热态半焦和冷态半焦催化裂解煤焦油研究

引用本文: 刘殊远, 汪印, 武荣成, 曾玺, 许光文. 热态半焦和冷态半焦催化裂解煤焦油研究[J]. 燃料化学学报, 2013, 41(9): 1041-1049. shu

Citation: LIU Shu-yuan, WANG Yin, WU Rong-cheng, ZENG Xi, XU Guang-wen. Research on coal tar catalytic cracking over hot in-situ chars[J]. Journal of Fuel Chemistry and Technology, 2013, 41(9): 1041-1049. shu

热态半焦和冷态半焦催化裂解煤焦油研究

刘殊远 ^1,2, ,
汪印 ^{3,
,} ,
武荣成 ^1, ,
曾玺 ^1, ,
许光文 ^{1,
,}

通讯作者: 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。; 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。

基金项目:
国家自然科学基金(51176197) (51176197)

国家科技支撑项目(2012BAC03B05, 2010BAC66B01)。 (2012BAC03B05, 2010BAC66B01)

摘要: 对比研究了热态半焦(原位热解半焦)和冷态半焦(热解后温度降至常温的半焦)对煤焦油的催化裂解特性。结果表明,相同条件下,热态煤半焦比冷态煤半焦具有更高的催化裂解焦油能力。当裂解温度为1 100 ℃,热解气体在热态半焦层中的停留时间为1.2 s时,催化裂解后燃气中焦油含量可降至100 mg/m³。BET分析结果表明,热态半焦比冷态半焦具有更大的比表面积和更发达的微孔结构。同时,在不可避免经历相对明显的高温过程中,冷态半焦的碳微晶结构有序度增加,进而导致其活性有所降低。随着气体停留时间的延长或催化裂解温度的提高,燃气中焦油含量迅速降低,但热态半焦与冷态半焦催化裂解焦油的活性差异也变小。半焦催化裂解焦油后,活性明显降低,但使这种半焦与水蒸气发生部分气化反应后,其活性基本得到恢复。

关键词:

English

Research on coal tar catalytic cracking over hot in-situ chars

1.
1. State Key Laboratory of Multi-phase Complex Systems, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, China;

Corresponding author: 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。; 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。

Received Date: 24 December 2012
Fund Project:
国家自然科学基金(51176197)

国家科技支撑项目(2012BAC03B05, 2010BAC66B01)。

Abstract: A comparison of coal tar catalytic cracking over hot char from in-situ coal pyrolysis and cooling char was investigated. The results show that the in-situ char has a higher capability of removing tar than the cooling char under the same reaction conditions. The tar content in the product gas is reduced to as low as 100 mg/m³ when the temperature of the in-situ char bed and the gas residence time in the bed are 1 100 ℃ and 1.2 s, respectively. BET analysis shows that the in-situ char has larger specific surface area and more micro pores than the cooling char, while the uniformity of the carbon crystallite structure in the cooling char increases, causing the decrease of the char's catalytic activity for tar removal. With the increase of gas residence time in the char bed or of cracking temperature, the tar content in the product gas decreases greatly, while the difference of catalytic activity for tar cracking between in-situ char and cooling char also decreases. The activity of the spent char is decreased significantly. However, the activity of the spent char can be basically recovered when it is partially gasified with steam.

Key words:

hot char
/ cold char
/ tar
/ catalytic cracking

1. [1] BRAGE C, YU Q Z, CHEN G X, SJOSTROM K. Tar evolution profiles obtained from gasification of biomass and coal[J]. Biomass Bioenergy, 2000, 18(1): 87-91.[1] BRAGE C, YU Q Z, CHEN G X, SJOSTROM K. Tar evolution profiles obtained from gasification of biomass and coal[J]. Biomass Bioenergy, 2000, 18(1): 87-91.
2. [2] MILNE T A, EVANS R J. Biomass gasifier "tars": Their nature, formation, and conversion[R]. Colorado: Nrel, 1998.[2] MILNE T A, EVANS R J. Biomass gasifier "tars": Their nature, formation, and conversion[R]. Colorado: Nrel, 1998.
3. [3] HAN J, KIM H. The reduction and control technology of tar during biomass gasification/pyrolysis: An overview[J]. Renew Sust Energ Rev, 2008, 12(2): 397-416.[3] HAN J, KIM H. The reduction and control technology of tar during biomass gasification/pyrolysis: An overview[J]. Renew Sust Energ Rev, 2008, 12(2): 397-416.
4. [4] BAKER E G, MUDGE L K, BROWN M D. Steam gasification of biomass with nickel secondary catalysts[J]. Ind Eng Chem Res, 1987, 26(7): 1335-1339.[4] BAKER E G, MUDGE L K, BROWN M D. Steam gasification of biomass with nickel secondary catalysts[J]. Ind Eng Chem Res, 1987, 26(7): 1335-1339.
5. [5] KINOSHITA C M, WANG Y, ZHOU J. Effect of reformer conditions on catalytic reforming of biomass-gasification tars[J]. Ind Eng Chem Res, 1995, 34(9): 2949-2954.[5] KINOSHITA C M, WANG Y, ZHOU J. Effect of reformer conditions on catalytic reforming of biomass-gasification tars[J]. Ind Eng Chem Res, 1995, 34(9): 2949-2954.
6. [6] ARAUZO J, RADLEIN D, PISKORZ J, SCOTT D S. Catalytic pyrogasification of biomass. Evaluation of modified nickel catalysts[J]. Ind Eng Chem Res, 1997, 36(1): 67-75.[6] ARAUZO J, RADLEIN D, PISKORZ J, SCOTT D S. Catalytic pyrogasification of biomass. Evaluation of modified nickel catalysts[J]. Ind Eng Chem Res, 1997, 36(1): 67-75.
7. [7] MIYAZAWA T, KIMURA T, NISHIKAWA J, KADO S, KUNIMORI K, TOMISHIGE K. Catalytic performance of supported Ni catalysts in partial oxidation and steam reforming of tar derived from the pyrolysis of wood biomass[J]. Catal Today, 2006, 115(1-4): 254-262.[7] MIYAZAWA T, KIMURA T, NISHIKAWA J, KADO S, KUNIMORI K, TOMISHIGE K. Catalytic performance of supported Ni catalysts in partial oxidation and steam reforming of tar derived from the pyrolysis of wood biomass[J]. Catal Today, 2006, 115(1-4): 254-262.
8. [8] DELGADO J, AZNAR M P, CORELLA J. Calcined dolomite, magnesite, and calcite for cleaning hot gas from a fluidized bed biomass gasifier with steam: Life and usefulness[J]. Ind Eng Chem Res, 1996, 35(10): 3637-3643.[8] DELGADO J, AZNAR M P, CORELLA J. Calcined dolomite, magnesite, and calcite for cleaning hot gas from a fluidized bed biomass gasifier with steam: Life and usefulness[J]. Ind Eng Chem Res, 1996, 35(10): 3637-3643.
9. [9] DELGADO J, AZNAR M P, CORELLA. Biomass gasification with steam in fluidized bed: Effectiveness of CaO, MgO, and CaO-MgO for hot raw gas cleaning[J]. Ind Eng Chem Res, 1997, 36(5): 1535-1543.[9] DELGADO J, AZNAR M P, CORELLA. Biomass gasification with steam in fluidized bed: Effectiveness of CaO, MgO, and CaO-MgO for hot raw gas cleaning[J]. Ind Eng Chem Res, 1997, 36(5): 1535-1543.
10. [10] HOSOKAI S, NORINAGA K, KIMURA T, NAKANO M, LI C Z, HAYASHI J. Reforming of volatiles from the biomass pyrolysis over charcoal in a sequence of coke deposition and steam gasification of coke[J]. Energy Fuels, 2011, 25(11): 5387-5393.[10] HOSOKAI S, NORINAGA K, KIMURA T, NAKANO M, LI C Z, HAYASHI J. Reforming of volatiles from the biomass pyrolysis over charcoal in a sequence of coke deposition and steam gasification of coke[J]. Energy Fuels, 2011, 25(11): 5387-5393.
11. [11] CHEMBUKULAM S K, DANDGE A S, KOVLLU RAO N L, SESHAGIRI K, VAIDYESWARAN R. Smokeless fuel from carbonized sawdust[J]. Ind Eng Chem Prod Res Dev, 1981, 20(4): 714-719.[11] CHEMBUKULAM S K, DANDGE A S, KOVLLU RAO N L, SESHAGIRI K, VAIDYESWARAN R. Smokeless fuel from carbonized sawdust[J]. Ind Eng Chem Prod Res Dev, 1981, 20(4): 714-719.
12. [12] HOSOKAI S, HAYASHI J, SHIAMADA T, KOBOYASHI Y, KURAMOTO K, LI C Z, CHIBA T. Spontaneous generation of tar decomposition promoter in a biomass steam reformer[J]. Ind Eng Chem Res, 2005, 83(9): 1093-1102.[12] HOSOKAI S, HAYASHI J, SHIAMADA T, KOBOYASHI Y, KURAMOTO K, LI C Z, CHIBA T. Spontaneous generation of tar decomposition promoter in a biomass steam reformer[J]. Ind Eng Chem Res, 2005, 83(9): 1093-1102.
13. [13] BRANDT P, LARSEN E, HENRIKSEN U. High tar reduction in a two-stage gasifier[J]. Energy Fuels, 2000, 41(4): 816-819.[13] BRANDT P, LARSEN E, HENRIKSEN U. High tar reduction in a two-stage gasifier[J]. Energy Fuels, 2000, 41(4): 816-819.
14. [14] HOSOKAI S,KISHIMOTO K,NORINAGA K, LI C Z, HAYASHI J. Characteristics of gas-phase partial oxidation of nascent tar from the rapid pyrolysis of cedar sawdust at 700-800℃[J]. Energy Fuels, 2010, 24(5): 2900-2909.[14] HOSOKAI S,KISHIMOTO K,NORINAGA K, LI C Z, HAYASHI J. Characteristics of gas-phase partial oxidation of nascent tar from the rapid pyrolysis of cedar sawdust at 700-800℃[J]. Energy Fuels, 2010, 24(5): 2900-2909.
15. [15] ABU E-R Z, BRAMER E A, BREM G. Experimental comparison of biomass chars with other catalysts for tar reduction[J]. Fuel, 2008, 87(10-11): 2243-2252.[15] ABU E-R Z, BRAMER E A, BREM G. Experimental comparison of biomass chars with other catalysts for tar reduction[J]. Fuel, 2008, 87(10-11): 2243-2252.
16. [16] HAYASHI J I, IWATSUKI M, MORISHITA K, TSUTSUMI A, LI C Z, TADATOSHI C. Roles of inherent metallic species in secondary reactions of tar and char during rapid pyrolysis of brown coals in a drop-tube reactor[J]. Fuel, 2002, 81(5): 1977-1987.[16] HAYASHI J I, IWATSUKI M, MORISHITA K, TSUTSUMI A, LI C Z, TADATOSHI C. Roles of inherent metallic species in secondary reactions of tar and char during rapid pyrolysis of brown coals in a drop-tube reactor[J]. Fuel, 2002, 81(5): 1977-1987.
17. [17] ZENG X, WANG Y, YU J, WU S S, ZHONG M, XU S P, XU G W. Coal pyrolysis in a fluidized bed for adapting to a two-stage gasification process[J]. Energy Fuels, 2011, 25(3): 1092-1098.[17] ZENG X, WANG Y, YU J, WU S S, ZHONG M, XU S P, XU G W. Coal pyrolysis in a fluidized bed for adapting to a two-stage gasification process[J]. Energy Fuels, 2011, 25(3): 1092-1098.
18. [18] ZENG X, WANG Y, YU J, WU S S, ZHONG M, XU S P, XU G W. Gas upgrading in a downdraft fixed-bed reactor downstream of a fluidized-bed coal pyrolyzer[J]. Energy Fuels, 2011, 25(11): 5242-5249.[18] ZENG X, WANG Y, YU J, WU S S, ZHONG M, XU S P, XU G W. Gas upgrading in a downdraft fixed-bed reactor downstream of a fluidized-bed coal pyrolyzer[J]. Energy Fuels, 2011, 25(11): 5242-5249.
19. [19] HENRIKSEN U, AHRENFELDT J, JESEN T K, GOBEL B, BENTZEN J D, HINDSGAUL C, SORENSEN L H. The design, construction and operation of a 75 kW two-stage gasifier[J]. Energy, 2006, 31(10-11): 1542-1553.[19] HENRIKSEN U, AHRENFELDT J, JESEN T K, GOBEL B, BENTZEN J D, HINDSGAUL C, SORENSEN L H. The design, construction and operation of a 75 kW two-stage gasifier[J]. Energy, 2006, 31(10-11): 1542-1553.
20. [20] GILBERT P, RYU C, SHARIFI V, SWITHENBANK J. Tar reduction in pyrolysis vapors from biomass over a hot char bed[J]. Bioresource technology, 2009, 100(23): 6045-6051.[20] GILBERT P, RYU C, SHARIFI V, SWITHENBANK J. Tar reduction in pyrolysis vapors from biomass over a hot char bed[J]. Bioresource technology, 2009, 100(23): 6045-6051.
21. [21] SENNECA O, SALATINO P, MASI S. Microstructure changes and loss of gasification reactivity of char upon heat treatment[J]. Fuel, 1998, 77(13): 1483-1493.[21] SENNECA O, SALATINO P, MASI S. Microstructure changes and loss of gasification reactivity of char upon heat treatment[J]. Fuel, 1998, 77(13): 1483-1493.
22. [22] FENG B, BHATIA S K, BARRY J C. Structural ordering of coal char during heat treatment and its impact on reactivity[J]. Carbon, 2002, 40(4): 481-496.[22] FENG B, BHATIA S K, BARRY J C. Structural ordering of coal char during heat treatment and its impact on reactivity[J]. Carbon, 2002, 40(4): 481-496.
23. [23] SHARMA A, KADOOKA H, KYOTANI T, TOMITA A. Effect of micro structural changes on gasification reactivity of coal chars during low temperature gasification[J]. Energy Fuels, 2002, 16(1): 54-61.[23] SHARMA A, KADOOKA H, KYOTANI T, TOMITA A. Effect of micro structural changes on gasification reactivity of coal chars during low temperature gasification[J]. Energy Fuels, 2002, 16(1): 54-61.
24. [24] YIP K, WU H, ZHANG D. Effect of inherent moisture in collie coal during pyrolysis due to in-situ steam gasification[J]. Energy Fuels, 2007, 21(5): 2883-2891.[24] YIP K, WU H, ZHANG D. Effect of inherent moisture in collie coal during pyrolysis due to in-situ steam gasification[J]. Energy Fuels, 2007, 21(5): 2883-2891.
25. [25] SENNECA O, SALATINO P, MASI S. Heat treatment-induced loss of combustion reactivity of a coal char: The effect of exposure to oxygen[J]. Exp Therm Fluid Sci, 2004, 28(7): 735-741.[25] SENNECA O, SALATINO P, MASI S. Heat treatment-induced loss of combustion reactivity of a coal char: The effect of exposure to oxygen[J]. Exp Therm Fluid Sci, 2004, 28(7): 735-741.
26. [26] SHENG C D. Char structure characterized by Raman spectroscopy and its correlations with combustion reactivity[J]. Fuel, 2007, 86(15): 2316-2324.[26] SHENG C D. Char structure characterized by Raman spectroscopy and its correlations with combustion reactivity[J]. Fuel, 2007, 86(15): 2316-2324.

扫一扫看文章

计量

PDF下载量: 0
文章访问数: 0
HTML全文浏览量: 0

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

热态半焦和冷态半焦催化裂解煤焦油研究

通讯作者: 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。; 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。

English

Research on coal tar catalytic cracking over hot in-situ chars

Corresponding author: 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。; 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

热态半焦和冷态半焦催化裂解煤焦油研究

通讯作者: 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。; 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。

English

Research on coal tar catalytic cracking over hot in-situ chars

Corresponding author: 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。; 汪印、许光文, Tel: 010-82544886, E-mail: yinwang@iue.ac.cn, gwxu@home.ipe.ac.cn。

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南： 你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

文章相关

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs