Citation: Qi YUAN, Gao-Bin LIU, Sen WANG. Effect of B₂O₃-Bi₂O₃-ZnO-Al₂O₃ glass additive on sintering condition, crystal structure, and dielectric properties of BaTiO₃ ceramics[J]. Chinese Journal of Inorganic Chemistry, ;2023, 39(3): 485-491. doi: 10.11862/CJIC.2023.014 shu

Effect of B₂O₃-Bi₂O₃-ZnO-Al₂O₃ glass additive on sintering condition, crystal structure, and dielectric properties of BaTiO₃ ceramics

School of Materials and Metallurgy Engineering, University of Science and Technology Liaoning, Anshan, Liaoning 114051, China

Corresponding author: Sen WANG, wsenl@yeah.net
Received Date: 23 September 2022
Revised Date: 12 December 2022

Figures(8)

The effects of B₂O₃-Bi₂O₃-ZnO-Al₂O₃ (BBZA) glass on the sintering conditions, crystal structure, and dielectric properties of barium titanate (BaTiO ₃) ceramics were investigated. The results show that the addition of the appropriate amount of BBZA glass powder can effectively reduce the sintering temperature of BaTiO₃ ceramics from 1 350 to 950 ℃ and make it densified. Consequently, the structure of BaTiO₃ phase changed (cubic phase → tetragonal phase) with the increase of sintering temperature after adding BBZA glass. Additionally, the Curie peak of BaTiO₃ ceramics were effectively suppressed and broadened. The ceramic microstructure showed that the glass phase was uniformly distributed on the surface of BaTiO₃ grains. The optimized preparing conditions for the BaTiO₃ ceramics were as follows: the addition (mass fraction) of BBZA glass was 2.0% and the sintering temperature was 950 ℃. The BaTiO₃ ceramics prepared under these conditions had a dielectric constant of 1 364 and a dielectric loss as low as 1.2%. When the sintering temperature was higher than 950℃, the addition amount of BBZA glass should not be greater than 2.0%, too much BBZA glass will lead to the semiconducting of BaTiO₃.
- BaTiO₃,
- B₂O₃-Bi₂O₃-ZnO-Al₂O₃ glass,
- low-temperature sintering
1. [1]
  Gotor F J, Perez-Maqueda L A, Criado J M. Synthesis of BaTiO₃ by applying the sample controlled reaction temperature (SCRT) method to the thermal decomposition of barium titanyl oxalate[J]. J. Eur. Ceram. Soc., 2003,23(3):505-513. doi: 10.1016/S0955-2219(02)00099-7
2. [2]
  ZHOU Z. Study on preparation and doping modification of barium titanate based ceramics. Guangzhou: Guangdong University of Technology, 2014: 3-11
3. [3]
  Shaifudin M S, Ghazali M S M, Abdullah W R W, Lkhmal W M, Kassim S. Microstructure and electrical properties of low-voltage barium titanate doped zinc oxide varistor ceramics[J]. International Journal of Recent Technology and Engineering, 2019,8:2713-2718.
4. [4]
  Glitzky C, Rabe T, Eberstein M, Schiller W A, Töpfer J, Barth S, Kipka A. LTCC-modules with integrated ferrite layers—Strategies for material development and Co-sintering[J]. J. Microelectron. Electron. Packag., 2009,6(1):49-53. doi: 10.4071/1551-4897-6.1.49
5. [5]
  Valant M, Suvorov D, Pullar R C, Sarma K, Alford N M. A mechanism for low-temperature sintering[J]. J. Eur. Ceram. Soc., 2006,26(13):2777-2783. doi: 10.1016/j.jeurceramsoc.2005.06.026
6. [6]
  Naghib-zadeh H, Glitzky C, Dörfel I, Rabe T. Low temperature sintering of barium titanate ceramics assisted by addition of lithium fluoridecontaining sintering additives[J]. J. Eur. Ceram. Soc., 2010,30(1):81-86. doi: 10.1016/j.jeurceramsoc.2009.07.005
7. [7]
  Hsiang H I, Hsi C S, Huang C C, Fu S L. Sintering behavior and dielectric properties of BaTiO₃ ceramics with glass addition for internal capacitor of LTCC[J]. J. Alloy. Compd., 2008,459(1/2):307-310.
8. [8]
