Citation: Pei-Song LIU, Li-Jun SONG, Chao-Lian HUANG, Lei HU, Xiao-Ying LU, Qi JIANG. Effects of manganese sources on the high temperature performance of spinel LiMn₂O₄[J]. Chinese Journal of Inorganic Chemistry, ;2023, 39(1): 55-62. doi: 10.11862/CJIC.2022.258 shu

Effects of manganese sources on the high temperature performance of spinel LiMn₂O₄

Pei-Song LIU ^{1, 2} ,
Li-Jun SONG ^{1, 3} ,
Chao-Lian HUANG ¹ ,
Lei HU ¹ ,
Xiao-Ying LU ^1,, ,
Qi JIANG ^1,,

1.
Key Laboratory of Advanced Technologies of Materials (Ministry of Education of China), Superconductivity and New Energy R&D Centre, Southwest Jiaotong University, Chengdu 610031, China
2.
Anhui Nandu Huatuo New Energy Technology Co., Ltd., Fuyang, Anhui 236000, China
3.
Suzhou Nuclear Power Research Institute, Suzhou, Jiangsu 215004, China

Corresponding author: Xiao-Ying LU, luxy2005@swjtu.cn Qi JIANG, jiangqi66@163.com
Received Date: 9 June 2022
Revised Date: 18 October 2022

Figures(5)

