Citation: Hong-qing Liang, Ling-shu Wan, Zhi-kang Xu. Poly (vinylidene fluoride) Separators with Dual-asymmetric Structure for High-performance Lithium Ion Batteries[J]. Chinese Journal of Polymer Science, ;2016, 34(12): 1423-1435. doi: 10.1007/s10118-016-1860-y shu

Poly (vinylidene fluoride) Separators with Dual-asymmetric Structure for High-performance Lithium Ion Batteries

a.
MOE Key Laboratory of Macromolecular Synthesis and Functionalization, Department of Polymer Science and Engineering, Zhejiang University, Hangzhou 310027, China
b.
Key Laboratory of Adsorption and Separation Materials & Technologies of Zhejiang Province, Department of Polymer Science and Engineering, Zhejiang University, Hangzhou 310027, China

Corresponding author: Zhi-kang Xu, xuzk@zju.edu.cn
Received Date: 25 July 2016
Revised Date: 13 September 2016
Accepted Date: 13 September 2016

Fund Project: the National Natural Science Foundation of China 21534009the National Natural Science Foundation of China 21174124

Dual-asymmetric poly (vinylidene fluoride) (PVDF) separators have been fabricated by thermally induced phase separation with dimethyl sulfone (DMSO2) and glycerol as mixed diluents. The separators have a porous bulk with large interconnected pores (~1.0 μm) and two surfaces with small pores (~30 nm). This dual-asymmetric porous structure endows the separators with higher electrolyte uptake amount and rapider uptake rate, as well as better electrolyte retention ability than the commercialized Celgard 2400. The separators even maintain their dimensional stability up to 160℃, at which temperature the surface pores close up, leading to a dramatic decrease of air permeability. The electrolyte filled separators also show high ion conductivity (1.72 mS·cm^-1) at room temperature. Lithium iron phosphate (LiFePO₄)/lithium (Li) cells using these separators display superior discharge capacity and better rate performance as compared with those from the commercialized ones. The results provide new insight into the design and development of separators for high-performance lithium ion batteries with enhanced safety.
- Polymer separator,
- Lithium ion battery,
- Dual-asymmetric structure,
- Porous membrane,
- Thermally induced phase separation
1. [1]
  Whittingham, M.S., Chem. Rev., 2004, 104(10):4271 doi: 10.1021/cr020731c
2. [2]
  Arico, A.S., Bruce, P., Scrosati, B., Tarascon, J.M. and van Schalkwijk, W., Nat. Mater., 2005, 4(5):366 doi: 10.1038/nmat1368
3. [3]
  Armand, M. and Tarascon, J.M., Nature, 2008, 451(7179):652 doi: 10.1038/451652a
4. [4]
  Bruce, P.G., Scrosati, B. and Tarascon, J.M., Angew. Chem. Int. Ed., 2008, 47(16):2930 doi: 10.1002/(ISSN)1521-3773
5. [5]
  Goodenough, J.B. and Kim, Y., Chem. Mater., 2010, 22(3):587 doi: 10.1021/cm901452z
6. [6]
  Etacheri, V., Marom, R., Elazari, R., Salitra, G. and Aurbach, D., Energy Environ. Sci., 2011, 4(9):3243 doi: 10.1039/c1ee01598b
7. [7]
  Arora, P. and Zhang, Z., Chem. Rev., 2004, 104(10):4419 doi: 10.1021/cr020738u
8. [8]
  Zhang, S.S., J. Power Sources, 2007, 164(1):351 doi: 10.1016/j.jpowsour.2006.10.065
9. [9]
  Costa, C.M., Silva, M.M. and Lanceros-Mendez, S., RSC Adv., 2013, 3(29):11404 doi: 10.1039/c3ra40732b
10. [10]
  Nunes-Pereira, J., Costa, C.M. and Lanceros-Méndez, S., J. Power Sources, 2015, 281:378 doi: 10.1016/j.jpowsour.2015.02.010
11. [11]
  Deimede, V. and Elmasides, C., Energy Technol., 2015, 3(5):453 doi: 10.1002/ente.v3.5
12. [12]
  Ryou, M.H., Lee, Y.M., Park, J.K. and Choi, J.W., Adv. Mater., 2011, 23(27):3066 doi: 10.1002/adma.v23.27
13. [13]
  Shi, J.L., Li, H., Fang, L.F., Liang, Z.Y. and Zhu, B.K., Chinese J. Polym. Sci., 2013, 31(2):309 doi: 10.1007/s10118-013-1222-y
14. [14]
  Shi, Q., Yu, M., Zhou, X., Yan, Y. and Wan, C., J. Power Sources, 2002, 103(2):286 doi: 10.1016/S0378-7753(01)00868-0
15. [15]
  Costa, C.M., Rodrigues, L.C., Sencadas, V., Silva, M.M., Rocha, J.G. and Lanceros-Mendez, S., J. Membr. Sci., 2012, 407:193
16. [16]
  Shubha, N., Prasanth, R., Hng, H.H. and Srinivasan, M., J. Power Sources, 2014, 267:48 doi: 10.1016/j.jpowsour.2014.05.074
17. [17]
  Kim, M. and Park, J.H., Adv. Energy Mater., 2013, 3(11):1417 doi: 10.1002/aenm.v3.11
18. [18]
  Zhang, J., Sun, B., Huang, X., Chen, S. and Wang, G., Sci. Rep., 2014, 4:6007 doi: 10.1038/srep06007
19. [19]
  Kim, M., Kim, J.K. and Park, J.H., Adv. Funct. Mater., 2015, 25(22):3399 doi: 10.1002/adfm.v25.22
20. [20]
  Pu, W.H., He, X.M., Wang, L., Jiang, C.Y. and Wan, C.R., J. Membr. Sci., 2006, 272(1-2):11 doi: 10.1016/j.memsci.2005.12.038
21. [21]
  Croce, F., Focarete, M.L., Hassoun, J., Meschini, I. and Scrosati, B., Energy Environ. Sci., 2011, 4(3):921 doi: 10.1039/c0ee00348d
22. [22]
  Costa, C.M., Gomez Ribelles, J.L., Lanceros-Mendez, S., Appetecchi, G.B. and Scrosati, B., J. Power Sources, 2014, 245:779 doi: 10.1016/j.jpowsour.2013.06.151
23. [23]
  Wang, X., Gong, C., He, D., Xue, Z., Chen, C., Liao, Y. and Xie, X., J. Membr. Sci., 2014, 454:298 doi: 10.1016/j.memsci.2013.12.016
24. [24]
  Zhang, J., Yue, L., Kong, Q., Liu, Z., Zhou, X., Zhang, C., Xu, Q., Zhang, B., Ding, G., Qin, B., Duan, Y., Wang, Q., Yao, J., Cui, G. and Chen, L., Sci. Rep., 2014, 4:3935
25. [25]
  Matsuyama, H., Berghmans, S., Batarseh, M.T. and Lloyd, D.R., J. Membr. Sci., 1998, 142(1):27 doi: 10.1016/S0376-7388(97)00313-X
26. [26]
  Atkinson, P.M. and Lloyd, D.R., J. Membr. Sci., 2000, 171(1):1 doi: 10.1016/S0376-7388(99)00376-2
27. [27]
  Atkinson, P.M. and Lloyd, D.R., J. Membr. Sci., 2000, 175(2):225 doi: 10.1016/S0376-7388(00)00422-1
28. [28]
  Matsuyama, H., Yuasa, M., Kitamura, Y., Teramoto, M. and Lloyd, D.R., J. Membr. Sci., 2000, 179(1-2):91 doi: 10.1016/S0376-7388(00)00506-8
29. [29]
  Cui, A., Liu, Z., Xiao, C. and Zhang, Y., J. Membr. Sci., 2010, 360(1):259
30. [30]
  Cui, Z., Hassankiadeh, N.T., Lee, S.Y., Lee, J.M., Woo, K.T., Sanguineti, A., Arcella, V., Lee, Y.M. and Drioli, E., J. Membr. Sci., 2013, 444:223 doi: 10.1016/j.memsci.2013.05.031
31. [31]
  Lal, J. and Bansil, R., Macromolecules, 1991, 24(1):290 doi: 10.1021/ma00001a044
32. [32]
  Nunes, S.P. and Inoue, T., J. Membr. Sci., 1996, 111(1):93 doi: 10.1016/0376-7388(95)00281-2
33. [33]
  Wu, Q.Y., Liang, H.Q., Li, M., Liu, B.T. and Xu, Z.K., Chinese J. Polym. Sci., 2016, 34(1):23 doi: 10.1007/s10118-016-1723-6
34. [34]
  Liang, H.Q., Wu, Q.Y., Wan, L.S., Huang, X.J. and Xu, Z.K., J. Membr. Sci., 2013, 446:482 doi: 10.1016/j.memsci.2013.07.008
35. [35]
  Liang, H.Q., Wu, Q.Y., Wan, L.S., Huang, X.J. and Xu, Z.K., J. Membr. Sci., 2014, 465:56 doi: 10.1016/j.memsci.2014.03.068
36. [36]
  Matsuyama, H., Berghmans, S., Batarseh, M.T. and Lloyd, D.R., J. Membr. Sci., 1998, 142(1):27 doi: 10.1016/S0376-7388(97)00313-X
37. [37]
  Wu, Q.Y., Liu, B.T., Li, M., Wan, L.S. and Xu, Z.K., J. Membr. Sci., 2013, 437:227 doi: 10.1016/j.memsci.2013.03.018
38. [38]
  Wu, Q.Y., Wan, L.S. and Xu, Z.K., J. Membr. Sci., 2012, 409:355
39. [39]
  Park, M.J. and Kim, C.K., J. Membr. Sci., 2014, 449:127 doi: 10.1016/j.memsci.2013.08.004
40. [40]
  Shou, D., Ye, L., Fan, J. and Fu, K., Langmuir, 2014, 30(1):149 doi: 10.1021/la4034063
41. [41]
  Gambaryan-Roisman, T., Curr. Opin. Colloid Interface Sci., 2014, 19(4):320 doi: 10.1016/j.cocis.2014.09.001
42. [42]
  Chen, J., Wang, S., Ding, L., Jiang, Y. and Wang, H., J. Membr. Sci., 2014, 461:22 doi: 10.1016/j.memsci.2014.03.005
43. [43]
  Shi, J., Xia, Y., Yuan, Z., Hu, H., Li, X., Zhang, H. and Liu, Z., Sci. Rep., 2015, 5:8255 doi: 10.1038/srep08255
44. [44]
  Zhai, Y., Wang, N., Mao, X., Si, Y., Yu, J., Al-Deyab, S.S., El-Newehy, M. and Ding, B., J. Mater. Chem. A, 2014, 2(35):14511 doi: 10.1039/C4TA02151G
45. [45]
  Benz, M., Euler, W. B. and Gregory, O. J., Macromolecules, 2002, 35(7):2682 doi: 10.1021/ma011744f
46. [46]
  Ji, G.L., Zhu, B.K., Cui, Z.Y., Zhang, C.F. and Xu, Y.Y., Polymer, 2007, 48(21):6415 doi: 10.1016/j.polymer.2007.08.049
47. [47]
  Cui, Z.Y., Xu, Y.Y., Zhu, L.P., Wang, J.Y., Xi, Z.Y. and Zhu, B.K., J. Membr. Sci., 2008, 325(2):957 doi: 10.1016/j.memsci.2008.09.022
48. [48]
  Cui, Z.Y., Xu, Y.Y., Zhu, L.P., Wang, J.Y. and Zhu, B.K., Ionics, 2009, 15(4):469 doi: 10.1007/s11581-008-0253-9
49. [49]
  Nunes-Pereira, J., Costa, C.M., Sousa, R.E., Machado, A.V., Silva, M.M. and Lanceros-Mendez, S., Electrochim. Acta, 2014, 117:276 doi: 10.1016/j.electacta.2013.11.122
50. [50]
  He, M., Zhang, X., Jiang, K., Wang, J. and Wang, Y., Acs Appl. Mater. Interfaces, 2015, 7(1):738 doi: 10.1021/am507145h
51. [51]
  Zhang, J., Yue, L., Hu, P., Liu, Z., Qin, B., Zhang, B., Wang, Q., Ding, G., Zhang, C., Zhou, X., Yao, J., Cui, G. and Chen, L., Sci. Rep., 2014, 4:6272 doi: 10.1038/srep06272
52. [52]
  Zhu, Y., Xiao, S., Shi, Y., Yang, Y. and Wu, Y., J. Mater. Chem. A, 2013, 1(26):7790 doi: 10.1039/c3ta00167a
53. [53]
  Zhu, Y., Xiao, S., Shi, Y., Yang, Y., Hou, Y. and Wu, Y., Adv. Energy Mater., 2014, 4(1):1300647 doi: 10.1002/aenm.201300647
54. [54]
  Zhang, J., Chen, S., Xie, X., Kretschmer, K., Huang, X., Sun, B. and Wang, G., J. Membr. Sci., 2014, 472:133 doi: 10.1016/j.memsci.2014.08.049
1. [1]
  Xingang Kong , Yabei Su , Cuijuan Xing , Weijie Cheng , Jianfeng Huang , Lifeng Zhang , Haibo Ouyang , Qi Feng . Facile synthesis of porous TiO₂/SnO₂ nanocomposite as lithium ion battery anode with enhanced cycling stability via nanoconfinement effect. Chinese Chemical Letters, 2024, 35(11): 109428-. doi: 10.1016/j.cclet.2023.109428
2. [2]
  Haixia Wu , Kailu Guo . Iodized polyacrylonitrile as fast-charging anode for lithium-ion battery. Chinese Chemical Letters, 2024, 35(10): 109550-. doi: 10.1016/j.cclet.2024.109550
3. [3]
  Fangling Cui , Zongjie Hu , Jiayu Huang , Xiaoju Li , Ruihu Wang . MXene-based materials for separator modification of lithium-sulfur batteries. Chinese Journal of Structural Chemistry, 2024, 43(7): 100337-100337. doi: 10.1016/j.cjsc.2024.100337
4. [4]
  Xin-Tong Zhao , Jin-Zhi Guo , Wen-Liang Li , Jing-Ping Zhang , Xing-Long Wu . Two-dimensional conjugated coordination polymer monolayer as anode material for lithium-ion batteries: A DFT study. Chinese Chemical Letters, 2024, 35(6): 108715-. doi: 10.1016/j.cclet.2023.108715
5. [5]
  Yang LIU , Lijun WANG , Hongyu WANG , Zhidong CHEN , Lin SUN . Surface and interface modification of porous silicon anodes in lithium-ion batteries by the introduction of heterogeneous atoms and hybrid encapsulation. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 773-785. doi: 10.11862/CJIC.20250015
6. [6]
  Hengying Xiang , Nanping Deng , Lu Gao , Wen Yu , Bowen Cheng , Weimin Kang . 3D core-shell nanofibers framework and functional ceramic nanoparticles synergistically reinforced composite polymer electrolytes for high-performance all-solid-state lithium metal battery. Chinese Chemical Letters, 2024, 35(8): 109182-. doi: 10.1016/j.cclet.2023.109182
7. [7]
  Yu ZHANG , Fangfang ZHAO , Cong PAN , Peng WANG , Liangming WEI . Application of double-side modified separator with hollow carbon material in high-performance Li-S battery. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1218-1232. doi: 10.11862/CJIC.20230412
8. [8]
  Yue Qian , Zhoujia Liu , Haixin Song , Ruize Yin , Hanni Yang , Siyang Li , Weiwei Xiong , Saisai Yuan , Junhao Zhang , Huan Pang . Imide-based covalent organic framework with excellent cyclability as an anode material for lithium-ion battery. Chinese Chemical Letters, 2024, 35(6): 108785-. doi: 10.1016/j.cclet.2023.108785
9. [9]
  Zhihong LUO , Yan SHI , Jinyu AN , Deyi ZHENG , Long LI , Quansheng OUYANG , Bin SHI , Jiaojing SHAO . Two-dimensional silica-modified polyethylene oxide solid polymer electrolyte to enhance the performance of lithium-ion batteries. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 1005-1014. doi: 10.11862/CJIC.20230444
10. [10]
  Ya Song , Mingxia Zhou , Zhu Chen , Huali Nie , Jiao-Jing Shao , Guangmin Zhou . Integrated interconnected porous and lamellar structures realized fast ion/electron conductivity in high-performance lithium-sulfur batteries. Chinese Chemical Letters, 2024, 35(6): 109200-. doi: 10.1016/j.cclet.2023.109200
11. [11]
  Ningning Zhao , Yuyan Liang , Wenjie Huo , Xinyan Zhu , Zhangxing He , Zekun Zhang , Youtuo Zhang , Xianwen Wu , Lei Dai , Jing Zhu , Ling Wang , Qiaobao Zhang . Separator functionalization enables high-performance zinc anode via ion-migration regulation and interfacial engineering. Chinese Chemical Letters, 2024, 35(9): 109332-. doi: 10.1016/j.cclet.2023.109332
12. [12]
  Huanyan Liu , Jiajun Long , Hua Yu , Shichao Zhang , Wenbo Liu . Rational design of highly conductive and stable 3D flexible composite current collector for high performance lithium-ion battery electrodes. Chinese Chemical Letters, 2025, 36(3): 109712-. doi: 10.1016/j.cclet.2024.109712
13. [13]
  Zhong-Hui Sun , Yu-Qi Zhang , Zhen-Yi Gu , Dong-Yang Qu , Hong-Yu Guan , Xing-Long Wu . CoPSe nanoparticles confined in nitrogen-doped dual carbon network towards high-performance lithium/potassium ion batteries. Chinese Chemical Letters, 2025, 36(1): 109590-. doi: 10.1016/j.cclet.2024.109590
14. [14]
  Mengyuan Li , Xitong Ren , Yanmei Gao , Mengyao Mu , Shiping Zhu , Shufang Tian , Minghua Lu . Constructing bifunctional magnetic porous poly(divinylbenzene) polymer for high-efficient removal and sensitive detection of bisphenols. Chinese Chemical Letters, 2024, 35(12): 109699-. doi: 10.1016/j.cclet.2024.109699
15. [15]
  Ting Shi , Ziyang Song , Yaokang Lv , Dazhang Zhu , Ling Miao , Lihua Gan , Mingxian Liu . Hierarchical porous carbon guided by constructing organic-inorganic interpenetrating polymer networks to facilitate performance of zinc hybrid supercapacitors. Chinese Chemical Letters, 2025, 36(1): 109559-. doi: 10.1016/j.cclet.2024.109559
16. [16]
  Chao Ma , Cong Lin , Jian Li . MicroED as a powerful technique for the structure determination of complex porous materials. Chinese Journal of Structural Chemistry, 2024, 43(3): 100209-100209. doi: 10.1016/j.cjsc.2023.100209
17. [17]
  Guilong Li , Wenbo Ma , Jialing Zhou , Caiqin Wu , Chenling Yao , Huan Zeng , Jian Wang . A composite hydrogel with porous and homogeneous structure for efficient osmotic energy conversion. Chinese Chemical Letters, 2025, 36(2): 110449-. doi: 10.1016/j.cclet.2024.110449
18. [18]
  Yan Zou , Yin-Shuang Hu , Deng-Hui Tian , Hong Wu , Xiaoshu Lv , Guangming Jiang , Yu-Xi Huang . Tuning the membrane rejection behavior by surface wettability engineering for an effective water-in-oil emulsion separation. Chinese Chemical Letters, 2024, 35(6): 109090-. doi: 10.1016/j.cclet.2023.109090
19. [19]
  Changle Liu , Mingyuzhi Sun , Haoran Zhang , Xiqian Cao , Yuqing Li , Yingtang Zhou . All in one doubly pillared MXene membrane for excellent oil/water separation, pollutant removal, and anti-fouling performance. Chinese Journal of Structural Chemistry, 2024, 43(8): 100355-100355. doi: 10.1016/j.cjsc.2024.100355
20. [20]
  Lingjun Sha , Bing Bo , Jiayu Li , Qi Liu , Ya Cao , Jing Zhao . Precise assessment of lung cancer-derived exosomes based on dual-labelled membrane interface. Chinese Chemical Letters, 2025, 36(4): 110109-. doi: 10.1016/j.cclet.2024.110109

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(789)
HTML views(1)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142