MnOx/MWCNTs低温氨选择性催化还原NOx硫中毒机理

引用本文: 罗红成, 黄碧纯, 付名利, 吴军良, 叶代启. MnO_x/MWCNTs低温氨选择性催化还原NO_x硫中毒机理[J]. 物理化学学报, doi: 10.3866/PKU.WHXB201207062 shu

Citation: LUO Hong-Cheng, HUANG Bi-Chun, FU Ming-Li, WU Jun-Liang, YE Dai-Qi. SO₂ Deactivation Mechanism of MnO_x/MWCNTs Catalyst for Low-Temperature Selective Catalytic Reduction of NOx by Ammonia[J]. Acta Physico-Chimica Sinica, doi: 10.3866/PKU.WHXB201207062 shu

MnO_x/MWCNTs低温氨选择性催化还原NO_x硫中毒机理

基金项目:
国家自然科学基金(209077034)资助项目 (209077034)

摘要:

以经过浓硝酸和等离子体放电预处理后的多壁碳纳米管(MWCNTs)为载体, 锰氧化物(MnO_x)为活性组分, 采用等体积浸渍法制备MnO_x/MWCNTs 催化剂. 利用热重分析(TGA)、扫描电子显微镜(SEM)、X射线衍射(XRD)、X射线光电子能谱(XPS)、程序升温还原/脱附(TPR/TPD)以及傅里叶变换红外(FTIR)光谱对催化剂进行表征, 探讨SO₂对催化剂低温氨选择性催化还原(SCR)NO_x活性的影响及SO₂中毒机理. 结果表明, 低温下SO₂对MnO_x/MWCNTs 催化剂活性有明显毒化作用. 反应温度越高, SO₂浓度越大, 催化剂SCR活性下降越快. 活性中心Mn原子硫酸化是催化剂失活的主要原因. 另外, 催化剂表面生成硫酸铵盐以及SO₂对NO吸附的抑制作用也一定程度上造成了催化剂的失活.

关键词:

English

SO₂ Deactivation Mechanism of MnO_x/MWCNTs Catalyst for Low-Temperature Selective Catalytic Reduction of NOx by Ammonia

1.
1. College of Environmental Science and Engineering, South China University of Technology, Guangzhou 510006, P. R. China;
2. Key Laboratory of the Ministry of Education for Pollution Control and Ecosystem Restoration in Industry Clusters, South China University of Technology, Guangzhou 510006, P. R. China
Received Date: 18 June 2012
Available Online: 02 August 2012
Fund Project:
国家自然科学基金(209077034)资助项目

Abstract:

Manganese oxides supported on multi-walled carbon nanotubes (MnO_x/MWCNTs) catalysts were prepared by pore volume impregnation using MWCNTs as the catalyst support which was pretreated by concentrated nitric acid and oxygen dielectric barrier discharge plasma. The catalysts were characterized by thermogravimetric analysis (TGA), scanning electron microscopy (SEM), X-ray powder diffraction (XRD), X-ray photoelectron spectroscopy (XPS), temperature-programmed reduction/desorption (TPR/ TPD), and Fourier transform infrared (FTIR) spectroscopy. The effect of SO₂ on the activity of the catalysts for low-temperature selective catalytic reduction (SCR) of NOx by ammonia and the SO₂ poisoning mechanism were investigated. The results showed that SO₂ had an obvious poisoning effect on the SCR activity of MnO_x/MWCNTs at low temperature. The activity decreased more rapidly as reaction temperature and SO₂ concentration increased. The observed deactivation was attributed to the sulfation of the active center atoms. Formation of ammonium sulfate on the catalyst surface and the inhibiting effect of SO₂ on NO adsorption also resulted in the deactivation of the catalysts to some extent.

Key words:

1. [1]
 
 (1) Busca, G.; Lietti, L.; Ramis, G.; Berti, F. Appl. Catal. B 1998,18, 1. doi: 10.1016/S0926-3373(98)00040-X
 (1) Busca, G.; Lietti, L.; Ramis, G.; Berti, F. Appl. Catal. B 1998,18, 1. doi: 10.1016/S0926-3373(98)00040-X
2. [2]
 (2) Notoya, F.; Su, C.; Sasaoka, E. Ind. Eng. Chem. Res. 2001, 40,3732. doi: 10.1021/ie000972f(2) Notoya, F.; Su, C.; Sasaoka, E. Ind. Eng. Chem. Res. 2001, 40,3732. doi: 10.1021/ie000972f
3. [3]
 (3) Huang, J. H.; Tong, Z. Q.; Huang, Y.; Zhang, J. F. Appl. Catal. B2008, 78, 309. doi: 10.1016/j.apcatb.2007.09.031(3) Huang, J. H.; Tong, Z. Q.; Huang, Y.; Zhang, J. F. Appl. Catal. B2008, 78, 309. doi: 10.1016/j.apcatb.2007.09.031
4. [4]
 (4) Lin, T.; Zhang, Q. L.; Li,W.; ng, M. C.; Xing, Y. X.; Chen, Y.Q. Acta Phys. -Chim. Sin. 2008, 24, 1127. [林涛, 张秋林,李伟, 龚茂初, 幸怡汛, 陈耀强. 物理化学学报, 2008, 24,1127.] doi: 10.1016/S1872-1508(08)60046-7(4) Lin, T.; Zhang, Q. L.; Li,W.; ng, M. C.; Xing, Y. X.; Chen, Y.Q. Acta Phys. -Chim. Sin. 2008, 24, 1127. [林涛, 张秋林,李伟, 龚茂初, 幸怡汛, 陈耀强. 物理化学学报, 2008, 24,1127.] doi: 10.1016/S1872-1508(08)60046-7
5. [5]
 (5) Qi, G.; Yang, R. T. Appl. Catal. B 2003, 44, 217. doi: 10.1016/S0926-3373(03)00100-0(5) Qi, G.; Yang, R. T. Appl. Catal. B 2003, 44, 217. doi: 10.1016/S0926-3373(03)00100-0
6. [6]
 (6) Smirniotis, P. G.; Pena, D. A.; Uphade, B. S. Angew. Chem. Int. Edit. 2001, 40, 2479. doi: 10.1002/1521-3773(20010702)40:13<2479::AID-ANIE2479>3.0.CO;2-7(6) Smirniotis, P. G.; Pena, D. A.; Uphade, B. S. Angew. Chem. Int. Edit. 2001, 40, 2479. doi: 10.1002/1521-3773(20010702)40:13<2479::AID-ANIE2479>3.0.CO;2-7
7. [7]
 (7) Wang, L. S.; Huang, B. C.; Su, Y. X.; Zhou, G. Y.;Wang, K. L.;Luo, H. C.; Ye, D. Q. J. Chem. Eng. 2012, 192, 232. doi: 10.1016/j.cej.2012.04.012(7) Wang, L. S.; Huang, B. C.; Su, Y. X.; Zhou, G. Y.;Wang, K. L.;Luo, H. C.; Ye, D. Q. J. Chem. Eng. 2012, 192, 232. doi: 10.1016/j.cej.2012.04.012
8. [8]
 (8) Kijlstra,W. S.; Biervliet, M.; Poels, E. K.; Bliek, A. Appl. Catal. B 1998, 16, 327. doi: 10.1016/S0926-3373(97)00089-1(8) Kijlstra,W. S.; Biervliet, M.; Poels, E. K.; Bliek, A. Appl. Catal. B 1998, 16, 327. doi: 10.1016/S0926-3373(97)00089-1
9. [9]
 (9) Xie, G. Y.; Liu, Z. Y.; Zhu, Z. P.; Liu, Q. Y.; Ge, J.; Huang, Z. G.J. Catal. 2004, 224, 36. doi: 10.1016/j.jcat.2004.02.015(9) Xie, G. Y.; Liu, Z. Y.; Zhu, Z. P.; Liu, Q. Y.; Ge, J.; Huang, Z. G.J. Catal. 2004, 224, 36. doi: 10.1016/j.jcat.2004.02.015
10. [10]
 (10) Shen, B. X.; Liu, T. Acta Phys. -Chim. Sin. 2010, 26, 3009. [沈伯雄, 刘亭. 物理化学学报, 2010, 26, 3009.] doi: 10.3866/PKU.WHXB20101120(10) Shen, B. X.; Liu, T. Acta Phys. -Chim. Sin. 2010, 26, 3009. [沈伯雄, 刘亭. 物理化学学报, 2010, 26, 3009.] doi: 10.3866/PKU.WHXB20101120
11. [11]
 (11) Jiang, B. Q.;Wu, Z. B.; Liu, Y.; Lee, S. C.; Ho,W. K. J. Phys. Chem. C 2010, 114, 4961. doi: 10.1021/jp907783g(11) Jiang, B. Q.;Wu, Z. B.; Liu, Y.; Lee, S. C.; Ho,W. K. J. Phys. Chem. C 2010, 114, 4961. doi: 10.1021/jp907783g
12. [12]
 (12) Forzatti, P.; Lietti, L. Catal. Taday 1999, 62, 51.(12) Forzatti, P.; Lietti, L. Catal. Taday 1999, 62, 51.
13. [13]
 (13) Svachula, J.; Ferlazzo, N.; Forzatti, P.; Tronconi, E.; Bregani, F.Ind. Eng. Chem. Res. 1993, 32, 826. doi: 10.1021/ie00017a009(13) Svachula, J.; Ferlazzo, N.; Forzatti, P.; Tronconi, E.; Bregani, F.Ind. Eng. Chem. Res. 1993, 32, 826. doi: 10.1021/ie00017a009
14. [14]
 (14) Cao, Z. L.;Wang, Z. Y. Inorganic Chemistry Formula Manual;Hunan Science and Technology Press: Changsha, 1972; p 171.[曹忠良, 王珍云. 无机化学方程式手册. 长沙: 湖南科学技术出版社, 1972: 171.](14) Cao, Z. L.;Wang, Z. Y. Inorganic Chemistry Formula Manual;Hunan Science and Technology Press: Changsha, 1972; p 171.[曹忠良, 王珍云. 无机化学方程式手册. 长沙: 湖南科学技术出版社, 1972: 171.]
15. [15]
 (15) Venezia, A. M.; Carlo, G. D.; Pantaleo, G.; Liotta, L. F.; Melaet,G.; Kruse, N. Appl. Catal. B 2009, 88, 430. doi: 10.1016/j.apcatb.2008.10.023(15) Venezia, A. M.; Carlo, G. D.; Pantaleo, G.; Liotta, L. F.; Melaet,G.; Kruse, N. Appl. Catal. B 2009, 88, 430. doi: 10.1016/j.apcatb.2008.10.023
16. [16]
 (16) Reddy, B. M.; Sreekanth, P. M.; Yamada, Y.; Xu, Q.; Kobayashi,T. Appl. Catal. A 2002, 228, 269. doi: 10.1016/S0926-860X(01)00982-6(16) Reddy, B. M.; Sreekanth, P. M.; Yamada, Y.; Xu, Q.; Kobayashi,T. Appl. Catal. A 2002, 228, 269. doi: 10.1016/S0926-860X(01)00982-6
17. [17]
 (17) Román, E.; de Se via, J. L.; Martín-Ga , J. A.; Comtet, G.;Hellner, L. Vacuum 1997, 48, 597. doi: 10.1016/S0042-207X(97)00074-2(17) Román, E.; de Se via, J. L.; Martín-Ga , J. A.; Comtet, G.;Hellner, L. Vacuum 1997, 48, 597. doi: 10.1016/S0042-207X(97)00074-2
18. [18]
 (18) Romano, E. J.; Schulz, K. H. Appl. Surf. Sci. 2004, 246, 262.(18) Romano, E. J.; Schulz, K. H. Appl. Surf. Sci. 2004, 246, 262.
19. [19]
 (19) Liu, J.; Zhao, Z.;Wang, J. Q.; Xu, C. M.; Duan, A. J.; Jiang, G.Y.; Yang, Q. Appl. Catal. B 2008, 84, 185. doi: 10.1016/j.apcatb.2008.03.017(19) Liu, J.; Zhao, Z.;Wang, J. Q.; Xu, C. M.; Duan, A. J.; Jiang, G.Y.; Yang, Q. Appl. Catal. B 2008, 84, 185. doi: 10.1016/j.apcatb.2008.03.017
20. [20]
 (20) Macleod, N.; Cropley, R.; Lambert, R. M. Catal. Lett. 2003, 86,69. doi: 10.1023/A:1022611109139(20) Macleod, N.; Cropley, R.; Lambert, R. M. Catal. Lett. 2003, 86,69. doi: 10.1023/A:1022611109139
21. [21]
 (21) Jin, R. B.; Liu, Y.;Wu, Z. B.;Wang, H. Q.; Gu, T. T. Catal. Today 2010, 153, 84. doi: 10.1016/j.cattod.2010.01.039(21) Jin, R. B.; Liu, Y.;Wu, Z. B.;Wang, H. Q.; Gu, T. T. Catal. Today 2010, 153, 84. doi: 10.1016/j.cattod.2010.01.039
22. [22]
 (22) Takagi, M.; Kawai, T.; Soma, M.; Onishi, T.; Tamaru, K.J. Phys. Chem. 1976, 80, 430. doi: 10.1021/j100545a019(22) Takagi, M.; Kawai, T.; Soma, M.; Onishi, T.; Tamaru, K.J. Phys. Chem. 1976, 80, 430. doi: 10.1021/j100545a019
23. [23]
 (23) Lin, S. D.; Gluhoi, A. C.; Nieuwenhuys, B. E. Catal. Today2004, 90, 3. doi: 10.1016/j.cattod.2004.04.047(23) Lin, S. D.; Gluhoi, A. C.; Nieuwenhuys, B. E. Catal. Today2004, 90, 3. doi: 10.1016/j.cattod.2004.04.047
24. [24]
 (24) Yang, S. X.; Li, X.; Zhu,W. P.;Wang, J. B.; Descorme, C.Carbon 2008, 46, 445. doi: 10.1016/j.carbon.2007.12.006(24) Yang, S. X.; Li, X.; Zhu,W. P.;Wang, J. B.; Descorme, C.Carbon 2008, 46, 445. doi: 10.1016/j.carbon.2007.12.006
25. [25]
 (25) Lambia, M. A.; Ramis, G.; Busca, G. Appl. Catal. B 2000, 27,145. doi: 10.1016/S0926-3373(00)00150-8(25) Lambia, M. A.; Ramis, G.; Busca, G. Appl. Catal. B 2000, 27,145. doi: 10.1016/S0926-3373(00)00150-8
26. [26]
 (26) Wang,W. H.; Huang, B. C.;Wang, L. S.; Ye, D. Q. Surf. Coat. Technol. 2011, 205, 4896. doi: 10.1016/j.surfcoat.2011.04.100(26) Wang,W. H.; Huang, B. C.;Wang, L. S.; Ye, D. Q. Surf. Coat. Technol. 2011, 205, 4896. doi: 10.1016/j.surfcoat.2011.04.100
27. [27]
 (27) Luo, J.; Tong, Z. Q.; Huang, Y.; Xia, B.; Luo, H. Acta. Sci. Circumst. 2010, 30, 1023. [罗晶, 童志权, 黄妍, 夏斌,罗河. 环境科学学报, 2010, 30, 1023.](27) Luo, J.; Tong, Z. Q.; Huang, Y.; Xia, B.; Luo, H. Acta. Sci. Circumst. 2010, 30, 1023. [罗晶, 童志权, 黄妍, 夏斌,罗河. 环境科学学报, 2010, 30, 1023.]
28. [28]
 (28) Hadjiivanov, K.; Avreyska, V.; Klissurski, D.; Marinova, T.Langmuir 2002, 18, 1619. doi: 10.1021/la0110895(28) Hadjiivanov, K.; Avreyska, V.; Klissurski, D.; Marinova, T.Langmuir 2002, 18, 1619. doi: 10.1021/la0110895
29. [29]
 (29) Pirngruber, G. D.; Pieterse, J. A. Z. J. Catal. 2006, 237, 237.doi: 10.1016/j.jcat.2005.11.012(29) Pirngruber, G. D.; Pieterse, J. A. Z. J. Catal. 2006, 237, 237.doi: 10.1016/j.jcat.2005.11.012
30. [30]
 (30) Zhang, X.; Ji, L. Y.; Zhang, S. C.; Yang,W. S. J. Power Sources2007, 173, 1017. doi: 10.1016/j.jpowsour.2007.08.083(30) Zhang, X.; Ji, L. Y.; Zhang, S. C.; Yang,W. S. J. Power Sources2007, 173, 1017. doi: 10.1016/j.jpowsour.2007.08.083
31. [31]
 (31) Xu,W. Q.; Hong, H.; Yu, Y. B. J. Phys. Chem. C 2009, 113,4426. doi: 10.1021/jp8088148
 (31) Xu,W. Q.; Hong, H.; Yu, Y. B. J. Phys. Chem. C 2009, 113,4426. doi: 10.1021/jp8088148

扫一扫看文章

计量

PDF下载量: 805
文章访问数: 2379
HTML全文浏览量: 62

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

MnO_x/MWCNTs低温氨选择性催化还原NO_x硫中毒机理

English

SO₂ Deactivation Mechanism of MnO_x/MWCNTs Catalyst for Low-Temperature Selective Catalytic Reduction of NOx by Ammonia

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

MnOx/MWCNTs低温氨选择性催化还原NOx硫中毒机理

English

SO2 Deactivation Mechanism of MnOx/MWCNTs Catalyst for Low-Temperature Selective Catalytic Reduction of NOx by Ammonia

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南： 你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

文章相关

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

MnO_x/MWCNTs低温氨选择性催化还原NO_x硫中毒机理

SO₂ Deactivation Mechanism of MnO_x/MWCNTs Catalyst for Low-Temperature Selective Catalytic Reduction of NOx by Ammonia

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs