.11895/j.issn.0253-3820.171064 shu

Simultaneous Determination of Twelve Kinds of Residual Solvents in A New Drug CBT108 By Headspace Gas Chromatography

¹ Department of Pharmaceutical Engineering, School of Chemical and Environmental Engineering, Shanghai Institute of Technology, Shanghai 201418, China;
² Shanghai Ecust Biomedicine Co. Ltd, Shanghai 202231, China;
³ Zhejiang Wild Wind Pharmaceutical Co. Ltd, Shanghai 202231, China

Received Date: 5 July 2017
Revised Date: 27 February 2018

A simple and sensitive method for simultaneous determination of 12 kinds of residual solvents in a new drug CBT108 was established and validated by headspace gas chromatographic technology. The rationality, accuracy and feasibility of the analytical method were verified. Under the optimized conditions, simultaneous separation and determination of 12 kinds of residual solvents, including methanol, ethanol, ether, acetone, acetonitrile, dichloromethane, n-hexane, ethyl acetate, tetrahydrofuran, heptane, toluene and carbon tetrachloride was carried out by using a DB624 capillary column (30 m × 0.53 mm × 3.0 μm) for separation, a flame ionization detector for detection and internal standard method for quantitation. Good linearity was obtained for 12 solvents with the correlation coefficients (R²) of more than 0.997. The limits of quantitation and detection were defined at S/N=3 and S/N=10, respectively. LOQ and LOD for 12 solvents were given as 0.024 μg/mL and 0.0072 μg/mL for methanol, 0.1 μg/mL and 0.012 μg/mL for ethanol, 0.01 μg/mL and 0.005 μg/mL for ether, 0.1 μg/mL and 0.008 μg/mL for acetone, 1.025 μg/mL and 0.0615 μg/mL for acetonitrile, 0.09 μg/mL and 0.06 μg/mL for dichloromethane, 0.09 μg/mL and 0.06 μg/mL for n-hexane, 0.25 μg/mL and 0.008 μg/mL for ethyl acetate, 0.108 μg/mL and 0.014 μg/mL for tetrahydrofuran, 0.16 μg/mL and 0.0004 μg/mL for carbon tetrachloride, 0.0075 μg/mL and 0.005 μg/mL for heptane, and 0.0445 μg/mL and 0.0014 μg/mL for toluene. The adding standards recoveries for 12 residual solvents at three spiked levels were in the range of 90.96%-108.67%, with relative standard deviations of 0.1%-5.7%. This simple, high accuracy and good repeatability method is feasible for rapidly determination of 12 residual solvents in drug candidate CBT108. Meanwhile, this simple method provides a consulted value for detection of residual solvents in other medicines.
- Headspace gas chromatography,
- Residual solvents,
- New drug CBT108,
- Simultaneous determination
1. [1]
2. [2]
3. [3]
4. [4]
5. [5]
6. [6]
7. [7]
8. [8]
9. [9]
10. [10]
11. [11]
12. [12]
13. [13]
14. [14]
15. [15]
16. [16]
17. [17]
18. [18]
19. [19]
20. [20]
21. [21]
22. [22]
23. [23]
1. [1]
  Mi Wen , Baoshuo Jia , Yongqi Chai , Tong Wang , Jianbo Liu , Hailong Wu . Improvement of Fluorescence Quantitative Analysis Experiment: Simultaneous Determination of Rhodamine 6G and Rhodamine 123 in Food Using Chemometrics-Assisted Three-Dimensional Fluorescence Method. University Chemistry, 2025, 40(4): 390-398. doi: 10.12461/PKU.DXHX202405147
2. [2]
  Shunü Peng , Huamin Li , Zhaobin Chen , Yiru Wang . Simultaneous Application of Multiple Quantitative Analysis Methods in Gas Chromatography for the Determination of Active Ingredients in Traditional Chinese Medicine Preparations. University Chemistry, 2025, 40(10): 243-249. doi: 10.12461/PKU.DXHX202412043
3. [3]
  Hui Zhang , Zijian Zhao , Yajing Wang , Kai Ni , Yanfei Wang , Liang Zhu , Jianyun Liu , Xiaoyu Zhao . Structurally engineered solvent-free LiFePO₄ electrodes via hot-pressing with efficient ion transport pathways for lithium extraction from brine. Acta Physico-Chimica Sinica, 2026, 42(2): 100130-0. doi: 10.1016/j.actphy.2025.100130
4. [4]
  Runjie Li , Hang Liu , Xisheng Wang , Wanqun Zhang , Wanqun Hu , Kaiping Yang , Qiang Zhou , Si Liu , Pingping Zhu , Wei Shao . 氨基酸的衍生及手性气相色谱分离创新实验. University Chemistry, 2025, 40(6): 286-295. doi: 10.12461/PKU.DXHX202407059
5. [5]
  Qilong Fang , Yiqi Li , Jiangyihui Sheng , Quan Yuan , Jie Tan . Magical Pesticide Residue Detection Test Strips: Aptamer-based Lateral Flow Test Strips for Organophosphorus Pesticide Detection. University Chemistry, 2024, 39(5): 80-89. doi: 10.3866/PKU.DXHX202310004
6. [6]
  Ke Qiu , Fengmei Wang , Mochou Liao , Kerun Zhu , Jiawei Chen , Wei Zhang , Yongyao Xia , Xiaoli Dong , Fei Wang . A Fumed SiO₂-based Composite Hydrogel Polymer Electrolyte for Near-Neutral Zinc-Air Batteries. Acta Physico-Chimica Sinica, 2024, 40(3): 2304036-0. doi: 10.3866/PKU.WHXB202304036
7. [7]
  Yanhui Zhong , Ran Wang , Zian Lin . Analysis of Halogenated Quinone Compounds in Environmental Water by Dispersive Solid-Phase Extraction with Liquid Chromatography-Triple Quadrupole Mass Spectrometry. University Chemistry, 2024, 39(11): 296-303. doi: 10.12461/PKU.DXHX202402017
8. [8]
  Danqing Wu , Jiajun Liu , Tianyu Li , Dazhen Xu , Zhiwei Miao . Research Progress on the Simultaneous Construction of C—O and C—X Bonds via 1,2-Difunctionalization of Olefins through Radical Pathways. University Chemistry, 2024, 39(11): 146-157. doi: 10.12461/PKU.DXHX202403087
9. [9]
  Chengshan Yuan , Xiaolong Li , Xiuping Yang , Xiangfeng Shao , Zitong Liu , Xiaolei Wang , Yongwen Shen . Standardized Operational Guidelines for Mixed-Solvent Recrystallization in Organic Chemistry Experiment. University Chemistry, 2025, 40(5): 122-127. doi: 10.12461/PKU.DXHX202504073
10. [10]
  Zunxiang Zeng , Yuling Hu , Yufei Hu , Hua Xiao . Analysis of Plant Essential Oils by Supercritical CO₂Extraction with Gas Chromatography-Mass Spectrometry: An Instrumental Analysis Comprehensive Experiment Teaching Reform. University Chemistry, 2024, 39(3): 274-282. doi: 10.3866/PKU.DXHX202309069
11. [11]
  Yifan Xie , Liyun Yao , Ruolin Yang , Yuxing Cai , Yujie Jin , Ning Li . Exploration and Practice of Online and Offline Hybrid Teaching Mode in High-Performance Liquid Chromatography Experiment. University Chemistry, 2025, 40(11): 100-107. doi: 10.12461/PKU.DXHX202412133
12. [12]
  Houzhen Xiao , Mingyu Wang , Yong Liu , Bangsheng Lao , Lingbin Lu , Minghuai Yu . Course Ideological and Political Design of Combustion Heat Measurement Experiment. University Chemistry, 2024, 39(2): 7-13. doi: 10.3866/PKU.DXHX202310011
13. [13]
  Mei Yan , Rida Feng , Yerdos·Tohtarkhan , Biao Long , Li Zhou , Chongshen Guo . Expansion and Extension of Liquid Saturated Vapor Measurement Experiment. University Chemistry, 2024, 39(3): 294-301. doi: 10.3866/PKU.DXHX202308103
14. [14]
  Liuxie Liu , Jing He , Jiali Du , Shuang Mao , Qianggen Li . Extension of Computational Chemical-Assisted Dipole Moment Measurement Experiment. University Chemistry, 2025, 40(3): 363-370. doi: 10.12461/PKU.DXHX202407108
15. [15]
  Shuyong Zhang , Yaxian Zhu , Wenqing Zhang , Yuzhi Wang , Jing Lu . Ideological and Political Design of Combustion Heat Measurement Experiment: Determination of Heat Value of Agricultural and Forestry Wastes. University Chemistry, 2024, 39(2): 1-6. doi: 10.3866/PKU.DXHX202303026
16. [16]
  Nengmin ZHU , Wenhao ZHU , Xiaoyao YIN , Songzhi ZHENG , Hao LI , Zeyuan WANG , Wenhao WEI , Xuanheng CHEN , Weihai SUN . Preparation of high-performance CsPbBr₃ perovskite solar cells by the aqueous solution solvent method. Chinese Journal of Inorganic Chemistry, 2025, 41(6): 1131-1140. doi: 10.11862/CJIC.20240419
17. [17]
  Qiuyang LUO , Xiaoning TANG , Shu XIA , Junnan LIU , Xingfu YANG , Jie LEI . Application of a densely hydrophobic copper metal layer in-situ prepared with organic solvents for protecting zinc anodes. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1243-1253. doi: 10.11862/CJIC.20240110
18. [18]
  Jiandong Liu , Xin Li , Daxiong Wu , Huaping Wang , Junda Huang , Jianmin Ma . Anion-Acceptor Electrolyte Additive Strategy for Optimizing Electrolyte Solvation Characteristics and Electrode Electrolyte Interphases for Li||NCM811 Battery. Acta Physico-Chimica Sinica, 2024, 40(6): 2306039-0. doi: 10.3866/PKU.WHXB202306039
19. [19]
  Zhenhuan Wang , Weifei Wei , Ruijie Ma , Dou Luo , Zhanxiang Chen , Jun Zhang , Liyang Yu , Gang Li , Zhenghui Luo . 苯并[a]苯嗪受体的核心氰基化实现高效(19.04%)绿色溶剂加工的二元有机太阳能电池. Acta Physico-Chimica Sinica, 2026, 42(2): 100182-0. doi: 10.1016/j.actphy.2025.100182
20. [20]
  Chunai Dai , Yongsheng Han , Luting Yan , Zhen Li , Yingze Cao . Ideological and Political Design of Solid-liquid Contact Angle Measurement Experiment. University Chemistry, 2024, 39(2): 28-33. doi: 10.3866/PKU.DXHX202306065

Get Citation

PDF

XML

Metrics

PDF Downloads(14)
Abstract views(652)
HTML views(67)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142