Citation: An-qi Tang, Jing-yu Lu, Wei-lin Feng, Pei-bin Zhang, Li-ping Zhu. Performance Control of Polydopamine Compsite Nanofiltration Membranes Fabricated by Interfacial Crosslinking[J]. Acta Polymerica Sinica, ;2018, 0(12): 1524-1531. doi: 10.11777/j.issn1000-3304.2018.18109 shu

Performance Control of Polydopamine Compsite Nanofiltration Membranes Fabricated by Interfacial Crosslinking

Ministry of Education Key Laboratory of Macromolecule Synthesis and Functionalization, Department of Polymer Science and Engineering, Zhejiang University, Hangzhou 310027

Corresponding author: Li-ping Zhu, lpzhu@zju.edu.cn
Received Date: 20 April 2018
Revised Date: 22 May 2018
Available Online: 4 July 2018

Composite nanofiltration membranes with tunable permeation and separation properties were prepared by interfacial crosslinking reaction between polydopamine (PDA) and trimesoyl chloride (TMC). Dopamine was first allowed to self-polymerize into oligomers or nanoaggregates in its aqueous solution at room temperature. As the size of PDA aggregates was readily modulated by measuring the pH of water phase, the separation precision of composite membranes could then be controlled. Ultraviolet spectra and dynamic light scattering ensured that the size of PDA nanoaggregates varied with pH values of aqueous solution. Attenuated total reflectance Fourier transform infrared spectroscopy, scanning electronic microscopy and contact angle measurement were employed to characterize the surface chemistry and morphology of the obtained composite membranes. It was found that, when the pH value of aqeuous phase increased from 6 to 12, the separation scale of composite membranes became progressively smaller and reached its highest selectivity at pH = 12, with rejection of Na₂SO₄ and sunset yellow being 90% and 97% respectively, flux reaching 64 L m⁻² h⁻¹ under 0.4 MPa. Increasing pH value to 13 caused a decline of separation properties, probably owing to a decomposition of PDA aggregates under strongly alkaline condition. Compared with PDA deposition method, which had been reported before, this work has considerably reduced the deposition time and produced a denser top layer, improving both preparation and separation efficiencies. By adjusting the size of the reactants before interfacial crosslinking, this study facilitated the regulation of separation precision of nanofiltration membranes.
- Polydopamine,
- Interfacial crosslinking,
- Nanofiltration,
- Separation precision
1. [1]
  Mohammad A W, Teow Y H, Ang W L, Chung Y T, Oatley-Radcliffe D L, Hilal N. Desalination, 2015, 356: 226 − 254 doi: 10.1016/j.desal.2014.10.043
2. [2]
  Szymczyk A, Fievet P. J Membr Sci, 2005, 252: 77 − 88 doi: 10.1016/j.memsci.2004.12.002
3. [3]
  Schaep J, Vandecasteele C. J Membr Sci, 2001, 188: 129 − 136 doi: 10.1016/S0376-7388(01)00368-4
4. [4]
  Gohil J M, Ray P. Sep Purif Technol, 2017, 181: 159 − 182 doi: 10.1016/j.seppur.2017.03.020
5. [5]
  Paul M, Jons S D. Polymer (United Kingdom), 2016, 103: 417 − 456
6. [6]
  Tul Muntha S, Kausar A, Siddiq M. Polym Plast Technol Eng, 2017, 56: 841 − 856 doi: 10.1080/03602559.2016.1233562
7. [7]
  Gin D L, Noble R D. Science, 2011, 332: 674 − 676 doi: 10.1126/science.1203771
8. [8]
  Lee H, Dellatore S M, Miller W M, Messersmith P B. Science, 2007, 318: 426 − 430 doi: 10.1126/science.1147241
9. [9]
  Ju K Y, Lee Y, Lee S, Park S B, Lee J K. Biomacromolecules, 2011, 12: 625 − 632 doi: 10.1021/bm101281b
10. [10]
  Jiang J H, Zhu L P, Zhu L J, Zhu B K, Xu Y Y. Langmuir, 2011, 27: 14180 − 14187 doi: 10.1021/la202877k
11. [11]
  Liu Y L, Ai K L, Lu L H. Chem Rev, 2014, 114: 5057 − 5115 doi: 10.1021/cr400407a
12. [12]
  Pan J M, Ma Y, Zeng J, Niu X H, Zhang T, Qiu F X, Peng Y X, Yan Y S. Chem Eng J, 2016, 302: 670 − 681 doi: 10.1016/j.cej.2016.05.102
13. [13]
  Rao Z, Feng K, Tang B, Wu P. ACS Appl Mater Interfaces, 2017, 9: 2594 − 2605 doi: 10.1021/acsami.6b15873
14. [14]
  Zhang Y, Zhang S, Gao J, Chung T S. J Membr Sci, 2016, 515: 230 − 237 doi: 10.1016/j.memsci.2016.05.035
15. [15]
  Wang T Y, Qiblawey H, Sivaniah E, Mohammadian A. J Membr Sci, 2016, 511: 65 − 75 doi: 10.1016/j.memsci.2016.03.043
16. [16]
  Zhang C, Lv Y, Qin W Z, He A, Xu Z K. ACS Appl Mater Interfaces, 2017, 9: 14437 − 14444 doi: 10.1021/acsami.7b03115
17. [17]
  Li M M, Xu J, Chang C Y, Feng C C, Zhang L L, Tang Y Y, Gao C J. J Membr Sci, 2014, 459: 62 − 71 doi: 10.1016/j.memsci.2014.01.038
18. [18]
  Xi Z Y, Xu Y Y, Zhu L P, Wang Y, Zhu B K. J Membr Sci, 2009, 327: 244 − 253 doi: 10.1016/j.memsci.2008.11.037
19. [19]
  Li X L, Zhu L P, Jiang J H, Yi Z A, Zhu B K, Xu Y Y. Chinese J Polym Sci, 2012, 30: 152 − 163 doi: 10.1007/s10118-012-1107-5
20. [20]
  Zhang P B, Liu C J, Sun J, Zhu B K, Zhu L P. J Zhejiang Univ-Sc A, 2017, 18: 138 − 150
21. [21]
  Li Y, Su Y, Zhao X, He X, Zhang R, Zhao J, Fan X, Jiang Z. ACS Appl Mater Interfaces, 2014, 6: 5548 − 5557 doi: 10.1021/am405990g
22. [22]
  Yang H C, Liao K J, Huang H, Wu Q Y, Wan L S, Xu Z K. J Mater Chem A, 2014, 2: 10225 − 10230 doi: 10.1039/C4TA00143E
23. [23]
  Lv Y, Yang H C, Liang H Q, Wan L S, Xu Z K. J Membr Sci, 2015, 476: 50 − 58 doi: 10.1016/j.memsci.2014.11.024
24. [24]
  Yang X, Du Y, Zhang X, He A, Xu Z K. Langmuir, 2017, 33: 2318 − 2324 doi: 10.1021/acs.langmuir.6b04465
25. [25]
  Li S, Luo J, Wan Y. J Membr Sci, 2018, 549: 120 − 128 doi: 10.1016/j.memsci.2017.11.075
26. [26]
  Cao X, Luo J, Woodley J M, Wan Y. ACS Appl Mater Interfaces, 2016, 8: 30511 − 30522 doi: 10.1021/acsami.6b10823
27. [27]
  Zhu J, Wang J, Uliana A A, Tian M, Zhang Y, Zhang Y, Volodin A, Simoens K, Yuan S, Li J, Lin J, Bernaerts K, van der Bruggen B. ACS Appl Mater Interfaces, 2017, 9: 28990 − 29001 doi: 10.1021/acsami.7b05930
28. [28]
  Zhu J, Yuan S, Uliana A, Hou J, Li J, Li X, Tian M, Chen Y, Volodin A, der Bruggen B V. J Membr Sci, 2018, 554: 97 − 108 doi: 10.1016/j.memsci.2018.03.004
29. [29]
  d'Ischia M, Napolitano A, Pezzella A, Meredith P, Sarna T. Angew Chem Int Ed, 2009, 48: 3914 − 3921 doi: 10.1002/anie.v48:22
30. [30]
  Della Vecchia N F, Avolio R, Alfe M, Errico M E, Napolitano A, d'Ischia M. Adv Funct Mater, 2013, 23: 1331 − 1340 doi: 10.1002/adfm.v23.10
31. [31]
  Ho C C, Ding S J. J Mater Sci-Mater Med, 2013, 24: 2381 − 2390 doi: 10.1007/s10856-013-4994-2
32. [32]
33. [33]
  Jiang J H, Zhu L P, Li X L, Xu Y Y, Zhu B K. J Membr Sci, 2010, 364: 194 − 202 doi: 10.1016/j.memsci.2010.08.017
1. [1]
  Peiyu Zhang , Aixin Song , Jingcheng Hao , Jiwei Cui . 高频超声法制备聚多巴胺薄膜综合实验. University Chemistry, 2025, 40(6): 210-214. doi: 10.12461/PKU.DXHX202407081
2. [2]
  Jing SU , Bingrong LI , Yiyan BAI , Wenjuan JI , Haiying YANG , Zhefeng Fan . Highly sensitive electrochemical dopamine sensor based on a highly stable In-based metal-organic framework with amino-enriched pores. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1337-1346. doi: 10.11862/CJIC.20230414
3. [3]
  Tiantian MA , Sumei LI , Chengyu ZHANG , Lu XU , Yiyan BAI , Yunlong FU , Wenjuan JI , Haiying YANG . Methyl-functionalized Cd-based metal-organic framework for highly sensitive electrochemical sensing of dopamine. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 725-735. doi: 10.11862/CJIC.20230351
4. [4]
  Qiuting Zhang , Fan Wu , Jin Liu , Zian Lin . Chromatographic Stationary Phase and Chiral Separation Using Frame Materials. University Chemistry, 2025, 40(4): 291-298. doi: 10.12461/PKU.DXHX202405174
5. [5]
  Peipei Sun , Jinyuan Zhang , Yanhua Song , Zhao Mo , Zhigang Chen , Hui Xu . 引入内建电场增强光载流子分离以促进H₂的生产. Acta Physico-Chimica Sinica, 2024, 40(11): 2311001-. doi: 10.3866/PKU.WHXB202311001
6. [6]
  Lan Ma , Cailu He , Ziqi Liu , Yaohan Yang , Qingxia Ming , Xue Luo , Tianfeng He , Liyun Zhang . Magical Surface Chemistry: Fabrication and Application of Oil-Water Separation Membranes. University Chemistry, 2024, 39(5): 218-227. doi: 10.3866/PKU.DXHX202311046
7. [7]
  Zijuan LI , Xuan LÜ , Jiaojiao CHEN , Haiyang ZHAO , Shuo SUN , Zhiwu ZHANG , Jianlong ZHANG , Yanling MA , Jie LI , Zixian FENG , Jiahui LIU . Synthesis of visual fluorescence emission CdSe nanocrystals based on ligand regulation. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 308-320. doi: 10.11862/CJIC.20240138
8. [8]
  Runjie Li , Hang Liu , Xisheng Wang , Wanqun Zhang , Wanqun Hu , Kaiping Yang , Qiang Zhou , Si Liu , Pingping Zhu , Wei Shao . 氨基酸的衍生及手性气相色谱分离创新实验. University Chemistry, 2025, 40(6): 286-295. doi: 10.12461/PKU.DXHX202407059
9. [9]
  Wendian XIE , Yuehua LONG , Jianyang XIE , Liqun XING , Shixiong SHE , Yan YANG , Zhihao HUANG . Preparation and ion separation performance of oligoether chains enriched covalent organic framework membrane. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1528-1536. doi: 10.11862/CJIC.20240050
10. [10]
  Xinhao Yan , Guoliang Hu , Ruixi Chen , Hongyu Liu , Qizhi Yao , Jiao Li , Lingling Li . Polyethylene Glycol-Ammonium Sulfate-Nitroso R Salt System for the Separation of Cobalt (II). University Chemistry, 2024, 39(6): 287-294. doi: 10.3866/PKU.DXHX202310073
11. [11]
  Jie ZHAO , Sen LIU , Qikang YIN , Xiaoqing LU , Zhaojie WANG . Theoretical calculation of selective adsorption and separation of CO₂ by alkali metal modified naphthalene/naphthalenediyne. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 515-522. doi: 10.11862/CJIC.20230385
12. [12]
  Yan LIU , Jiaxin GUO , Song YANG , Shixian XU , Yanyan YANG , Zhongliang YU , Xiaogang HAO . Exclusionary recovery of phosphate anions with low concentration from wastewater using a CoNi-layered double hydroxide/graphene electronically controlled separation film. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1775-1783. doi: 10.11862/CJIC.20240043
13. [13]
  Shui Hu , Houjin Li , Zhenming Zang , Lianyun Li , Rong Lai . Integration of Science and Education Promotes the Construction of Undergraduate-to-Master’s Integration Experimental Courses: A Case Study on the Extraction, Separation and Identification of Artemisinin from Artemisia annua. University Chemistry, 2024, 39(4): 314-321. doi: 10.3866/PKU.DXHX202310063
14. [14]
  Junjie Zhang , Yue Wang , Qiuhan Wu , Ruquan Shen , Han Liu , Xinhua Duan . Preparation and Selective Separation of Lightweight Magnetic Molecularly Imprinted Polymers for Trace Tetracycline Detection in Milk. University Chemistry, 2024, 39(5): 251-257. doi: 10.3866/PKU.DXHX202311084
15. [15]
  Yang Chen , Peng Chen , Yuyang Song , Yuxue Jin , Song Wu . Application of Chemical Transformation Driven Impurity Separation in Experiments Teaching: A Novel Method for Purification of α-Fluorinated Mandelic Acid. University Chemistry, 2024, 39(6): 253-263. doi: 10.3866/PKU.DXHX202310077
16. [16]
  Changjun You , Chunchun Wang , Mingjie Cai , Yanping Liu , Baikang Zhu , Shijie Li . 引入内建电场强化BiOBr/C₃N₅ S型异质结中光载流子分离以实现高效催化降解微污染物. Acta Physico-Chimica Sinica, 2024, 40(11): 2407014-. doi: 10.3866/PKU.WHXB202407014
17. [17]
  Jie ZHAO , Huili ZHANG , Xiaoqing LU , Zhaojie WANG . Theoretical calculations of CO₂ capture and separation by functional groups modified 2D covalent organic framework. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 275-283. doi: 10.11862/CJIC.20240213
18. [18]
  Xinlong WANG , Zhenguo CHENG , Guo WANG , Xiaokuen ZHANG , Yong XIANG , Xinquan WANG . Enhancement of the fragile interface of high voltage LiCoO₂ by surface gradient permeation of trace amounts of Mg/F. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 571-580. doi: 10.11862/CJIC.20230259
19. [19]
  Chunai Dai , Yongsheng Han , Luting Yan , Zhen Li , Yingze Cao . Ideological and Political Design of Solid-liquid Contact Angle Measurement Experiment. University Chemistry, 2024, 39(2): 28-33. doi: 10.3866/PKU.DXHX202306065
20. [20]
  Jiayu Tang , Jichuan Pang , Shaohua Xiao , Xinhua Xu , Meifen Wu . Improvement for Measuring Transference Numbers of Ions by Moving-Boundary Method. University Chemistry, 2024, 39(5): 193-200. doi: 10.3866/PKU.DXHX202311021

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(112)
HTML views(11)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142