  Jeon H P, Lee S K, Kim S W, Choi D K. Effects of BaO-B₂O₃-SiO₂ glass additive on densification and dielectric properties of BaTiO₃ ceramics[J]. Mater. Chem. Phys., 2005,94(2/3):185-189.
9. [9]
  Tian Y S, Gong Y S, Zhang Z L, Meng D W. Phase evolutions and electric properties of BaTiO₃ ceramics by a low-temperature sintering process[J]. J. Mater. Sci.-Mater. Electron., 2014,25(12):5467-5474. doi: 10.1007/s10854-014-2330-3
10. [10]
  Wang S, He H, Su H. Effect of Bi₂O₃ doping on the dielectric properties of medium-temperature sintering BaTiO₃-based X8R ceramics[J]. J. Mater. Sci.-Mater. Electron., 2013,24(7):2385-2389. doi: 10.1007/s10854-013-1106-5
11. [11]
  Sun C K, Wang X H, Ma C, Li L T. Low-temperature sintering barium titanate-based X8R ceramics with Nd₂O₃ dopant and ZnO-B₂O₃ flux agent[J]. J. Am. Ceram. Soc., 2009,92(7):1613-1616. doi: 10.1111/j.1551-2916.2009.03066.x
12. [12]
  Fisher J G, Lee B K, Choi S Y, Wang S M, Kang S J L. Inhibition of abnormal grain growth in BaTiO₃ by addition of Al₂O₃[J]. J. Eur. Ceram. Soc., 2006,26(9):1619-1628. doi: 10.1016/j.jeurceramsoc.2005.03.234
13. [13]
  Chen Y, Ye H H, Wang X S, Li Y X, Yao X. Grain size effects on the electric and mechanical properties of submicro BaTiO₃ ceramics[J]. J. Eur. Ceram. Soc., 2020,40(2):391-400. doi: 10.1016/j.jeurceramsoc.2019.09.033
14. [14]
  Buscaglia V, Buscaglia M T, Canu G. BaTiO₃-based ceramics: Fundamentals, properties and applications//Encyclopedia of materials: Technical ceramics and glasses: Vol. 3. Elsevier, 2021: 311-344
15. [15]
  Nièpce J C, Pizzagalli L. Structure and phase transitions in nanocrystals//Bréchignac C, Houdy P, Lahmani M. Nanomaterials and nanochemistry. Berlin, Heidelberg: Springer, 2008: 35-54
16. [16]
  Wang H X, Zhao P Y, Chen L L, Li L T, Wang X H. Energy storage properties of 0.87BaTiO₃-0.13Bi(Zn_2/3(Nb_0.85Ta_0.15)_1/3)O₃ multilayer ceramic capacitors with thin dielectric layers[J]. J. Adv. Ceram., 2020,9(3):292-302.
17. [17]
  Wei M, Zhang J H, Wu K T, Chen H W, Yang C R. Effect of BiMO₃ (M=Al, In, Y, Sm, Nd, and La) doping on the dielectric properties of BaTiO₃ ceramics[J]. Ceram. Int., 2017,43(13):9593-9599. doi: 10.1016/j.ceramint.2017.03.139
18. [18]
  Gao W L, Deng H M, Huang D J, Yang P X, Chu J H. Microstructure and optical properties of Zn-doped BaTiO₃ thin films[J]. J. Phys.: Conf. Ser., 2011,276(1)012163.
19. [19]
  Wang J, Huang Y F, Guo W L, Xing Z G, Wang H D, Lu Z L, Zhang Z N. First-principles calculations of electronic and optical properties of A and B site substituted BaTiO₃[J]. Vacuum, 2021,193110530. doi: 10.1016/j.vacuum.2021.110530
20. [20]
  Niu X, Jian X D, Chen X Y, Li H X, Liang W, Yao Y B, Tao T, Liang B, Lu S G. Enhanced electrocaloric effect at room temperature in Mn²⁺ doped lead-free (BaSr)TiO₃ ceramics via a direct measurement[J]. J. Adv. Ceram., 2021,10(3):482-492. doi: 10.1007/s40145-020-0450-1
21. [21]
  Feteira A, Sarma K, Alford N M N, Reaney I M, Sinclair D C. Microwave dielectric properties of gallium-doped hexagonal barium titanate ceramics[J]. J. Am. Ceram. Soc., 2003,86(3):511-513. doi: 10.1111/j.1151-2916.2003.tb03330.x
22. [22]
  Zhuo Q Z, Xiao P Z. Reduction of Ti⁴⁺ to Ti³⁺ in boron-doped BaTiO₃ at very low temperature[J]. J. Am. Ceram. Soc., 2013,96(11):3504-3510. doi: 10.1111/jace.12512
23. [23]
  Buscaglia V, Buscaglia M T, Viviani M, Mitoseriu L, Nanni P, Trefiletti V, Piaggio P, Gregora I, Ostapchuk T, Pokorný J, Petzelt J. Grain size and grain boundary-related effects on the properties of nanocrystalline barium titanate ceramics[J]. J. Eur. Ceram. Soc., 2006,26(14):2889-2898. doi: 10.1016/j.jeurceramsoc.2006.02.005
24. [24]
  El-Shaarawy M G, Rashad M M, Shash N M, Maklad M H, Afifi A F. Structural, AC conductivity, dielectric behavior and magnetic properties of Mg-substituted LiFe₅O₈ powders synthesized by sol-gel autocombustion method[J]. J. Mater. Sci.-Mater. Electron., 2015,26(8):6040-6050. doi: 10.1007/s10854-015-3181-2
25. [25]
  Chiang C C, Wang S F, Wang Y R, Wei W C J. Densification and microwave dielectric properties of CaO-B₂O₃-SiO₂ system glassceramics[J]. Ceram. Int., 2008,34(3):599-604. doi: 10.1016/j.ceramint.2006.12.008
26. [26]
  Wang F, Lou Y H, Li Z J, Lei W, Lu Y, Dong Z W, Lu W Z. Improved flexural strength and dielectric loss in Al₂O ₃-based LTCC with La₂O ₃-CaO-B₂O₃-SiO₂ glass[J]. Ceram. Int., 2021,47(7):9955-9960. doi: 10.1016/j.ceramint.2020.12.140
27. [27]
  Cai W, Fu C L, Chen G, Gao R L, Deng X L. Dielectric and ferroelectric properties of xBaZr_0.52Ti_0.48O₃-(1-x)BiFeO₃ solid solution ceramics[J]. J. Mater. Sci.-Mater. Electron., 2015,26(1):322-330. doi: 10.1007/s10854-014-2403-3
28. [28]
  Arshad M, Du H, Javed M S, Maqsood A, Ashraf I, Hussain S, Ma W, Ran H. Fabrication, structure, and frequency-dependent electrical and dielectric properties of Sr-doped BaTiO₃ ceramics[J]. Ceram. Int., 2020,46(2):2238-2246. doi: 10.1016/j.ceramint.2019.09.208
1. [1]
  Zhiwen HU , Weixia DONG , Qifu BAO , Ping LI . Low-temperature synthesis of tetragonal BaTiO₃ for piezocatalysis. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 857-866. doi: 10.11862/CJIC.20230462
2. [2]
  Zhiwen HU , Ping LI , Yulong YANG , Weixia DONG , Qifu BAO . Morphology effects on the piezocatalytic performance of BaTiO₃. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 339-348. doi: 10.11862/CJIC.20240172
3. [3]
  Juan WANG , Zhongqiu WANG , Qin SHANG , Guohong WANG , Jinmao LI . NiS and Pt as dual co-catalysts for the enhanced photocatalytic H₂ production activity of BaTiO₃ nanofibers. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1719-1730. doi: 10.11862/CJIC.20240102
4. [4]
  Teng Wang , Jiachun Cao , Juan Li , Didi Li , Zhimin Ao . A novel photocatalytic mechanism of volatile organic compounds degradation on BaTiO₃ under visible light: Photo-electrons transfer from photocatalyst to pollutant. Chinese Chemical Letters, 2025, 36(3): 110078-. doi: 10.1016/j.cclet.2024.110078
5. [5]
  Jijoe Samuel Prabagar , Kumbam Lingeshwar Reddy , Dong-Kwon Lim . Visible-light responsive gold nanoparticle and nano-sized Bi2O3-x sheet heterozygote structure for efficient photocatalytic conversion of N2 to NH3. Chinese Journal of Structural Chemistry, 2025, 44(4): 100564-100564. doi: 10.1016/j.cjsc.2025.100564
6. [6]
  Juan Guo , Mingyuan Fang , Qingsong Liu , Xiao Ren , Yongqiang Qiao , Mingju Chao , Erjun Liang , Qilong Gao . Zero thermal expansion in Cs₂W₃O₁₀. Chinese Chemical Letters, 2024, 35(7): 108957-. doi: 10.1016/j.cclet.2023.108957
7. [7]
  Liuyun Chen , Wenju Wang , Tairong Lu , Xuan Luo , Xinling Xie , Kelin Huang , Shanli Qin , Tongming Su , Zuzeng Qin , Hongbing Ji . 软模板法诱导Cu/Al₂O₃深孔道结构促进等离子催化CO₂加氢制二甲醚. Acta Physico-Chimica Sinica, 2025, 41(6): 100054-. doi: 10.1016/j.actphy.2025.100054
8. [8]
  Guangchang Yang , Shenglong Yang , Jinlian Yu , Yishun Xie , Chunlei Tan , Feiyan Lai , Qianqian Jin , Hongqiang Wang , Xiaohui Zhang . Regulating local chemical environment in O3-type layered sodium oxides by dual-site Mg²⁺/B³⁺ substitution achieves durable and high-rate cathode. Chinese Chemical Letters, 2024, 35(9): 109722-. doi: 10.1016/j.cclet.2024.109722
9. [9]
  Renshu Huang , Jinli Chen , Xingfa Chen , Tianqi Yu , Huyi Yu , Kaien Li , Bin Li , Shibin Yin . Synergized oxygen vacancies with Mn2O3@CeO2 heterojunction as high current density catalysts for Li–O2 batteries. Chinese Journal of Structural Chemistry, 2023, 42(11): 100171-100171. doi: 10.1016/j.cjsc.2023.100171
10. [10]
  Guanyang Zeng , Xingqiang Liu , Liangqiao Wu , Zijie Meng , Debin Zeng , Changlin Yu . Novel visible-light-driven I- doped Bi2O2CO3 nano-sheets fabricated via an ion exchange route for dye and phenol removal. Chinese Journal of Structural Chemistry, 2024, 43(12): 100462-100462. doi: 10.1016/j.cjsc.2024.100462
11. [11]
  Xiuzheng Deng , Yi Ke , Jiawen Ding , Yingtang Zhou , Hui Huang , Qian Liang , Zhenhui Kang . Construction of ZnO@CDs@Co₃O₄ sandwich heterostructure with multi-interfacial electron-transfer toward enhanced photocatalytic CO₂ reduction. Chinese Chemical Letters, 2024, 35(4): 109064-. doi: 10.1016/j.cclet.2023.109064
12. [12]
  Yang Xia , Kangyan Zhang , Heng Yang , Lijuan Shi , Qun Yi . 构建双通道路径增强iCOF/Bi₂O₃ S型异质结在纯水体系中光催化合成H₂O₂性能. Acta Physico-Chimica Sinica, 2024, 40(11): 2407012-. doi: 10.3866/PKU.WHXB202407012
13. [13]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
14. [14]
  Haojie Duan , Hejingying Niu , Lina Gan , Xiaodi Duan , Shuo Shi , Li Li . Reinterpret the heterogeneous reaction of α-Fe₂O₃ and NO₂ with 2D-COS: The role of SDS, UV and SO₂. Chinese Chemical Letters, 2024, 35(6): 109038-. doi: 10.1016/j.cclet.2023.109038
15. [15]
  Cailiang Yue , Nan Sun , Yixing Qiu , Linlin Zhu , Zhiling Du , Fuqiang Liu . A direct Z-scheme 0D α-Fe₂O₃/TiO₂ heterojunction for enhanced photo-Fenton activity with low H₂O₂ consumption. Chinese Chemical Letters, 2024, 35(12): 109698-. doi: 10.1016/j.cclet.2024.109698
16. [16]
  Hongyi LI , Aimin WU , Liuyang ZHAO , Xinpeng LIU , Fengqin CHEN , Aikui LI , Hao HUANG . Effect of Y(PO₃)₃ double-coating modification on the electrochemical properties of Li[Ni_0.8Co_0.15Al_0.05]O₂. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1320-1328. doi: 10.11862/CJIC.20230480
17. [17]
  Fei ZHOU , Xiaolin JIA . Co₃O₄/TiO₂ composite photocatalyst: Preparation and synergistic degradation performance of toluene. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2232-2240. doi: 10.11862/CJIC.20240236
18. [18]
  Ran Yu , Chen Hu , Ruili Guo , Ruonan Liu , Lixing Xia , Cenyu Yang , Jianglan Shui . 杂多酸H₃PW₁₂O₄₀高效催化MgH₂储氢. Acta Physico-Chimica Sinica, 2025, 41(1): 2308032-. doi: 10.3866/PKU.WHXB202308032
19. [19]
  Honglin Gao , Chunlin Yuan , Hongyu Chen , Aiyi Dong , Pan Gao , Guangjin Hou . Surface gallium hydride on Ga2O3 polymorphs: A comparative solid-state NMR study. Chinese Journal of Structural Chemistry, 2025, 44(4): 100561-100561. doi: 10.1016/j.cjsc.2025.100561
20. [20]
  Dong-Xue Jiao , Hui-Li Zhang , Chao He , Si-Yu Chen , Ke Wang , Xiao-Han Zhang , Li Wei , Qi Wei . Layered (C5H6ON)2[Sb2O(C2O4)3] with a large birefringence derived from the uniform arrangement of π-conjugated units. Chinese Journal of Structural Chemistry, 2024, 43(6): 100304-100304. doi: 10.1016/j.cjsc.2024.100304

Get Citation

PDF

XML

Metrics

PDF Downloads(9)
Abstract views(936)
HTML views(181)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Effect of B2O3-Bi2O3-ZnO-Al2O3 glass additive on sintering condition, crystal structure, and dielectric properties of BaTiO3 ceramics

Metrics

通讯作者: 陈斌, bchen63@163.com

Effect of B₂O₃-Bi₂O₃-ZnO-Al₂O₃ glass additive on sintering condition, crystal structure, and dielectric properties of BaTiO₃ ceramics