To research the effect of different manganese sources on the prepared spinel LiMn₂O₄ (LMO), the precursors of the manganese sources were prepared by the precipitation method. And then, the most commonly used manganese oxides (MnO₂, Mn₂O₃, and Mn₃O₄) were prepared by different calcination temperatures. The LMO cathode materials were prepared with manganese oxides under the same preparation conditions. And the relationship between manganese sources and the electrochemical performance of the obtained cathode materials was investigated by examining the morphology and electrochemical properties of LMO. The research result showed that different manganese oxides with different morphological structures can be obtained from the same precursor at different calcination temperatures. The morphology structures of LMOs and the contents and sizes of octahedral crystals were different. LMO prepared from Mn₂O₃ had the most octahedral crystals and the most uniform size. It also had the best capacity performance, rate performance, and cycle performance among the three LMOs: the first discharge-specific capacity was 131.8 mAh·g^-1 (0.2C); the discharge-specific capacity of 100.4 mAh·g^-1 at 3C; after 100 cycles at 0.5C (half-cell), the discharge specific capacity was still 116.0 mAh·g^-1, and the capacity retention rate was 93.9%, which is far superior to the other two LMOs, indicating a good application prospect. Even at a high temperature of 55 ℃, LMO from Mn₂O₃ exhibited significantly higher rate performance and stronger anti-attenuation ability than the other two LMOs.
- spinel LiMn₂O₄,
- manganese oxide,
- electrochemical energy storage performance,
- high temperature performance
1. [1]
  Croguennec L, Palacin M R. Recent achievements on inorganic electrode materials for lithium-ion batteries[J]. J. Am. Chem. Soc., 2015,137(9):3140-3156. doi: 10.1021/ja507828x
2. [2]
  Luo J Y, Wang Y G, Xiong H M, Xia Y Y. Ordered mesoporous spinel LiMn₂O₄ by a soft-chemical process as a cathode material for lithiumion batteries[J]. Chem. Mater., 2007,19(19):4791-4795. doi: 10.1021/cm0714180
3. [3]
  Jiang C H, Tang Z L, Deng S Q, Hong Y, Wang S T, Zhang Z T. High-performance carbon-coated mesoporous LiMn₂O₄ cathode materials synthesized from a novel hydrated layered-spinel lithium manganate composite[J]. RSC Adv., 2017,7(7):3746-3751. doi: 10.1039/C6RA25802F
4. [4]
  Amatucci G, Tarascon J M. Optimization of insertion compounds such as LiMn₂O₄ for Li-ion batteries[J]. J. Electrochem. Soc., 2002,149(12):K31-K46. doi: 10.1149/1.1516778
5. [5]
  Amatucci G G, Schmutz C N, Blyr A, Sigala C, Gozdz A S, Larcher D, Tarascon J M. Materials' effects on the elevated and room temperature performance of C/LiMn₂O₄ Li-ion batteries[J]. J. Power Sources, 1997,69(1):11-25.
6. [6]
  Yamada A, Tanaka M, Tanaka K, Sekai K. Jahn-Teller instability in spinel Li-Mn-O[J]. J. Power Sources, 1999,81:73-78.
7. [7]
  Xia Y, Zhou Y, Yoshio M. Capacity fading on cycling of 4V Li/LiMn₂O₄ cells[J]. J. Electrochem. Soc., 1997,144(8):2593-2600. doi: 10.1149/1.1837870
8. [8]
  Fang H S, Li L P, Yang Y, Yan G F, Li G S. Low-temperature synthesis of highly crystallized LiMn₂O₄ from alpha manganese dioxide nanorods[J]. J. Power Sources, 2008,184(2):494-497. doi: 10.1016/j.jpowsour.2008.04.011
9. [9]
  Hai Y, Zhang Z W, Liu H, Liao L B, Fan P, Wu Y Y, L v, G C, Mei L F. Facile controlled synthesis of spine LiMn₂O₄ porous microspheres as cathode material for lithium ion batteries[J]. Front. Chem., 2019,7437. doi: 10.3389/fchem.2019.00437
10. [10]
  Zhang X, Xing Z, Yu Y, Li Q W, Tang K B, Huang T, Zhu Y C, Qian Y T, Chen D. Synthesis of Mn₃O₄ nanowires and their transformation to LiMn₂O₄ polyhedrons, application of LiMn₂O₄ as a cathode in a lithium-ion battery[J]. CrystEngComm, 2012,14(4):1485-1489. doi: 10.1039/C1CE06289A
11. [11]
  Gao Y K, Peng J Q, Duan Z H, Hu A L, Lu X Y, Jiang Q. Preparation of spheroidal spinel LiMn₂O₄ and its high temperature performance[J]. J. Electrochem. Soc., 2019,166(13):A2903-A2909. doi: 10.1149/2.0731913jes
12. [12]
  Huang C L, Zhang R B, Gao Y K, Lu X Y, Jiang Q, Zhang H, Li Z C. Effects of lithium salt addition methods on the high-temperature electrochemical performance of LiMn₂O₄[J]. J. Electrochem. Soc., 2021,168(9)090509. doi: 10.1149/1945-7111/ac208f
13. [13]
  Li W, Siqin G W, Zhu Z, Qi L, Tian W H. Electrochemical properties of niobium and phosphate doped spherical Li-rich spinel LiMn₂O₄ synthesized by ion implantation method[J]. Chinese Chem. Lett., 2017,28(7):1438-1446. doi: 10.1016/j.cclet.2017.03.035
14. [14]
  Li X F, Xu Y L. Spinel LiMn₂O₄ active material with high capacity retention[J]. Appl. Surf. Sci., 2007,253(21):8592-8596. doi: 10.1016/j.apsusc.2007.04.070
15. [15]
  Ding Y L, Xie J A, Cao G S, Zhu T J, Yu H M, Zhao X B. Singlecrystalline LiMn₂O₄ nanotubes synthesized via template-engaged reaction as cathodes for high-power lithium ion batteries[J]. Adv. Funct. Mater., 2011,21(2):348-355. doi: 10.1002/adfm.201001448
16. [16]
  Lee J F, Tsai Y W, Santhanam R, Hwang B J, Yang M H, Liu D G. Local structure transformation of nano-sized Al-doped LiMn₂O₄ sintered at different temperatures[J]. J. Power Sources, 2003,119:721-726.
17. [17]
  Bakierska M, Swietoslawski M, Dziembaj R, Molenda M. Nature of the electrochemical properties of sulphur substituted LiMn₂O₄ spinel cathode material studied by electrochemical impedance spectroscopy[J]. Materials, 2016,9(8):2-12.
18. [18]
  Koao L F, Motloung S V, Motaung T E, Kebede M A. Influence of ammonium hydroxide solution on LiMn₂O₄ nanostructures prepared by modified chemical bath method[J]. Physica B, 2018,535:323-329. doi: 10.1016/j.physb.2017.08.016
19. [19]
  Guo J C, Xu Y H, Wang C S. Sulfur-impregnated disordered carbon nanotubes cathode for lithium-sulfur batteries[J]. Nano Lett., 2011,11(10):4288-4294. doi: 10.1021/nl202297p
20. [20]
  Zhang S S, Xu K, Jow T R. Understanding formation of solid electrolyte interface film on LiMn₂O₄ electrode[J]. J. Electrochem. Soc., 2002,149(12):A1521-A1526. doi: 10.1149/1.1516220
21. [21]
  He Y B, Liu M, Huang Z D, Zhang B, Yu Y, Li B H, Kang F Y, Kim J K. Effect of solid electrolyte interface (SEI) film on cyclic performance of Li₄Ti₅O₁₂ anodes for Li ion batteries[J]. J. Power Sources, 2013,239:269-276. doi: 10.1016/j.jpowsour.2013.03.141
22. [22]
  Zhan C, Wu T P, Lu J, Amine K. Dissolution, migration, and deposition of transition metal ions in Li-ion batteries exemplified by Mn-based cathodes—A critical review[J]. Energ. Environ. Sci., 2018,11(2):243-257. doi: 10.1039/C7EE03122J
23. [23]
  Jiang C H, Tang Z L, Wang S T, Zhang Z T. A truncated octahedral spinel LiMn₂O₄ as high-performance cathode material for ultrafast and long-life lithium-ion batteries[J]. J. Power Sources, 2017,357:144-148. doi: 10.1016/j.jpowsour.2017.04.079
24. [24]
  Zhao H Y, Li D D, Wang Y S, Li F, Wang G F, Wu T T, Wang Z K, Li Y F, Su J X. Sol-Gel synthesis of silicon-doped lithium manganese oxide with enhanced reversible capacity and cycling stability[J]. Materials, 2018,11(8)1455. doi: 10.3390/ma11081455
25. [25]
  Jiang Q, Gao Y K, Peng J Q, Li H, Liu Q Q, Jiang L, Lu X Y, Hu A L. Effects of polyvinyl alcohol on the electrochemical performance of LiNi_0.8Co_0.15Al_0.05O₂ cathode material[J]. J. Solid State Electrochem., 2018,22(12):3807-3813. doi: 10.1007/s10008-018-4085-x
1. [1]
  Qin ZHU , Jiao MA , Zhihui QIAN , Yuxu LUO , Yujiao GUO , Mingwu XIANG , Xiaofang LIU , Ping NING , Junming GUO . Morphological evolution and electrochemical properties of cathode material LiAl_0.08Mn_1.92O₄ single crystal particles. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1549-1562. doi: 10.11862/CJIC.20240022
2. [2]
  Chuanming GUO , Kaiyang ZHANG , Yun WU , Rui YAO , Qiang ZHAO , Jinping LI , Guang LIU . Performance of MnO₂-0.39IrO_x composite oxides for water oxidation reaction in acidic media. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1135-1142. doi: 10.11862/CJIC.20230459
3. [3]
  Qianwen Han , Tenglong Zhu , Qiuqiu Lü , Mahong Yu , Qin Zhong . 氢电极支撑可逆固体氧化物电池性能及电化学不对称性优化. Acta Physico-Chimica Sinica, 2025, 41(1): 2309037-. doi: 10.3866/PKU.WHXB202309037
4. [4]
  Xueyu Lin , Ruiqi Wang , Wujie Dong , Fuqiang Huang . 高性能双金属氧化物负极的理性设计及储锂特性. Acta Physico-Chimica Sinica, 2025, 41(3): 2311005-. doi: 10.3866/PKU.WHXB202311005
5. [5]
  Ping ZHANG , Chenchen ZHAO , Xiaoyun CUI , Bing XIE , Yihan LIU , Haiyu LIN , Jiale ZHANG , Yu'nan CHEN . Preparation and adsorption-photocatalytic performance of ZnAl@layered double oxides. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1965-1974. doi: 10.11862/CJIC.20240014
6. [6]
  Yaping ZHANG , Tongchen WU , Yun ZHENG , Bizhou LIN . Z-scheme heterojunction β-Bi₂O₃ pillared CoAl layered double hydroxide nanohybrid: Fabrication and photocatalytic degradation property. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 531-539. doi: 10.11862/CJIC.20240256
7. [7]
  Xin Han , Zhihao Cheng , Jinfeng Zhang , Jie Liu , Cheng Zhong , Wenbin Hu . Design of Amorphous High-Entropy FeCoCrMnBS (Oxy) Hydroxides for Boosting Oxygen Evolution Reaction. Acta Physico-Chimica Sinica, 2025, 41(4): 100033-. doi: 10.3866/PKU.WHXB202404023
8. [8]
  Yuanchao LI , Weifeng HUANG , Pengchao LIANG , Zifang ZHAO , Baoyan XING , Dongliang YAN , Li YANG , Songlin WANG . Effect of heterogeneous dual carbon sources on electrochemical properties of LiMn_0.8Fe_0.2PO₄/C composites. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 751-760. doi: 10.11862/CJIC.20230252
9. [9]
  Zhihuan XU , Qing KANG , Yuzhen LONG , Qian YUAN , Cidong LIU , Xin LI , Genghuai TANG , Yuqing LIAO . Effect of graphene oxide concentration on the electrochemical properties of reduced graphene oxide/ZnS. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1329-1336. doi: 10.11862/CJIC.20230447
10. [10]
  Qingtang ZHANG , Xiaoyu WU , Zheng WANG , Xiaomei WANG . Performance of nano Li₂FeSiO₄/C cathode material co-doped by potassium and chlorine ions. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1689-1696. doi: 10.11862/CJIC.20240115
11. [11]
  Jiahong ZHENG , Jiajun SHEN , Xin BAI . Preparation and electrochemical properties of nickel foam loaded NiMoO₄/NiMoS₄ composites. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 581-590. doi: 10.11862/CJIC.20230253
12. [12]
  Xinpeng LIU , Liuyang ZHAO , Hongyi LI , Yatu CHEN , Aimin WU , Aikui LI , Hao HUANG . Ga₂O₃ coated modification and electrochemical performance of Li_1.2Mn_0.54Ni_0.13Co_0.13O₂ cathode material. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1105-1113. doi: 10.11862/CJIC.20230488
13. [13]
  Xiaofeng Zhu , Bingbing Xiao , Jiaxin Su , Shuai Wang , Qingran Zhang , Jun Wang . Transition Metal Oxides/Chalcogenides for Electrochemical Oxygen Reduction into Hydrogen Peroxides. Acta Physico-Chimica Sinica, 2024, 40(12): 2407005-. doi: 10.3866/PKU.WHXB202407005
14. [14]
  Jiahong ZHENG , Jingyun YANG . Preparation and electrochemical properties of hollow dodecahedral CoNi₂S₄ supported by MnO₂ nanowires. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1881-1891. doi: 10.11862/CJIC.20240170
15. [15]
  Yingchun ZHANG , Yiwei SHI , Ruijie YANG , Xin WANG , Zhiguo SONG , Min WANG . Dual ligands manganese complexes based on benzene sulfonic acid and 2, 2′-bipyridine: Structure and catalytic properties and mechanism in Mannich reaction. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1501-1510. doi: 10.11862/CJIC.20240078
16. [16]
  Ru SONG , Biao WANG , Chunling LU , Bingbing NIU , Dongchao QIU . Electrochemical properties of stable and highly active PrBa_0.5Sr_0.5Fe_1.6Ni_0.4O_5+δ cathode material. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 639-649. doi: 10.11862/CJIC.20240397
17. [17]
  Caixia Lin , Zhaojiang Shi , Yi Yu , Jianfeng Yan , Keyin Ye , Yaofeng Yuan . Ideological and Political Design for the Electrochemical Synthesis of Benzoxathiazine Dioxide Experiment. University Chemistry, 2024, 39(2): 61-66. doi: 10.3866/PKU.DXHX202309005
18. [18]
  Hongyi LI , Aimin WU , Liuyang ZHAO , Xinpeng LIU , Fengqin CHEN , Aikui LI , Hao HUANG . Effect of Y(PO₃)₃ double-coating modification on the electrochemical properties of Li[Ni_0.8Co_0.15Al_0.05]O₂. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1320-1328. doi: 10.11862/CJIC.20230480
19. [19]
  Xiangyu CAO , Jiaying ZHANG , Yun FENG , Linkun SHEN , Xiuling ZHANG , Juanzhi YAN . Synthesis and electrochemical properties of bimetallic-doped porous carbon cathode material. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 509-520. doi: 10.11862/CJIC.20240270
20. [20]
  Endong YANG , Haoze TIAN , Ke ZHANG , Yongbing LOU . Efficient oxygen evolution reaction of CuCo₂O₄/NiFe-layered bimetallic hydroxide core-shell nanoflower sphere arrays. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 930-940. doi: 10.11862/CJIC.20230369

Get Citation

PDF

XML

Metrics

PDF Downloads(13)
Abstract views(1775)
HTML views(349)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Effects of manganese sources on the high temperature performance of spinel LiMn2O4

Metrics

通讯作者: 陈斌, bchen63@163.com

Effects of manganese sources on the high temperature performance of spinel LiMn₂O₄