Mg、Ti离子复合掺杂改性磷酸铁锂正极材料及其电池性能

引用本文: 王震坡, 刘文, 王悦, 赵春松, 张淑萍, 陈继涛, 周恒辉, 张新祥. Mg、Ti离子复合掺杂改性磷酸铁锂正极材料及其电池性能[J]. 物理化学学报, 2012, 28(09): 2084-2090. doi: 10.3866/PKU.WHXB201207043 shu

Citation: WANG Zhen-Po, LIU Wen, WANG Yue, ZHAO Chun-Song, ZHANG Shu-Ping, CHEN Ji-Tao, ZHOU Heng-Hui, ZHANG Xin-Xiang. Synthesis and Characterization of Mg and Ti Ions Co-Doped Lithium Iron Phosphate and Its Lithium-Ion Batteries[J]. Acta Physico-Chimica Sinica, 2012, 28(09): 2084-2090. doi: 10.3866/PKU.WHXB201207043 shu

Mg、Ti离子复合掺杂改性磷酸铁锂正极材料及其电池性能

王震坡 ^1, ,
刘文 ^2, ,
王悦 ^3, ,
赵春松 ^4, ,
张淑萍 ^4, ,
陈继涛 ^2, ,
周恒辉 ^2, ,
张新祥 ^2,

基金项目:
国家自然科学基金(61004092) (61004092)

国家高技术研究发展计划项目(863) (2009AA035200)资助 (863) (2009AA035200)

摘要:

在氮气气氛下采用高温固相方法, 合成了Mg、Ti 离子复合掺杂改性的锂离子电池正极材料(Li_0.98Mg_0.01)(Fe_0.98Ti_0.01)PO₄/C, 并通过粉末X射线衍射(XRD)、扫描电子显微镜(SEM)、透射电子显微镜(TEM)和充放电循环对材料进行性能表征. 测试结果表明, 复合离子掺杂可显著改善材料的电化学性能, 模拟电池在0.2C和1C倍率下的放电比容量分别为154.7 和146.9 mAh·g^-1. 以此复合掺杂样品为正极材料组装60 Ah动力电池, 其3C倍率放电容量仍保持为1C倍率放电容量的100%; 低温0 和-20 °C测试条件下, 动力电池放电容量分别保持为常温初始放电容量的89.7%和63.1%; 在常温1C/1C充放电条件下, 经过2000次循环后, 电池容量依然保持为初始放电容量的89%, 显示出优良的倍率放电性能和循环性能. 研究结果表明, Mg、Ti 离子复合掺杂改性的磷酸铁锂正极材料及其电池具有优良的放电性能和循环稳定性, 可广泛应用于电动(或混合动力)汽车和储能电池系统.

关键词:

English

Synthesis and Characterization of Mg and Ti Ions Co-Doped Lithium Iron Phosphate and Its Lithium-Ion Batteries

1.
1. National Engineering Laboratory for Electric Vehicles, Beijing Institute of Technology, Beijing 100081, P. R. China;
2. Beijing National Laboratory for Molecular Sciences, College of Chemistry and Molecular Engineering, Peking University, Beijing 100871, P. R. China;
3. Institute of Chemical Defense of PLA, Beijing 102205, P. R. China;
4. Pulead Technology Industry Co., LTD., Beijing 102200, P. R. China
Received Date: 20 April 2012
Available Online: 02 August 2012
Fund Project:
国家自然科学基金(61004092)

国家高技术研究发展计划项目(863) (2009AA035200)资助

Abstract:

Mg and Ti ions co-doped (Li_0.98Mg_0.01)(Fe_0.98Ti_0.01)PO₄/C cathode material for lithium-ion batteries was prepared by a solid-state method under N₂ atmosphere. The samples were characterized by X-ray diffraction (XRD), scanning electron microscopy (SEM), transmission electron microscopy (TEM), and galvanostatic charge-discharge test. Results indicated that Mg and Ti ions co-doping remarkably improved the electrochemical performance of LiFePO₄, including rate capacity, temperature behavior, and cycling stability. Discharge capacities of 154.7 and 146.9 mAh·g^-1 were obtained at the rates of 0.2C and 1C for half-cell tests, respectively. For 60 Ah full-cell tests, 100% of 1C capacity was maintained even at 3C rate, 89.7% and 63.1% of initial capacity at room temperature were retained at 0 and -20 °C, respectively. 89% capacity retention remained after 2000 cycles at room temperature, presenting excellent cycle stability. This investigation suggests that the present co-doping material and the resulting battery possess large discharge capacity and excellent cycling performance, making it applicable in electric vehicle (EV)/hybrid electric vehicle (HEV) and energy storage systems on a large scale.

Key words:

1. [1]
  
  (1) Padhi, A. K.; Nanjundaswamy, K. S.; odenough, J. B.J. Electrochem. Soc. 1997, 144, 1188. doi: 10.1149/1.1837571
  (1) Padhi, A. K.; Nanjundaswamy, K. S.; odenough, J. B.J. Electrochem. Soc. 1997, 144, 1188. doi: 10.1149/1.1837571
2. [2]
  (2) Tarascon, J. M.; Armand, M. Nature 2001, 414, 359. doi: 10.1038/35104644(2) Tarascon, J. M.; Armand, M. Nature 2001, 414, 359. doi: 10.1038/35104644
3. [3]
  (3) Yuan, L. X.;Wang, Z. H.; Zhang,W. X.; Hu, X. L.; Chen, J. T.;Huang, Y. H.; odenough, J. B. Energy & Environmental Science 2011, 4, 269. doi: 10.1039/c0ee00029a(3) Yuan, L. X.;Wang, Z. H.; Zhang,W. X.; Hu, X. L.; Chen, J. T.;Huang, Y. H.; odenough, J. B. Energy & Environmental Science 2011, 4, 269. doi: 10.1039/c0ee00029a
4. [4]
  (4) Zhou, H.; Upreti, S.; Chernova, N. A.; Hautier, G.; Ceder, G.;Whittingham, M. S. Chem. Mater. 2011, 23, 293. doi: 10.1021/cm102922q(4) Zhou, H.; Upreti, S.; Chernova, N. A.; Hautier, G.; Ceder, G.;Whittingham, M. S. Chem. Mater. 2011, 23, 293. doi: 10.1021/cm102922q
5. [5]
  (5) Wang, Y. G.; He, P.; Zhou, H. S. Energy & Environmental Science 2011, 4, 805. doi: 10.1039/c0ee00176g(5) Wang, Y. G.; He, P.; Zhou, H. S. Energy & Environmental Science 2011, 4, 805. doi: 10.1039/c0ee00176g
6. [6]
  (6) Andersson, A. S.; Thomas, J. O. Journal of Power Sources2001, 97-98, 498.(6) Andersson, A. S.; Thomas, J. O. Journal of Power Sources2001, 97-98, 498.
7. [7]
  (7) Okada, S.; Sawa, S.; Egashira, M.; Yamaki, J.; Tabuchi, M.;Kageyama, H.; Konishi, T.; Yoshino, A. Journal of Power Sources 2001, 97, 430. doi: 10.1016/S0378-7753(01)00631-0(7) Okada, S.; Sawa, S.; Egashira, M.; Yamaki, J.; Tabuchi, M.;Kageyama, H.; Konishi, T.; Yoshino, A. Journal of Power Sources 2001, 97, 430. doi: 10.1016/S0378-7753(01)00631-0
8. [8]
  (8) Prosini, P. P.; Lisi, M.; Zane, D.; Pasquali, M. Solid State Ionics2002, 148, 45. doi: 10.1016/S0167-2738(02)00134-0(8) Prosini, P. P.; Lisi, M.; Zane, D.; Pasquali, M. Solid State Ionics2002, 148, 45. doi: 10.1016/S0167-2738(02)00134-0
9. [9]
  (9) Ouyang, C. Y.; Shi, S. Q.;Wang, Z. X.; Huang, X. J.; Chen, L.Q. Physical Review B 2004, 69, 104303. doi: 10.1103/PhysRevB.69.104303(9) Ouyang, C. Y.; Shi, S. Q.;Wang, Z. X.; Huang, X. J.; Chen, L.Q. Physical Review B 2004, 69, 104303. doi: 10.1103/PhysRevB.69.104303
10. [10]
  (10) Morgan, D.; Van der Ven, A.; Ceder, G. Electrochem. Solid-State Lett. 2004, 7, A30.(10) Morgan, D.; Van der Ven, A.; Ceder, G. Electrochem. Solid-State Lett. 2004, 7, A30.
11. [11]
  (11) Wang, Y.;Wang, Y.; Hosono, E.;Wang, K.; Zhou, H. Angew. Chem. Int. Edit. 2008, 47, 7461. doi: 10.1002/anie.200802539(11) Wang, Y.;Wang, Y.; Hosono, E.;Wang, K.; Zhou, H. Angew. Chem. Int. Edit. 2008, 47, 7461. doi: 10.1002/anie.200802539
12. [12]
  (12) Arnold, G.; Garche, J.; Hemmer, R.; Strobele, S.; Vogler, C.;Wohlfahrt-Mehrens, A. Journal of Power Sources 2003, 119,247. doi: 10.1016/S0378-7753(03)00241-6(12) Arnold, G.; Garche, J.; Hemmer, R.; Strobele, S.; Vogler, C.;Wohlfahrt-Mehrens, A. Journal of Power Sources 2003, 119,247. doi: 10.1016/S0378-7753(03)00241-6
13. [13]
  (13) Franger, S.; Le Cras, F.; Bourbon, C.; Rouault, H. Journal of Power Sources 2003, 119, 252. doi: 10.1016/S0378-7753(03)00242-8(13) Franger, S.; Le Cras, F.; Bourbon, C.; Rouault, H. Journal of Power Sources 2003, 119, 252. doi: 10.1016/S0378-7753(03)00242-8
14. [14]
  (14) Huang, H.; Yin, S. C.; Nazar, L. F. Electrochem. Solid-State Lett. 2001, 4, A170.(14) Huang, H.; Yin, S. C.; Nazar, L. F. Electrochem. Solid-State Lett. 2001, 4, A170.
15. [15]
  (15) Prosini, P. P.; Zane, D.; Pasquali, M. Electrochim. Acta 2001,46, 3517. doi: 10.1016/S0013-4686(01)00631-4(15) Prosini, P. P.; Zane, D.; Pasquali, M. Electrochim. Acta 2001,46, 3517. doi: 10.1016/S0013-4686(01)00631-4
16. [16]
  (16) Chen, Z. H.; Dahn, J. R. J. Electrochem. Soc. 2002, 149, A1184(16) Chen, Z. H.; Dahn, J. R. J. Electrochem. Soc. 2002, 149, A1184
17. [17]
  (17) Chung, S. Y.; Bloking, J. T.; Chiang, Y. M. Nat. Mater. 2002, 1,123. doi: 10.1038/nmat732(17) Chung, S. Y.; Bloking, J. T.; Chiang, Y. M. Nat. Mater. 2002, 1,123. doi: 10.1038/nmat732
18. [18]
  (18) Ni, J. F.; Zhou, H. H.; Chen, J. T.; Zhang, X. X. Mater. Lett.2005, 59, 2361. doi: 10.1016/j.matlet.2005.02.080(18) Ni, J. F.; Zhou, H. H.; Chen, J. T.; Zhang, X. X. Mater. Lett.2005, 59, 2361. doi: 10.1016/j.matlet.2005.02.080
19. [19]
  (19) Islam, M. S.; Driscoll, D. J.; Fisher, C. A. J.; Slater, P. R. Chem. Mater. 2005, 17, 5085. doi: 10.1021/cm050999v(19) Islam, M. S.; Driscoll, D. J.; Fisher, C. A. J.; Slater, P. R. Chem. Mater. 2005, 17, 5085. doi: 10.1021/cm050999v
20. [20]
  (20) Ni, J. F.; Zhou, H. H.; Chen, J. T.; Su, G. Y. Acta Phys. -Chim. Sin. 2004, 20, 582. [倪江锋, 周恒辉, 陈继涛, 苏光耀. 物理化学学报, 2004, 20, 582.] doi: 10.3866/PKU.WHXB20040606(20) Ni, J. F.; Zhou, H. H.; Chen, J. T.; Su, G. Y. Acta Phys. -Chim. Sin. 2004, 20, 582. [倪江锋, 周恒辉, 陈继涛, 苏光耀. 物理化学学报, 2004, 20, 582.] doi: 10.3866/PKU.WHXB20040606
21. [21]
  (21) Wen, Y. X.; Zheng, M. P.; Tong, Z. F.; Su, H. F.; Xue, M. H.J. Inorg. Mater. 2006, 21, 115. [文衍宣, 郑绵平, 童张法,粟海锋, 薛敏华. 无机材料学报, 2006, 21, 115.](21) Wen, Y. X.; Zheng, M. P.; Tong, Z. F.; Su, H. F.; Xue, M. H.J. Inorg. Mater. 2006, 21, 115. [文衍宣, 郑绵平, 童张法,粟海锋, 薛敏华. 无机材料学报, 2006, 21, 115.]
22. [22]
  (22) Zhuang, D. G.; Zhao, X. B.; Xie, J.; Tu, J.; Zhu, T. J.; Cao, G. S.Acta Phys. -Chim. Sin. 2006, 22, 840. [庄大高, 赵新兵,些健, 涂健, 朱铁军, 曹高劭. 物理化学学报, 2006, 22,840.] doi: 10.1016/S1872-1508(06)60037-5(22) Zhuang, D. G.; Zhao, X. B.; Xie, J.; Tu, J.; Zhu, T. J.; Cao, G. S.Acta Phys. -Chim. Sin. 2006, 22, 840. [庄大高, 赵新兵,些健, 涂健, 朱铁军, 曹高劭. 物理化学学报, 2006, 22,840.] doi: 10.1016/S1872-1508(06)60037-5
23. [23]
  (23) Wu, S. H.; Chen, M. S.; Chien, C. J.; Fu, Y. P. Journal of Power Sources 2009, 189, 440. doi: 10.1016/j.jpowsour.2009.01.015(23) Wu, S. H.; Chen, M. S.; Chien, C. J.; Fu, Y. P. Journal of Power Sources 2009, 189, 440. doi: 10.1016/j.jpowsour.2009.01.015
24. [24]
  (24) Lu, J. B.; Tang, Z. L.; Zhang, Z. T.; Jin, Y. Z. Acta Phys. -Chim. Sin. 2005, 21, 319. [卢俊彪, 唐子龙, 张中太, 金永柱. 物理化学学报, 2005, 21, 319.] doi: 10.3866/PKU.WHXB20050319(24) Lu, J. B.; Tang, Z. L.; Zhang, Z. T.; Jin, Y. Z. Acta Phys. -Chim. Sin. 2005, 21, 319. [卢俊彪, 唐子龙, 张中太, 金永柱. 物理化学学报, 2005, 21, 319.] doi: 10.3866/PKU.WHXB20050319
25. [25]
  (25) Wang, D. Y.; Li, H.; Shi, S. Q.; Huang, X. J.; Chen, L. Q.Electrochim. Acta 2005, 50, 2955. doi: 10.1016/j.electacta.2004.11.045(25) Wang, D. Y.; Li, H.; Shi, S. Q.; Huang, X. J.; Chen, L. Q.Electrochim. Acta 2005, 50, 2955. doi: 10.1016/j.electacta.2004.11.045
26. [26]
  (26) Ou, X. Q.; Liang, G. C.;Wang, L.; Xu, S. Z.; Zhao, X. Journal of Power Sources 2008, 184, 543. doi: 10.1016/j.jpowsour.2008.02.077(26) Ou, X. Q.; Liang, G. C.;Wang, L.; Xu, S. Z.; Zhao, X. Journal of Power Sources 2008, 184, 543. doi: 10.1016/j.jpowsour.2008.02.077
27. [27]
  (27) Huang, Y. Y.; Zhou, H. H.; Chen, J. T.; Gao, D. S.; Su, G. Y.Acta Phys. -Chim. Sin. 2005, 21, 725. [黄友元, 周恒辉, 陈继涛, 高德淑, 苏光耀. 物理化学学报, 2005, 21, 725.] doi: 10.3866/PKU.WHXB20050706(27) Huang, Y. Y.; Zhou, H. H.; Chen, J. T.; Gao, D. S.; Su, G. Y.Acta Phys. -Chim. Sin. 2005, 21, 725. [黄友元, 周恒辉, 陈继涛, 高德淑, 苏光耀. 物理化学学报, 2005, 21, 725.] doi: 10.3866/PKU.WHXB20050706
28. [28]
  (28) Wang, Z. H.; Yuan, L. X.;Wu, M.; Sun, D.; Huang, Y. H.Electrochim. Acta 2011, 56, 8477. doi: 10.1016/j.electacta.2011.07.018(28) Wang, Z. H.; Yuan, L. X.;Wu, M.; Sun, D.; Huang, Y. H.Electrochim. Acta 2011, 56, 8477. doi: 10.1016/j.electacta.2011.07.018
29. [29]
  (29) Roberts, M. R.; Vitins, G.; Owen, J. R. Journal of Power Sources 2008, 179, 754. doi: 10.1016/j.jpowsour.2008.01.034(29) Roberts, M. R.; Vitins, G.; Owen, J. R. Journal of Power Sources 2008, 179, 754. doi: 10.1016/j.jpowsour.2008.01.034
30. [30]
  (30) Meethong, N.; Kao, Y. H.; Speakman, S. A.; Chiang, Y. M. Adv. Funct. Mater. 2009, 19, 1060. doi: 10.1002/adfm.200801617(30) Meethong, N.; Kao, Y. H.; Speakman, S. A.; Chiang, Y. M. Adv. Funct. Mater. 2009, 19, 1060. doi: 10.1002/adfm.200801617
31. [31]
  (31) Zhang, P. X.;Wang, Y. Y.; Lin, M. C.; Zhang, D. Y.; Ren, X. Z.;Yuan, Q. H. Journal of the Electrochemical Society 2012, 159,A402.(31) Zhang, P. X.;Wang, Y. Y.; Lin, M. C.; Zhang, D. Y.; Ren, X. Z.;Yuan, Q. H. Journal of the Electrochemical Society 2012, 159,A402.
32. [32]
  (32) Li, J.; Yuan, C. F.; Guo, Z. H.; Zhang, Z. A.; Lai, Y. Q.; Liu, J. Electrochim. Acta 2012, 59, 69. doi: 10.1016/j.electacta.2011.10.041
  (32) Li, J.; Yuan, C. F.; Guo, Z. H.; Zhang, Z. A.; Lai, Y. Q.; Liu, J. Electrochim. Acta 2012, 59, 69. doi: 10.1016/j.electacta.2011.10.041

扫一扫看文章

计量

PDF下载量: 1215
文章访问数: 3252
HTML全文浏览量: 122

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Mg、Ti离子复合掺杂改性磷酸铁锂正极材料及其电池性能

English

Synthesis and Characterization of Mg and Ti Ions Co-Doped Lithium Iron Phosphate and Its Lithium-Ion Batteries

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

Mg、Ti离子复合掺杂改性磷酸铁锂正极材料及其电池性能

English

Synthesis and Characterization of Mg and Ti Ions Co-Doped Lithium Iron Phosphate and Its Lithium-Ion Batteries

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南： 你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

文章相关

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs