丙醇和丁醇异构体在钯镍电极上的电催化氧化

引用本文: 孙丽枝, 易清风, 刘小平. 丙醇和丁醇异构体在钯镍电极上的电催化氧化[J]. 燃料化学学报, 2013, 41(10): 1274-1280. shu

Citation: SUN Li-zhi, YI Qing-feng, LIU Xiao-ping. Electrocatalytic oxidation of propanol and butanol isomers on palladium-nickel catalyst[J]. Journal of Fuel Chemistry and Technology, 2013, 41(10): 1274-1280. shu

丙醇和丁醇异构体在钯镍电极上的电催化氧化

通讯作者: 易清风(1963-),男,教授,E-mail:yqfyy2001@hnust.edu.cn;Tel:13107222527。

基金项目:
国家自然科学基金(21376070, 20876038) (21376070, 20876038)

湖南省高校创新平台开放基金(11K023) (11K023)

湖南省发委科技基本建设项目([2010]1060)。 ([2010]1060)

摘要: β环糊精(β-CD)具有特殊的空腔结构,将β-CD修饰的多壁碳纳米管(MWCNT)涂在钛基底上,采用电沉积的方法在修饰的钛基底上沉积纳米PdNi催化剂。SEM结果表明,PdNi纳米颗粒在β-CD/MWCNT修饰的钛片上有较好的分散度,粒径为90~130 nm。在碱性溶液中,测试了PdNi-β-CD/MWCNT/Ti电极分别对丙醇和丁醇不同异构体氧化的电催化活性;通过计算与-OH相连的碳原子上的Muliken净电荷,分析不同异构体的氧化机理。结果表明,不同异构体的氧化活性不同,PdNi-β-CD/MWCNT/Ti电极对正丙醇和正丁醇的氧化活性明显高于其异构体,-OH所在碳原子上的Muliken 净电荷越小,醇类分子越容易被氧化。

关键词:

English

Electrocatalytic oxidation of propanol and butanol isomers on palladium-nickel catalyst

1.
School of Chemistry and Chemical Engineering, Hunan University of Science and Technology, Xiangtan 411201, China

Corresponding author: 易清风(1963-),男,教授,E-mail:yqfyy2001@hnust.edu.cn;Tel:13107222527。

Received Date: 25 February 2013
Fund Project:
国家自然科学基金(21376070, 20876038)

湖南省高校创新平台开放基金(11K023)

湖南省发委科技基本建设项目([2010]1060)。

Abstract: β-cyclodextrin (β-CD) with a special cavity structure was firstly grafted on the surface of multi-walled carbon nanotubes (MWCNTs), which were then immobilized on Ti plates to obtain the β-CD/MWCNT/Ti substrate. Binary Pd-Ni nanoparticles were electrodeposited on the surface of β-CD/MWCNT/Ti substrate to prepare the PdNi-β-CD/MWCN/Ti electrode; its activity in electrocatalytic oxidation of propanol and butanol isomers in alkaline media was then investigated by voltammetry, chronoamperometry and electrochemical impedance spectroscopy. The results indicated that the binary PdNi nanoparticles are highly dispersed with the size of 90~130 nm on the β-CD/MWCNT/Ti substrate. The configuration of alcohols plays a significant role in their electrochemical oxidation activity in alkaline media on the PdNi-β-CD/MWCNT/Ti electrode. For the two propanol isomers, the PdNi-β-CD/MWCNT/Ti electrode exhibits much higher electroactivity for 1-propanol oxidation than that for 2-propanol oxidation. For the four butanol isomers, the electrocatalytic activity of the PdNi-β-CD/MWCNT/Ti electrode towards their oxidation follows the order of 1-butanol > 2-methyl-propanol > 2-butanol >> 2-methyl-2-propanol; the electrode shows almost no electrocatalytic activity in the oxidation of tertiary butanol. The mechanism for the electrocatalytic oxidation of various propanol and butanol isomers was also analyzed by considering the Muliken net charge on the different carbon atoms bonded with hydroxyl –OH, which indicates that the alcohol molecule with lower Muliken net charge value will be more easily oxidized over the PdNi-β-CD/MWCNT/Ti electrode.

Key words:

1. [1] KAMARUDIN S K, DAUD W R W, HO S L, HASRAN U A. Over view on the challenges and developments of micro-direct methanol fuel cells (DMFC)[J]. J Power Sources, 2007, 163(2): 743-754.[1] KAMARUDIN S K, DAUD W R W, HO S L, HASRAN U A. Over view on the challenges and developments of micro-direct methanol fuel cells (DMFC)[J]. J Power Sources, 2007, 163(2): 743-754.
2. [2] CAO D X, BERGENS S H. A direct 2-propanol polymer electrolyte fuel cell[J]. J Power Sources, 2003, 124(1): 12-17.[2] CAO D X, BERGENS S H. A direct 2-propanol polymer electrolyte fuel cell[J]. J Power Sources, 2003, 124(1): 12-17.
3. [3] ZHANG Z Y, LE X, SUN K, LI W Z. Pd-Ni electrocatalysts for efficient ethanol oxidation reaction in alkaline electrolyte[J]. Chem Eng Sci, 2011, 36(20): 12686-12697.[3] ZHANG Z Y, LE X, SUN K, LI W Z. Pd-Ni electrocatalysts for efficient ethanol oxidation reaction in alkaline electrolyte[J]. Chem Eng Sci, 2011, 36(20): 12686-12697.
4. [4] LI H Z, SHEN J Z, YANG G X. Anodic Pd catalyst in direct formic acid fuel cell and its electrocatalytic stability[J]. Chem J Chinese U, 2011, 32(7): 1445-1450.[4] LI H Z, SHEN J Z, YANG G X. Anodic Pd catalyst in direct formic acid fuel cell and its electrocatalytic stability[J]. Chem J Chinese U, 2011, 32(7): 1445-1450.
5. [5] MAIYALAGAN T, SCOTT K. Performance of carbon nanofiber supported Pd-Ni catalysts for electro-oxidation of ethanol in alkaline medium[J]. J Power Sources, 2010, 195(16): 5246-525.[5] MAIYALAGAN T, SCOTT K. Performance of carbon nanofiber supported Pd-Ni catalysts for electro-oxidation of ethanol in alkaline medium[J]. J Power Sources, 2010, 195(16): 5246-525.
6. [6] LIU J P, YE J Q, XU C W, JIANG S P, TONG Y X. Electro-oxidation of methanol, 1-propanol and 2-propanolon Pt and Pd in alkaline medium[J]. J Power Sources, 2008, 177(1): 67-70.[6] LIU J P, YE J Q, XU C W, JIANG S P, TONG Y X. Electro-oxidation of methanol, 1-propanol and 2-propanolon Pt and Pd in alkaline medium[J]. J Power Sources, 2008, 177(1): 67-70.
7. [7] QI Z G, HOLLETT M, ATTIA A, KAUFMAN A. Low temperature direct 2-propanol fuel cells[J]. Electrochem Solid ST, 2002, 5(6): A129-A130.[7] QI Z G, HOLLETT M, ATTIA A, KAUFMAN A. Low temperature direct 2-propanol fuel cells[J]. Electrochem Solid ST, 2002, 5(6): A129-A130.
8. [8] QI Z G, KAUFMAN A. Permance of 2-propanol in direct-oxidation fuel cells[J]. J Power Sources, 2002, 112(l): 121-129.[8] QI Z G, KAUFMAN A. Permance of 2-propanol in direct-oxidation fuel cells[J]. J Power Sources, 2002, 112(l): 121-129.
9. [9] XING X L, CHEREVKO S, CHUNG C H. Porous Pd films as effective ethanol oxidation electrocatalysts in alkaline medium[J]. Mater Chem Phys, 2011, 126(1/2): 36-40.[9] XING X L, CHEREVKO S, CHUNG C H. Porous Pd films as effective ethanol oxidation electrocatalysts in alkaline medium[J]. Mater Chem Phys, 2011, 126(1/2): 36-40.
10. [10] MARKIEWICZ M E P, HEBERT D M, BERGENS S H. Electro-oxidation of 2-propanol on platinum in alkaline electrolytes[J]. J Power Sources, 2006, 161(2): 761-767.[10] MARKIEWICZ M E P, HEBERT D M, BERGENS S H. Electro-oxidation of 2-propanol on platinum in alkaline electrolytes[J]. J Power Sources, 2006, 161(2): 761-767.
11. [11] YE J Q, LIU J P, XU C W, JIANG S P, TONG Y X. Electrooxidation of 2-propanol on Pt, Pd and Au in alkaline medium[J]. Electrochem Commun, 2007, 9(12): 2760-2763.[11] YE J Q, LIU J P, XU C W, JIANG S P, TONG Y X. Electrooxidation of 2-propanol on Pt, Pd and Au in alkaline medium[J]. Electrochem Commun, 2007, 9(12): 2760-2763.
12. [12] YI P G, LUI Z J, WANG Z X, HOU B,YU X Y, LIU X F. Alkali (Alkali Earth) metal ions with 2-(3'-Hydroxy-2'-pyridyl)benz-oxazole cation-π complexes and its intramolecular protontransfer process: A theoretical investigation[J]. Acta Chim Sinica, 2012, 70(12): 1347-1354.[12] YI P G, LUI Z J, WANG Z X, HOU B,YU X Y, LIU X F. Alkali (Alkali Earth) metal ions with 2-(3'-Hydroxy-2'-pyridyl)benz-oxazole cation-π complexes and its intramolecular protontransfer process: A theoretical investigation[J]. Acta Chim Sinica, 2012, 70(12): 1347-1354.
13. [13] SU Y Z, XU C W, LIU J P, LIU Z Q. Electrooxidation of 2-propanol compared ethanol on Pd electrode in alkaline medium[J]. J Power Sources, 2009, 194(1): 295-297.[13] SU Y Z, XU C W, LIU J P, LIU Z Q. Electrooxidation of 2-propanol compared ethanol on Pd electrode in alkaline medium[J]. J Power Sources, 2009, 194(1): 295-297.
14. [14] XU C W, TIAN Z Q, CHEN Z C, JIANG S P. Pd/C promoted by Au for 2-propanol electrooxidation in alkaline media[J]. Electrochem Commun, 2008, 10(2): 246-249.[14] XU C W, TIAN Z Q, CHEN Z C, JIANG S P. Pd/C promoted by Au for 2-propanol electrooxidation in alkaline media[J]. Electrochem Commun, 2008, 10(2): 246-249.
15. [15] WANG D Y, LIU J P, WU Z Y, ZHANG J H, SU Y Z, LIU Z L, XU C W. Electrooxidation of methanol, ethanol and 1-propanol on Pd electrode in alkaline medium[J]. Int J Electrochem Sci, 2009, 4(12): 1672-1678.[15] WANG D Y, LIU J P, WU Z Y, ZHANG J H, SU Y Z, LIU Z L, XU C W. Electrooxidation of methanol, ethanol and 1-propanol on Pd electrode in alkaline medium[J]. Int J Electrochem Sci, 2009, 4(12): 1672-1678.
16. [16] KANNAN R, KARUNAKARAN K, VASANTHKUMAR S. PdNi-decorated manganite nanocatalyst for electrooxidation of ethylene glycol in alkaline media[J]. Ionics, 2012, 18(8): 803-809.[16] KANNAN R, KARUNAKARAN K, VASANTHKUMAR S. PdNi-decorated manganite nanocatalyst for electrooxidation of ethylene glycol in alkaline media[J]. Ionics, 2012, 18(8): 803-809.
17. [17] MARKIEWICZ M E P, BERGENS S H. A liquid electrolyte alkaline direct 2-propanol fuel cell[J]. J Power Sources, 2010, 195(21): 7196-7201.[17] MARKIEWICZ M E P, BERGENS S H. A liquid electrolyte alkaline direct 2-propanol fuel cell[J]. J Power Sources, 2010, 195(21): 7196-7201.

扫一扫看文章

计量

PDF下载量: 0
文章访问数: 0
HTML全文浏览量: 0

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

丙醇和丁醇异构体在钯镍电极上的电催化氧化

通讯作者: 易清风(1963-),男,教授,E-mail:yqfyy2001@hnust.edu.cn;Tel:13107222527。

English

Electrocatalytic oxidation of propanol and butanol isomers on palladium-nickel catalyst

Corresponding author: 易清风(1963-),男,教授,E-mail:yqfyy2001@hnust.edu.cn;Tel:13107222527。

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

丙醇和丁醇异构体在钯镍电极上的电催化氧化

通讯作者: 易清风(1963-),男,教授,E-mail:yqfyy2001@hnust.edu.cn;Tel:13107222527。

English

Electrocatalytic oxidation of propanol and butanol isomers on palladium-nickel catalyst

Corresponding author: 易清风(1963-),男,教授,E-mail:yqfyy2001@hnust.edu.cn;Tel:13107222527。

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南： 你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

文章相关

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs